automatic transmission JEEP WRANGLER 2016 JK / 3.G Workshop Manual

VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take steps to protect your battery.
You may:
•Remove Cartridge fuse #J13 in the Power Distribution
Center (PDC) labeled Ignition-Off Draw (IOD) and
store it in a safe location within the PDC. •
Or, disconnect the negative cable from the battery.
• Anytime you store your vehicle, or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT BULBS
Interior Bulbs
Bulb Number
Automatic Transmission Indicator Lamp 658
Heater Control Lamps (2) 194
Rocker Switch Indicator Lamp (Rear Window Defogger, and Rear Wash/Wipe) **
Soundbar Dome Lamp 912
** Bulbs only available from authorized dealer.
654 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission –
If Equipped Use only ATF+4 Automatic Transmission Fluid. Failure to use ATF+4 fluid may affect
the function or performance of your transmission. We recommend MOPAR ATF+4
fluid.
Manual Transmission – If
Equipped We recommend you use MOPAR Manual Transmission Lubricant meeting the
requirements of FCA Material Standard MS-9224.
Transfer Case We recommend you use MOPAR ATF+4 Automatic Transmission Fluid.
Axle Differential (Front) We recommend you use MOPAR Gear & Axle Lubricant (SAE 80W-90) (API GL-5).
Axle Differential (Rear) 226 RBI (Model 44)– We recommend you use MOPAR Gear & Axle Lubricant (SAE
80W-90) (API GL-5) or equivalent. For trailer towing, use MOPAR Synthetic Gear &
Axle Lubricant (SAE 75W-140). Models equipped with Trac-Lok require an additive.
Brake Master Cylinder We recommend you use MOPAR DOT 3 Brake Fluid, SAE J1703. If DOT 3, SAE J1703 brake fluid is not available, then DOT 4 is acceptable.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +4, MOPAR ATF+4 Automatic Transmission Fluid.
662 MAINTAINING YOUR VEHICLE

Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By OilChange Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required
• Inspect automatic transmission fluid if equipped
with dipstick
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Inspect engine cooling system protection and
hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions
• Inspect all door latches for presence of grease,
reapply if necessary.
Maintenance Chart
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
666 MAINTENANCE SCHEDULES

Mileage or time passed (whichevercomes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Replace air conditioning/cabin air filter. X X X X XXX
Replace spark plugs ** X
Flush and replace the engine coolant at
10 years or 150,000 miles (240,000 km)
whichever comes first. XX
Change automatic transmission fluid
and filter if using your vehicle for any of
the following: police, taxi, fleet, or fre-
quent trailer towing. XX
Change the automatic transmission fluid
and filter. X
668 MAINTENANCE SCHEDULES

Automatic Dimming Mirror..................112
Automatic Door Locks ......................41
Automatic Headlights ..................... .169
Automatic Oil Change Indicator ...............353
Automatic Temperature Control (ATC) ..........419
Automatic Transmission ..............445, 632, 635
Adding Fluid ......................... .635
Fluid And Filter Changes ..................635
Fluid Change ......................... .635
Fluid Level Check ...................... .633
Fluid Type ........................ .632, 662
Special Additives ...................... .633
Autostick .............................. .451
Auxiliary Electrical Outlet (Power Outlet) ........185
Auxiliary Power Outlet .....................185
Axle Fluid ............................. .662
Axle Lock .............................. .459
Battery ............................ .315, 609Charging System Light
...................315
Keyless Transmitter Replacement (RKE) ........27
Belts, Seat .............................. .101
Body Mechanism Lubrication .................614
B-Pillar Location ......................... .505
Brake Assist System ...................... .484
Brake Control System, Electronic ..............481
Brake Fluid ............................ .662
Brakes ................................ .480
Brake System ........................ .480, 630
Master Cylinder ....................... .631
Parking ............................. .478
Warning Light ..................... .318, 480
Brake/Transmission Interlock .................444
Bulb Replacement ..................... .654, 656
Bulbs, Light ......................... .104, 654
Calibration, Compass .................. .341, 349
Capacities,

Fluid ......................... .659
10
INDEX 683

Automatic Door.........................41
Child Protection .........................42
Door .................................38
Power Door ............................40
Lubrication, Body ........................ .614
Lug Nuts .............................. .571
Maintenance Free Battery ....................609
Maintenance Procedures ....................599
Maintenance Schedule ..................... .664
Malfunction Indicator Light (Check Engine) . . .326, 597
Manual, Service ......................... .678
Manual Transmission ...................438, 636
Fluid Level Check ...................... .636
Lubricant Selection ...................636, 662
Shift Speeds .......................... .439
Master Cylinder (Brakes) ....................631
Methanol .............................. .535
Mini-Trip Computer ....................338, 347 Mirrors
.................................111
Automatic Dimming .....................112
Electric Powered ........................113
Electric Remote .........................113
Heated ...............................114
Outside ..............................112
Rearview .............................111
Vanity ...............................114
Modifications/Alterations, Vehicle ...............9
Modular Hard Top ....................... .206
Monitor, Tire Pressure System ................523
MOPAR Parts ........................ .598, 677
MTBE/ETBE ........................... .535
New Vehicle Break-In Period ..................98
Occupant Restraints ........................47
Octane Rating, Gasoline (Fuel) .............534, 660
Oil Change Indicator ...................... .353
692 INDEX

Front Seat....................... .49, 51, 54
Inspection ........................... .101
Operating Instructions ....................54
Pregnant Women ........................59
Pretensioners ...........................59
Rear Seat ..............................51
Reminder ............................ .316
Untwisting Procedure .....................56
Seats ................................. .152
Adjustment .......................... .153
Easy Entry ........................... .155
Fold And Tumble Rear ...................163
Heated .............................. .159
Height Adjustment ..................... .154
Rear Folding ......................... .165
Removal ............................ .165
Seatback Release ....................... .154
Tilting .............................. .154
Security Alarm ........................ .20, 322Security System
...........................20
Selection Of Coolant (Antifreeze) ..............660
Sentry Key (Immobilizer) ....................16
Sentry Key Programming ....................18
Sentry Key Replacement .....................17
Service Assistance ........................ .673
Service Contract ......................... .675
Service Manuals ......................... .678
Settings, Personal ........................ .354
Setting The Clock ...................359, 368, 385
Shifting ............................... .442
Automatic Transmission ..................442
Manual Transmission ....................438
Transfer Case, Shifting Into Transfer Case
Neutral (N) .......................... .565
Transfer Case, Shifting Out Of Transfer Case
Neutral (N) .......................... .567
Shift Lever Override ...................... .587
Shoulder Belts ............................51
696 INDEX

Side Window Demisters (Defrosters)............427
Signals, Turn ...................104, 170, 657, 658
Snow Chains (Tire Chains) ...................521
Snow Tires ............................. .514
Soft Top ............................ .225, 258
Spare Tire .....................515, 516, 517, 575
Spark Plugs ............................ .660
Specifications Fuel (Gasoline) ........................ .660
Oil................................. .660
Speed Control Accel/Decel .......................... .184
Cancel .............................. .183
Resume ............................. .183
Speed Control (Cruise Control) ................181
Starting ......................... .28, 434, 435
Automatic Transmission ..................434
Cold Weather ......................... .435
Engine Block Heater .....................437 Engine Fails To Start
.....................435
Manual Transmission ....................434
Remote ...............................28
Starting And Operating .....................435
Starting Procedures ....................... .435
Steering Power ........................... .476, 477
Tilt Column .......................... .180
Wheel, Tilt ........................... .180
Steering Wheel Audio Controls ................411
Steering Wheel Mounted Sound System Controls . . .411
Storage ............................... .654
Storage, Behind the Seat ....................193
Storage, Vehicle ...................... .426, 654
Storing Your Vehicle ...................... .654
Stuck, Freeing ........................... .585
Sunrider ........................... .255, 291
Supplemental Restraint System - Air Bag .........63
Sway Bar Disconnect, Electronic ...............460
10
INDEX 697

Towing......................... .544, 548, 589
24-Hour Towing Assistance ................129
Disabled Vehicle ....................... .589
Recreational .......................... .563
Weight .............................. .548
Towing Assistance ........................ .129
Towing Vehicle Behind A Motorhome ...........563
Trac-Lok Rear Axle ....................... .458
Traction Control ......................... .487
Trailer Sway Control (TSC) ..................496
Trailer Towing .......................... .544
Cooling System Tips .....................562
Hitches ............................. .546
Minimum Requirements ..................556
Trailer And Tongue Weight .............548, 555
Wiring .............................. .559
Trailer Towing Guide ...................... .548
Trailer Weight ........................... .548Transaxle
Autostick ............................ .451
Transfer Case ........................... .637
Fluid ............................... .662
Four-Wheel-Drive Operation ...............454
Maintenance .......................... .637
Transmission ........................... .632
Automatic ........................ .445, 632
Fluid ............................... .662
Manual ............................. .438
Shifting ............................. .442
Transmitter Battery Service (Remote Keyless Entry) ....................27
Tread Wear Indicators ..................... .518
Trip Computer .......................... .338
Turn Signals ..................... .170, 657, 658
UCI Connector .......................... .404
10
INDEX 699