steering wheel KIA OPTIMA PHEV 2019 Service Manual

817
Maintenance
Exhaust pipe and muffler
Visually inspect the exhaust pipes,
muffler and hangers for cracks, dete-
rioration, or damage. Start the
engine and listen carefully for any
exhaust gas leakage. Tighten con-
nections or replace parts as neces-
sary.
Suspension mounting bolts
Check the suspension connections
for looseness or damage. Retighten
to the specified torque.
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine
off, check for excessive free-play in
the steering wheel.
Check the linkage for bends or dam-
age. Check the dust boots and ball
joints for deterioration, cracks, or
damage. Replace any damaged
parts.
Drive shafts and boots
Check the drive shafts, boots and
clamps for cracks, deterioration, or
damage. Replace any damaged
parts and, if necessary, repack the
grease.
Air conditioning refrigerant
Check the air conditioning lines and
connections for leakage and dam-
age.When checking engine oil, engine
coolant, brake fluid, and washer fluid,
always be sure to clean the area
around any filler plug, drain plug, or
dipstick before checking or draining
any lubricant or fluid. This is espe-
cially important in dusty or sandy
areas and when the vehicle is used
on unpaved roads. Cleaning the plug
and dipstick areas will prevent dirt
and grit from entering the engine and
other mechanisms that could be
damaged.
CHECKING FLUID LEVELS

Maintenance
62
8
Fuse NameFuse ratingCircuit Protected
MDPS10AMDPS Unit (Column/Rack)
IG125APCB Block (Fuse - OPCU2/ELECTRICAL WATER PUMP/TCU2/ACTIVE HYDRAULIC BOOTER 3/HEV
ECU2/ECU3)
MODULE 910ASmart Key Control Module
WASHER15AMultifunction Switch (Wiper Low & Washer Switch)
MODULE 810ADriver/Passenger Door Module
CLUSTER10AInstrument Cluster
MULTI MEDIA15AAudio, A/V & Navigation Head Unit, Keyboard
HTD STRG15ABCM (Steering Wheel Heated)
MODULE 110AConsole Switch, Active Air Flap Unit, Gateway, Driver/Passenger Door Module
DR LOCK20ADoor Lock Relay, Door Unlock Relay, ICM Relay Box (Dead Lock Relay)
MEMORY 210ASiren Control Module, Ultrasonic Instrusion Protection Sensor
SMART KEY15ASmart Key Control Module

893
Maintenance
Keep paint and trim in good con-
dition
Scratches or chips in the finish
should be covered with "touch-up"
paint as soon as possible to reduce
the possibility of corrosion. If bare
metal is showing through, the atten-
tion of a qualified body and paint
shop is recommended.
Bird droppings : Bird droppings are
highly corrosive and may damage
painted surfaces in just a few hours.
Always remove bird droppings as
soon as possible.
Don't neglect the interior
Moisture can collect under the floor
mats and carpeting and cause corro-
sion. Check under the mats periodi-
cally to be sure the carpeting is dry.
Use particular care if you carry fertil-
izers, cleaning materials or chemi-
cals in the vehicle.
These should be carried only in prop-
er containers and any spills or leaks
should be cleaned up, flushed with
clean water and thoroughly dried.Interior care
Interior general precautions
Prevent chemicals such as perfume,
cosmetic oil, sun cream, hand clean-
er, and air freshener from contacting
the interior parts because they may
cause damage or discoloration. If
they do contact the interior parts,
wipe them off immediately. If neces-
sary, use a vinyl cleaner, see product
instructions for correct usage.
CAUTION - Electrical
components
Never allow water or other liq-uids to come in contact withelectrical/electronic compo-nents inside the vehicle as thismay damage them.
CAUTION - Leather
When cleaning leather products(steering wheel, seats etc.), useneutral detergents or low alco-hol content solutions. If you usehigh alcohol content solutionsor acid/alkaline detergents, thecolor of the leather may fade orthe surface may get stripped off.

I9
Index
Smart trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18\
Detecting area. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-21
Emergency trunk safety release . . . . . . . . . . . . . . . . 4-22
How to deactivate the Smart Trunk function using the smart key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-20
How to use the Smart Trunk . . . . . . . . . . . . . . . . . . 4-18
Special driving conditions . . . . . . . . . . . . . . . . . . . . . 6-104 Driving at night . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-105
Driving in flooded areas. . . . . . . . . . . . . . . . . . . . . 6-107
Driving in the rain . . . . . . . . . . . . . . . . . . . . . . . . . 6-106
Driving off-road . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-107
Hazardous driving conditions . . . . . . . . . . . . . . . . 6-104
Highway driving . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-107
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . 6-104
Smooth cornering . . . . . . . . . . . . . . . . . . . . . . . . . . 6-105
Starting the hybrid/plug-in hybrid vehicle (smart key). . H32
Steering wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43 Electric Power Steering (EPS) . . . . . . . . . . . . . . . . . 4-43
Heated steering wheel . . . . . . . . . . . . . . . . . . . . . . . 4-45
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-46
Tilt and telescopic steering. . . . . . . . . . . . . . . . . . . . 4-44
Storage compartments . . . . . . . . . . . . . . . . . . . . . . . . 4-137 Center console storage . . . . . . . . . . . . . . . . . . . . . . 4-137
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-138 Theft-alarm system . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Armed stage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Disarmed stage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Theft-alarm stage . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Tire Pressure Monitoring System (TPMS) . . . . . . . . . . . 7-9 Changing a tire with TPMS . . . . . . . . . . . . . . . . . . . 7-13
Check tire pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-9
Low tire pressure position telltale . . . . . . . . . . . . . . 7-11
Tire specification and pressure label . . . . . . . . . . . . . . . 9-9
Tires and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-4
Tires and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-39 All season tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-51
Checking tire inflation pressure . . . . . . . . . . . . . . . . 8-40
Low aspect ratio tire. . . . . . . . . . . . . . . . . . . . . . . . . 8-53
Radial-ply tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-52
Recommended cold tire inflation pressures . . . . . . . 8-39
Snow tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-51
Summer tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-51
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-39
Tire chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-52
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-44
Tire pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-40
Tire replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-43
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-41
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . 8-44T