catalytic converter KIA SORENTO PHEV 2022 Warranty and Consumer Information Guide

17
(a) “EPA” means the U.S. Environmental Protection
Agency.
(b) “Owner” means the original and each subsequent
owner of a Kia Vehicle.
(c) “Kia Part” means a part sold by an Authorized
Kia Dealer, whether new or remanufactured,
and supplied by Kia.
(d) “Emission Warranty Part” means a catalytic
converter, thermal reactor, or other component
installed on or in a Kia Vehicle by or at the
direction of Kia for the sole or primary purpose
of reducing the Kia Vehicle’s emissions (not
including those vehicle components which
were in general use prior to model year 1968
and the primary function of which is not related
to emission control). A list of typical Emission
Warranty Parts is set forth at the end of this
warranty.
(e) “Certified Part” means a replacement part for a
Kia Vehicle certified in accordance with after
market part certification regulations issued by
the EPA.
(f) “Written Maintenance Instructions” means those
maintenance and operation instructions,
together with the time and/or mileage interval
at which such maintenances are to be
performed, specified in the Owner’s Manual for
the Kia Vehicle or this Warranty and Consumer
Information Manual as being necessary to
assure compliance of the Kia Vehicle with
applicable emission standards during the term
of this warranty, as specified by law.
Emission Warranty Definitions
Federal
Emission Control Warranty
22MY HEV & PHEV(��1).indd 172021-06-23 �� 2:42:06

24Federal Emission Control Warranty
Federal Emission Control Warranty
Air Induction System Air Cleaner Assembly Intake ManifoldFuel Metering System Engine Coolant Temperature Sensor Manifold Absolute Pressure Sensor Wheel Speed Sensor Fuel Injector Fuel Delivery Line Throttle Body Oxygen Sensor Pulsation Damper Engine Control Module * 8/80Ignition System Spark Plugs Spark Plugs Cable Set Ignition Coil Camshaft Position Sensor Crankshaft Position Sensor GeneratorValve Timing System CVVT Assy Oil Control Valve Assy Oil Temperature Sensor
Evaporative Control System Vapor Storage Canister Canister Close Valve Purge Control Solenoid Valve Fuel Pump Fuel Tank Fuel Filler Cap Fuel Tank Pressure Sensor ORVR(Vent) Valve Rollover(Cut) ValvePositive Crankcase Ventilation System PCV Valve and HoseCatalyst and Exhaust System Exhaust Manifold Exhaust Manifold Catalytic Assembly * 8/80 Exhaust Pipe Catalytic Converter Assembly * 8/80Hybrid System Hybrid Battery Pack Assy #10/100 Battery Management System #10/100 Hybrid Power Control Unit #10/100 On Board Charger #10/100 Traction Motor #10/100Miscellaneous Items Used In Above Systems Hose, Clamps,Gasket or Seals Wires, Harnesses Connectors All Sensor(Switches,Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device Malfunction Indicator Light and Bulb * 8/80 Data Link Connector * 8/80
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, or up to the fist required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maintenance).NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first.NOTE 3 : Specific Hybrid System Parts designated by "10/100" are warranted for 10 years or 100,000 miles, whichever occurs first.
22MY HEV & PHEV(��1).indd 242021-06-23 �� 2:42:07

25
California
Emission Control Warranty
Your Warranty Rights And Obligations
The California Air Resources Board and Kia America,
Inc., are pleased to explain the emission control system
warranty on your 2022 Kia vehicle. In California, new
motor vehicles must be designed, built and equipped to
meet the State’s stringent anti-smog standards. Kia
must warrant the emission control system on your Kia
vehicle for the periods of time listed below provided
there has been no abuse, neglect or improper
maintenance of your Kia vehicle.
Your emission control system may include parts such
as the carburetor or fuel-injection system, the ignition
system, catalytic converter, and engine computer. Also
included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable
condition exists, Kia will repair your Kia vehicle at no
cost to you including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage
For 3 years or 50,000 miles, whichever first occurs:
1. If your Kia vehicle fails a Smog Check inspection, all necessary repairs and adjustments will be made by Kia to ensure that your vehicle passes the inspection. This is your emission control system PERFORMANCE WARRANTY.
2. If any emission-related part on your Kia vehicle is defective, the part will be repaired or replaced by Kia. This is your short-term emission control system DEFECTS WARRANTY.
For 7 years or 70,000 miles for emission related parts, whichever first occurs (8 years or 80,000 miles for Federal Emission Control Warranty) :
If an emission-related part listed in this warranty booklet specially noted with coverage for 7 years or 70,000 miles is defective, the part will be repaired or replaced by Kia. This is your long-term emission control system DEFECTS WARRANTY.
For 2022 SULEV(Super Ultra Low Emission Vehicle), all parts covered under the PERFORMANCE WARRANTY and the DEFECT WARRANTY, which are listed in this warranty booklet on the Emission Warranty Parts List, are warranted for
15 years or 150,000 miles, whichever occurs first.
California Emission Control Warranty Statement
22MY HEV & PHEV(��1).indd 252021-06-23 �� 2:42:07

28CaliforniaEmission Control Warranty
What The Owner Must Do
It is your responsibility to perform the required
maintenance and use the vehicle in accordance with
Kia’s written instructions. Warranty coverage will not be
denied solely because there is no record of maintenance.
However, failures caused by lack of required
maintenance are not covered by the warranty. To avoid
questions as to whether the vehicle maintenance has
been performed, Kia urges that you retain all receipts
and/or maintenance records indicating that service has
been performed on the vehicle and these documents
should be transferred to any subsequent owner of the
vehicle.
Service
MAINTENANCE SERVICE CAN BE PERFORMED
BY ANY QUALIFIED SERVICE OUTLET OR BY
THE OWNER. HOWEVER, EXCEPT IN AN
EMERGENCY SITUATION (SEE EMERGENCY
SERVICE), WARRANTY SERVICE MUST BE
PERFORMED BY AN AUTHORIZED KIA DEALER.
Parts
IT IS RECOMMENDED THAT ANY REPLACEMENT
PARTS USED FOR MAINTENANCE OR FOR THE
REPAIR OF EMISSIONS CONTROL SYSTEMS BE
NEW, KIA GENUINE PARTS. However, the warranty
obligations are not dependent upon the use of any
particular brand of replacement parts. The owner may
elect to use non-Kia parts for maintenance purposes. Use
of replacement parts which are not of equivalent quality
may impair the effectiveness of emissions control systems.
What Is Not Covered By Emission Warranty
Malfunctions in any part caused by misuse, alteration,
tampering, disconnection or improper or inadequate
maintenance.
Damage to catalytic converter due to use of leaded
gasoline.
Damage resulting from fire, accident, negligence, act of
God or other events beyond the control of Kia.
Maintenance replacement parts (such as spark plugs)
beyond the first scheduled replacement point.
22MY HEV & PHEV(��1).indd 282021-06-23 �� 2:42:07

30CaliforniaEmission Control Warranty
California Emission Control Warranty
Air Induction System Air Cleaner Assembly Intake Manifold (* 7/70) Turbo Charger (* 7/70)Fuel Metering System Head Assy-Cylinder (* 7/70) Thermostat Assembly (* 7/70) Engine Coolant Temperature Sensor Manifold Absolute Pressure Sensor Wheel Speed Sensor Fuel Injector (* 7/70) Fuel Delivery Line Throttle Body Oxygen Sensor Pulsation Damper Engine Control Module (* 8/80)Ignition System Spark Plugs Spark Plugs Cable Set Ignition Coil Camshaft Assy (* 7/70) Camshaft Position Sensor Crankshaft Position Sensor GeneratorValve Timing System CVVT(D) Assy (* 7/70) Oil Control Valve Assy (* 7/70) Oil Temperature Sensor (* 7/70) Valve (* 7/70)Auto Transmission System Transmission Control Unit (* 7/70)
Evaporative Control System Vapor Storage Canister Canister Close Valve Purge Control Solenoid Valve Fuel Pump Fuel Tank (* 7/70) Fuel Filler Cap Fuel Tank Pressure Sensor ORVR(Vent) Valve Rollover(Cut) Valve EGR Cooler & Valve (* 7/70)Positive Crankcase Ventilation System PCV Valve and HoseCatalyst and Exhaust System Exhaust Manifold Exhaust Manifold Catalytic Assembly (* 8/80) Exhaust Pipe Catalytic Converter Assembly (* 8/80)Hybrid System Hybrid Battery Pack Assy #10/150 (#10/100) Battery Management System #10/150 (#10/100) Hybrid Power Control Unit #10/150 (#10/100) On Board Charger #10/150 (#10/100) Traction Motor #10/150 (#10/100)Miscellaneous Items Used In Above Systems Hose, Clamps,Gasket or Seals Wires, Harnesses Connectors All Sensor(Switches, Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device Malfunction Indicator Light and Bulb (* 8/80) Data Link Connector (* 8/80)
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.NOTE 1 : The above parts for a Sorento hybrid, Sorento plug-in hybrid, Optima hybrid, Optima plug-in hybrid, Niro hybrid and Niro plug-in hybrid SULEV vehicles are warranted for 15 years or 150,000 miles, whichever occurs first, with the exception of Pennsylvania and Washington.NOTE 2 :
Specific Hybrid System parts designated by "10/150" are warranted for 10 years or 150,000 miles, whichever occurs first, with the exception of Pennsylvania and Washington.NOTE 3 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 4 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 5 : Parts designated by "7/70" are warranted for 7 years or 70,000 miles, whichever occurs first, in Pennsylvania and Washington.NOTE 6 : Specific Hybrid System parts designated by "10/100" are warranted for 10 years or 100,000 miles, whichever occurs first, in Pennsylvania and Washington.
* (Pennsylvania and Washington only)
22MY HEV & PHEV(��1).indd 302021-06-23 �� 2:42:07