clock KIA Optima Hybrid 2012 3.G User Guide

What to do in an emergency
14
6
Do not allow anyone to remain in the
vehicle while it is on the jack.
Make sure any children present are
in a secure place away from the road
and from the vehicle to be raised with
the jack.
Removing and storing the spare
tire
Turn the tire hold-down wing bolt
counterclockwise.
Store the tire in the reverse order of
removal.
To prevent the spare tire and tools
from “rattling” while the vehicle is in
motion, store them properly.
Changing tires
1. Park on a level surface and apply the parking brake firmly.
2. Shift the shift lever into R (Reverse) for manual transaxle or
P (Park) for automatic transaxle.
3. Activate the hazard warning flash- er.
OED066033
WARNING- Runningvehicle on
jack
Do not start or run the engine of
the vehicle while the vehicle is
on the jack as this may cause
the vehicle to fall off the jack.ONF068004

615
What to do in an emergency
4. Remove the wheel lug nut wrench,jack, jack handle, and spare tire
from the vehicle.
5. Block both the front and rear of the wheel that is diagonally opposite
the jack position. To prevent vehicle movement while
changing a tire, always set the park-
ing brake fully, and always block the
wheel diagonally opposite the wheel
being changed.
We recommend that the wheels of
the vehicle be chocked, and that no
person remain in a vehicle that is
being jacked.
6. Loosen the wheel lug nuts coun-terclockwise one turn each, but do
not remove any nut until the tire
has been raised off the ground.
1JBA6504OTFH062004

What to do in an emergency
16
6
7. Place the jack at the front or rear
jacking position closest to the tire
you are changing. Place the jack
at the designated locations under
the frame. The jacking positions
are plates welded to the frame
with two tabs and a raised dot to
index with the jack. 8. Insert the jack handle into the jack
and turn it clockwise, raising the
vehicle until the tire just clears the
ground. This measurement is
approximately 30 mm (1.2 in).
Before removing the wheel lug
nuts, make sure the vehicle is sta-
ble and that there is no chance for
movement or slippage. 9. Loosen the wheel nuts and
remove them with your fingers.
Slide the wheel off the studs and
lay it flat so it cannot roll away. To
put the wheel on the hub, pick up
the spare tire, line up the holes
with the studs and slide the wheel
onto them. If this is difficult, tip the
wheel slightly and get the top hole
in the wheel lined up with the top
stud. Then jiggle the wheel back
and forth until the wheel can be
slid over the other studs.
1JBA6025OTFH062008

617
What to do in an emergency
Wheels and wheel covers may have
sharp edges. Handle them carefully
to avoid possible injury. Before put-
ting the wheel into place, be sure
that there is nothing on the hub or
wheel (such as mud, tar, gravel, etc.)
that prevents with the wheel from fit-
ting solidly against the hub.10. To install the wheel, hold it on the
studs, put the wheel nuts on the
studs and tighten them finger
tight. Jiggle the tire to be sure it is
completely seated, then tighten
the nuts as much as possible
with your fingers again.
11. Lower the vehicle to the ground by turning the wheel nut wrench
counterclockwise.
Then position the wrench as shown
in the drawing and tighten the wheel
nuts. Be sure the socket is seated
completely over the nut. Do not stand
on the wrench handle or use an
extension pipe over the wrench han-
dle.
Go around the wheel tightening
every nut following the numerical
sequence shown in the image until
they are tight. Then double-check
each nut for tightness. After changing
the wheels, have an authorized Kia
dealer tighten the wheel nuts to their
proper torque as soon as possible.
Wheel nut tightening torque:
Steel wheel & aluminium alloy wheel:
9~11 kg.m (65~79 lb.ft)
WARNING- Installing awheel
Make sure the wheel makes
good contact with the hub when
installed. If the contact of the
mounting surface between the
wheel and hub is not good, the
wheel nuts could come loose
and cause the loss of a wheel.
Loss of a wheel may result in
loss of control of the vehicle.OTF060007

725
Maintenance
Check the condition and connections of
all cooling system hoses and heater
hoses. Replace any swollen or deterio-
rated hoses.
The coolant level should be filled
between F and L marks on the side of the
coolant reservoir when the engine is
cool.
If the coolant level is low, add enough
distilled (deionized) water to provide pro-
tection against freezing and corrosion.
Bring the level to F, but do not overfill. If
frequent additions are required, see an
authorized Kia dealer for a cooling sys-
tem inspection.
(Continued)
The engine coolant level is influ-enced by hybrid system tempera-
ture. Before filling the engine
coolant and/or inverter coolant,
turn the hybrid vehicle off, fill the
engine coolant and/or inverter
coolant carefully.
Turn the engine off and wait until it cools down. Use extreme care
when removing the radiator cap.
Wrap a thick towel around it, and
turn it counterclockwise slowly to
the first stop. Step back while the
pressure is released from the
cooling system. When you are
sure all the pressure has been
released, press down on the cap,
using a thick towel, and continue
turning counterclockwise to
remove it.
Even if the engine is not operat- ing, do not remove the radiator
cap and/or inverter or the drain
plug while the engine and radia-
tor are hot. Hot coolant and
steam may still blow out under
pressure, causing serious injury.
OYFH071005N
WARNING
The electronic motor
(cooling fan) is con-
trolled by engine
coolant temperature,
refrigerant pressure and
vehicle speed. It may sometimes
operate even when the engine is
not running. Use extreme caution
when working near the blades of
the cooling fan so that you are not
injured by the rotating fan blades.
As the engine coolant temperature
decreases, the electric motor will
automatically shut off. This is a nor-
mal condition.

737
Maintenance
Battery recharging
Your vehicle has a maintenance-free,
calcium-based battery.
If the battery becomes discharged in ashort time (because, for example, the
headlights or interior lights were left on
while the vehicle was not in use),
recharge it by slow charging (trickle)
for 10 hours.
If the battery gradually discharges because of high electric load while the
vehicle is being used, recharge it at 20-
30A for two hours. When recharging the battery, observe
the following precautions:
The battery must be removed from the
vehicle and placed in an area with
good ventilation.
Watch the battery during charging, and stop or reduce the charging rate if the
battery cells begin gassing (boiling)
violently or if the temperature of the
electrolyte of any cell exceeds 49°C
(120°F).
Wear eye protection when checking the battery during charging.
Disconnect the battery charger in the following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery terminal.
3. Unhook the positive clamp from the positive battery terminal.
Before performing maintenance or recharging the battery, turn off all
accessories and stop the engine.
The negative battery cable must be removed first and installed last when
the battery is disconnected.
Reset items
Items should be reset after the battery
has been discharged or the battery has
been disconnected.
Auto down window (See section 4)
Sunroof (See section 4)
Trip computer (See section 4)
Climate control system (See section 4)
Clock (See section 4)
Audio (See section 4)

753
Maintenance
✽
✽NOTICE
• If the memory fuse is pulled up from
the fuse panel, the warning chime,
audio, clock and interior lamps, etc.,
will not operate. Some items must be
reset after replacement. Refer to
“Battery” in this section.
• Even when the memory fuse is pulled up, the battery can still be discharged
by operation of the headlights or other
electrical devices.
Engine compartment panel fuse
replacement
1. Turn the ignition switch and all other switches off.
2. Remove the fuse box cover by press- ing the tap and pulling up the cover.
3. Check the removed fuse; replace it if it is blown. To remove or insert the fuse,
use the fuse puller in the engine com-
partment fuse panel.
4. Push in a new fuse of the same rating, and make sure it fits tightly in the clips.
If it fits loosely, consult an authorized
Kia dealer.
CAUTION - Fuse panel
covers
After checking the fuse panel in theengine compartment, securely install the fuse panel cover to pre-vent electrical failures which mayoccur from water leaking in.
OTF070020

Maintenance
56
7
Inner fuse panel (Driver’s side fuse panel)
Description Fuse rating Protected component
MODULE 3 7.5A Sport Mode Switch, Natural Vacuum Leak Detection, VESS Unit
PDM 1 25A Smart Key Control Module
POWER OUTLET 15A Front Power Outlet
MODULE 5 7.5A Smart Key Control Module, Rear Seat Warmer Relay LH/RH
MODULE 2 7.5A BCM, Panorama Sunroof, Rain Sensor
TRUNK 10A I/P Junction Box (Trunk Lid Relay), Fuel Filler Door & Trunk Lid Switch, Trunk Room Lamp
CLOCK 10AA/V & Navigation Head Unit, Audio, Smart Key Control Module, Overhead Console Lamp,
Crash Pad Mood Lamp, VESS Unit,A/C Control Module, BCM, AMP,
Power Outside Mirror Switch, Driver/Passenger Door Mood Lamp
C/LIGHTER 15A Cigarette Lighter
HTD STRG 15A Steering Wheel Heater
A/CON 7.5AA/C Control Module, E/R Fuse & Relay Box (Blower Relay, Water Pump Relay),
Electronic A/C Compressor
WIPER 25A Multifunction Switch, Front Wiper Motor, E/R Fuse & Relay Box (Wiper Relay, Rain SNSR Relay)
S/HEATER FRT 20A Driver/Passenger CCS Cushion Warmer, Driver/Passenger Seat Warmer Module
E_WATER_PUMP 10A Hybrid Water Pump
HTD MIRR 10A Driver/Passenger Power Outside Mirror
MODULE 4 HEV 7.5AMCU, Hydraulic Power Unit, Low Voltage DC-DC Converter, BMS Control Module,
Active Air Flap
A/BAG IND 7.5A Instrument Cluster (Air Bag IND.)
START 7.5A Transaxle Range Switch, Hybrid Control Unit
S/HEATER RR 15A Rear Seat Warmer Relay LH/RH
P/SEAT PASS 20A Passenger Seat Manual Switch

I3
Index
Camera (Rear view) ··················\
··················\
··················\
·4-84
Capacities (Lubricants) ··················\
··················\
················8-5
Capacity/weight ··················\
··················\
··················\
·········8-2
CareExterior care ··················\
··················\
··················\
··········7-61
Interior care ··················\
··················\
··················\
···········7-66
Tire care ··················\
··················\
··················\
················7-38
Cargo weight ··················\
··················\
··················\
············5-45
Center console storage ··················\
··················\
·············4-111
Central door lock switch··················\
··················\
············4-14
Certification label ··················\
··················\
··················\
····5-43
Certification label ··················\
··················\
··················\
······8-7
Changing tires (with spare tire) ··················\
··················\
·6-13
Checking tire inflation pressure··················\
··················\
·7-39
Child restraint system ··················\
··················\
················3-27 Lower anchor system··················\
··················\
···············3-31
Seat belt ··················\
··················\
··················\
·················3-16\
Tether anchor system ··················\
··················\
···············3-30
Child-protector rear door lock ··················\
··················\
···4-15
Climate control air filter ··················\
··················\
·4-106, 7-31
Clock (Digital) ··················\
··················\
··················\
·······4-115
Clothes hanger ··················\
··················\
··················\
·······4-115
Combined instrument, see instrument cluster ···············4-47
Compact spare tire (with spare tire) ··················\
············6-19
Compact spare tire replacement ··················\
··················\
7-42
Coolant ··················\
··················\
··················\
··················\
···7-24 Cooling fluid, see engine coolant ··················\
················7-24
Crankcase emission control system ··················\
·············7-68
Cruise control system ··················\
··················\
················5-27
Cup holder ··················\
··················\
··················\
·············4-113
Curtain air bag ··················\
··················\
··················\
·········3-49
Dashboard illumination, see instrument panel
illumination··················\
··················\
··················\
············4-47
Dashboard, see instrument cluster ··················\
···············4-47
Defogging (Windshield) ··················\
··················\
··········4-108
Defogging logic (Windshield) ··················\
··················\
·4-109
Defroster (Rear window) ··················\
··················\
···········4-96
Defrosting (Windshield) ··················\
··················\
··········4-108
Digital clock··················\
··················\
··················\
···········4-115
Dimensions ··················\
··················\
··················\
················8-3
Display illumination, see instrument panel illumination··················\
··················\
··················\
············4-47
Displays, see instrument cluster ··················\
··················\
4-47
Door locks··················\
··················\
··················\
················4-12 Central door lock switch ··················\
··················\
·········4-14
Child-protector rear door lock ··················\
··················\
·4-15
Drinks holders, see cup holders··················\
·················4-11\
3
Driver's 3-point system with evergency locking retractor··················\
··················\
··················\
··················\
3-18
Driver's air bag··················\
··················\
··················\
·········3-45
Driving at night ··················\
··················\
··················\
········5-34
C
D

I5
Index
GaugeEngine temperature gauge ··················\
··················\
·······4-50
Fuel gauge ··················\
··················\
··················\
·············4-49
Glass antenna ··················\
··················\
··················\
·········4-117
Glove box··················\
··················\
··················\
···············4-111
Hazard warning flasher ··················\
··················\
··············4-80
Hazardous driving conditions ··················\
··················\
··· 5-33
Headrest ··················\
··················\
··················\
············3-8, 3-13
HEV powertrain ··················\
··················\
··················\
·········1-5
Highway driving ··················\
··················\
··················\
······5-36
Homelink mirror, see the Electric chromic mirror (ECM) with homeLink system ··················\
··················\
············4-37
Hood··················\
··················\
··················\
··················\
·······4-24
Horn ··················\
··················\
··················\
··················\
·······4-35
How to use this manual ··················\
··················\
···············1-2
Hybrid Kia Hybrid system ··················\
··················\
··················\
···H2
State of charge (SOC) ··················\
··················\
················H3
Optima hev energy flow ··················\
··················\
···H4, 4-53
The componets of hybrid vehicle ··················\
················H8
The air intake of hybrid battery ··················\
·················H13
The READY indicator ··················\
··················\
·············4-52
The ECO level display mode ··················\
··················\
·····H2 The EV MODE··················\
··················\
··················\
······4-62
The service indicator ··················\
··················\
···············4-62
The ECO GUIDE ··················\
··················\
··················\
··4-51
Indicator symbols on the instrument cluster ··················\
·1-6
Indicators and warnings ··················\
··················\
·············4-61
Inside rearview mirror ··················\
··················\
···············4-37
Instrument cluster ··················\
··················\
··················\
····4-47 Engine temperature gauge ··················\
··················\
·······4-50
Fuel gauge ··················\
··················\
··················\
·············4-49
Instrument panel illumination ··················\
··················\
·4-48
Odometer ··················\
··················\
··················\
···············4-48
Speedometer ··················\
··················\
··················\
··········4-48
Trip computer ··················\
··················\
··················\
········4-52
Warning and indicators ··················\
··················\
············4-61
Instrument panel fuse··················\
··················\
·················7-52\
Instrument panel illumination··················\
··················\
····4-48
Instrument panel overview··················\
··················\
···········2-3
Interior care··················\
··················\
··················\
··············7-66
Interior features··················\
··················\
··················\
······4-113 Aux, USB and iPod port··················\
··················\
········4-119
Clothes hanger ··················\
··················\
··················\
·····4-115
Cup holder ··················\
··················\
··················\
···········4-113
Digital clock ··················\
··················\
··················\
········4-115
Floor mat anchor(s) ··················\
··················\
···············4-116
Power outlet ··················\
··················\
··················\
········ 4-114
Sunvisor ··················\
··················\
··················\
···············4-113
I
G
H