Lexus GS350 2015 Warranty and Services Guide

59
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
108 Months or 90,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

60
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
114 Months or 95,000 Miles
❑ Inspect and adjust all fluid levels
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
Note: If 0W-20 oil was not used at last oil
change, or if you drive primarily under certain
special operating conditions, you should also
replace the engine oil with 0W-20 oil and
replace the oil filter. See page 44 for conditions
that apply. Some conditions require additional
maintenance. See below.
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
120 Months or 100,000 Miles
❑ Replace engine oil with 0W-20 oil;
replace oil filter
❑ Replace cabin air filter
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Replace engine coolant (see page 69)
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
1 Applies to models with same size front and rear tires and wheels.
Date: _______ Mileage: ________Date: _______ Mileage: ________

61
SCHEDULED MAINTENANCE LOG
Scheduled Maintenance Log
126 Months or 105,000 Miles
❑ Inspect and adjust all fluid levels
❑ Replace Smart Key battery
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Drive belt
__ Exhaust pipes and mountings
Note: If 0W-20 oil was not used at last oil change, or if you drive primarily under certain special operating
conditions, you should also replace the engine oil with 0W-20 oil and replace the oil filter. See page 44 for
conditions that apply. Some conditions require additional maintenance. See below.
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect engine air filter
❑ Tighten nuts and bolts on chassis __ Front differential oil (AWD)
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Wiper blades
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________
MAINTENANCE

62
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
132 Months or 110,000 Miles
❑ Replace engine oil with 0W-20 oil;
replace oil filter
❑ Replace cabin air filter
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
138 Months or 115,000 Miles
❑ Inspect and adjust all fluid levels
❑ Inspect engine coolant (see page 69)
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
Note: If 0W-20 oil was not used at last oil
change, or if you drive primarily under certain
special operating conditions, you should also
replace the engine oil with 0W-20 oil and
replace the oil filter. See page 44 for conditions
that apply. Some conditions require additional
maintenance. See below.
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
1 Applies to models with same size front and rear tires and wheels.
Date: _______ Mileage: ________Date: _______ Mileage: ________

63
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
144 Months or 120,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Replace spark plugs1
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires2
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1Required under the terms of the Emission Control Warranty.
2 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

64
SCHEDULED MAINTENANCE LOG
Scheduled Maintenance Log
150 Months or 125,000 Miles
❑ Inspect and adjust all fluid levels
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
Note: If 0W-20 oil was not used at last oil
change, or if you drive primarily under certain
special operating conditions, you should also
replace the engine oil with 0W-20 oil and
replace the oil filter. See page 44 for conditions
that apply. Some conditions require additional
maintenance. See below.
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
156 Months or 130,000 Miles
❑ Replace engine oil with 0W-20 oil;
replace oil filter
❑ Replace cabin air filter
❑ Inspect engine coolant (see page 69)
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
1 Applies to models with same size front and rear tires and wheels.
Date: _______ Mileage: ________Date: _______ Mileage: ________
MAINTENANCE

65
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
162 Months or 135,000 Miles
❑ Inspect and adjust all fluid levels
❑ Replace Smart Key battery
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Drive belt
__ Exhaust pipes and mountings
Note: If 0W-20 oil was not used at last oil change, or if you drive primarily under certain special operating
conditions, you should also replace the engine oil with 0W-20 oil and replace the oil filter. See page 44 for
conditions that apply. Some conditions require additional maintenance. See below.
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect engine air filter
❑ Tighten nuts and bolts on chassis __ Front differential oil (AWD)
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Wiper blades
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

66
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
168 Months or 140,000 Miles
❑ Replace engine oil with 0W-20 oil;
replace oil filter
❑ Replace cabin air filter
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
174 Months or 145,000 Miles
❑ Inspect and adjust all fluid levels
❑ Inspect engine coolant (see page 69)
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Inspect wiper blades
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
Note: If 0W-20 oil was not used at last oil
change, or if you drive primarily under certain
special operating conditions, you should also
replace the engine oil with 0W-20 oil and
replace the oil filter. See page 44 for conditions
that apply. Some conditions require additional
maintenance. See below.
If you drive primarily under this
special operating condition, perform
these additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect axle shaft boots
❑ Inspect ball joints and dust covers
❑ Inspect engine air filter
❑ Inspect steering linkage and boots
❑ Tighten nuts and bolts on chassis
1 Applies to models with same size front and rear tires and wheels.
Date: _______ Mileage: ________Date: _______ Mileage: ________

67
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
180 Months or 150,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace engine coolant (see page 69)
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

68
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
The following descriptions are provided
to give you a better understanding of
the maintenance services that should
be performed on your vehicle. The
scheduled maintenance log indicates
at which time/mileage intervals each
service should be performed. Please
note that many maintenance services
should be performed only by a
qualified technician.
Axle Shaft Boots
Check the axle shaft boots and
clamps for cracks, deterioration
and damage. Replace any damaged
parts and, if necessary, repack
the grease. A qualified technician
should perform these operations.
Ball Joints and Dust Covers
Check the suspension and steering
linkage ball joints for looseness
and damage. Check all dust covers
for deterioration and damage. A
qualified technician should perform
these inspections.
Body Inspection
Visually check for corrosion, scratches
and other damage. Check outer
body panels, inner panels of the
hood and doors, and underneath the
vehicle. Apply touch-up paint to any
chips and scratches or have them
repaired by a qualified technician.
Brake Fluid
Replace using fluid type specified in
your Owner’s Manual. A qualified tech-
nician should perform this operation.
Brake Lines and Hoses
Visually inspect for proper installation.
Check for chafing, cracks, deterioration
and signs of leakage. Replace any
deteriorated or damaged parts.
A qualified technician should perform
these operations.
Brake Pads, Calipers and Rotors
Check brake pads and rotors for
excessive wear; check brake rotors for
runout. Check brake calipers for fluid
leakage. Some models are equipped
with directional rotors. When servicing
these rotors, reinstall at same location.
A qualified technician should perform
these operations.
For further information on
maintenance services that you
can perform yourself, see the
maintenance sections of your
Owner’s Manual.