radiator JEEP LIBERTY 2008 KK / 2.G User Guide

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
²The warning words ªDO NOT OPEN HOTº on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
²Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children,
do not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine idling, and warm to normal operating tempera-
ture, the level of the coolant in the bottle should be
between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
MAINTAINING YOUR VEHICLE 419
7

service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
²Do not overfill the coolant bottle.
²Check coolant freeze point in the radiator and in the
coolant recovery bottle. If coolant needs to be added,
contents of coolant recovery bottle must also be pro-
tected against freezing.
²If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
²Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine, which contains
aluminum components.
²Make sure that the radiator and coolant recovery
bottle hoses are not kinked or obstructed.
420 MAINTAINING YOUR VEHICLE

²Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
²Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory cooling performance, poor gas
mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Fuel System
The Electronic Fuel Injection high-pressure fuel system's
tubes, special connectors, connections, and clamps have
unique material characteristics that provide adequate
sealing and resist attack by deteriorated gasoline.
You are urged to use only the manufacture specified
tubes, connections, and clamps, or their equivalent in
material and specification, in any fuel system servicing.
MAINTAINING YOUR VEHICLE 421
7

Cavity Cartridge
FuseMini
FuseDescription
J3 40 Amp
GreenÐ Rear Door Modules
J4 25 Amp
WhiteÐ Driver Door Node
J5 25 Amp
WhiteÐ Passenger Door Node
J6 40 Amp
GreenÐ Anti-Lock Brake Sys-
tem (ABS) Pump/ESP
- if equipped
J7 30 Amp
PinkÐ Anti-Lock Brake Sys-
tem (ABS) Valve/ESP
- if equipped
J8 40 Amp
GreenÐ Power Seats - if
equipped
J9 40 Amp
GreenÐ PZEV/Flex Fuel - if
equipped
J10 Ð Ð ÐCavity Cartridge
FuseMini
FuseDescription
J11ÐÐÐ
J13 60 Amp
YellowÐ Ignition Off Draw
(IOD)
J14 40 Amp
GreenÐ EBL (Rear Window
Defogger) - if
equipped
J15 Ð Ð Ð
J17 40 Amp
GreenÐ Starter Solenoid
J18 20 Amp
BlueÐ Powertrain Control
Module (PCM) Trans-
mission Relay
J19 60 Amp
YellowÐ Radiator Fan
J20 30 Amp
PinkÐ Front Wiper
MAINTAINING YOUR VEHICLE 437
7

Brake, Parking.......................... 308
Brake System........................... 422
Anti-Lock (ABS)....................310,315
Fluid Check.......................423,449
Hoses.............................. 422
Master Cylinder....................... 423
Parking............................. 308
Warning Light........................ 202
Brakes............................... 422
Brake/Transmission Interlock............... 283
Break-In Recommendations, New Vehicle........ 79
Brightness, Interior Lights.................. 138
Bulb Replacement....................... 443
Bulbs, Light..........................82,443
Calibration, Compass..................204,212
Capacities, Fluid........................ 447
Caps, Filler
Fuel................................ 359Oil (Engine).......................... 404
Radiator (Coolant Pressure)............... 418
Car Washes............................ 429
Carbon Monoxide Warning...............80,358
Cargo Area Cover....................... 178
Cargo Area Features...................... 174
Cargo Compartment...................... 174
Light............................... 138
Cargo Light............................ 138
Cargo Load Floor........................ 174
Cargo Tie-Downs........................ 176
Cargo (Vehicle Loading)................... 361
Catalytic Converter...................... 407
CD (Compact Disc) Player................. 237
CD (Compact Disc) Player Maintenance........ 259
Cellular Phone.....................92,237,239
Certification Label....................... 361
Changing A Flat Tire..................... 385
Charging System Light.................... 194
472 INDEX

Chart, Tire Sizing........................ 330
Check Engine Light (Malfunction Indicator
Light)................................ 400
Checking Your Vehicle For Safety............. 79
Checks, Safety........................... 79
Child Restraint....................69,70,74,76
Child Restraint Tether Anchors.............73,74
Child Safety Locks........................ 33
Clean Air Gasoline....................... 356
Cleaning
Windshield Wiper Blades................. 413
Climate Control......................... 260
Clock...........................224,239,243
Clutch Fluid Reservoir.................... 424
Clutch Interlocking Ignition System........... 288
Coin Holder........................... 173
Cold Weather Operation................... 278
Command-Trac Operation.................. 292
Compact Disc (CD) Maintenance............. 259Compass.............................. 212
Compass Calibration..................204,212
Compass Variance....................204,213
Computer, Trip/Travel.................... 210
Console.............................. 173
Console, Floor.......................... 173
Contract, Service........................ 462
Converter, Catalytic...................... 407
Coolant Pressure Cap (Radiator Cap).......... 418
Cooling System......................... 416
Adding Coolant (Antifreeze).............. 418
Coolant Capacity...................... 447
Coolant Level......................416,419
Disposal of Used Coolant................ 419
Drain, Flush, and Refill.................. 417
Inspection........................... 419
Points to Remember.................... 420
Pressure Cap......................... 418
Selection of Coolant (Antifreeze)......417,447,448
INDEX 473
10

Power Steering Fluid..................412,449
Pregnant Women and Seat Belts.............. 50
Preparation for Jacking.................... 387
Pretensioners
Seat Belts............................. 47
Programmable Electronic Features............ 216
Programming Transmitters (Remote Keyless
Entry)................................. 20
Radial Ply Tires......................... 340
Radiator Cap (Coolant Pressure Cap).......... 418
Radio Broadcast Signals................... 221
Radio, Navigation....................... 237
Radio Operation........................ 239
Radio Remote Controls.................... 258
Radio, Satellite....................237,239,254
Radio (Sound Systems).................... 237
Rain Sensitive Wiper System................ 143
Rear Axle (Differential).................... 428Rear Cup Holder........................ 172
Rear Park Sense System................... 150
Rear Seat, Folding....................... 124
Rear Washer Fluid....................... 181
Rear Window Defroster................... 181
Rear Window Features.................... 180
Rear Wiper/Washer...................... 180
Rearview Mirrors........................ 88
Reception, Radio........................ 221
Reclining Front Seats..................... 119
Recorder, Event Data...................... 67
Recreational Towing...................... 378
Reformulated Gasoline.................... 356
Refrigerant............................ 412
Release, Hood.......................... 131
Reminder, Lights On..................... 135
Reminder, Seat Belt....................... 48
Remote Control
Starting System........................ 27
INDEX 485
10