tire pressure KIA Rio 2005 2.G Owner's Manual

Suggestions for Economical
OperationYour vehicle’s fuel economy is mainly dependent on
your style of driving, how you drive, where you drive
and when you drive.
Each of these factors has an effect on how many miles
(kilometers) you can get from a gallon (liter) of fuel.
To operate your vehicle as economically as possible,
use the following driving suggestions to help save
money in both fuel and repairs:
 Avoid lengthy warm-up idling. Once the engine
is running smoothly, begin driving. Remember,
though, that on cold days, engine warm-up may take
a little longer.
 Save fuel by accelerating slowly after stopping.
 Keep the engine in tune and follow the
recommended periodic maintenance schedule.
This will increase the life of all parts and lower your
operating costs.
 Do not use the air conditioner unnecessarily.
 Slow down when driving on rough roads. For longer tire life and better fuel economy, always
keep the tires inflated to the recommended
pressures.
 Maintain a safe distance from other vehicles to
avoid sudden stops. This will reduce wear on brake
linings and pads and save fuel because extra fuel is
required to accelerate back to driving speed.
 Do not carry unnecessary weight in the vehicle.
 Do not rest your foot on the brake pedal while
driving. This can cause needless wear, possible
damage to the brakes, and poor fuel economy.
 Improper wheel alignment causes the tires to roll
at excessive angles, which results in faster tire wear.
It takes more power to overcome this improper
alignment, which wastes fuel.
 Open windows at high speeds can reduce fuel
economy.
 Crosswinds and headwinds reduce fuel economy. To
help offset some of this loss, slow down when
driving in these conditions.Driving Tips5-6
RIO ENG CNA 5.qxd 7/29/05 5:07 PM Page 6

Driving Tips5-10
Snow Tires
When snow tires are used, select the size and
construction specified on the Tire Pressure Label. It is
strongly recommended that snow tires be used on all
four wheels, or poor handling may result. Snow tires
should not be operated at speeds exceeding 75 mph
(120 km/h).
These tires should be inflated 4 psi (28 kPa,
0.3 kg/cm
2) above the recommended pressures shown
on the Tire Specification/Pressure Label, but inflation
should never exceed the maximum cold-tire pressure
shown on the tire sidewalls.
Do not install studded tires without first checking
local, provincial and municipal regulations for
possible restrictions against their use.
WARNING - Snow Tire Size
Snow tires should be equivalent in size and
type to the vehicle’s standard tires. Otherwise,
the safety and handling of your vehicle may be
adversely affected.
Winter Driving We recommend that you carry emergency
equipment. Some things you might include are tire
chains, a window scraper, windshield de-icer, a bag
of sand or salt, flares, a small shovel and jumper
cables.
 Make sure you have sufficient ethylene glycol
coolant in the radiator.
 Check the battery condition and cables. Cold
temperatures reduce the capacity of any battery, so it
must be in top shape to provide enough winter
starting power.
 Make sure the engine oil viscosity is suitable for
cold weather.
 Check the ignition system for loose connections and
damage.
 Use antifreeze-formulated windshield washer fluid
and make sure you have sufficient fluid for your
trip. (Do not use engine coolant antifreeze.)
 Do not use the parking brake if it might freeze. This
is most likely to happen after driving in slushy or
wet conditions and temperatures drop into the
freezing range. When parking, shift to P (Park) with
automatic transaxle, or to 1 (First) or R (Reverse)
with a manual transaxle and block the rear wheels.
RIO ENG CNA 5.qxd 7/29/05 5:07 PM Page 10

5-15
Tire Specification/Pressure Label
AS2B05005
Chassis Number(Frame number)
Frame Number is located under the front passenger
seat. Please detach the plastic cover to see the frame
number.
FRAME NO.
Pull
1B3104004E
Frame number cover
RIO ENG CNA 5.qxd 7/29/05 5:07 PM Page 15

In Case Of An Emergency6-18The compact spare should be inflated to 60 psi
(415 kPa).
When using a compact spare tire, observe the
following precautions:
 Under no circumstances should you exceed 80 km/h
(50 mph); a higher speed could damage the tire.
 Ensure that you drive slowly enough for the road
conditions to avoid all hazards. Any road hazard,
such as a pothole or debris, could seriously damage
the compact spare.
 Any continuous road use of this tire could result in
tire failure, loss of vehicle control, and possible
personal injury.
 Do not exceed the vehicle’s maximum load rating or
the load-carrying capacity shown on the sidewall of
the compact spare tire. Avoid driving over obstacles. The compact spare tire
diameter is smaller than the diameter of a
conventional tire and reduces the ground clearance
approximately 25 mm (1 in.), which could result in
damage to the vehicle.
 Do not take this vehicle through an automatic car
wash.
 Do not use tire chains on this tire. Because of the
smaller size, a tire chain will not fit properly. This
could damage the vehicle and result in loss of the
chain.
 This tire should not be installed on the front axle if
the vehicle must be driven in snow or on ice.
 Do not use the compact spare tire on any other
vehicle because this tire has been designed
especially for your vehicle.
 The compact spare’s tread life is shorter than a
regular tire. Inspect your compact spare tire
regularly and replace worn compact spare tires with
the same size and design, mounted on the same
wheel.
✽
NOTICE
Check the inflation pressure after installing the
spare tire. Adjust it to the specified pressure, as
necessary.
RIO ENG CNA 6.qxd 7/29/05 5:15 PM Page 18

6-23
To prevent the jack, jack handle, wheel lug nut, wrench
and spare tire from rattling while the vehicle is in
motion, store them properly.
WARNING - Wheel Studs
If the studs are damaged, they may lose their
ability to retain the wheel. This could lead to
the loss of the wheel and a collision.✽
NOTICE
Check the inflation pressures as soon as possible
after installing the spare tire. Adjust it to the
specified pressure, if necessary.
Standard Tire: 29 psi
Compact Spare Tire: 60 psi
RIO ENG CNA 6.qxd 7/29/05 5:15 PM Page 23

Maintenance7-8Chassis and Body (cont.)I: Inspect these items and their related parts. If necessary,
Check the engine oil and coolant levels every week.
R: Replace or change.
Kilometers or Time in Months, Whichever Comes First
km 8 16 24 32 40 48 56 64 72 80 88 96 104 112 120 128Months 4 8 12 16 20 24 28 32 36 40 44 48 52 56 60 64
Brake lines & connections (including booster)IIIIIManual transaxle oil
IIIRIIIRIIIRIIIR
Clutch & brake pedal free playI IIIIIIIIII IIIII
Automatic transaxle fluid
IIIRIIIRIIIRIIIR
Chassis & underbody bolts & nuts
I IIIIIIIIII IIIII
Tire condition & inflation pressure
I IIIIIIIIII IIIII
Wheel alignmentInspect when abnormal condition noted
Tire rotationSteering operation & linkageI IIIIIIIIII IIIII
MAINTENANCE
INTERVALS
MAINTENANCE
ITEM
x 1,000
Rotate the tires every 12,000 km (1)
(1)
(4)
(1) Refer to the lubricant and coolant specifications in the Owner’s Manual.
(4) If necessary, rotate and balance the wheels.
RIO ENG CNA 7-1.qxd 7/29/05 5:16 PM Page 8

Maintenance7-10Owner MaintenanceOwner Maintenance ScheduleA qualified service technician should perform these
vehicle inspections at the indicated intervals to ensure
safe and dependable operation.
Bring any problem to the attention of an Authorized
Kia Dealer as soon as possible.
When refueling, check:
 Engine oil level
 Engine coolant level
 Brake and clutch fluid level
 Washer fluid level
CAUTION
Be careful when checking your engine coolant
level. The engine compartment will be hot and
you could be burned.
At least monthly:
 Tire inflation pressures (cold)
 Coolant level in reservoir (cold engine)
Every 6 months, check:
 Power steering fluid level
 Automatic transaxle fluid level
You can do the following scheduled maintenance items
if you have some mechanical ability, a few basic tools
and if you closely follow the directions in this manual.
RIO ENG CNA 7-1.qxd 7/29/05 5:16 PM Page 10

Tires and WheelsTire CareFor proper maintenance, safety, and maximum fuel
economy, you must always maintain recommended tire
inflation pressures and stay within the load limits and
weight distribution recommended for your vehicle.Inflation PressuresCheck all tire pressures (including the spare) monthly
when the tires are cold. “Cold tires” means the car has
not been driven for at least three hours or driven less
than 1.6 km (one mile). Recommended pressures must
be maintained to ensure ride quality, vehicle handling,
and minimum tire wear.Maintenance7-34
All specifications (sizes and pressures) can be found
on a label attached to the front passenger door sill.
The correct tire pressure is 200 kPa (29 psi)
The compact spare should be at 415 kPa (60 psi).
AS2B07021
RIO ENG CNA 7-2.qxd 7/29/05 5:18 PM Page 34

7-35
Tire Rotation
To equalize tread wear, it is recommended that the tires
be rotated every 12,000 km (7,500 miles), or sooner if
irregular wear develops.
✻ ✻
NOTICE
 Warm tires normally exceed recommended
cold tire pressures by 28 to 41 kPa (4 to 6 psi).
Do not release air from warm tires to adjust the
pressure. The tires will become underinflated
when cold.
 Underinflation results in excessive wear, poor
handling, reduced fuel economy, and the
possibility of blowouts from overheated tires.
Also, low tire pressure can cause poor sealing
of the tire bead. If the tire pressure is
excessively low, wheel deformation and/or tire
separation are possible. Keep tire pressures at
the proper levels. If a tire frequently needs
refilling, have it checked by an authorized Kia
dealer or a tire shop.
 Overinflation produces a harsh ride, handling
problems, excessive wear at the center of the
tire tread, and a greater possibility of damage
from road hazards.
WARNING -Tire Inflation
Overinflation or underinflation can reduce tire
life, adversely affect vehicle handling, and lead
to sudden tire failure. This could result in loss
of vehicle control.
AS2B07022A
Do not include compact spare tire in rotationFront
RIO ENG CNA 7-2.qxd 7/29/05 5:18 PM Page 35

During tire rotation, check the tires for correct balance.
Check for uneven wear and damage. Abnormal wear is
usually caused by incorrect tire pressure, improper
wheel alignment, an out-of-balance condition, severe
braking or severe cornering. Look for bumps or bulges
in the tread or side of tire. Replace the tire if you find
either of these conditions. Also, replace the tire if you
can see fabric or cord. After rotation, be sure to bring
the front and rear tire pressures to specification and
check lug nut tightness.
Disc brake pads should be inspected for wear
whenever tires are rotated. Maintenance7-36
Tire Replacement
If the tire is worn evenly, a tread wear indicator will
appear as a solid band, 12.7 mm wide (1/2 inch) acrossthe tread. This shows there is less than 1.6 mm (1/16 inch)of tread remaining on the tire. Replace the tire when
this happens.
Do not wait for this band to appear across the entire
tread before replacing the tire.
✻ ✻
NOTICE
Rotate radial tires that have an asymmetric tread
pattern from front to rear only and not from right
to left.
AS2B07023
Tread wear indicator
New tread Worn tread
RIO ENG CNA 7-2.qxd 7/29/05 5:18 PM Page 36