engine oil KIA AMANTI 2006 Owner's Manual

727
Maintenance
1
2
3
4
5
6
7
8
910
Changing the automatic
transaxle fluid 1. Raise and suitably support thevehicle. 2. Remove the drain plug located at
the bottom of the transaxle pan.
3. After the oil has drained complete- ly, install a new washer on the
plug, reinstall the drain plug, and
tighten to 21~24 lbin (290~340
kgcm, 29~33 Nm).
4. Lower the vehicle.
5. Remove the automatic transaxle dipstick located near the center of
the engine compartment bulkhead
and, using a funnel, add approxi-
mately 2 US quarts (2 liters) of
automatic transaxle fluid.
Use only the specified automatictransaxle fluid. (Refer to"Recommended Lubricants" later inthis section.)
✽ ✽ NOTICEDo NOT overfill the automatic
transaxle reservoir. Doing so can
cause a seal “blow out”, loss of fluid,
and damage to the transaxle. If you
overfill the reservoir, you must drain
the excess prior to driving the vehi-
cle. The transaxle will hold 2.5 US
qt. (2.5 liters) when completely
empty. However, it is likely that
there will be fluid left in the
transaxle after draining, especially if
the front of the vehicle was raised to
remove the drain plug. 6. Check the fluid level. If necessary,
add a small amount of fluid and
check the level again. Continue
this process until the level reads
within “HOT” range.
7. Replace the dipstick and properly dispose of the used transaxle fluid.
WARNING
- Lifting your
vehicle
If you raise your vehicle, always
ensure that it is supported at all
four jacking or lift points for the
vehicle. Only if this level of sup-
port is provided can you ensure
that the vehicle will remain sta-
ble and not fall off the jack
stands or other supports. If you
do not provide such support,
the vehicle may fall off the jack
stands, or other supports, caus-
ing serious injury or death.

Maintenance28
7
1
2
3
4
5
6
7
8
910
LUBRICANTS AND FLUIDS Checking the washer fluid
level The reservoir is translucent so that
you can check the level with a quick
visual inspection.
Check the fluid level in the washer
fluid reservoir and add fluid if neces-
sary. Plain water may be used if
washer fluid is not available.
However, use washer solvent with
antifreeze characteristics in cold cli-
mates to prevent freezing.
Body lubrication All moving points of the body, such
as door hinges, hood hinges, and
locks, should be lubricated each time
the engine oil is changed. Use a non-
freezing lubricant on locks during
cold weather.
Make sure the engine hood second-
ary latch keeps the hood from open-
ing when the primary latch is
released.
1GHA421A
WARNING
 Do not use radiator coolant or
antifreeze in the washer fluid
reservoir.
 Radiator coolant can severely obscure visibility when
sprayed on the windshield
and may cause loss of vehicle
control or damage to paint
and body trim.
 Windshield Washer fluid agents contain some amounts
of alcohol and can be flamma-
ble under certain circum-
stances. Do not allow sparks
or flame to contact the washer
fluid or the washer fluid reser-
voir. Damage to the vehicle or
it's occupants could occur.
 Windshield washer fluid is poisonous to humans and ani-
mals. Do not drink and avoid
contacting windshield washer
fluid. Serious injury or death
could occur.

Maintenance36
7
1
2
3
4
5
6
7
8
910
Items to be reset after the battery
has been discharged or the bat-tery has been disconnected. Driver seat position memory sys-
tem (See page 3-34)
 Power window (See page 3-15)
 Clock (See page 3-106)
 Climate control system (See pages
4-59)
 Audio (See the audio manual)
 Sunroof (See page 3-110)
✽ ✽
NOTICE• Before performing maintenance
or recharging the battery, turn off
all accessories and stop the engine.
• The negative battery cable must be removed first and installed last
when the battery is disconnected.
WARNING
- Recharging
battery
When recharging the battery,
observe the following precau-
tions:
 The battery must be removed
from the vehicle and placed in
an area with good ventilation.
 Do not allow cigarettes,
sparks, or flame near the bat-
tery.
 Watch the battery during
charging, and stop or reduce
the charging rate if the battery
cells begin gassing (boiling)
violently or if the temperature
of the electrolyte of any cell
exceeds 120°F (49°C).
 Wear eye protection when
checking the battery during
charging.
(Continued)
(Continued)
Disconnect the battery charg-
er in the following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery ter-
minal.
3. Unhook the positive clamp from the positive battery ter-
minal.

745
Maintenance
1
2
3
4
5
6
7
8
910
1. Open the hood.
2. Remove the engine compartmentshroud.
3. Remove the headlight bulb cover by turning it counterclockwise.
4. Disconnect the headlight bulb socket-connector.
5. Unsnap the headlight bulb retain- ing wire by depressing the end
and pushing it upward.
6. Remove the bulb from the head- light assembly.
WARNING
- Halogen
bulbs
 Halogen bulbs contain pres-
surized gas that will produce
flying pieces of glass if bro-
ken.
 Always handle them carefully,
and avoid scratches and abra-
sions. If the bulbs are lit, avoid
contact with liquids. Never
touch the glass with bare
hands. Residual oil may cause
the bulb to overheat and burst
when lit. A bulb should be
operated only when installed
in a headlight.
(Continued)
(Continued)
If a bulb becomes damaged or
cracked, replace it immediate-
ly and carefully dispose of it.
 Wear eye protection when
changing a bulb. Allow the
bulb to cool down before han-
dling it.
1GHA423
2GHA744

751
Maintenance
1
2
3
4
5
6
7
8
910
LUBRICANT SPECIFICATIONS Recommended lubricants To help achieve proper engine and
powertrain performance and durabil-
ity, use only lubricants of the proper
quality. The correct lubricants also
help promote engine efficiency that
results in improved fuel economy.
Engine oils labeled Energy
Conserving Oil are now available.
Along with other additional benefits,
they contribute to fuel economy by
reducing the amount of fuel neces-
sary to overcome engine friction.
Often, these improvements are diffi-
cult to measure in everyday driving,
but in a year’s time, they can offer
significant cost and energy savings.
*¹ Refer to the recommended SAE viscosity numbers on the next page.These lubricants and fluids are recommended for use in your vehicle.
Lubricant Classification
Engine oil *¹
API Service SL or above, ILSAC GF-3 or above
Automatic transaxle fluid DIAMOND ATF SP-III or SK ATF SP-III
Power steering fluid PSF-IV
Brake fluid FMVSS116 DOT-3 or DOT-4

Maintenance52
7
1
2
3
4
5
6
7
8
910
Recommended SAE viscosity
number ✽ ✽
NOTICEAlways be sure to clean the area
around any filler plug, drain plug,
or dipstick before checking or drain-
ing any lubricant. This is especially
important in dusty or sandy areas
and when the vehicle is used on
unpaved roads. Cleaning the plug
and dipstick areas will prevent dirt
and grit from entering the engine
and other mechanisms that could be
damaged. Engine oil viscosity (thickness) has
an effect on fuel economy and cold
weather operating (starting and oil
flow). Lower viscosity engine oils can
provide better fuel economy and cold
weather performance, however,
higher viscosity engine oils are
required for satisfactory lubrication in
hot weather. Using oils of any viscos-
ity other than those recommended
could result in engine damage.
When choosing an oil, consider the range of temperature your vehicle will be
operated in before the next oil change. Proceed to select the recommended
oil viscosity from the chart.
Temperature Range for SAE Viscosity Numbers
Temperature
Gasoline
Engine Oil *
1° C
( ° F)
-30 -20 -10 0 10 20 30 40 50
-10 0 20 40 60 80 100 120
1. For better fuel economy, it is recommended to use the engine oil of a viscosity grade SAE 5W-
20,5W-30 (API SL / ILSAC GF-3). However, the engine oil is not available in your country,
select the proper engine oil using the engine oil viscosity chart.
10W-30
5W-20, 5W-30

85
1
2
3
4
5
6
7
8
910
Specifications
Light Bulbs1)HID(High Intensity Discharge) type2)With sunroof
* This mark indicates the filament is not used Capacities
Light Bulb
Wattage
Headlights (High/Low) 55/55 or 35
1)
Front turn signal lights (LED type) 13.2
Position lights 5
Side mark lights 5
Front fog lights (if equipped) 55
Stop and tail lights 28/8
Rear turn signal lights 28/8*
Back-up lights 16
High mounted stop light (LED type) 2.54
License plate lights 5
Front map lamp 5 or 10
2)
Center dome lamp 10
Door courtesy lamps 5
Vanity mirror lamps 3
Trunk room lamp 5
Foot lamp 5
Glove box lamp 5
LubricantVolume Classification
Engine oil
*1
4.5 qt. (4.3 l)
API Service SL or above,
(with filter change) ILSAC GF-3 or above
Transaxle
9.0 qt. (8.5 l)DIAMOND ATF SP-III,
fluid SK ATF SP-III
Power steering 1.1 qt. (1.0 l) PSF-IV
Coolant 10.8 qt.
Ethylene glycol base for
(10.2
l) aluminum radiator
Brake fluid0.7~0.8 qt.
FMVSS116 DOT-3
(
0.7~0.8
l) or DOT-4
Fuel 18.5 gal Unleaded gasoline with
(70 l) AKI 87 or higher
*¹Refer to the recommended SAE viscosity numbers on the page 7-52.

Index4
10Economical Operation, Suggestions for . . . . . . . . . . . 5-6
Electrical
Circuit Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-4
Power socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-105
System (Specifications) . . . . . . . . . . . . . . . . . . . . . . 8-3
Electronic stability program . . . . . . . . . . . . . . . . . . . 4-29
Emergency In Case of an . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
Roadside Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 9-2
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
Emission Control System . . . . . . . . . . . . . . . . . . . . . . 5-3
Engine Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-14
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-18
Exhaust Gas Precautions . . . . . . . . . . . . . . . . . . . . . 5-3
Oil and Filter, Changing the . . . . . . . . . . . . . . . . . . 7-15
Oil and Oil Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Oil Level, Checking the . . . . . . . . . . . . . . . . . . . . . 7-15
Oil Pressure Warning . . . . . . . . . . . . . . . . . . . . . . . 4-37
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Starting the . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Exhaust Gas Precautions, Engine . . . . . . . . . . . . . . . . 5-3
Exterior Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
7-53
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2 Fan Speed Control Button . . . . . . . . . . . . . . . . . . . . . 4-58
Filler Lid, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-89
Filter
Changing the Engine Oil and . . . . . . . . . . . . . . . . . 7-15
Engine Oil and Oil . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Finish Damage Repair . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-54
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Flasher, Hazard Warning . . . . . . . . . . . . . . . . . . 4-53, 6-2
Flat Tire, If You Have a . . . . . . . . . . . . . . . . . . . . . . . 6-20
Flooded Areas, Driving in . . . . . . . . . . . . . . . . . . . . . 5-12
Fluids, Lubricants and . . . . . . . . . . . . . . . . . . . . . . . . 7-28
Fuel Filler Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-89
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
Level Warning, Low . . . . . . . . . . . . . . . . . . . . . . . 4-39
Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
Fuse/Relay Panel Description . . . . . . . . . . . . . . . . . . 6-10
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. 6-7 Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8
Gasoline Engine (unleaded) . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
Containing Acohol and Methanol . . . . . . . . . . . . . . . 5-2
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
Glove Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-100
1
2
3
4
5
6
7
8
910
E
FG

10 7
Index
Oil And Filter, Changing the Engine . . . . . . . . . . . . . . 7-15
Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
Engine and Oil Filter . . . . . . . . . . . . . . . . . . . . . . . 7-15
Filter, Engine Oil and . . . . . . . . . . . . . . . . . . . . . . . 7-15
Level, Checking the Engine . . . . . . . . . . . . . . . . . . 7-15
Pressure Warning, Engine . . . . . . . . . . . . . . . . . . . 4-37
One-Touch Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
Outside Rearview Mirrors . . . . . . . . . . . . . . . . . . . . . 3-92
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3
Overloading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
Owner Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . 7-11 Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-13
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13, 7-22
Brake and Brake Fluid Warning . . . . . . . . . . . . . . . 4-38
Power Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-105
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18, 7-24
Steering Fluid Level, Checking the . . . . . . . . . . . . 7-24
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
Pregnant Women, Restraint of . . . . . . . . . . . . . . . . . . 3-47
Proper Use and Care of the Safety Belt System . . . . . 3-47
Push-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 Rain, Driving in the . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Rear
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-67
Door Child Safety Lock . . . . . . . . . . . . . . . . . . . . . 3-12
Lap/Shoulder Belt . . . . . . . . . . . . . . . . . . . . . . . . . 3-45
Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
3-30
Window Defroster . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Rearview Mirrors Day/Night . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-94
Outside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-92
Recharging, Battery . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Recliner, Adjusting the Driver’s seatback . . . . . . . . . . . . . . . 3-22
Adjusting seatback (Front Passenger Seat) . . . . . . . 3-26
Recommended Lubricants . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51
SAE Viscosity Number . . . . . . . . . . . . . . . . . . . . . 7-52
Registering Your Vehicle in a Foreign Country . . . . . . 9-3
Relay panel description . . . . . . . . . . . . . . . . . . . . . . . 6-10
Reminder Warning Chime, Key . . . . . . . . . . . . . . . . . 4-43
Remote Keyless entry . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Reporting Safety Defects . . . . . . . . . . . . . . . . . . . . . . 9-4
Restraint Of Infants and Small Children . . . . . . . . . . . . . . . . 3-48
Of Large Children . . . . . . . . . . . . . . . . . . . . . . . . . 3-49
Of Pregnant Women . . . . . . . . . . . . . . . . . . . . . . . . 3-47
System, Child . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-50
System, Safety Belt . . . . . . . . . . . . . . . . . . . . . . . . 3-39
1
2
3
4
5
6
7
8
910
P
R