engine Lexus ES300h 2018 (OM33D45U) Repair Manual

ES300h_OM_OM33D45U_(U)
5439-1. Specifications
9
Vehicle specifications
Cooling system
Capacity
Gasoline
engine7.6 qt. (7.2 L, 6.3 Imp.qt.)
Power
control unit
3.4 qt. (3.2 L, 2.8 Imp.qt.)
Coolant type
Use either of the following:
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based non-sili-
cate, non-amine, non-nitrite, and non-borate cool-
ant with long-life hybrid organic acid technology
Do not use plain water alone.
Ignition system
Spark plug
MakeDENSO FK16HR-A8
Gap0.031 in. (0.8 mm)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
Electrical system
12-volt battery
Open voltage at 68°F
(20° C):12.0 V or higher
(Voltage is checked 20 minutes after the hybrid system
and all lights are turned off.)
Charging rates5 A max.

547
ES300h_OM_OM33D45U_(U)9-1. Specifications
9
Vehicle specifications
Fuel information
■Gasoline quality
In very few cases, driveabilit
y problems may be caused by th e brand of gasoline you are
using. If driveability problems persist, try ch anging the brand of gasoline. If this does not
correct the problem, consult your Lexus dealer.
■Gasoline quality standards
●Automotive manufacturers in the U.S.A., Europe and Japan have developed a specifi-
cation for fuel quality calle d the World-Wide Fuel Charte r (WWFC), which is expected
to be applied worldwide.
●The WWFC consists of four categories that are based on required emission levels. In
the U.S., category 4 has been adopted.
●The WWFC improves air quality by lowering emissions in vehicle fleets, and improves
customer satisfaction th rough better performance.
■Recommendation of the use of gasoline containing detergent additives
●Lexus recommends the use of gasoline that contains detergent additives to avoid the
build-up of engine deposits.
●All gasoline sold in the U.S.A. contains minimum detergent additives to clean and/or
keep clean intake systems, per EPA’s lowest additives concentration program.
●Lexus strongly recommends the use of Top Tier Detergent Gasoline. For more informa-
tion on Top Tier Detergent Gasoline and a lis t of marketers, please go to the official
website www.toptiergas.com.
■Recommendation of the use of cleaner burning gasoline
Gasolines containing oxygenates such as et hers and ethanol, as well as reformulated
gasolines, are available in some cities. Thes e fuels are typically acceptable for use, pro-
viding they meet other fuel requirements.
Lexus recommends these fuels, since the form ulations allow for reduced vehicle emis-
sions.
You must only use unleaded gasoline.
Select octane rating 87 (Research Octane Number 91) or higher. Use of
unleaded gasoline with an octane rating lower than 87 may result in engine
knocking. Persistent knocking can lead to engine damage.
At minimum, the gasoline you use should meet the specifications of ASTM
D4814 in the U.S.A..

548
ES300h_OM_OM33D45U_(U)9-1. Specifications
■Non-recommendation of the use of blended gasoline
●If you use gasohol in your vehicle, be sure that it has an octane ra
ting no lower than 87.
●Lexus does not recommend the use of gasoline containing methanol.
■Non-recommendation of the use of gasoline containing MMT
Some gasoline contains an octane enhancing additive called MMT (Methylcyclopenta-
dienyl Manganese Tricarbonyl).
Lexus does not recommend the use of gasoline that contains MMT. If fuel containing
MMT is used, your emission control system may be adversely affected.
The malfunction indicator lamp on the instru ment cluster may come on. If this happens,
contact your Lexus dealer for service.
■If your engine knocks
●Consult your Lexus dealer.
●You may occasionally notice light knocking for a short time while accelerating or driv-
ing uphill. This is normal and there is no need for concern.
●Use only gasoline containing up to 15% etha-
nol.
DO NOT use any flex-fuel or gasoline that
could contain more than 15% ethanol, includ-
ing from any pump labeled E30, E50, E85
(which are only some examples of fuel con-
taining more than 15% ethanol).DO NOT use gasoline con-
taining more than 15% ethanol.
(30% ethanol)
(50% ethanol)
(85% ethanol)

ES300h_OM_OM33D45U_(U)
5499-1. Specifications
9
Vehicle specifications
NOTICE
■Notice on fuel quality
●Do not use improper fuels. If improper fuels are used, the engine will be damaged.
●Do not use leaded gasoline.
Leaded gasoline can cause damage to your vehicle’s three-way catalytic converters
causing the emission control system to malfunction.
●Do not use gasohol other than the type previously stated.
Other gasohol may cause fuel system damage or vehicle performance problems.
●Using unleaded gasoline with an octane numb er or rating lower than the level previ-
ously stated will cause pe rsistent heavy knocking.
At worst, this will lead to engine damage.
■Fuel-related poor driveability
If poor driveability is encountered after using a different type of fuel (poor hot starting,
vaporization, engine knocking, etc.), discontinue the use of that type of fuel.
■When refueling with gasohol
Take care not to spill gasohol. It can damage your vehicle’s paint.

556
ES300h_OM_OM33D45U_(U)9-1. Specifications
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pressure
Tire pressure when the vehicle has been parked for
three hours or more, or has no
t been driven more than 1
mile or 1.5 km un der that condition
Maximum inflation pres-
sureThe maximum cold inflated pr essure to which a tire may
be inflated, shown on the sidewall of the tire
Recommended inflation
pressureCold tire inflation pressure recommended by a manu-
facturer
Accessory weight
The combined weight (in exce ss of those standard items
which may be replaced) of hybrid transmission, power
steering, power brakes, power windows, power seats,
radio and heater, to the extent that these items are avail-
able as factory-installed eq uipment (whether installed
or not)
Curb weight
The weight of a motor vehicle with standard equipment,
including the maximum capacity of fuel, oil and coolant,
and if so equipped, air co nditioning and additional
weight optional engine
Maximum loaded vehicle
weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight
Normal occupant weight150 lb. (68 kg) times the numb er of occupants specified
in the second column of Table 1* that follows
Occupant distributionDistribution of occupants in a vehicle as specified in the
third column of Table 1
* below
Production options weight
The combined weight of in stalled regular production
options weighing over 5 lb. (2.3 kg) in excess of the
standard items which they re place, not previously con-
sidered in curb weight or accessory weight, including
heavy duty brakes, ride levelers, roof rack, heavy duty
battery, and special trim
RimA metal support for a tire or a tire and tube assembly
upon which the tire beads are seated
Rim diameter
(Wheel diameter)Nominal diameter of the bead seat
Rim size designationRim diameter and width
Rim type designationThe industry manufacturer’s designation for a rim by
style or code

592Alphabetical index
ES300h_OM_OM33D45U_(U)
Emergency, in case ofIf a warning buzzer sounds................................................. 503
If a warning light turns on.............. 503
If a warning message is displayed ....................................... 509
If the 12-volt battery is discharged ......................................... 527
If the electronic key does not operate properly ....... 525
If the hybrid system will not start ................................................523
If you have a flat tire ........................... 513
If you think something is wrong.............................................. 502
If your vehicle becomes stuck ..................................................... 535
If your vehicle has to be stopped in an emergency .......... 497
If your vehicle needs to be towed ...................................... 498
If your vehicle overheats ................. 531
Emergency flashers ............................. 496
Energy monitor .........................................97 Engine
Accessory mode .................................169
Compartment ..................................... 447
Hood........................................................ 445
How to start the hybrid system ................................................... 168
Identification number.......................540
Ignition switch (power switch) ..... 168
Overheating...........................................531
Power switch. ....................................... 168
Engine compartment cover............. 448
Engine coolant Capacity................................................. 543
Checking ............................................... 453
Preparing and checking before winter ....................................280
Engine coolant temperature gauge ........................................................ 86
Engine oil Capacity...................................................541
Checking ............................................... 449
Preparing and checking before winter ....................................280

595Alphabetical index
ES300h_OM_OM33D45U_(U)
I/M test ..................................................... 442
IdentificationEngine ..................................................... 540
Vehicle ................................................... 539
Ignition switch (power switch) ......... 168
Illuminated entry system .................... 398
Immobilizer system..................................76
Indicators .................................................... 84
Initialization Maintenance......................................... 437
Tire pressure warning system................................462
Initiators (tire pressure warning system)................................. 469
Inside rear view mirror ........................ 140
Instrument panel light control ............ 87
Interior light............................................. 396
Intuitive parking assist Function .................................................. 237 Jack
Positioning a floor jack.................... 446
Vehicle-equipped jack .....................514
Jack handle ...................................................514
Jam protection function Moon roof ...............................................149
Power trunk opener and closer ............................................. 116
Power windows....................................145
Keyless entry Smart access system with push-button start................... 108
Wireless remote control................. 108
Keys Battery-saving function .................... 123
Electronic key ........................................104
If the electronic key does not operate properly ........ 525
Key number plate ................................104
Keyless entry ......................................... 108
Mechanical key.................................... 105
Power switch ........................................ 168
Replacing the battery ...................... 478
Warning buzzer................................... 122
Wireless remote control key ........ 108
Knee airbags .............................................. 37
IJ
K
*: For vehicles with navigation system, refer to the
“NAVIGATION SYSTEM OWNER’S MANUAL”.

597Alphabetical index
ES300h_OM_OM33D45U_(U)
MirrorsInside rear view mirror ..................... 140
Outside rear view mirror defoggers .......................................... 388
Outside rear view mirrors ...............142
Vanity mirrors ..................................... 405
Moon roof Door lock linked moon roof operation ..................... 149
Jam protection function ................... 149
Operation ............................................... 148
MP3 disc
*................................................ 318
Multi-information display .......................91 Drive information .................................. 92
Dynamic radar cruise control...... 225
Energy monitor ...................................... 97
Language ...............................................562
Switching the display........................... 92
Trip information ..................................... 87
Warning message ............................ 509
Navigation system
*
Noise from under vehicle ....................... 8 Odometer .................................................. 86
Oil
Engine oil .................................................541
Opener Hood........................................................ 445
Trunk ............................................................114
Ornament lights ................................... 396
Outer foot lights Outer foot lights ................................. 396
Replacing light bulbs ....................... 492
Wattage ................................................. 546
Outside rear view mirrors Adjusting and folding ........................ 142
Blind spot monitor ............................ 264
Linked mirror function when reversing.................................. 143
Mirror position memory ................. 130
Outside rear view mirror defoggers........................... 388
Outside temperature display ............. 86
Overheating............................................. 531
N
O
*: For vehicles with navigation system, refer to the
“NAVIGATION SYSTEM OWNER’S MANUAL”.

608
ES300h_OM_OM33D45U_(U)GAS STATION INFORMATION
Auxiliary catch leverTrunk openerFuel filler door
P. 445 P. 114 P. 196
Hood lock release leverFuel filler door openerTire inflation pressure
P. 445 P. 196 P. 545
Fuel tank capacity
(Reference) 17.0 gal. (64.35 L, 14.2 Imp.gal.)
Fuel type
Unleaded gasoline only P. 540
Cold tire inflation
pressure P. 545
Engine oil capacity
(Drain and refill —
reference)qt. (L, Imp.qt.)
With filter 4.6 (4.4, 3.9)
Without filter 4.2 (4.0, 3.5)
Engine oil type “Toyota Genuine Motor
Oil” or equivalent
Oil grade: ILSAC GF-5 multigrade engine oil
Recommended viscosity: SAE 0W-20
P. 541