battery replacement KIA SORENTO PHEV 2022 Warranty and Consumer Information Guide

3
This overview chart illustrates warranty coverage and term by months and miles. Please refer to the appropriate
sections in this book for detailed information regarding each of these warranties.
Warranty Program Coverage at a Glance
Warranty Coverage
Emissions Defect
• Any Related Parts
• Specific Parts
Emission Performance
• Any Related Parts
• Specific Parts
Emissions Defect
• Any Related Parts
• Specific Parts*2
• SULEV*3
Emission Performance
Replacement Parts & Accessories
BasicPower Train*1Service AdjustmentOriginal Equipment BatteryPaintAudio / EntertainmentAnti-PerforationHybrid System
60,000 100,000 36,000 36,000 36,000
100,000 100,000
24
96
24
96
36
84
180
36
12
601201236363660120
Months in MILES IN SERVICE Service 10,000 20,000 30,000 40,000 50,000 60,000 70,000 80,000 90,000 100,000 150,000
WARRANTY TERM(whichever comes first)
Federal
California
24,000
12,000
12,000
80,000
24,000
50,000
50,000
70,000
80,000
NOTE: Tires are warranted by the tire manufacturers. *1 Original owner 120 Months/100,000 Miles Second and Subsequent Owner(s) 60 Months/60,000 Miles. *2 Except those specified parts covered by the Federal Emission Performance W arranty. *3 SULEV covers specific parts for 180 months / 150,000 miles, whichever occurs first. This Limitied California Emission Control Warranty applies ONLY to SULEV vehicles which are first sold as new vehicles by dealers in California or any other states adopting and mandating the California Emission Standards. These warranties do not provide any further warranty coverage beyond what is required by state law.
EMISSION WARRANTY
LIMITED WARRANTY
Original Owner Only
150,000
22MY HEV & PHEV(��1).indd 32021-06-23 �� 2:42:06

7
• Air Conditioner Refrigerant Charge
Air conditioner refrigerant charge is covered for the
first 12 months of the warranty period regardless of
mileage. Over the balance of the warranty period,
refrigerant charge is covered only when replenished
as part of a warranty repair.
• Audio / Entertainment System
An original equipment radio, compact disk player,
OE DVD / RSE (Rear Seat Entertainment System)
or navigation system is covered for the first
36months/36,000 miles.
• Battery (Non Hybrid)
The original equipment battery is covered by a
limited warranty for a period of 36 months / 36,000
miles. During 36 months / 36,000 miles of the
warranty period, a defective battery will be replaced
at no cost to you. Kia will cover diagnostic,
installation and replacement battery costs.
Kia will not reimburse you for any portion of the
cost of a non-Kia replacement battery.
* Refer to page 24 for Hybrid Battery Pack
Coverage.
• Brake and Clutch Linings
Brake linings, including pads and shoes, and clutch
linings are warranted for 12 months/12,000 miles,
whichever comes first, if they fail to function
properly during normal use. Brake linings are
designed to wear out as part of the process of
stopping your vehicle safely and consistently while
providing reasonable levels of noise and vibration
during normal use. Brake or clutch linings function
properly during normal use even if they need
replacement in less than the full warranty period.
Rather, most replacements at lower mileage are
required by driver usage habits which can cause high
rates of wear. In addition, brake lining wear is
substantially increased by environmental conditions
such as exposure to road salt or due to regular
driving in stop and go rush hour traffic. The more
wear factors which are present, the more rapid the
wear. Resulting repairs and replacements of linings
are not covered by your warranty.
New Vehicle Limited Warranty
22MY HEV & PHEV(��1).indd 72021-06-23 �� 2:42:06

14Hybrid System Warranty
What is Covered
Repair or replacement of HYBRID SYSTEM
components listed below, originally manufactured or
installed by Kia Corporation, Kia Georgia or Kia
America that are found to be defective in material or
factory workmanship under normal use and maintenance,
except any item specifically referred to in the section
“What is Not Covered”. Towing expense to the nearest
Kia Dealership or authorized service location is covered
when the vehicle is inoperable due to a warrantable
defect within 10 years from the date of original retail
delivery or date of first use, or 100,000 miles, whichever
occurs first. “Owner’s Responsibilities” and “Obtaining
Warranty Service” are the same as specified under the
Kia New Vehicle Limited Warranty. Repairs will be
made using new Kia Genuine Parts or Kia authorized
remanufactured parts.
The Warranty Period
The Warranty period for the following HYBRID
SYSTEM components is limited to 10 years from the
date of original retail delivery or date of first use, or
100,000 miles, whichever occurs first.
Note : For California Emissions Vehicles (excluding
Pennsylvania and Washington), the Hybrid System is
covered for 10 years from the date of original retail
delivery or date of first use, or 150,000 miles, whichever
occurs first.
Hybrid System
Hybrid Battery Pack Assy, Hybrid Starter & Generator,
Hybrid Power Control Unit, Traction Motor, clutch, On
board charger(OBC) and all internal parts.
Owner’s Responsibilities
Your responsibilities are the same as those described in
the Kia New Vehicle Limited Warranty.
What is Not Covered
Items not covered by this warranty and any exclusion or
limitations relating to this warranty are the same as those
set forth in the "What is Not Covered" section of the Kia
New Vehicle Limited Warranty already described in this
handbook. INCIDENTAL OR CONSEQUENTIAL
DAMAGES, INCLUDING WITHOUT LIMITATION,
LOSS OF TIME, INCONVENIENCE, LOSS OF USE
OF THE VEHICLE, OR COMMERCIAL LOSS ARE
NOT COVERED UNDER THIS WARRANTY.
22MY HEV & PHEV(��1).indd 142021-06-23 �� 2:42:06

24Federal Emission Control Warranty
Federal Emission Control Warranty
Air Induction System Air Cleaner Assembly Intake ManifoldFuel Metering System Engine Coolant Temperature Sensor Manifold Absolute Pressure Sensor Wheel Speed Sensor Fuel Injector Fuel Delivery Line Throttle Body Oxygen Sensor Pulsation Damper Engine Control Module * 8/80Ignition System Spark Plugs Spark Plugs Cable Set Ignition Coil Camshaft Position Sensor Crankshaft Position Sensor GeneratorValve Timing System CVVT Assy Oil Control Valve Assy Oil Temperature Sensor
Evaporative Control System Vapor Storage Canister Canister Close Valve Purge Control Solenoid Valve Fuel Pump Fuel Tank Fuel Filler Cap Fuel Tank Pressure Sensor ORVR(Vent) Valve Rollover(Cut) ValvePositive Crankcase Ventilation System PCV Valve and HoseCatalyst and Exhaust System Exhaust Manifold Exhaust Manifold Catalytic Assembly * 8/80 Exhaust Pipe Catalytic Converter Assembly * 8/80Hybrid System Hybrid Battery Pack Assy #10/100 Battery Management System #10/100 Hybrid Power Control Unit #10/100 On Board Charger #10/100 Traction Motor #10/100Miscellaneous Items Used In Above Systems Hose, Clamps,Gasket or Seals Wires, Harnesses Connectors All Sensor(Switches,Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device Malfunction Indicator Light and Bulb * 8/80 Data Link Connector * 8/80
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, or up to the fist required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maintenance).NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first.NOTE 3 : Specific Hybrid System Parts designated by "10/100" are warranted for 10 years or 100,000 miles, whichever occurs first.
22MY HEV & PHEV(��1).indd 242021-06-23 �� 2:42:07

30CaliforniaEmission Control Warranty
California Emission Control Warranty
Air Induction System Air Cleaner Assembly Intake Manifold (* 7/70) Turbo Charger (* 7/70)Fuel Metering System Head Assy-Cylinder (* 7/70) Thermostat Assembly (* 7/70) Engine Coolant Temperature Sensor Manifold Absolute Pressure Sensor Wheel Speed Sensor Fuel Injector (* 7/70) Fuel Delivery Line Throttle Body Oxygen Sensor Pulsation Damper Engine Control Module (* 8/80)Ignition System Spark Plugs Spark Plugs Cable Set Ignition Coil Camshaft Assy (* 7/70) Camshaft Position Sensor Crankshaft Position Sensor GeneratorValve Timing System CVVT(D) Assy (* 7/70) Oil Control Valve Assy (* 7/70) Oil Temperature Sensor (* 7/70) Valve (* 7/70)Auto Transmission System Transmission Control Unit (* 7/70)
Evaporative Control System Vapor Storage Canister Canister Close Valve Purge Control Solenoid Valve Fuel Pump Fuel Tank (* 7/70) Fuel Filler Cap Fuel Tank Pressure Sensor ORVR(Vent) Valve Rollover(Cut) Valve EGR Cooler & Valve (* 7/70)Positive Crankcase Ventilation System PCV Valve and HoseCatalyst and Exhaust System Exhaust Manifold Exhaust Manifold Catalytic Assembly (* 8/80) Exhaust Pipe Catalytic Converter Assembly (* 8/80)Hybrid System Hybrid Battery Pack Assy #10/150 (#10/100) Battery Management System #10/150 (#10/100) Hybrid Power Control Unit #10/150 (#10/100) On Board Charger #10/150 (#10/100) Traction Motor #10/150 (#10/100)Miscellaneous Items Used In Above Systems Hose, Clamps,Gasket or Seals Wires, Harnesses Connectors All Sensor(Switches, Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device Malfunction Indicator Light and Bulb (* 8/80) Data Link Connector (* 8/80)
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.NOTE 1 : The above parts for a Sorento hybrid, Sorento plug-in hybrid, Optima hybrid, Optima plug-in hybrid, Niro hybrid and Niro plug-in hybrid SULEV vehicles are warranted for 15 years or 150,000 miles, whichever occurs first, with the exception of Pennsylvania and Washington.NOTE 2 :
Specific Hybrid System parts designated by "10/150" are warranted for 10 years or 150,000 miles, whichever occurs first, with the exception of Pennsylvania and Washington.NOTE 3 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 4 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 5 : Parts designated by "7/70" are warranted for 7 years or 70,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 6 : Specific Hybrid System parts designated by "10/100" are warranted for 10 years or 100,000 miles, whichever occurs first, in Pennsylvania and Washington.
* (Pennsylvania and Washington only)
22MY HEV & PHEV(��1).indd 302021-06-23 �� 2:42:07

32Replacement Parts and Accessories Limited Warranty
Warranty Period
• Kia Genuine replacement parts
Kia Genuine replacement parts (except battery)
installed by an Authorized Kia Dealer under
warranty are covered for the greater of (1) the
duration of the New Vehicle Limited Warranty or
(2) the first 12 months from the date of
installation of the Kia Genuine replacement parts
or 12,000 miles.
• Kia Genuine replacement battery
This warranty applies only to Kia Genuine
replacement batteries purchased from an
Authorized Kia Dealer in the United States. Kia
Genuine replacement batteries are covered by a
limited warranty for the period of 36 months
from the date of installation, regardless of
mileage. During the first 12 months of the
warranty period a defective Kia Genuine
replacement battery will be replaced at no charge
for the new battery, labor or installation. If a Kia
Genuine replacement battery fails during the last
24 months of the 36-month warranty period, you
will receive a pro-rated credit toward the
purchase of a new Kia battery. You are
responsible for all diagnostic, labor and
installation charges.
Pro-Ration Chart:
Months Of Use Consumer Portion Warranty Portion
13-16 months 10% 90%
17-20 months 30% 70%
21-23 months 45% 55%
24-26 months 60% 40%
27-30 months 75% 25%
31-33 months 85% 15%
34-36 months 90% 10%
Kia will not reimburse you for any portion of the
cost of a non-Kia replacement battery.
22MY HEV & PHEV(��1).indd 322021-06-23 �� 2:42:07