ignition KIA AMANTI 2009 Repair Manual

In case of an emergency46EMERGENCY STARTING Jump starting Jump starting can be dangerous if done
incorrectly. Therefore, to avoid harm to
yourself or damage to your vehicle or
battery, follow the jump starting proce-
dures listed on page 6-5. If in doubt, we
strongly recommend that you have a
competent technician or towing service
jump start your vehicle.✽ ✽NOTICEUse only a 12-volt jumper system. You
can damage a 12-volt starting motor,
ignition system, and other electrical
parts beyond repair by use of a 24-volt
power supply (either two 12-volt batter-
ies in series or a 24-volt motor generator
set).
WARNING
- Battery
Never attempt to check the elec-
trolyte level of the battery as this
may cause the battery to rupture or
explode causing serious injury.
WARNING
- Battery
• Keep all flames or sparks away
from the battery. The battery pro-
duces hydrogen gas which may
explode if exposed to flame or
sparks.
Do not attempt to jump start the vehicle if the discharged battery
is frozen or if the electrolyte level
is low; the battery may rupture or
explode.

67
In case of an emergency
WARNING
- Fuse replace-ment
Never replace a fuse with any-
thing but another fuse of the
same rating.
A higher capacity fuse could cause damage and possibly a
fire.
Never install a wire instead of the proper fuse - even as a temporary
repair. It may cause extensive
wiring damage and possibly a
fire.
Do not use a screwdriver or any other metal object to remove
fuses because it may cause a
short circuit and damage the sys-
tem.
This vehicle has two fuse panels, one
located in the driver's side knee bolster,
the other in the engine compartment
near the battery.
If any of your vehicle’s lights, acces-
sories, or controls do not work, check the
appropriate circuit fuse. If a fuse has
blown, the element inside the fuse will be
melted.
If the electrical system does not work,
first check the driver’s side fuse panel.
Always replace a blown fuse with one of
the same rating.
If the replacement fuse blows, this indi-
cates an electrical problem. Avoid using
the system involved and immediately
consult an Authorized Kia Dealer.
Fuse replacement
1. Turn the ignition switch and all other switches off.
2. Pull the suspected fuse straight out. Use the removal tool provided on the
main fuse box in the engine compart-
ment.
3. Check the removed fuse; replace it if it is blown.
Spare fuses are provided in the fusepanel.
4. Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
If it fits loosely, consult an Authorized Kia
Dealer.
1GHA402
Driver - side knee bolster

In case of an emergency86If you do not have a spare, use a fuse ofthe same rating from a circuit you maynot need for operating the vehicle, suchas the radio or room lamp fuse.If the headlights or other electrical com-
ponents do not work and the fuses are
OK, check the fuse block in the engine
compartment. If a fuse is blown, it must
be replaced. To check the fuse or relay in the engine
compartment, remove the engine com-
partment shroud.
1. Turn the ignition switch and all other
switches off.
2. Remove the fuse box cover by remov- ing the bolt on the cover and unhook-
ing the tab on one end and tilting the
cover back toward the other end.
3. Check the fuses. If one is blown, replace it with a new one of the same
rating.
✽ ✽NOTICEAfter checking the fuse box in the engine
compartment, securely install the fuse
box cover. If not, electrical failures may
occur from water leaking in.
1GHA403A
1GHA404
OGH056001
Engine compartment➀
➁
➀
Junction Box
➁ Main Fuse

In case of an emergency10
6
Description Fuse rating Protected component
1 FUEL PUMP 20A Fuel pump
2 H/LP (LO-LH) 15A Headlight (low-left)
3 ABS 10A Anti-lock brake system
4 IGN COIL 15A Ignition coil
5 A/CON COMP 10A Air-conditioner compressor
6 ATM 20A Automatic transaxle control relay
7 MAIN 20A Engine control unit relay
8 O2 SNSR 15A Oxygen sensor
9 EGR 15A
Power train control system sensors
10 HORN 15A Horn
11 TAIL 20A Tail light
12 SUNROOF 20A Sun roof
13 P/SEAT (RH) 20A Power seat (right)
14 FOG LP (FR) 15A Fog light (front)
15 H/LP (HI) 15A Headlight (high)
16 SPARE 30A spare fuse
17 SPARE 20A spare fuse
18 SPARE 15A spare fuse
19 SPARE 10A spare fuse
20 P/SEAT (LH) 30A Power seat (left)
21 AMP 20A Radio amplifier
22 DRL* 15A Daytime running lightEngine compartment
Description Fuse rating Protected component
23 H/LP (LO-RH) 15A Headlight (low beam-right)
24 I/P B+ 30A All electrical system
25 ECU 10A Engine control unit
26 INJECTOR 10A Injector
27 ECS * 15A Electronic control suspension
BLOWER 40A Blower motor
IGN 1 30A Ignition switch
ABS 2 30A Anti-lock brake system
ABS 1 30A Anti-lock brake system
IGN 2 30A Ignition switch
S/WARM 30A Seat warmer
H/LP (LO-LH) - Headlight relay (low beam-left)
FUEL PUMP - Fuel pump relay
HORN - Horn relay
START - Start motor relay
A/CON - Air conditioner relay
H/LP (HI) - Headlight relay (high beam)
FOG LP (FR) - Fog light relay (front)
TAIL LP - Taillight relay
WIPER - Wiper relay
BATT 60A Alternator, Battery
ALT 150A Alternator
COOLING 60A Cooling fan
* : if equipped

In case of an emergency14
6When towing your vehicle in an emer-
gency without wheel dollies :
1. Set the ignition switch in the ACC posi-
tion.
2. Place the transaxle shift lever in N (Neutral).
3. Release the parking brake.
Tie-down hook
(for flatbed towing)
Towing with a vehicle other than
a tow truck
If towing is necessary, we recommend
you to have it done by an Authorized Kia
dealer or a commercial tow truck service.
OGH046012A
Tie-down hook
WARNING
Do not use the hooks under the
front of the vehicle for towing pur-
poses. These hooks are designed
ONLY for transport tie-down. If the
tie-down hooks are used for towing,
the tie-down hooks will be damaged
and this could lead to serious
injury.
CAUTION
Failure to place the transaxle shift
lever in N (Neutral) may cause inter-nal damage to the transaxle.
OGH046012
OGH046013

In case of an emergency16
6 Use a towing strap less than 16 feet (5
m) long. Attach a white or red cloth
(about 12 inches (30 cm) wide) in the
middle of the strap for easy visibility.
Drive carefully so that the towing strap is not loosened during towing.
When your vehicle is being towed
by another vehicle other than a
tow truck (In case of an emer-
gency) Turn the ignition switch to ACC so thesteering wheel isn’t locked.
Place the transaxle shift lever in N (Neutral).
Release the parking bake.
Vehicle equipped with automatic transaxles should not exceed 28 mph
(45 km/h) and should not be towed
more than 50 miles (80 km).
Press the brake pedal with more force than normal since you will have
reduced brake performance.
More steering effort will be required because the power steering system
will be disabled.
If you are driving down a long hill, the brakes may overheat and brake per-
formance will be reduced. Stop often
and let the brakes cool off.
Tips for towing a stuck vehicleThe following methods are effective
when your vehicle is stuck in mud, sand
or similar substances that prevent the
vehicle from being driven out under its
own power.
Remove the soil and sand, etc. fromthe front and the back of the tires.
Place a stone or wood under the tires.
1GHA4107
CAUTION
To prevent internal damage to the transaxle, never tow your vehiclefrom the rear (backwards) with allfour tires in contact with the sur- face.

Maintenance26
7
(Continued)
When lifting a plastic-cased bat-
tery, excessive pressure on the
case may cause battery acid to
leak, resulting in personal injury.
Lift with a battery carrier or with
your hands on opposite corners.
Never attempt to charge the bat- tery when the battery cables are
connected.
The electrical ignition system works with high voltage. Never
touch these components with the
engine running or the ignition
switched on.
BATTERY
WARNING
- Battery dangers
Always read the following
instructions carefully when
handling a battery.
Keep lighted cigarettes and all other flames or sparks
away from the battery.
Hydrogen, which is a highly combustible gas, is always
present in battery cells and
may explode if ignited.
Keep batteries out of the reach of children because
batteries contain highly
corrosive SULFURIC ACID.
Do not allow battery acid to
contact your skin, eyes,
clothing or paint finish.
(Continued)
(Continued)If any electrolyte gets intoyour eyes, flush your eyes
with clean water for at least
15 minutes and get immedi-
ate medical attention. If
possible, continue to apply
water with a sponge or
cloth until medical attention
is received.
If electrolyte gets on your
skin, thoroughly wash the
contacted area. If you feel a
pain or a burning sensation,
get medical attention imme-
diately.
Wear eye protection whencharging or working near a
battery. Always provide
ventilation when working in
an enclosed space.
(Continued)
PROPOSITION 65 WARN-
ING
Battery posts, terminals, and relat-
ed accessories contain lead and
lead compounds, chemicals known
to the State of California to cause
cancer and reproductive harm.
Batteries also contain other chemi-
cals known to the State of California
to cause cancer. Wash hands after
handling.

741
Maintenance
BULB REPLACEMENT Use only the bulbs of the specifiedwattage.
Headlight bulb replacement ✽
✽ NOTICEAfter heavy, driving rain or washing,
headlight and taillight lenses could
appear frosty. This condition is caused by
the temperature difference between the
lamp inside and outside. This is similar
to the condensation on your windows
inside your vehicle during the rain and
doesn’t indicate a problem with your
vehicle. If the water leaks into the lamp
bulb circuitry, have the vehicle checked
by an Authorized Kia Dealer.
WARNING
- Working on
the lights
Prior to working on the light, firmly
apply the parking brake and ensure
that the ignition switch is turned to
the “LOCK” position to avoid sud-
den movement of the vehicle and
burning your fingers or receiving an
electric shock.
CAUTION
If you don’t have necessary tools,
the correct bulbs and the expertise,consult an Authorized Kia Dealer. In many cases, it is difficult to replacevehicle light bulbs because otherparts of the vehicle must beremoved before you can get the bulb. Especially if you must removethe front bumper to replace the lightbulbs in the front of the vehicle. This may result in damage to thevehicle.
OGH056016
➀ Headlight (High)
➁ Headlight (Low)
➂ Front fog light
➃ Position light
➄ Front turn signal light
\b Side mark light
WARNING
- Halogen bulbs
Halogen bulbs contain pressur-
ized gas that will produce flying
pieces of glass if broken.
Always handle them carefully, and avoid scratches and abra-
sions. If the bulbs are lit, avoid
contact with liquids. Never touch
the glass with bare hands.
Residual oil may cause the bulb
to overheat and burst when lit. A
bulb should be operated only
when installed in a headlight.
(Continued)
G270A03ON

Index2
10
Air Bags - Advanced Supplemental Restraint System ··3-52
Air Bag Curtain ··················\
··················\
··················\
··················\
·3-65
Driver's ··················\
··················\
··················\
··················\
3-57
Front Passenger's ··················\
··················\
··················\
···3-58
Side ··················\
··················\
··················\
··················\
······3-64
Warning Light ··················\
··················\
················3-73, 4-\
35
Air Cleaner··················\
··················\
··················\
···············7-21
Air Conditioning Button ··················\
··················\
··················\
··················\
··4-53
System Operation Tips ··················\
··················\
············4-54
Air Intake Control Button··················\
··················\
··········4-49
Alignment, Tire Balance and Wheel ··················\
···········7-32
Aluminum Wheel Maintenance ··················\
··················\
·7-50
Antenna ················\
··················\
··················\
··················\
···3-98
Anti-Lock Brake System ··················\
··················\
···········4-15 Warning Light ··················\
··················\
··················\
········4-31
Anti-Theft Steering Column Lock, Ignition Switch and ··················\
··················\
··················\
·4-2
Ashtray ··················\
··················\
··················\
··················\
···3-91
Audio Remote Control ··················\
··················\
··················\
·····3-99
Systems ··················\
··················\
··················\
················3-100
Automatic Climate Control System ··················\
··················\
··········4-46
Transaxle ··················\
··················\
··················\
········4-5, 7-18
Transaxle Fluid Level, Checking the ··················\
········7-18 Balance, Wheel Alignment and Tire··················\
············7-32
Battery··················\
··················\
··················\
··················\
····7-26
Recharging ··················\
··················\
··················\
·············7-27
Service, For Best ··················\
··················\
··················\
···7-27
Before Driving ··················\
··················\
··················\
···········5-5
Belts, Safety ··················\
··················\
··················\
··················\
···3-30
Pre-tensioner, seat··················\
··················\
··················\
··3-30
Blade Replacement, Windshield Wiper ··················\
·······7-24
Blades, Wiper··················\
··················\
··················\
···········7-24
Body Lubrication ··················\
··················\
··················\
·····7-20
Brake Fluid Level, Checking ··················\
··················\
·············7-16
Parking··················\
··················\
··················\
··················\
·4-13
System ··················\
··················\
··················\
··················\
·4-10
System, Anti-Lock ··················\
··················\
··················\
·4-15
Wear Indicators, Disc ··················\
··················\
··············4-11
Brakes ··················\
··················\
··················\
··················\
····7-16 Power ··················\
··················\
··················\
··················\
···4-10
Trailer ··················\
··················\
··················\
··················\
··5-21
Break-In Process, Vehicle ··················\
··················\
············1-3
Bulb Replacement··················\
··················\
··················\
····7-41
Bulbs, Light ··················\
··················\
··················\
···············8-2A
B

10
5
Index
Glove Box ··················\
··················\
··················\
················3-90
Hazard Warning Flasher ··················\
··················\
·····4-45, 6-2
Hazardous Driving conditions ··················\
··················\
·····5-7
HeadlightHigh Beam Indicator ··················\
··················\
···············4-34
Bulb Replacement ··················\
··················\
··················\
·7-41
Headrest Adjustment ··················\
··················\
········3-24, 3-26
Hitches ··················\
··················\
··················\
··················\
···5-20
Homelink Wireless Control System ··················\
············5-27
Hood··················\
··················\
··················\
··················\
·······3-80
Horn ··················\
··················\
··················\
··················\
·······4-18
How To Use This Manual··················\
··················\
············1-2
If You Have a Flat Tire ··················\
··················\
··············6-22
Ignition Switch··················\
··················\
··················\
···········4-2 and Anti-Theft Steering Column Lock ··················\
········4-2
Illumination, Instrument Panel ··················\
··················\
··4-27
Immobilizer System ··················\
··················\
··················\
···3-7
In case of an emergency while driving··················\
··········6-2
Indicators, Warnings and ··················\
··················\
···········4-32
Infants and Small Children, Restraint of ··················\
·····3-41
Inspections, Necessary··················\
··················\
·················5-5 Instrument
Cluster··················\
··················\
··················\
··················\
··4-25
Panel Illumination ··················\
··················\
··················\
·4-27
Panel Overview ··················\
··················\
··················\
·······2-3
Interior Care··················\
··················\
··················\
··················\
······7-51
Features··················\
··················\
··················\
··················\
3-91
Lights ··················\
··················\
··················\
··················\
···3-88
Overview ··················\
··················\
··················\
·················2-2
Trim, Cleaning the Upholstery and ··················\
···········7-51
Window Glass, Cleaning the ··················\
··················\
···7-51
Intermittent Wipers, Variable ··················\
··················\
·····4-42
Jacking Instructions ··················\
··················\
··················\
·6-24
Jump Starting ··················\
··················\
··················\
·············6-4
Keyless Entry, Remote ··················\
··················\
················3-4
Key Reminder Warning Chime ··················\
··················\
·4-36
Keys ··················\
··················\
··················\
··················\
·········3-2
Knowing Your Vehicle ··················\
··················\
·················3-1HI
JK