coolant level Lancia Flavia 2013 Owner handbook (in English)

INSTRUMENT CLUSTER
DESCRIPTIONS
1. Temperature Gauge
The temperature gauge shows engine
coolant temperature. Any reading be-
low theH(red) mark of the gauge
shows that the engine cooling system
is operating properly. The gauge
pointer may show a higher than nor-
mal temperature when driving in hot
weather, up mountain grades, in
heavy stop and go traffic, or when
towing a trailer.
If the pointer rises to the H(red)
mark, the instrument cluster will
sound a chime. Pull over and stop the
vehicle. Idle the vehicle with the air
conditioner turned off until the
pointer drops back into the normal
range. If the pointer remains on the H
(red) mark, turn the engine off imme-
diately and call for service.
There are steps that you can take to
slow down an impending overheat
condition. If your air conditioning is
on, turn it off. The air conditioning
system adds heat to the engine cooling system and turning off the A/C re-
moves this heat. You can also turn the
Temperature control to maximum
heat, the Mode control to Floor and
the Fan control to High. This allows
the heater core to act as a supplement
to the radiator and aids in removing
heat from the engine cooling system.
2. Fuel Door Reminder
This is a reminder that the
Fuel Filler Door is located
on the left side of the vehicle.
3. Fuel Gauge
When the ignition switch is in the
ON/RUN position, the pointer will
show the level of fuel remaining in the
fuel tank.
4. Speedometer
Indicates the vehicle speed in miles
per hour (MPH) and kilometers per
hour (km/h).
5. Low Fuel Light
When the fuel level drops to
approximately 7.6 Liters, the
fuel symbol will light and a single
chime will sound. NOTE: This light will remain on
until a minimum of approximately
11 Liters of fuel is added.
6. Charging System Light
This light shows the status of
the electrical charging system.
The light should come on briefly when
the ignition is first turned on and re-
main on briefly as a bulb check. If the
light stays on or comes on while driv-
ing, turn off some of the vehicle's elec-
trical devices, such as the Front Fog
Lights or Rear Window Defroster. If
the Charging System Light remains
on, it means that the vehicle is expe-
riencing a problem with the charging
system. Obtain SERVICE IMMEDI-
ATELY. See your local authorized
dealer.
If jump starting is required, refer to
“Jump Starting Procedures” in “What
To Do In Emergencies”.
111

7. Air Bag Warning LightThis light will turn on for
four to eight seconds as a
bulb check when the igni-
tion switch is first turned to
ON/RUN. If the light is either not on
during starting, stays on, or turns on
while driving, have the system in-
spected at an authorized dealer as
soon as possible. Refer to “Occupant
Restraints” in “Things To Know Be-
fore Starting Your Vehicle” for further
information.
8. Seat Belt Reminder Light
When the ignition switch is
first turned to ON/RUN, this
light will turn on for four to
eight seconds as a bulb check. During
the bulb check, if the driver's seat belt
is unbuckled, a chime will sound.
After the bulb check or when driving,
if the driver seat belt remains unbuck-
led, the Seat Belt Warning Light will
flash or remain on continuously. Refer
to “Occupant Restraints” in “Things
To Know Before Starting Your Ve-
hicle” for further information. 9. Oil Pressure Warning Light
This light indicates low engine
oil pressure. The light will
come on and remain on when the
ignition switch is turned from the
OFF to the ON/RUN position, and the
light will turn off after the engine is
started. If the bulb does not come on
during starting, have the system
checked by an authorized dealer.
If the light comes on and remains on
while driving, stop the vehicle and
shut off the engine. DO NOT OPER-
ATE THE VEHICLE UNTIL THE
CAUSE IS CORRECTED.
The light does not show the quantity
of oil in the engine. This can be deter-
mined using the procedure shown in
“Maintaining Your Vehicle”.
10. Engine Temperature Warning
Light
This light warns of an over-
heated engine condition. As
engine coolant temperature rise and
the gauge approaches H, the light will
illuminate and a single chime will
sound after reaching a set threshold. Further overheating will cause a con-
tinuous chime sound for 4 minutes or
until the engine is allowed to cool.
If the light turns on while driving, safely
pull over and stop the vehicle. If the A/C
system is on, turn it off. Also, shift the
transmission into NEUTRAL and idle
the vehicle. If the temperature reading
does not return to normal, turn the
engine off immediately and call for ser-
vice. Refer to “If Your Engine Over-
heats” in “What To Do In Emergencies”
for further information.11. Brake Warning Light
This light monitors various
brake functions, including
brake fluid level and parking brake ap-
plication. If the brake light turns on it
may indicate that the parking brake is
applied, that the brake fluid level is low,
or that there is a problem with the anti-
lock brake system.
The dual brake system provides a re-
serve braking capacity in the event of
a failure to a portion of the hydraulic
system. Failure of either half of the
dual brake system is indicated by the
Brake Warning Light which will turn
112

CAUTION!
 Mixing of engine coolant (anti-freeze) other than specified en-
gine coolant (antifreeze), may re-
sult in engine damage and may
decrease corrosion protection. If a
non-specified engine coolant (an-
tifreeze) is introduced into the
cooling system in an emergency, it
should be replaced with the speci-
fied engine coolant (antifreeze) as
soon as possible.
Do not use plain water alone or
alcohol-based engine coolant (an-
tifreeze) products. Do not use ad-
ditional rust inhibitors or antirust
products, as they may not be com-
patible with the radiator engine
coolant (antifreeze) and may plug
the radiator. This vehicle has not been de- signed for use with Propylene
Glycol based engine coolant (an-
tifreeze). Use of Propylene Glycol
based engine coolant (antifreeze)
is not recommended. Adding Coolant
Your vehicle has been built with an
improved engine coolant (antifreeze)
that allows extended maintenance in-
tervals. This engine coolant (anti-
freeze) can be used up to ten years or
240 000 km before replacement. To
prevent reducing this extended main-
tenance period, it is important that
you use the same engine coolant (an-
tifreeze) throughout the life of your
vehicle.
When adding engine coolant (anti-
freeze):
Use only high purity water such as
distilled or deionized water when
mixing the water/engine coolant (an-
tifreeze) solution. The use of lower
quality water will reduce the amount
of corrosion protection in the engine
cooling system.
Please note that it is the owner's respon-
sibility to maintain the proper level of
protection against freezing according to
the temperatures occurring in the area
where the vehicle is operated.
NOTE: Mixing engine coolant
(antifreeze) types will decrease the
life of the engine coolant (anti-
freeze) and will require more fre-
quent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that the engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle.The cap should be inspected and
cleaned if there is any accumulation of
foreign material on the sealing surfaces.WARNING!
 The warning words “DO NOT
OPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine cool-
ant (antifreeze) when the engine
is overheated. Do not loosen or
remove the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
(Continued)
199

WARNING!(Continued)
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or
under pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your
community. To prevent ingestion by
animals or children, do not store eth-
ylene glycol-based engine coolant in
open containers or allow it to remain
in puddles on the ground. If ingested
by a child or pet, seek emergency as-
sistance immediately. Clean up any
ground spills immediately. Coolant Level
Four-Cylinder Engines –
the cool-
ant bottle provides a quick visual
method for determining that the en-
gine coolant (antifreeze) level is ad-
equate. With the engine idling and
warm to normal operating tempera-
ture, the level of the engine coolant
(antifreeze) in the bottle should be
between the “ADD” and “FULL”
lines, shown on the bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing coolant. Ad-
vise your service attendant of this. As
long as the engine operating tempera-
ture is satisfactory, the coolant bottle
need only be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill. Points To Remember
NOTE:
When the vehicle is stopped
after a few kilometers of operation,
you may observe vapor coming from
the front of the engine compartment.
This is normally a result of moisture
from rain, snow, or high humidity
accumulating on the radiator and
being vaporized when the thermo-
stat opens, allowing hot engine cool-
ant (antifreeze) to enter the radiator.
If an examination of your engine com-
partment shows no evidence of radiator
or hose leaks, the vehicle may be safely
driven. The vapor will soon dissipate. Do not overfill the coolant recovery bottle.
 Check engine coolant (antifreeze) freeze point in the radiator and in
the coolant recovery bottle. If en-
gine coolant (antifreeze) needs to
be added, the contents of the cool-
ant recovery bottle must also be
protected against freezing.
200

 If frequent engine coolant (anti-freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
Maintain engine coolant (antifreeze)
concentration at 50% engine coolant
(antifreeze) (minimum) and dis-
tilled water for proper corrosion pro-
tection of your engine, which con-
tains aluminum components. Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, keep the front of the
condenser clean.
Do not change the thermostat for
Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsatis-
factory cooling performance, poor
gas mileage, and increased emissions.
BRAKE SYSTEMIn order to assure brake system perfor-
mance, all brake system components
should be inspected periodically. Refer
to the “Maintenance Schedule” for the
proper maintenance intervals.WARNING!
Riding the brakes can lead to brake
failure and possibly a collision.
Driving with your foot resting or
riding on the brake pedal can result
in abnormally high brake tempera-
tures, excessive lining wear, and
possible brake damage. You would
not have your full braking capacity
in an emergency.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience. Master Cylinder – Brake Fluid
Level Check
Check the fluid level in the master cyl-
inder immediately if the brake system
warning light indicates system failure.
Check the fluid level in the master cyl-
inder when performing underhood ser-
vices.Clean the top of the master cylinder
area before removing the cap. If nec-
essary, add fluid to bring the fluid
level up to the requirements described
on the brake fluid reservoir.
Overfilling of fluid is not recom-
mended because it may cause leaking
in the system.
Fluid level can be expected to fall as
the brake pads wear. Brake fluid level
should be checked when pads are re-
placed. However, low fluid level may
be caused by a leak and a checkup
may be needed.
Use only manufacturer's recom-
mended brake fluid. Refer to “Fluids,
Lubricants, and Genuine Parts” in
“Maintaining Your Vehicle” for fur-
ther information.
201

FLUID CAPACITIES
Metric
Fuel (Approximate)
All 64 Liters
Engine Oil with Filter
2.4L Engine 4.4 Liters
Cooling System*
2.4L Engine 7.3 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
FLUIDS, LUBRICANTS AND GENUINE PARTS
ENGINE
Component Fluids and Lubricants Specs (Genuine Parts)
Engine Coolant* Red protective agent with antifreeze action, based on inhibited monoethyl glycol with organic formula. Exceeds CUNA NC 956-16, ASTM D 3306 specifications, FIAT
Classification 9.55523 (PARAFLU UP Contractual Technical Reference N° F101.M01.
Cooling circuit usage percentage: 50% water 50% PARAFLU UP **)
Engine Oil**
SAE 5W-20 grade totally synthetic lubricant that meets FIAT Classification 9.55535-CR1,
API SN, ILSAC GF-5 (SELENIA K POWER, Contractual Technical Reference N° F102.F11)
Spark Plugs ZFR5F-11 (Gap 1.1 mm)
Fuel Selection 91 Octane or higher
* Do not top up or mix with fluids
with different specifications. **
For particularly harsh climate con-
ditions, a mixture of 60% PARA-
FLUUP and 40% demineralised water
is recommended.
*** In the event of an emergency in
which the original products are not
available, lubricants with at least IL-
SAC GF-5 performance are acceptable.
216

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Check windshield/rear window wiper blade position/wear.        
Check cleanliness of hood and tailgate locks and cleanliness
and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, underbody
protection, pipes and hoses (exhaust - fuel system - brakes),
rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, windshield
washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check the handbrake lever stroke and adjust it, if necessary. 
Check exhaust gas emissions.        
Check engine management system operation (via diagnostic
socket).        
Change the automatic transmission fluid and filter. (*) 
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter.**
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 kkm or
48 months if using your vehicle for
any of the following: city driving, short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
** The engine oil and the oil filter
must be changed when the instrument
panel warning light comes on or in
any case every 12 months.
223

Periodic Checks
Every1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;
 power steering fluid;
tire inflation pressure and condition; operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level. Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;

short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures; engine often idling or driving long
distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;  visually inspect conditions of: en-
gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the accessory drive belts;
 check and, if necessary, change engine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
224

About Your Brakes. . . . . . . . . . .150
ABS (Anti-Lock Brake System) . . .151
Adding Engine Coolant (Antifreeze) . . . . . . . . . . . . . .199
Adding Fuel . . . . . . . . . . . . . . .167
Adding Washer Fluid . . . . . . . . .196
Additives, Fuel . . . . . . . . . . . . . .166
Airbag . . . . . . . . . . . . . . . . . . . .31
Airbag Deployment . . . . . . . . . . .36
Airbag Light . . . . . . .34, 37, 49, 112
Airbag Maintenance . . . . . . . . . . .37
Airbag, Side . . . . . . . . . . .32, 34, 35
Airbag, Window (Side Curtain) . . . .34
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . . . . . . . .192
Air Conditioner Maintenance . . . .194
Air Conditioning Filter . . . . .136, 194
Air Conditioning, Operating Tips . . . . . . . . . . . .135
Air Conditioning Refrigerant . . . .194
Air Conditioning System . . .129, 194
Air Pressure, Tires . . . . . . . . . . .157
Alarm (Security Alarm) . . . . . . . . .15
Alarm System (Security Alarm) . . . . . . . . . . . . . .15, 116
Alterations/Modifications, Vehicle . . .7
Antifreeze (Engine Coolant) . . . . . . . . . . . .198, 216
Disposal . . . . . . . . . . . . . . .200 Anti-Lock Brake System (ABS)
. . .151
Anti-Lock Warning Light . . . . . .151
Anti-Theft Security Alarm (Theft Alarm) . . . . . . . . . . . . .15
Ashtray . . . . . . . . . . . . . . . . . .103
Auto Down Power Windows . . . . . .20
Automatic Door Locks . . . . . . . . .19
Automatic Headlights . . . . . . . . . .94
Automatic Oil Change Indicator . . . . . . . . . . . .114, 121
Automatic Temperature Control (ATC) . . . . . . . . . . . .129
Automatic Transaxle . . . . . . .12, 140
Automatic Transmission . . . .141, 202
Adding Fluid . . . . . . . . . . . .203
Fluid and Filter Changes . . . .203
Fluid Level Check . . . . . . . . .203
Fluid Type . . . . . . . . . . . . . .202
Gear Ranges . . . . . . . . . . . . .143
Autostick . . . . . . . . . . . . . . . . .147
Auto Unlock, Doors . . . . . . . . . . .19
Battery . . . . . . . . . . . . . . . . . . .193
Keyless Transmitter
Replacement (RKE) . . . . . . . . .18
Location . . . . . . . . . . . . . . .193
Belts, Seat . . . . . . . . . . . . . . .24, 48
Body Mechanism Lubrication . . . .195
Brake Assist System . . . . . . . . . .154 Brake, Parking
. . . . . . . . . . . . . .150
Brakes . . . . . . . . . . . . . . . . . . .201
Brake System . . . . . . . . . . . . . . .201
Anti-Lock (ABS) . . . . . . . . . .151
Fluid Check . . . . . . . . . . . . .201
Master Cylinder . . . . . . . . . .201
Parking . . . . . . . . . . . . . . . .150
Warning Light . . . . . . . . . . .112
Brake/Transmission Interlock . . . .142
Break-In Recommendations, New Vehicle . . . . . . . . . . . . . . .47
Bulb Replacement . . . . . . . .212, 213
Bulbs, Light . . . . . . . . . . . . .50, 212
Calibration, Compass . . . . . . . . .123
Capacities, Antifreeze (Engine Coolant) . . . . . . . . . . .16
Capacities, Fluid . . . . . . . . . . . .216
Caps, Filler Fuel . . . . . . . . . . . . . . . . . .167
Oil (Engine) . . . . . . . . . . . . .189
Power Steering . . . . . . . . . . .153
Radiator (Coolant Pressure) . .199
Carbon Monoxide Warning . . . . . .48
Car Washes . . . . . . . . . . . . . . . .204
Cellular Phone . . . . . . . . . . .67, 129
Checking Your Vehicle For Safety . . . . . . . . . . . . . . . . . . .47
Checks, Safety . . . . . . . . . . . . . . .47
226

Child Restraint. . .39, 41, 42, 44, 45
Child Restraint Tether Anchors . . . . . . . . . . . . . . .43, 44
Cigar Lighter . . . . . . . . . . . . . . .103
Clean Air Gasoline . . . . . . . . . . .165
Cleaning Wheels . . . . . . . . . . . . . . . .205
Windshield Wiper Blades . . . .196
Climate Control . . . . . . . . . . . . .129
Clock . . . . . . . . . . . . . . . . . . . .127
Compass . . . . . . . . . . . . . . . . . .122
Compass Calibration . . . . . . . . . .123
Compass Variance . . . . . . . . . . .123
Computer, Trip/Travel . . . . . .16, 122
Console . . . . . . . . . . . . . . . . . .104
Console, Floor . . . . . . . . . . . . . .104
Convertible . . . . . . . . . . . . . . . . .55
Convertible Top . . . . . . . . . . . . . .55
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . . . . . . . . . .199
Cooling System . . . . . . . . . . . . .198
Adding Coolant (Antifreeze) . .199
Coolant Capacity . . . . . . . . . .216
Coolant Level . . . . . . . .198, 200
Disposal of Used Coolant . . . .200
Drain, Flush, and Refill . . . . .198
Inspection . . . . . . . . . . . . . .200
Points to Remember . . . . . . .200
Pressure Cap . . . . . . . . . . . .199 Radiator Cap
. . . . . . . . . . . .199
Selection of Coolant
(Antifreeze) . . . . . . . . .198, 216
Corrosion Protection . . . . . . . . . .204
Crankcase Ventilation Module . . . .16
Cruise Light . . . . . . . . . . . . . . .115
Cupholders . . . . . . . . . . . .103, 206
Customer Programmable Features . . . . . . . . . . . . . . . .126
Data Recorder, Event . . . . . . . . . .38
Deck Lid, Power Release . . . . . . . .21
Defroster, Rear Window . . . . . . . .105
Defroster, Windshield . . . . . .49, 132
Delay (Intermittent) Wipers . . . . . .98
Diagnostic System, Onboard . . . . .190
Diesel Fuel . . . . . . . . . . . . . . . .216
Dimmer Switch, Headlight . . . . . . .96
Dipsticks Automatic Transmission . . . . .203
Oil (Engine) . . . . . . . . . . . . .191
Power Steering . . . . . . . . . . .153
Disabled Vehicle Towing . . . . . . .184
Disposal Antifreeze (Engine Coolant) . .200
Door Locks . . . . . . . . . . . . . . . . .18
Door Locks, Automatic . . . . . . . . .19
Driver's Seat Back Tilt . . . . . . . . .91Driving
Through Flowing, Rising, or
Shallow Standing Water . . . . .148
Electrical Power Outlets . . . . . . .102
Electric Rear Window Defrost . . . .105
Electric Remote Mirrors . . . . . . . . .66
Electronic Speed Control (Cruise Control) . . . . . . . . . . .100
Electronic Stability Control (ESC) . . . . . . . . . . . .154
Electronic Vehicle Information Center (EVIC) . . . . . . . . . . . .119
Emergency, In Case of Jump Starting . . . . . . . . . . . .179
Towing . . . . . . . . . . . . . . . .184
Engine . . . . . . . . . . . . . . . . . . .189
Air Cleaner . . . . . . . . . . . . .192
Break-In Recommendations . . .47
Checking Oil Level . . . . . . . .191
Coolant (Antifreeze) . . . .198, 216
Cooling . . . . . . . . . . . . . . . .198
Exhaust Gas Caution . . . . . . . .48
Fails to Start . . . . . . . . . . . .140
Flooded, Starting . . . . . . . . .140
Fuel Requirements . . . . .164, 216
Jump Starting . . . . . . . . . . . .179
Oil . . . . . . . . . . . . . . .191, 216
227