ignition KIA Rio 2011 2.G Workshop Manual

611
In case of an emergency
Driver-side knee bolster
Description Fuse rating Protected component
RR WIPER15A Rear wiper
H/LP(LH) 10A Headlight (left)
FR WIPER 25A Front wiper
BLOWER 10A Blower
H/LP(RH) 10A Headlight (right)
S/ROOF 20A Sunroof
STOP LP 15A Stop light
C/DR LOCK 20A Central door lock
IGN COIL 15A Ignition coil
ABS 10A ABS
B/UP LP 10A Back-up light
SPARE - Spare fuse
C/LIGHTER 25A Cigar lighter
FOLD'G 10A Outside rearview mirror folding
HTD SEAT 20A Seat warmer
AMP 25A Amplifier
FR FOG LP 10A Front fog light
SPARE - Spare fuse
ECU 10A Engine control unit
CLUSTER 10A Cluster
P/WDW RH 25A Power window (right)
AUDIO 10A Audio
RR FOG LP 10A Rear fog light
IGN 10A Ignition
Description Fuse rating Protected component
HTD GLASS30A Rear window defroster
A/BAG 15A Air bag
TCU 10A Automatic transaxle control
SNSR 10A Sensors
SPARE - Spare fuse
MULT B/UP 10A Cluster, ETACS, A/C, Clock,
Room lamp
AUDIO 15A Audio
P/WDW LH 25A Power window (left)
HTD MIRR 10A Outside rearview mirror heater
TAIL LP(LH) 10A Taillight (left)
TAIL LP(RH) 10A Taillight (right)
HAZARD 10A Hazard warning light
T/SIG LP 10A Turn signal light
A/BAG IND 10A Air bag warning
START 10A Start motor

613
In case of an emergency
It is acceptable to tow the vehicle with the
rear wheels on the ground (without dol-
lies) and the front wheels off the ground.
When being towed by a commercial tow
truck and wheel dollies are not used, the
front of the vehicle should always be lift-
ed, not the rear.
✽ ✽NOTICE
• Do not tow the vehicle backwards
with the front wheels on the ground as
this may cause damage to the vehicle.
• Do not tow with sling-type equipment. Use wheel lift or flatbed equipment.
When towing your vehicle in an emer-
gency without wheel dollies :
1. Set the ignition switch in the ACC posi-
tion.
2. Place the transaxle shift lever in N (Neutral).
3. Release the parking brake.
✽ ✽ NOTICE
Failure to place the transaxle shift lever
in N (Neutral) may cause internal dam-
age to the transaxle.
2GHA41071JBA6503
1JBA6502

In case of an emergency
16
6
Before emergency towing, check that
the hook is not broken or damaged.
Fasten the towing cable or chain securely to the hook.
Do not jerk the hook. Apply steady and even force.
To avoid damaging the hook, do not pull from the side or at a vertical angle.
Always pull straight ahead.
Use a towing strap less than 5m (16feet) long. Attach a white or red cloth
(about 30cm (12 inches) wide) in the
middle of the strap for easy visibility.
Drive carefully so that the towing strap is not loosened during towing.
When your vehicle is being towed
by another vehicle other than a tow
truck (in case of an emergency)
Turn the ignition switch to ACC so thesteering wheel isn’t locked.
Place the transaxle shift lever in N (Neutral).
Release the parking bake. Vehicles equipped with automatic
transaxles should not exceed 45 km/h
(28 mph) and should not be towed
more than 80 km (50 miles).
Vehicles equipped with manual transaxle should not be towed in
excess of 88 km/h (55 mph) and
should not be towed more than 645 km
(400 miles).
Press the brake pedal with more force than normal since you will have
reduced brake performance.
More steering effort will be required because the power steering system
will be disabled.
If you are driving down a long hill, the brakes may overheat and brake per-
formance will be reduced. Stop often
and let the brakes cool off.
✽ ✽ NOTICE
To prevent internal damage to the
transaxle, never tow your vehicle from
the rear (backwards) with all four tires
in contact with the surface.
CAUTION
Use extreme caution when towing
the vehicle.
driving maneuvers which wouldplace excessive stress on theemergency towing hook and tow-ing cable or chain. The hook andtowing cable or chain may break and cause serious injury or dam-age.
If the towing vehicle does not move easily, do not forcibly continue thetowing. Contact an authorized Kiadealer or a commercial tow truckservice for assistance.
Tow the vehicle as straight ahead as possible.
Keep away from the vehicle dur- ing towing.1JBA4124

617
In case of an emergency
Tips for towing a stuck vehicle
The following methods are effective
when your vehicle is stuck in mud, sand
or similar substances that prevent the
vehicle from being driven out under its
own power.
Remove the soil and sand, etc. fromthe front and the back of the tires.
Place a stone or wood under the tires.
The spare tire, jack, jack handle,
front towing hook, wheel lug nut
wrench are stored in the luggage
compartment. Move the carpeting
out of the way to reach this equip-
ment. Removing the spare tire
Turn the tire hold-down wing bolt
counterclockwise.
Store the tire in the reverse order of
removal.
To prevent the spare tire and tools
from “rattling” while the vehicle is in
motion, store them properly.
CAUTION - Automatic
transaxle
If the car is being towed with all
four wheels on the ground, it canbe towed only from the front. Besure that the transaxle is in neu-tral. Be sure the steering isunlocked by placing the ignitionswitch in the ACC position. Adriver must be in the towed vehi-cle to operate the steering and brakes.
To avoid serious damage to the automatic transaxle, limit thevehicle speed to 15 km/h (10 mph)and drive less than 1.5 km (1mile) when towing.
IF YOU HAVE A FLAT TIRE
1JBN60191JBN6020

73
Maintenance
MAINTENANCE SCHEDULE
Engine control system
MAINTENANCEINTERVALS
MAINTENANCE
ITEM
Replace every 6,000 km or 6 months.
Kilometers or time in months, whichever comes first
× 1,000 km 8 16 24 32 40 48 56 64 72 80 88 96 104 112 120 128
# Months 4 8 12 16 20 24 28 32 36 40 44 48 52 56 60 64
Engine oil & engine oil filter (1)
Drive belts (tension) I I I I
Cooling system hoses & connections I I I I I
Engine coolant (1) I I I I I R IIIIIRI III
Fuel filter RR
Fuel tank cap, lines, EVAP canister and hosesII
Fuel tank air filter I R I R I
Air cleaner element (2) I I I I I R IIIIIRI III
Ignition wires I I
Spark plugs R R
Idle speed I I I I I
Engine timing belt R

Maintenance
22
7
(Continued)
If any electrolyte gets intoyour eyes, flush your eyes
with clean water for at least
15 minutes and get immedi-
ate medical attention. If
possible, continue to apply
water with a sponge or
cloth until medical attention
is received.
If electrolyte gets on your
skin, thoroughly wash the
contacted area. If you feel a
pain or a burning sensation,
get medical attention imme-
diately.
Wear eye protection whencharging or working near a
battery. Always provide
ventilation when working in
an enclosed space.
An inappropriately dis- posed battery can be harm-
ful to the environment and
human health. Dispose the
battery according to your
local law(s) or regulation.
(Continued)(Continued)The battery contains lead.
Do not dispose of it after
use. Please return the bat-
tery to an authorized KIA
dealer to be recycled.
• When lifting a plastic-cased bat- tery, excessive pressure on the
case may cause battery acid to
leak, resulting in personal injury.
Lift with a battery carrier or with
your hands on opposite corners.
Never attempt to charge the bat- tery when the battery cables are
connected.
The electrical ignition system works with high voltage. Never
touch these components with the
engine running or the ignition
switched on.
Failure to follow the above warn-
ings can result in serious bodily
injury or death.CAUTION
When you don’t use the vehicle for a long time in the low temper-ature area, separate the battery and keep it indoors.
Always charge the battery fully to prevent battery case damage inlow temperature area.
If you use unauthorized electron- ic devices, the battery may be dis-charged. Never use unauthorizeddevices.
WARNING
Separating the battery from the
vehicle should be done in an
authorized KIA dealer.

Index
29
Air bags··················\
··················\
··················\
··················\
··3-49Air bag warning label··················\
··················\
············3-63
Air bag warning light ··················\
··················\
············3-62
Curtain air bag··················\
··················\
··················\
·····3-54
Driver's air bag ··················\
··················\
··················\
····3-51
Front passenger’s air bag ··················\
··················\
······3-52
Side impact air bag··················\
··················\
················3-53
Air cleaner ··················\
··················\
··················\
···············7-18
Alarm system ··················\
··················\
··················\
·············3-5
Antenna ··················\
··················\
··················\
··················\
··3-82
Anti-lock brake system (ABS) ··················\
··················\
··4-12
Appearance care··················\
··················\
··················\
·······7-34 Exterior care ··················\
··················\
··················\
········7-34
Interior care ··················\
··················\
··················\
·········7-36
Armrest ··················\
··················\
··················\
··················\
··3-22
Audio system ··················\
··················\
··················\
···········3-84 Antenna ··················\
··················\
··················\
···············3-82
Steering wheel audio control ··················\
··················\
3-83
Auto lock mode (Passenger seat belt) ··················\
·········3-44
Automatic transaxle ··················\
··················\
··················\
···4-6 Ignition key interlock system ··················\
··················\
··4-9
Shift lock system ··················\
··················\
··················\
···4-9 Battery··················\
··················\
··················\
··················\
····7-21
Battery saver function ··················\
··················\
················4-31
Before driving ··················\
··················\
··················\
············5-4
Bottle holders, see cup holders ··················\
··················\
··3-76
Brake system··················\
··················\
··················\
··············4-9
Anti-lock brake system (ABS) ··················\
················4-12
Parking brake··················\
··················\
··················\
·······4-10
Power brakes ··················\
··················\
··················\
·········4-9
Brakes fluid··················\
··················\
··················\
··············7-14
Bulb wattage ··················\
··················\
··················\
··············8-4
Capacities (Lubricants) ··················\
··················\
················8-4
Care Exterior care ··················\
··················\
··················\
········7-34
Interior care ··················\
··················\
··················\
·········7-36
Tire care··················\
··················\
··················\
···············7-24
Central door lock switch··················\
··················\
············3-10
Certification label ··················\
··················\
··················\
····5-10
Changing tires ··················\
··················\
··················\
··········6-19
Checking tire inflation pressure··················\
··················\
·7-25
Child-protector rear door lock ··················\
··················\
···3-12
Child restraint system ··················\
··················\
················3-42 Auto lock mode (Passenger seat belt) ··················\
·····3-44
Lower anchor system ··················\
··················\
············3-47
Tether anchor system··················\
··················\
·············3-46
AB
C

Index
49
Floor mat anchor(s) ··················\
··················\
··················\
·3-81
Fluid Brakes fluid ··················\
··················\
··················\
·········7-14
Folding the rear seat ··················\
··················\
··················\
3-23
Front seat adjustment ··················\
··················\
·················3-18\
Fuel filler lid ··················\
··················\
··················\
············3-67
Fuel requirements ··················\
··················\
··················\
······5-2
Fuses ··················\
··················\
··················\
··················\
········6-6 Fuse/relay panel description··················\
··················\
····6-9
Main fuse··················\
··················\
··················\
···············6-8
Memory fuse ··················\
··················\
··················\
·······6-12
Gauge Fuel gauge ··················\
··················\
··················\
···········4-21
Glassroof, see sunroof ··················\
··················\
···············3-79
Glove box··················\
··················\
··················\
·················3-75\
Hazard warning flasher ··················\
··················\
··············4-38
Hazardous driving conditions ··················\
··················\
······5-6
Headrest ··················\
··················\
··················\
··········3-21, 3-26
Heating and air conditioning ··················\
··················\
·····4-44
Hood··················\
··················\
··················\
··················\
·······3-66
Horn ··················\
··················\
··················\
··················\
·······4-19
How to use this manual ··················\
··················\
···············1-2 Ignition key interlock system ··················\
··················\
······4-9
Immobilizer system ··················\
··················\
··················\
···3-7
Indicators and warnings ··················\
··················\
·············4-25
Instrument cluster ··················\
··················\
··················\
····4-20
Fuel gauge ··················\
··················\
··················\
···········4-21
Instrument panel illumination ··················\
·················4-25\
Odometer ··················\
··················\
··················\
·············4-21
Speedometer ··················\
··················\
··················\
········4-21
Tachometer ··················\
··················\
··················\
··········4-21
Trip computer ··················\
··················\
··················\
······4-22
Tripmeter ··················\
··················\
··················\
·············4-22
Warning and indicators ··················\
··················\
·········4-25
Instrument panel illumination··················\
··················\
····4-25
Instrument panel overview··················\
··················\
···········2-3
Interior care··················\
··················\
··················\
··············7-36
Interior features··················\
··················\
··················\
········3-76 Cup holder ··················\
··················\
··················\
···········3-76
Digital clock ··················\
··················\
··················\
········3-78
Floor mat anchor(s) ··················\
··················\
···············3-81
Luggage net (holder) ··················\
··················\
·············3-81
Power outlet··················\
··················\
··················\
·········3-77
Sunvisor ··················\
··················\
··················\
···············3-77
Interior light ··················\
··················\
··················\
·············3-73
Interior overview··················\
··················\
··················\
········2-2
Interlock system ··················\
··················\
··················\
·········4-9
G
I
H