fuel pressure Lexus ES330 2004 Destination Input and Route Guidance / LEXUS 2004 ES330 OWNER'S MANUAL (OM33633U)

IMPORTANT INFORMATION ABOUT YOUR LEXUS
iv
Accessories, spare parts and modification of
your Lexus
A wide variety of non-genuine spare parts and accessories for
Lexus vehicles are currently available in the market. You
should know that Toyota does not warrant these products and
is not responsible for their performance, repair, or
replacement, or for any damage they may cause to, or adverse
effect they may have on, your Lexus vehicle.
This vehicle should not be modified with non-genuine Lexus
products. Modification with non- genuine Lexus products
could affect its performance, safety or durability, and may even
violate governmental regulations. In addition, damage or
performance problems resulting from the modification may not
be covered under warranty.
Spark ignition system of your Lexus
The spark ignition system in your Lexus meets all
requirements of the Canadian Interference- Causing
Equipment Standard.
Installation of a mobile two-way radio system
As the installation of a mobile two-way radio system in your
vehicle could affect electronic systems such as the multiport
fuel injection system/sequential multiport fuel injection system,
cruise control system, anti-lock brake system, SRS airbag
system and seat belt pretensioner system, be sure to check
with your Lexus dealer for precautionary measures or special
instructions regarding installation.
Tires and loading on your Lexus
Underinflated or overinflated tire pressure and the
excess load may result in the deterioration of steering
ability and braking ability, leading to an accident.
Check the tire inflation pressure periodically and be
sure to keep the load limits given in this Owner's
Manual. For details about tire inflation pressure and
load limits, see pages 389 and 309.
Scrapping of your Lexus
The SRS airbag and seat belt pretensioner devices in your
Lexus contain explosive chemicals. If the vehicle is scrapped
with the airbags and seat belt pretensioners left as they are,
this may cause an accident such as fire. Be sure to have the
systems of the SRS airbag and seat belt pretensioner removed
and disposed of by a qualified service shop or by your Lexus
dealer before you scrap your vehicle.

For detailed information, refer to the description given in each Section.
PICTORIAL INDEX
xi
Page
1Tachometer 53. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Traction control system off indicator light 284. . . .
3Vehicle stability control system/traction control
system warning light 64. . . . . . . . . . . . . . . . . . . . . . . . . .
4Engine oil replacement reminder light 61. . . . . . . . . .
5Headlight indicator light 34. . . . . . . . . . . . . . . . . . . . . . .
6Headlight high beam indicator light 40. . . . . . . . . . . .
7Turn signal indicator light 40. . . . . . . . . . . . . . . . . . . . .
8Fog light indicator light 41. . . . . . . . . . . . . . . . . . . . . . . .
9Cruise control indicator light 279. . . . . . . . . . . . . . . .
10Slip indicator light 283, 286. . . . . . . . . . . . . . . . . . . . . .
11Automatic headlight leveling system
warning light 64. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12Low fuel level warning light 64. . . . . . . . . . . . . . . . . . . .
13Automatic transmission indicator lights 272. . . . . .
14Engine coolant temperature gauge 51. . . . . . . . . . . . . Page
15Odometer and trip meter 54. . . . . . . . . . . . . . . . . . . . . .
16Trip meter reset knob 54. . . . . . . . . . . . . . . . . . . . . . . . .
17Fuel gauge 50. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
18Low washer fluid warning light 64. . . . . . . . . . . . . . . . .
19Low engine oil level warning light 60. . . . . . . . . . . . . .
20Multi-information display 66. . . . . . . . . . . . . . . . . . . . . .
21Rear light failure warning light 64. . . . . . . . . . . . . . . . .
22Low engine oil pressure warning light 59. . . . . . . . . .
23Brake system warning light 56. . . . . . . . . . . . . . . . . . . .
24Anti-lock brake system warning light 62. . . . . . . . . . .
25Driver's seat belt reminder light 57. . . . . . . . . . . . . . . .
26Discharge warning light 58. . . . . . . . . . . . . . . . . . . . . . .
27SRS warning light 57. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
28Open door warning light 63. . . . . . . . . . . . . . . . . . . . . . .
29Malfunction indicator lamp 61. . . . . . . . . . . . . . . . . . . .

For detailed information, refer to the description given in each Section.
PICTORIAL INDEX
xiii
Page
1Tachometer 53. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2Traction control system off indicator light 284. . . .
3Vehicle stability control system/traction control
system warning light 64. . . . . . . . . . . . . . . . . . . . . . . . . .
4Tail light indicator light 37. . . . . . . . . . . . . . . . . . . . . . . .
5Headlight high beam indicator light 40. . . . . . . . . . . .
6Turn signal indicator light 40. . . . . . . . . . . . . . . . . . . . .
7Fog light indicator light 41. . . . . . . . . . . . . . . . . . . . . . . .
8Cruise control indicator light 279. . . . . . . . . . . . . . . .
9Slip indicator light 283, 286. . . . . . . . . . . . . . . . . . . . . .
10Automatic headlight leveling system
warning light 64. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11Low fuel level warning light 64. . . . . . . . . . . . . . . . . . . .
12Automatic transmission indicator lights 272. . . . . .
13Engine coolant temperature gauge 51. . . . . . . . . . . . . Page
14Odometer and trip meter 54. . . . . . . . . . . . . . . . . . . . . .
15Trip meter reset knob 54. . . . . . . . . . . . . . . . . . . . . . . . .
16Fuel gauge 50. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17Low washer fluid warning light 64. . . . . . . . . . . . . . . . .
18Low engine oil level warning light 60. . . . . . . . . . . . . .
19Multi-information display 66. . . . . . . . . . . . . . . . . . . . . .
20Rear light failure warning light 64. . . . . . . . . . . . . . . . .
21Low engine oil pressure warning light 59. . . . . . . . . .
22Brake system warning light 56. . . . . . . . . . . . . . . . . . . .
23Anti-lock brake system warning light 62. . . . . . . . . . .
24Driver's seat belt reminder light 57. . . . . . . . . . . . . . . .
25Discharge warning light 58. . . . . . . . . . . . . . . . . . . . . . .
26SRS warning light 57. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
27Open door warning light 63. . . . . . . . . . . . . . . . . . . . . . .
28Malfunction indicator lamp 61. . . . . . . . . . . . . . . . . . . .

EXTERIOR EQUIPMENT
96
FUEL TANK CAP
This indicates that the fuel filler door is on the left side of
your vehicle.
1. To open the fuel filler door, push the switch.
When refueling, turn off the engine.
CAUTION
Do not smoke, cause sparks or allow open flames
when refuelling. The fumes are flammable.
When opening the cap, do not remove the cap
quickly. In hot weather, fuel under pressure could
cause injury by spraying out of the filler neck if the
cap is suddenly removed.

EXTERIOR EQUIPMENT
97
2. To remove the fuel tank cap, turn the cap
counterclockwise by 90 degrees (to the pressure point
1), and then turn it an additional 30 degrees (to point2). Pause slightly before removing it.
It is not unusual to hear a slight swoosh when the cap is
opened.
3. The removed cap can be stored on the back side of the
fuel filler door.
Position the cap so that the hooks point to the left and right, and
set it in the receptacle on the back side of the door.

EXTERIOR EQUIPMENT
98When installing the cap, turn the cap clockwise until you
hear a click. When you hear the click, the cap is fully
closed.
If the cap is not tightened securely, the malfunction indicator
lamp comes on. Make sure the cap is tightened securely.
The indicator lamp goes off after driving several times. If the
indicator lamp does not go off, contact your Lexus dealer as
soon as possible.
CAUTION
Make sure the cap is installed securely to prevent fuel
spillage in the event of an accident.
Use only a genuine Lexus fuel tank cap for
replacement. It is designed to regulate fuel tank
pressure.
NOTICE
To prevent damage to the cap, apply force only in the
turning direction to the cap. Do not pull or pry it.

DRIVING TIPS
307 3. Release the parking brake and brake pedal and slowly pull
or back away from the wheel blocks. Stop and apply your
brakes.
4. Have someone retrieve the blocks.
CAUTION
Do not exceed 72 km/h (45 mph) or the posted towing
speed limit, whichever is lower. Because instability
(swaying) of a towing vehicle-trailer combination
usually increases as the speed increases, exceeding
72 km/h (45 mph) may cause loss of control.
Slow down and downshift before descending steep
or long downhill grades. Do not make sudden
downshifts.
Avoid holding the brake pedal down too long or too
frequently. This could cause the brakes to overheat
and result in reduced braking efficiency.
HOW TO SAVE FUEL AND MAKE
YOUR VEHICLE LAST LONGER
Improving fuel economy is easy Ð just take it easy. It will help
make your vehicle last longer, too. Here are some specific tips
on how to save money on both fuel and repairs:
Keep your tires inflated at the correct pressure. Check
the pressure every two weeks, or at least once a month.
Underinflation causes tire wear and wastes fuel.
Do not carry unneeded weight in your vehicle. Excess
weight puts a heavier load on the engine, causing greater
fuel consumption.
Avoid lengthy warm-up idling. Once the engine is
running smoothly, begin driving Ð but gently. Remember,
however, that on cold winter days this may take a little
longer.
Always drive with the automatic transmission selector
lever in the Dº position when engine braking is not
required. Driving with the overdrive off will reduce the fuel
economy. (For details, see Automatic transmissionº on
page 272.)
Accelerate slowly and smoothly. Avoid jackrabbit starts.
Avoid long engine idling. If you have a long wait and you
are not in traffic, it is better to turn off the engine and start
again later.

MAINTENANCE
347 Accelerator pedal
Check the pedal for smooth operation and uneven pedal effort
or catching.
Brake pedal
Check the pedal for smooth operation and the proper
clearance and freeplay. Check the brake booster function.
Brakes
At a safe place, check that the brakes do not pull to one side
when applied.
Parking brake
Check that the pedal has the proper travel and that, on a safe
incline, your vehicle is held securely with only the parking brake
applied.
Automatic transmission Parkº mechanism
On a safe incline, check that your vehicle is held securely with
the selector lever in Pº position and all brakes released.
Vehicle exterior
Items listed below should be performed from time to time,
unless otherwise specified.
Wheel nuts
When checking the tires, make sure to check the nuts for
looseness. Tighten them if necessary.Fluid leaks
Check underneath for leaking fuel, oil, water or other fluid after
the vehicle has been parked for a while. If you smell fuel fumes
or notice any leak, have the cause found and corrected
immediately.
Doors and engine hood
Check that all doors, including trunk lid, operate smoothly and
all latches lock securely. Make sure the engine hood
secondary latch secures the hood when the primary latch is
released.
Tire inflation pressure
Check the tire inflation pressure with a gauge every
two weeks, or at least once a month and adjust as
shown on the tire and loading information label. See
page 389 for additional information.
Tire surface
Check the tires carefully for cuts, damage or
excessive wear. See page 402 for additional
information.
Tire rotation
Rotate the tires according to the maintenance
schedule. (For scheduled maintenance information,
please refer to the Owner's Manual
Supplement/Scheduled Maintenanceº.) See page 401
for additional information.

ENGINE
368
CAUTION
Inspect the ground under the vehicle before restarting
the engine. If you find that liquid has leaked onto the
ground, it is the fuel system has been damaged and it is
in need of repair. In this case, do not restart the engine.
FACTS ABOUT ENGINE OIL
CONSUMPTION
Functions of engine oil
Engine oil has the primary function of lubricating and cooling
the inside of the engine, and plays a major role in maintaining
the engine in proper working order.
Engine oil consumption
It is normal that an engine should consume some engine
oil during normal engine operation. The causes of oil
consumption in a normal engine are as follows.
Oil is used to lubricate pistons, piston rings and cylinders.
A thin film of oil is left on the cylinder wall when a piston
moves downwards in the cylinder. High negative pressure
generated when the vehicle is decelerating sucks some of
this oil into the combustion chamber. This oil as well as
some part of the oil film left on the cylinder wall is burned by
the high temperature combustion gases during the
combustion process.
Oil is also used to lubricate the stems of the intake valves.
Some of this oil is sucked into the combustion chamber
together with the intake air and is burned along with the fuel.
High temperature exhaust gases also burn the oil used to
lubricate the exhaust valve stems.
The amount of engine oil consumed depends on the
viscosity of the oil, the quality of the oil and the way the
vehicle is driven.

CHASSIS
390
Inspection and adjustment procedure

1Tire valve
2Tire pressure gauge
1. Remove the tire valve cap.
2. Press the tip of the tire pressure gauge to the tire
valve.
3. Read the pressure using a graduation of the gauge.
4. In case that the tire inflation pressure is not within
the prescribed range, insert the compressed air from
the valve. In case of applying too much air, press
the center of the valve and release the air to adjust.
5. After completing the tire inflation pressure
measurement and adjustment, apply soap water to
the valve and check the leakage.
6. Install the tire valve cap.If the gauge and the air pump are not available, have
your vehicle checked by your Lexus dealer.
CAUTION
Be sure to reinstall the tire valve caps. Without
the valve caps, dirt or moisture could get into
the valve core and cause air leakage. If the caps
have been lost, have new ones put on as soon
as possible.
Incorrect tire inflation pressure may waste fuel, reduce
the comfort of driving, reduce tire life and make your
vehicle less safe to drive.
If a tire frequently needs refilling, have it checked by
your Lexus dealer.