steering KIA QUORIS 2013 Manual PDF

723
Maintenance
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine
off, check for excessive free-play in
the steering wheel.
Check the linkage for bends or dam-
age. Check the dust boots and ball
joints for deterioration, cracks, or
damage. Replace any damaged
parts.
Power steering pump, belt and hoses
Check the power steering pump and
hoses for leakage and damage.
Replace any damaged or leaking
parts immediately. Inspect the power
steering belt (or drive belt) for evi-
dence of cuts, cracks, excessive
wear, oiliness and proper tension.
Replace or adjust it if necessary.Drive shafts and boots
Check the drive shafts, boots and
clamps for cracks, deterioration, or
damage. Replace any damaged
parts and, if necessary, repack the
grease.
Air conditioning refrigerant (if equipped)
Check the air conditioning lines and
connections for leakage and dam-
age.

Maintenance
30
7
POWER STEERING FLUID
Checking the power steering
fluid level
With the vehicle on level ground,
check the fluid level in the power
steering reservoir periodically. The
fluid should be between MAX and
MIN marks on the side of the gauge
at the normal temperature.
Before adding power steering fluid, thoroughly clean the area around the
reservoir cap to prevent power steer-ing fluid contamination.
If the level is low, add fluid to the
MAX level.
✽✽ NOTICE
Check that the fluid level is in the
"HOT" range on the gauge. If the
fluid is cold, check that it is in the
"COLD" range.
In the event the power steering sys- tem requires frequent additions of
fluid, we recommend that the system
be inspected by an authorized Kia
dealer.
Use only the specified power steer- ing fluid. (Refer to "Recommendedlubricants or capacities" in section8.)
Checking the power steering hose
Check the connections for oil leaks,
damage and twists in the power
steering hose before driving.OBH078022
CAUTION
To avoid damage to the power steering pump, do not operatethe vehicle for prolonged peri- ods with a low power steeringfluid level.
Never start the engine when the reservoir tank is empty.
When adding fluid, be careful that dirt does not get into thetank.
Too little fluid can result in increased steering effortand/or noise from the powersteering system.
(Continued)
(Continued) The use of the non-specified fluid could reduce the effective-ness of the power steering sys-tem and cause damage to it.

747
Maintenance
Tire replacement
If the tire is worn evenly, a tread wear indicator will appear as a solid band
across the tread. This shows there isless than 1.6 mm (1/16 inch) of tread
left on the tire. Replace the tire when
this happens.
Do not wait for the band to appear
across the entire tread before replac-
ing the tire.
OEN076053
Tread wear indicator
WARNING - Replacing
tires
To reduce the chance of serious
or fatal injuries from an acci-
dent caused by tire failure or
loss of vehicle control:
Replace tires that are worn, show uneven wear, or are
damaged. Worn tires can
cause loss of braking effec-
tiveness, steering control, andtraction.
Do not drive your vehicle with too little or too much pressure
in your tires. This can lead to
uneven wear and tire failure.
When replacing tires, never mix radial and bias-ply tires
on the same car. You must
replace all tires (including the
spare) if moving from radial to
bias-ply tires.
(Continued)(Continued)
Using tires and wheels otherthan the recommended sizes
could cause unusual handling
characteristics and poor vehi-
cle control, resulting in a seri-ous accident.
Wheels that do not meet Kia’s specifications may fit poorly
and result in damage to the
vehicle or unusual handling
and poor vehicle control.
The ABS works by comparing the speed of the wheels. The
tire size affects wheel speed.
When replacing tires, all 4
tires must use the same size
originally supplied with the
vehicle. Using tires of a differ-
ent size can cause the
ABS(Anti-lock Brake System)
and ESP(Electronic Stability
Program) to work irregularly.

759
Maintenance
Fuse NameSymbolFuse rastingCircuit Protected
AUDIO 210AA/V & Navigation Head Unit
MODULE 310A
A/C Control Module, Electro Chromic Mirror, Rear Seat Console Switch, Driver Haptic Control
Module, Rear CCS Control Module LH/RH, Driver/Passenger IMS Control Module,
Driver Power Seat Module, Rear Seat Warmer Control Module LH/RH,
Rear Smart Junction Box (IPS Control Module)
MODULE 210ASteering Tile & Telescopic Module, LDWS Camera Module, Crash Pad Switch, Stop Lamp Switch,
A/T Console Switch, Electric Parking Brake Switch, Console Switch, Smart Cruse Control Radar
SPARE10ASpare
WIPER10AAuto Light & Rain Sensor
MODULE 110ABCM, Trunk Lid Main Switch, Low Panel Switch
MEMORY 210AExternal Buzzer, Driver Smart Connector, Passenger Smart Connector
DRV HEAT15ADriver Haptic Control Module, Driver CCS Module
PASS HEAT15APassenger CCS Module
WINDOW LH30ARear Power Window Module LH, Rear Power Window Module RH
HEADREST15AActive Headrest Sensor
BCM10ABCM, Multifunction Switch, Driver/Passenger Power Seat Switch, Driver/Passenger Power Seat Switch, Rear Door Module LH/RH
EPB 115AElectric Parking Brake Module
P/HANDLE15ASteering Tilt & Telescopic Module

Maintenance
64
7
Fuse NameSymbolFuse rastingCircuit Protected
Stop Lamp15AStop Signal Electronic Module
Brake SW10AStop Lamp Switch, Smart Key Control Module
AAF10ANot Used
Injector15ANot Used
SMK (IGN1)40AE/R Fuse & Relay Box LH (RLY.5)
ESP 140AESP Control Module
ALT200AE/R Fuse & Relay Box LH (Fuse : F9, F15, F16, F18, F19), Alternator
Cooling70AE/R Fuse & Relay Box LH (RLY.6)
SMK (IGN2)30AE/R Fuse & Relay Box LH (RLY.3)
ESP 240AESP Control Module
Diagnosis25AMultipurpose Check Connector
H/Lamp Washer25AE/R Fuse & Relay Box LH (RLY.7)
Battery 340ASmart Junction Box (Fuse : F5, F6, F8, F9, F10)
SMK (ACC)40AE/R Fuse & Relay Box LH (RLY.9)
TCU10AECM, Transmission Range Switch, Transmission Park Postilion Sensor & Switch
ESP 310ASteering Angle Sensor, ESP Control Module
B/UP Lamp 110AE/R Fuse & Relay Box LH (RLY.4)

783
Maintenance
Keep paint and trim in good con- dition
Scratches or chips in the finish
should be covered with "touch-up"
paint as soon as possible to reduce
the possibility of corrosion. If bare
metal is showing through, the atten-tion of a qualified body and paintshop is recommended.
Bird droppings : Bird droppings are
highly corrosive and may damage
painted surfaces in just a few hours.
Always remove bird droppings as
soon as possible. Don't neglect the interior Moisture can collect under the floor
mats and carpeting to cause corro-
sion. Check under the mats periodi-
cally to be sure the carpeting is dry.
Use particular care if you carry fertil-
izers, cleaning materials or chemi-
cals in the car.
These should be carried only in
proper containers and any spills or
leaks should be cleaned up, flushed
with clean water and thoroughly
dried.Interior care
Interior general precautions
Prevent chemicals such as perfume, cosmetic oil, sun cream, hand cleanerand air freshener from contacting the
interior parts because they may
cause damage or discoloration. If they
do contact the interior parts, wipe
them off immediately. If necessary,
use a vinyle cleaner, see instructions
for corrrect usage.
CAUTION
Never allow water or other liq-
uids to come in contact withelectrical/electronic compo- nents inside the vehicle as thismay damage them.
CAUTION
When cleaning leather products(steering wheel, seats etc.), useneutral detergents or low alco- hol content solutions. If you usehigh alcohol content solutionsor acid/alkaline detergents, thecolor of the leather may fade or the surface may get stripped off.

Specifications & Consumer information
6
8
RECOMMENDED LUBRICANTS AND CAPACITIES
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
These lubricants and fluids are recommended for use in your vehicle.
Lubricant Volume Classification
Engine oil * 1
*2
(drain and refill) Recommends Gasoline Engine
Lambda II 3.8 5.7
l(6.02 US qt.) API Service SM *
3
,
ILSAC GF-4 or above ACEA A5 (or above)
Engine oil consumption Normal driving condition MAX. 1L / 1,500 km -
Severe driving condition MAX. 1L / 1,000 km -
Automatic transaxle fluid Gasoline Engine
Lambda II 3.8 9.6
l(10.14 US qt.) GS ATF SP-IV-RR,
Kia genuine ATF SP-IV-RR
Power steering fluid With EHPS 0.9
l(0.95 US qt.)
Pentosin CHF 202
Coolant Gasoline Engine
Lambda II 3.8 8.4 ~ 8.6
l
(8.88 ~ 9.09 US qt.) Mixture of antifreeze and distilled water
(Ethylene glycol base coolant for aluminum radiator)

Index
4
I
Defogging (Windshield) . . . . . . . . . . . . . . . . . . . . . . . 4-142
Defroster (Rear window) . . . . . . . . . . . . . . . . . . . . . . 4-127
Defrosting (Windshield) . . . . . . . . . . . . . . . . . . . . . . . 4-142
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Display illumination, see instrument panel illumination . . 4-50
Displays, see instrument cluster . . . . . . . . . . . . . . . . . . 4-49
Door courtesy lamp . . . . . . . . . . . . . . . . . . . . . . . . . . 4-124
Door locks. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
Central door lock/unlock switch . . . . . . . . . . . . . . . . 4-17
Child-protector rear door lock . . . . . . . . . . . . . . . . . . 4-19
Power door latch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
Drinks holders, see cup holders . . . . . . . . . . . . . . . . . 4-151
DRIVE mode / SNOW mode . . . . . . . . . . . . . . . . . . . . 5-58
Drive mode integrated control system . . . . . . . . . . . . . 5-58 DRIVE mode / SNOW mode . . . . . . . . . . . . . . . . . . . 5-58
Driver Information System (DIS). . . . . . . . . . . . . . . . 4-162
Driver position memory system . . . . . . . . . . . . . . . . . . . 3-7
Driver's and passenger's front air bag. . . . . . . . . . . . . . 3-50
Driving at night. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-98
Driving in flooded areas . . . . . . . . . . . . . . . . . . . . . . . . 5-99
Driving in the rain . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-98
Economical operation . . . . . . . . . . . . . . . . . . . . . . . . . . 5-94
Electric chromic mirror (ECM) . . . . . . . . . . . . . . . . . . 4-44
Electric parking brake (EPB) . . . . . . . . . . . . . . . . . . . . 5-36 Electronic controlled suspension (ECS) . . . . . . . . . . . . 5-61
Electronic Hydraulic Power Steering (EHPS) . . . . . . . 4-41
Electronic stability control (ESC) . . . . . . . . . . . . . . . . 5-46
Emergency commodity . . . . . . . . . . . . . . . . . . . . . . . . . 6-28
Emergency starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Jump starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Emergency while driving . . . . . . . . . . . . . . . . . . . . . . . . 6-3
Emission control system . . . . . . . . . . . . . . . . . . . . . . . . 7-85 Crankcase emission control system . . . . . . . . . . . . . . 7-85
Evaporative emission control System . . . . . . . . . . . . 7-85
Exhaust emission control system . . . . . . . . . . . . . . . . 7-86
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-7
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-26
Engine Coolant Temperature guage . . . . . . . . . . . . . . . 4-53
Engine number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-24
Engine overheats. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8
Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
Engine will not start . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
Evaporative emission control System . . . . . . . . . . . . . 7-85
Exhaust emission control system . . . . . . . . . . . . . . . . . 7-86
Explanation of scheduled maintenance items . . . . . . . 7-20
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-78
Exterior overview (Front) . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Exterior overview (Rear) . . . . . . . . . . . . . . . . . . . . . . . . 2-3
E

I5
Index
Feeling (Haptic switch feeling) (Type B) . . . . . . . . . . . 4-67
Flat tire (with spare tire) . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Changing tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-16
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Removing and storing the spare tire . . . . . . . . . . . . . 6-16
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Fluid Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-31
Fog light (front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Fog light (rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Front blind spot monitoring system . . . . . . . . . . . . . . 4-108
Front lamp switch (Type A) . . . . . . . . . . . . . . . . . . . . 4-121
Front lamp switch (Type B) . . . . . . . . . . . . . . . . . . . . 4-123
Front seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Fuel filler lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
Fuel requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-55
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-55
Fuse/relay panel description . . . . . . . . . . . . . . . . . . . . 7-57
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . . 7-54 Main fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-56
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-57
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147
Glove box lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-125
Gross vehicle weight . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Hazard warning flasher. . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Hazardous driving conditions . . . . . . . . . . . . . . . . . . . . 5-96
Head up display (HUD) . . . . . . . . . . . . . . . . . . . . . . . . 4-96
Headlight (Headlamp) escort function . . . . . . . . . . . . 4-110
Headlight bulb replacement . . . . . . . . . . . . . . . . . . . . . 7-74
Headlight leveling device . . . . . . . . . . . . . . . . . . . . . . 4-117
Headlight position . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Headlight washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-117
Headlight(Headlamp) welcome . . . . . . . . . . . . . . . . . 4-126
Headrest(front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Headrest(rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Heated steering wheel. . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Heater Automatic climate control system . . . . . . . . . . . . . . 4-128
Height adjustment(front seat) . . . . . . . . . . . . . . . . . . . . 3-22
F
G
H

Index
8
I
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Maintenance schedule. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Manual mode (shift by cable). . . . . . . . . . . . . . . . . . . . 5-14
Manual mode (shift by wire) . . . . . . . . . . . . . . . . . . . . 5-23
Map pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-149
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
Electric chromic mirror (ECM) . . . . . . . . . . . . . . . . . 4-44
Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-44
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-45
Moonroof, see sunroof . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-57
Multimedia system . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-161 Antenna. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-163
Audio / Video / Navigation system (AVN) . . . . . . . 4-161
Aux, USB and iPod port. . . . . . . . . . . . . . . . . . . . . . 4-161
Bluetooth® Wireless Technology hands-free. . . . . . 4-162
Driver Information System (DIS) . . . . . . . . . . . . . . 4-162
Steering wheel audio control . . . . . . . . . . . . . . . . . . 4-163
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-24
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-45
Outside Temperature Gauge . . . . . . . . . . . . . . . . . . . . . 4-55
Overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6 Parking assist system . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
Parking guide system . . . . . . . . . . . . . . . . . . . . . . . . . 4-105
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Power brakes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-31
Power door latch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-152
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Power window lock button . . . . . . . . . . . . . . . . . . . . . . 4-31
Pre-Safe Seat belt (PSB). . . . . . . . . . . . . . . . . . . . . . . . 3-28
Pre-tensioner seat belt. . . . . . . . . . . . . . . . . . . . . . . . . . 3-25
Puddle lamp and door handle lamp . . . . . . . . . . . . . . 4-126
Rear curtain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-159
Rear lamp switch (Type A) . . . . . . . . . . . . . . . . . . . . . 4-122
Rear lamp switch (Type B) . . . . . . . . . . . . . . . . . . . . . 4-124
Rear mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-158
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Rear seat storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Rear view camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-104
Recommended cold tire inflation pressures . . . . . . . . . 7-43
Recommended lubricants and capacities . . . . . . . . . . . . 8-6
Recommended SAE viscosity number . . . . . . . . . . . . . 8-8
Replacement light bulb . . . . . . . . . . . . . . . . . . . . . . . . . 7-74
O
P
R