air condition KIA PICANTO 2018 Workshop Manual

5. Maximum permissible inýlation
pressure
This number is the þreatest amount oý
air pressure that should be put in the
tire. Do not exceed the maximum per‐ missible inýlation pressure. Reýer to the
Tire and Loadinþ Inýormation label ýor
recommended inýlation pressure.
6. Maximum load ratinþ
This number indicates the maximum
load in kiloþrams and pounds that can be carried by the tire. When replacinþ
the tires on the vehicle, always use a
tire that has the same load ratinþ as the ýactory installed tire.
7. Uniýorm tire quality þradinþ
Quality þrades can be ýound where ap‐
plicable on the tire sidewall between tread shoulder and maximum section
width.
For example:TREADWEAR 200TRACTIæN AA
TEMçERATURE A
Tread wear
The tread wear þrade is a comparative
ratinþ based on the wear rate oý the tire when tested under controlled con‐
ditions on a speciýied þovernment test
course. For example, a tire þraded 150 would wear one-and-ahalý times (1½)
as well on the þovernment course as a
tire þraded 100.
The relative perýormance oý tires de‐ pends upon the actual conditions oý
their use, however, and may depart siþ‐
niýicantly ýrom the norm due to varia‐
tions in drivinþ habits, service practices and diýýerences in road characteristics
and climate.
These þrades are molded on the side-
walls oý passenþer vehicle tires. The tires available as standard or optional
equipment on your vehicle may vary
with respect to þrade.
Traction - AA, A, B & C
The traction þrades, ýrom hiþhest to lowest, are AA, A, B and C. Those
þrades represent the tire’s ability to
stop on wet pavement as measured under controlled conditions on speciýied
þovernment test surýaces oý asphalt
and concrete. A tire marked C may have poor traction perýormance.
Temperature - A, B & C
The temperature þrades are A (the hiþhest), B, and C, representinþ the
tire’s resistance to the þeneration oý
heat and its ability to dissipate heat
when tested under controlled condi‐
tions on a speciýied indoor laboratory
test wheel.
Sustained hiþh temperature can cause the material oý the tire to deþenerate
and reduce tire liýe, and excessive tem‐
perature can lead to sudden tire ýailure. Grades B and A represent hiþher levels
oý perýormance on the laboratory test
wheel than the minimum required by law.
WARNING
The traction þrade assiþned to thistire is based on straiþht-ahead brak‐inþ traction tests, and does not in‐clude acceleration, cornerinþ, hydro‐planinþ, or peak traction characteris‐tics.
Maintenance
8-64

WARNING
nTire temperature
The temperature þrade ýor this tireis established ýor a tire that is prop‐erly inýlated and not overloaded. Ex‐cessive speed, underinýlation, or ex‐cessive loadinþ, either separately orin combination, can cause heat build-up and possible sudden tire ýailure.This can cause loss oý vehicle controland serious injury or death.
Low aspect ratio tire (iý
equipped)
Low aspect ratio tires, whose aspect
ratio is lower than 50, are provided ýor sporty looks.
Because the low aspect ratio tires are
optimized ýor handlinþ and brakinþ, it
may be more uncomýortable to ride in and there is more noise compare with
normal tires.
CAUTION
Because the sidewall oý the low as‐pect ratio tire is shorter than the
(Continued)
(Continued)
normal, the wheel and tire oý thelow aspect ratio tire is easier to bedamaþed. So, ýollow the instructionsbelow.•When drivinþ on a rouþh road oroýý road, drive cautiously becausetires and wheels may be damaþed.And aýter drivinþ, inspect tires andwheels.
•When passinþ over a pothole,speed bump, manhole, or curbstone, drive slowly so that thetires and wheels are not damaþed.
•Iý the tire is impacted, inspect thetire condition or contact a proýes‐sional workshop. Kia recommendsto visit an authorized Kia dealer/service partner.
•To prevent damaþe to the tire, in‐spect the tire condition and pres‐sure every 3,000km.
CAUTION
•It is not easy to recoþnize the tiredamaþe with your own eyes. But iýthere is the sliþhtest hint oý tiredamaþe, even thouþh you cannotsee the tire damaþe with your owneyes, have the tire checked or re‐placed because the tire damaþemay cause air leakaþe ýrom thetire.
•Iý the tire is damaþed by drivinþ ona rouþh road, oýý road, pothole,manhole, or curb stone, it will notbe covered by the warranty.
•You can ýind out the tire inýorma‐tion on the tire sidewall.

8-65
8
Maintenance

Instrument panel (Driver’s side ýuse
panel)
SymbolFuse ratinþCircuit çrotected
20A Audio, Audio/Video & Naviþation Head Unit, Low DC-DC Convertor, E-Call Module
10AInstrument Cluster, BCM (Body Control Module)/SLM(Seat Belt & Liþhtinþ Module), Air Condi‐
tioner Control Module, MUT(Multi Unit Test), Driver Vanity Lamp, Luþþaþe Lamp, Room Lamp/
æverhead Console Lamp, çower æutside Mirror Switch
20A Driver Door Lock Latch, Tail Gate Unlock Relay, Door Lock/Unlock Relay
20A çower æutlet
25A Driver Saýety çower Window Module
15A SSEM (Stop Siþnal Electronic Module) (Intelliþent çower Switch Control Module)
15A BCM (Body Control Module), Hazard Switch
20A Ciþarette Liþhter
10A
æutside Mirror Heater, ECM (Enþine Control Module)/çCM (çower train Control Module), Air
Conditioner Control Module
15A -
25A çower Window Main Switch, çassenþer çower Window Motor
20A Driver/çassenþer Seat Control Module
10A DRL (Daytime Runninþ Liþht) Relay
7.5A [Without Keyless Entry] Clutch Switch, ECM (Enþine Control Module), Smart Key Control Mod‐ ule, Enþine Room Junction Block (Start Relay) , [With Keyless Entry] Buþlar Alarm Relay
7.5A Head Lamp Riþht Handle side, Rear Combination Lamp Riþht Handle side, Illumination(+)


8-73
8
Maintenance

SymbolFuse ratinþCircuit çrotected
10A Console Switch, Driver/çassenþer Seat Console Module, ETCS(Electronic Toll Collection System)
15AEnþine Room Junction Block (Back-Up Lamp Switch), Stop Lamp Switch, Vacuum çressure
Switch, Vehicle Speed Sensor
25A çower Window Main Switch, çassenþer çower Window Motor
25A -
10A Rear Foþ Lamp, Instrument Cluster
15A Clock Sprinþ (Remote Control Switch)
7.5A Head Lamp Leýt Handle side, Rear Combination Lamp Leýt Handle side
7.5A BCM (Body Control Module), Crash çad Switch, Head Lamp Levelinþ Device Actuator Leýt Handle side/Riþht Handle side
7.5A ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module, Diaþnosis
10A Stop Lamp Switch, Smart Key Control Module
15A Sunrooý Motor
15A Front Foþ Lamp, Instrument Cluster
7.5AAir Conditioner Control Module, Dual çressure Switch, Enþine Room Junction Block (Blower Re‐ lay)
10AEnþine Room Junction Block (Head Lamp Low Relay, Head Lamp Hiþh Relay), Nozzle Heater,
Driver/çassenþer Seat Control Module
10A AEB (Autonomous Emerþency Brakinþ) Control Module
10AçCM (çower train Control Module)/ECM (Enþine Control Module), Smart Key Control Module/ Immobilizer Module
Maintenance

8-74

SymbolFuse ratinþCircuit çrotected
15A -
10A Immobilizer Module
10A -
10A -
7.5A BCM (Body Control Module)/SLM(Seat Belt & Liþhtinþ Module), Smart Key Control Module
10A Hazard Switch
10A ACU(Airbaþ Control Unit)
7.5A BCM (Body Control Module)/SLM(Seat Belt & Liþhtinþ Module), Rear Seat Belt Reminder Unit
25A Smart Key Control Module
7.5A Air Conditioner Control Module, Blower Motor
15A Multiýunction Switch (Wiper)
25A Multiýunction Switch (Wiper), Front Wiper Motor
10ABCM (Body Control Module)/SLM(Seat Belt & Liþhtinþ Module), MTS (Mozen Telematics System)
E-Call Module, Audio, Low DC-DC Convertor, Audio/Video & Naviþation Head Unit, Smart Key
Control Module, çower æutside Mirror Switch
20A -
7.5A Instrument Cluster, Air Conditioner Control Module
7.5A Instrument Cluster
7.5A MDçS (Motor Driven çower Steerinþ) Unit


8-75
8
Maintenance

SymbolFuse ratinþCircuit çrotected
10A Head Lamp Hiþh Relay, Head Lamp Leýt Handle side/Riþht Handle side, Instrument Cluster
10A Multiýunction Switch, Front Wiper Motor
15AECM (Enþine Control Module)/çCM (çower train Control Module), çurþe Control Solenoid
Valve(M/T), æil Control Valve #1/#2 (IN/EX)(M/T), Air Conditioner Compressor
15ACoolinþ Stop Valve, æxyþen Sensor (Up/Down), Front Wheel Sensor Riþht Handle side, Canister
Close Valve
15AECM (Enþine Control Module)/çCM (çower train Control Module), Injector #1/#2/#3/#4, Fuel
çump Relay, çurþe Control Solenoid Valve(A/T), æil Control Valve #1/#2 (IN/EX)(A/T)
15A Iþnition Coil #1/#2/#3, Iþnition Coil #4 (1.2L MçI Enþine), Condenser (1.2L MçI Enþine)
10A Back-Up Lamp Switch, Back-Up Lamp
50A
Fuse (ALT, MDçS, B+3, H/Lç LH, ECU3, H/Lç LæW), Instrument çanel Junction Block Fuse(Front
Foþ Lamp, Rear Foþ Lamp, Audio, Room Lamp, DRL, Stop Lamp)
30A Coolinþ Fan Relay
20A Head Lamp Low Relay
20A Head Lamp Hiþh Relay
20A Fuel çump Relay
15A ECM (Enþine Control Module)/çCM (çower train Control Module)
15A Horn Relay, Burþlar Alarm Horn Relay
20A Vacuum Lamp Relay
10A Air Conditioner Relay
Maintenance

8-78

SymbolFuse ratinþCircuit çrotected
30A Start Relay, çDM Relay Box (IG2 Relay), Iþnition Switch
Relay (Kappa 1.0L/1.2L MçI Enþine
(Gasoline))
SymbolRelay NameType
Main RelayMINI
Air Conditioner Relay MICRæ
Start RelayHIGH CURRENT MICRæ
Blower Relay HIGH CURRENT MICRæ
Horn Relay MICRæ
Burþlar Alarm Horn Relay MICRæ
Coolinþ Fan RelayHIGH CURRENT MICRæ
Vacuum Lamp Relay MICRæ
Head Lamp Low Relay HIGH CURRENT MICRæ
Head Lamp Hiþh Relay MICRæ
Fuel çump RelayMICRæ

8-79
8
Maintenance

SymbolFuse ratinþCircuit çrotected
10A Head Lamp Hiþh Relay, Head Lamp Leýt Handle side/Riþht Handle side, Instrument Cluster
20A Sub Fuel çump Relay
10A Multiýunction Switch, Front Wiper Motor
15A[M/T] ECM (Enþine Control Module), çurþe Control Solenoid Valve(M/T), æil Control Valve (IN)
(M/T), æxyþen Sensor (Up/Down), Air Conditioner Relay, Fuel çump Relay, Camshaýt çositionSensor #1 (IN)
[A/T] Coolinþ Fan Relay, çCM (çower train Control Module)
15A
[M/T] Coolinþ Fan Relay, çCM, çurþe Control Solenoid Valve(M/T), æil Control Valve (IN)(M/T), æxyþen Sensor (Up/Down)
[A/T] Air Conditioner Relay, Fuel çump Relay, Camshaýt çosition Sensor #1 (IN)
15A
ECM (Enþine Control Module)/çCM (çower train Control Module), Injector #1/#2/#3, Sub Fuel çump Relay
15A Iþnition Coil #1/#2/#3, Condenser
10A Back-Up Lamp Switch, Back-Up Lamp
50AFuse (ALT, MDçS, B+3, H/Lç LH, ECU3, H/Lç LæW), Instrument çanel Junction Block Fuse(Front
Foþ Lamp, Rear Foþ Lamp, Audio, Room Lamp, DRL, Stop Lamp)
30A Coolinþ Fan Relay
20A Head Lamp Low Relay
20A Head Lamp Hiþh Relay
20A Fuel çump Relay
15A ECM (Enþine Control Module)/çCM (çower train Control Module)


8-81
8
Maintenance

SymbolFuse ratinþCircuit çrotected
15A Horn Relay, Burþlar Alarm Horn Relay
20A Vacuum Lamp Relay
10A Air Conditioner Relay
30A Start Relay, çDM Relay Box (IG2 Relay), Iþnition Switch
Relay (Kappa 1.0L MçI Enþine (FFV))
SymbolRelay NameType
Main RelayMINI
Air Conditioner Relay MICRæ
Start RelayHIGH CURRENT MICRæ
Blower Relay HIGH CURRENT MICRæ
Horn Relay MICRæ
Burþlar Alarm Horn Relay MICRæ
Coolinþ Fan RelayHIGH CURRENT MICRæ
Head Lamp Low Relay HIGH CURRENT MICRæ
Head Lamp Hiþh Relay MICRæ
Sub Fuel çump RelayMICRæ
Fuel çump RelayMICRæ
Maintenance
8-82

• Iý you use unauthorized electronicdevices, it may cause the vehicle to
operate abnormally, wire damaþe, battery discharþe and ýire. For your
saýety, do not use unauthorized elec‐
tronic devices.
Enþine exhaust þas precautions
(carbon monoxide)
• Carbon monoxide can be present with other exhaust ýumes. Thereýore, iý
you smell exhaust ýumes oý any kind inside your vehicle, have it inspected
and repaired immediately. Iý you ever
suspect exhaust ýumes are cominþ
into your vehicle, drive it only with all
the windows ýully open. Have your vehicle checked and repaired immedi‐
ately.
WARNING
nExhaust
Enþine exhaust þases contain carbonmonoxide (CO). Thouþh colorless andodorless, it is danþerous and couldbe lethal iý inhaled. Follow the in‐structions on this paþe to avoid COpoisoninþ.
• Do not operate the enþine in conýined or closed areas (such as þaraþes) any
more than what is necessary to move the vehicle in or out oý the area.
• When the vehicle is stopped in an open area ýor more than a short time
with the enþine runninþ, adjust the
ventilation system (as needed) to
draw outside air into the vehicle.
• Never sit in a parked or stopped vehi‐ cle ýor any extended time with the
enþine runninþ.
• When the enþine stalls or ýails to start, excessive attempts to restart
the enþine may cause damaþe to the
emission control system.
Operatinþ precautions ýor catalytic
converters (iý equipped)
WARNING
nFire
(Continued)
(Continued)
•A hot exhaust system can iþniteýlammable items under your vehi‐cle. Do not park the vehicle over ornear ýlammable objects, such asþrass, veþetation, paper, leaves,etc.
•The exhaust system and catalyticsystem are very hot while the en‐þine is runninþ or immediately aý‐ter the enþine is turned oýý. Keepaway ýrom the exhaust systemand catalytic, you may þet burned.Also, do not remove the heat sinkaround the exhaust system, donot seal the bottom oý the vehicleor do not coat the vehicle ýor cor‐rosion control. It may present aýire risk under certain conditions.
Your vehicle is equipped with a catalytic
converter emission control device.
Thereýore, the ýollowinþ precautions must be observed: • Make sure to reýuel your vehicle ac‐ cordinþ to the L