check engine KIA AMANTI 2009 Owner's Guide

Maintenance18
7AUTOMATIC TRANSAXLEChecking the automatic transaxle
fluid level The automatic transaxle fluid level
should be checked regularly.
Keep the vehicle on the level ground with
the parking brake applied and check the
fluid level according to the following pro-
cedure.
1. Place the selector lever in N (Neutral)
position and confirm the engine is run-
ning at normal idle speed.
2. After the transaxle is warmed up suffi- ciently (fluid temperature 158~176°F
(70~80°C)), for example by 10 minutes
usual driving, shift the selector lever
through all positions then place the
selector lever in N (Neutral) or P (Park)
position. 3. Confirm that the fluid level is in “HOT”
range on the level gauge. If the fluid
level is lower, add the specified fluid
from the fill hole. If the fluid level is
higher, drain the fluid from the drain
hole.
4. If the fluid level is checked in cold con- dition (fluid temperature 68~86°F
(20~30°C) add the fluid to “COLD” line
and then recheck the fluid level
according to the above step 2.
OGH057008
OVQ056002
COLD
HOT
WARNING -
Transaxle fluid
The transaxle fluid level should be
checked when the engine is at nor-
mal operating temperature. This
means that the engine, radiator,
radiator hose and exhaust system
etc., are very hot. Exercise great
care not to burn yourself during this
procedure.
WARNING
- Parking brake
To avoid sudden movement of the
vehicle, apply parking brake and
depress the brake pedal before
moving the shift lever.
CAUTION
Low fluid level causes transaxle slippage. Overfilling can causefoaming, loss of fluid and transaxle malfunction.
The use of a non-specified fluid could result in transaxle malfunc-tion and failure.

Maintenance20
7LUBRICANTS AND FLUIDS Checking the washer fluid level The reservoir is translucent so that you
can check the level with a quick visual
inspection.
Check the fluid level in the washer fluid
reservoir and add fluid if necessary. Plain
water may be used if washer fluid is not
available. However, use washer solvent
with antifreeze characteristics in cold cli-
mates to prevent freezing.
Body lubrication All moving points of the body, such as
door hinges, hood hinges, and locks,
should be lubricated each time the
engine oil is changed. Use a non-freez-
ing lubricant on locks during cold weath-
er.
Make sure the engine hood secondary
latch keeps the hood from opening when
the primary latch is released.
OGH057500
WARNING
Do not use radiator coolant or
antifreeze in the washer fluid
reservoir.
Radiator coolant can severely obscure visibility when sprayed
on the windshield and may cause
loss of vehicle control or damage
to paint and body trim.
Windshield Washer fluid agents contain some amounts of alcohol
and can be flammable under cer-
tain circumstances. Do not allow
sparks or flame to contact the
washer fluid or the washer fluid
reservoir. Damage to the vehicle
or it's occupants could occur.
Windshield washer fluid is poi- sonous to humans and animals.
Do not drink and avoid contacting
windshield washer fluid. Serious
injury or death could occur.

Maintenance28
7✽
✽
NOTICE• Before performing maintenance or
recharging the battery, turn off all
accessories and stop the engine.
• The negative battery cable must be removed first and installed last when
the battery is disconnected.
WARNING
- Recharging
battery
When recharging the battery,
observe the following precautions:
The battery must be removed
from the vehicle and placed in an
area with good ventilation.
Do not allow cigarettes, sparks, or flame near the battery.
Watch the battery during charg- ing, and stop or reduce the charg-
ing rate if the battery cells begin
gassing (boiling) violently or if
the temperature of the electrolyte
of any cell exceeds 120°F (49°C).
Wear eye protection when check- ing the battery during charging.
(Continued)
(Continued)
Disconnect the battery charger inthe following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery terminal.
3. Unhook the positive clamp from the positive battery terminal.

Maintenance42
7
1. Open the hood.
2. Remove the engine compartment
shroud.
3. Remove the headlight bulb cover by turning it counterclockwise.
4. Disconnect the headlight bulb assem- bly by turning it counterclockwise.
5. Install a new headlight bulb assembly.
6. Install the headlight bulb cover by turn- ing it clockwise.
Headlight (HID type), position and
front fog light, turn signal light
and side mark light bulb replace-
mentIf the light bulb is not operating, have the
vehicle checked by an authorized Kia
Dealer.
* HID : High Intensity Discharge
(Continued)
If a bulb becomes damaged orcracked, replace it immediately
and carefully dispose of it.
Wear eye protection when chang- ing a bulb. Allow the bulb to cool
down before handling it.
OMG075038N
WARNING
- HID Headlight
low beam (if equipped)
Do not attempt to replace or inspect
the low beam (XENON bulb) due to
electric shock danger. If the low
beam (XENON bulb) is not working,
have your vehicle checked by an
Authorized Kia Dealer.

747
Maintenance
Recommended SAE viscosity
number Engine oil viscosity (thickness) has an
effect on fuel economy and cold weather
operating (starting and oil flow). Lower
viscosity engine oils can provide better
fuel economy and cold weather perform-
ance, however, higher viscosity engine
oils are required for satisfactory lubrica-
tion in hot weather. Using oils of any vis-
cosity other than those recommended
could result in engine damage.
When choosing an oil, consider the range of temperature your vehicle will be operat-
ed in before the next oil change. Proceed to select the recommended oil viscosity
from the chart.
Temperature Range for SAE Viscosity Numbers
TemperatureGasoline
Engine Oil *
1°C
(°F)
-30 -20 -10 0 10 20 30 40 50 -10 0 20 40 60 80 100 120
1. For better fuel economy, it is recommended to use the engine oil of a viscosity grade SAE 5W-
20,5W-30 (API SL / ILSAC GF-3). However, the engine oil is not available in your country,
select the proper engine oil using the engine oil viscosity chart.
10W-30
5W-20, 5W-30
CAUTION
Always be sure to clean the areaaround any filler plug, drain plug, or dipstick before checking or drain-ing any lubricant. This is especiallyimportant in dusty or sandy areasand when the vehicle is used on unpaved roads. Cleaning the plugand dipstick areas will prevent dirt and grit from entering the engineand other mechanisms that couldbe damaged.

10
3
Index
California Perchlorate Notice ··················\
··················\
··· 7-52
Capacities ··················\
··················\
··················\
··················\
·8-3
Careof the Safety Belt System, Proper Use and ·················3-40\
Exterior ··················\
··················\
··················\
··················\
7-48
Interior ··················\
··················\
··················\
··················\
·7-51
Catalytic Converters, Operating Precautions for·············5-4
Chain Installation ··················\
··················\
··················\
·············5-11
Safety ··················\
··················\
··················\
··················\
···5-21
Tire··················\
··················\
··················\
··················\
·······5-10
Charging System Warning ··················\
··················\
·········4-32
Child Restraint System ··················\
··················\
··················\
····3-43
Safety Lock, Rear Door··················\
··················\
···········3-12
Children Restraint of Infants and Small ··················\
··················\
·3-41
Restraint of Larger··················\
··················\
··················\
·3-42
Cigarette Lighter ··················\
··················\
··················\
······3-91
Cleaner, Air ··················\
··················\
··················\
··············7-21
Cleaning Interior Window Glass·················\
··················\
··············7-51
Lap/Shoulder Belt Webbing ··················\
··················\
····7-51
Upholstery and Interior Trim··················\
··················\
···7-51
Climate Control System, Automatic ··················\
············4-46 Air Filter ··················\
··················\
··················\
················7-22
Clock ··················\
··················\
··················\
··················\
······3-95 Cluster, Instrument··················\
··················\
··················\
···4-25
Compartment, Engine··················\
··················\
·········2-4, 7-12
Consumer Assistance ··················\
··················\
··················\
·9-2
Coolant Level, Checking the ··················\
··················\
·····7-14
Cooling System, Engine ··················\
··················\
············7-14
Cruise Control System ··················\
··················\
···············4-19
Cup Holder··················\
··················\
··················\
···············3-92
Day/Night Rearview Mirror ··················\
··················\
······3-86
Defroster ··················\
··················\
··················\
··················\
4-44
Rear Window ··················\
··················\
··················\
·········4-44
Dimensions ··················\
··················\
··················\
················8-2
Disc Brake Wear Indicators ··················\
··················\
·······4-11
Dome Light ··················\
··················\
··················\
··············3-88
Door Child Safety Lock, Rear ··················\
··················\
··········3-12
Courtesy Lamp ··················\
··················\
··················\
······3-88
Locks ··················\
··················\
··················\
··················\
·····3-9
Open Display ··················\
··················\
··················\
·········4-34
Driver Position Memory System ··················\
·················3-28\
Driving at Night ··················\
··················\
··················\
··················\
··5-8
Conditions, Special ··················\
··················\
··················\
··5-7
Conditions, Hazardous ··················\
··················\
··············5-7
in Flooded Areas··················\
··················\
··················\
····5-12
in the Rain ··················\
··················\
··················\
···············5-8
Tips ··················\
··················\
··················\
··················\
········5-1C
D

Index4
10
your Vehicle ··················\
··················\
··················\
·············4-1
Winter ··················\
··················\
··················\
··················\
····5-9
with a Trailer ··················\
··················\
··················\
·········5-21
Economical Operation, Suggestions for ··················\
········5-6
Electrical Circuit Protection ··················\
··················\
··················\
····6-6
Equipment··················\
··················\
··················\
················9-4
Electronic Stability Control ··················\
··················\
·······4-22
Emergency In Case of an··················\
··················\
··················\
············6-1
Roadside Assistance ··················\
··················\
··················\
9-2
Starting··················\
··················\
··················\
··················\
···6-4
Emission Control System ··················\
··················\
············5-3
Engine Compartment ··················\
··················\
··················\
··2-4, 7-12
Cooling System ··················\
··················\
··················\
·····7-14
Exhaust Gas Precautions ··················\
··················\
···········5-3
Oil and Oil Filter ··················\
··················\
··················\
···7-13
Oil Level, Checking the ··················\
··················\
··········7-13
Oil Pressure Warning··················\
··················\
···············4-32
Starting the··················\
··················\
··················\
···············4-4
Exhaust Gas Precautions, Engine ··················\
··················\
5-3
Exterior Care··················\
··················\
··················\
············7-48 Fan Speed Control Knob ··················\
··················\
···········4-49
Filler Lid, Fuel ··················\
··················\
··················\
·········3-81
Finish
Damage Repair ··················\
··················\
··················\
······7-49
Maintenance ··················\
··················\
··················\
··········7-48
Flasher, Hazard Warning ··················\
··················\
···········4-45
Flat Tire, If You Have a ··················\
··················\
·············6-22
Flooded Areas, Driving in ··················\
··················\
·········5-12
Fluids, Lubricants and ··················\
··················\
···············7-20
Fuel Filler Lid ··················\
··················\
··················\
················3-81
Gauge ··················\
··················\
··················\
··················\
···4-27
Level Warning, Low ··················\
··················\
················4-34
Requirements ··················\
··················\
··················\
···········5-2
Fuse/Relay Panel Description··················\
··················\
······6-9
Fuses ··················\
··················\
··················\
··················\
········6-7 Driver-side Knee Bolster ··················\
··················\
·········6-11
Engine Compartment ··················\
··················\
···············6-10
Replacement ··················\
··················\
··················\
············6-7
Gasoline Engine (undleaded)··················\
··················\
··················\
··5-2
Containing Alcohol and Methanol ··················\
··············5-2E
FG

Index6
10
LabelInformation ··················\
··················\
··················\
············5-25
Tire Specification/Pressure ··················\
··················\
······5-26
Lamp, Door Courtesy ··················\
··················\
················3-88
Lap/Shoulder Belt ··················\
··················\
··················\
····3-36 Rear··················\
··················\
··················\
··················\
······3-38
Webbing, Cleaning the ··················\
··················\
············7-51
Light Bulbs (Specifications) ··················\
··················\
···············8-2
Bulb Replacement, Headlight············\
··················\
········7-41
Bulb Replacement, Interior ··················\
··················\
·····7-43
Bulb Replacement, License Plate ··················\
··············7-44
Bulb Replacement, Rear Combination ··················\
······7-44
Dome ··················\
··················\
··················\
··················\
···3-88
Interior ··················\
··················\
··················\
··················\
·3-88
Map ··················\
··················\
··················\
··················\
······3-88
Lighter, Cigarette ··················\
··················\
··················\
·····3-91
Lighting Control ··················\
··················\
··················\
······4-41
Locks, Door ··················\
··················\
··················\
···············3-9
Low Fuel Level Warning ··················\
··················\
···········4-34
Low Washer Fluid Level Warning Indicator ·················4-35\
Lubricant Specifications ··················\
··················\
············7-46
Lubricants and Fluids ··················\
··················\
················7-20
Lumbar Support ··················\
··················\
··················\
·······3-21 Main Fuse ··················\
··················\
··················\
··················\
6-9
Maintenance ··················\
··················\
··················\
···············7-1
Normal - Schedule··················\
··················\
··················\
·· 7-3
Owner ··················\
··················\
··················\
··················\
····7-9
Severe - Schedule ··················\
··················\
··················\
····7-6
Services··················\
··················\
··················\
··················\
··7-2
Malfunction Indicator ··················\
··················\
················4-34
Mirror ··················\
··················\
··················\
··················\
·····3-84 Day/Night Rearview ··················\
··················\
················3-86
Outside Rearview ··················\
··················\
··················\
··3-84
Modifications, Vehicle ··················\
··················\
·················5-3
Odometer ··················\
··················\
··················\
·················4-26\
Oil Level, Checking the Engine ··················\
··················\
····7-13
Pressure Warning, Engine ··················\
··················\
·······4-32
One-Touch Wiper··················\
··················\
··················\
·····4-43
Outside Rearview Mirror ··················\
··················\
···········3-84
Overheating··················\
··················\
··················\
················6-3
Owner Maintenance ··················\
··················\
··················\
···7-9 Precautions··················\
··················\
··················\
·············7-11L
MO