charging Lexus ES300 1997 Service Procedures And Specifications: Electrical Components

217
SECTION 6 ± 4
SERVICE PROCEDURES AND
SPECIFICATIONS
Electrical components
Specifications 218
Checking battery operation 222
Battery recharging precautions 226
Checking and replacing the blade type fuses 227
Checking the cartridge type fuses 229
Adding washer fluid 230
Checking the headlight aim 231
Replacing light bulbs 232

ELECTRICAL COMPONENTS
220No.
FUSEAMPERECIRCUIT
1ABS60Anti±lock brake system
2DRL NO. 25Vehicles sold in Canada
Daytime Running Light System
3H±LP
LH (LO)10Vehicles sold in Canada
Left-hand headlight (low beam)
4H±LP
RH (LO)10Vehicles sold in Canada
Right±hand headlight (low beam)
5ALT100Charging system
6CDS NO.230No circuit
7HTR30No circuit
8MAIN40Headlight, Starting system
9DOME7.5
Theft deterrent system, Clock,
Door courtesy light, Interior light,
Ignition switch light, Vanity light,
Wireless remote control system
10ECU±B10Cruise control system, Air
conditioning system, Power seat
system
11RAD NO.120Audio system
12HAZ10Emergency flashers, Turn signal
lights
13AM230Starting system
No.FUSEAMPERECIRCUIT
14TEL5Telephone
15
H±LP LH15Vehicles sold in U.S.A.
Left±hand headlight (high beam)
15H±LP
LH HI15Vehicles sold in Canada
Left±hand headlight (high beam)
16ALT±S5Charging system
17
H±LP RH15Vehicles sold in U.S.A.
Right±hand headlight (high beam)
17H±LP RH
HI15Vehicles sold in Canada
Right±hand headlight (high beam)
18EFI15Multiport fuel injection
19HORN10Theft deterrent system
20RDI FAN30Electronic cooling fan system
21CDS30Air conditioning system
22A/C10No circuit
23S±HTR20Seat heater system
24HTR10Air conditioning system
25GAUGE10
Gauges and measures, service
reminder indicators and warning
buzzers, Back±up light, Door
courtesy light, Seat heater, Power
window system
26WIP20Windshield wipers and washer

ELECTRICAL COMPONENTS
224(a) Checking by the fluid level lines (Maintenance type
battery only)


Upper line Lower line
The fluid (electrolyte) level must be between the upper
and lower lines.
When checking the fluid level, look at all six cells, not just one
or two.
If the level is lower than the lower line, add distilled water.
(See ªAdding distilled waterº on page 225.)(b) Checking the hydrometer
Check the battery condition by the hydrometer color.
Maintenance type battery

RED ± Add distilled water. (See ªAdding distilled waterº
on page 225.)
BLUE ± Good condition
WHITE ± Charging necessary. Have the battery checked
by your Lexus dealer.
Non±maintenance type battery

RED ± Have the battery checked by your Lexus dealer.
BLUE ± Good condition.
WHITE ± Charging necessary. Have the battery checked
by your Lexus dealer.

ELECTRICAL COMPONENTS
225
NOTICE
For non±maintenance battery:
Do not refill the battery with water.Adding distilled water
(Maintenance type battery only)


Low O.K.
1. Remove the vent plugs.
2. Add distilled water to cells needing fluid.
If the side of the battery is covered, check the water level by
looking down directly above the cell as illustrated above.
3. Retighten the vent plugs securely.
NOTICE
Do not overfill the cells. Excess electrolyte could
squirt out of the battery during heavy charging,
causing corrosion or damage.
Use a cover on the battery for longer life.

ELECTRICAL COMPONENTS
226
BATTERY RECHARGING
PRECAUTIONS
During recharging, the battery is producing hydrogen
gas.
Therefore, before recharging:
1. Maintenance type batteries ± Remove the vent plugs.
2. If recharging with the battery installed on the vehicle, be
sure to disconnect the ground cable.
3. Make sure the power switch on the recharger is off when
connecting the charger cables to the battery and when
disconnecting them.
CAUTION!
Always charge the battery in an unconfined area.
Do not charge the battery in a garage or closed
room where there is not sufficient ventilation.
Non±maintenance batteries: Only do a slow
charge (5A or less). Charging at a quicker rate is
dangerous. The battery may explode causing
personal injuries.
Maintenance type batteries: Be sure to remove
the vent plugs before recharging.
NOTICE
Never recharge the battery while the engine is
running. Also, be sure all accessories are turned
off.