belt Lexus GS350 2015 Warranty and Services Guide

18
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects
in materials or workmanship of any
part supplied by Lexus, subject to the
exceptions indicated under “What Is
Not Covered” on pages 19–20.
Coverage is for 48 months or
50,000 miles, whichever occurs
first, with the exception of wheel
alignment and wheel balancing,
which are covered for 12 months or
12,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed
to correct defects in materials or
workmanship of any component listed
here and supplied by Lexus, subject to
the exceptions indicated under “What
Is Not Covered” on pages 19–20.
Coverage is for 72 months or
70,000 miles, whichever occurs first.
Engine
Cylinder block and head and all
internal parts, timing belt and cover,
flywheel, oil pan, water pump, fuel
pump, engine mounts, engine control
computer, seals and gaskets.
Transmission and Transaxle
Case and all internal parts,
torque converter, clutch
cover, mounts, engine control
computer, seals and gaskets.
Front-Wheel-Drive System
Drive shaft, axle, hub, bearings,
seals and gaskets.
Rear-Wheel-Drive System
Differential carrier assembly, drive
shaft, axle carrier, axle case, axle
bearing, axle shaft, seals and gaskets.
Restraint Systems Warranty
This warranty covers repairs needed
to correct defects in materials or
workmanship of any seatbelt or air bag
system supplied by Lexus, subject to
the exceptions indicated under “What
Is Not Covered” on pages 19–20.
Coverage is for 72 months or
70,000 miles, whichever occurs first.
For vehicles sold and registered in
Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.
WHAT IS COVERED
AND HOW LONG
Your Warranties in Detail
NEW VEHICLE LIMITED WARRANTY
WARRANTY

24
Evaporative Control System
•
Charcoal canister
• Diaphragm valve
• Fuel filler cap
• Fuel tank
• Vapor liquid separator
Exhaust Gas Recirculation
(EGR) System
•
EGR gas temperature sensor
• E G R v a l v e
• Associated parts
Ignition System
•
Distributor and internal parts
• Ignition coil and ignitor
• Ignition wires
• S p a r k p l u g s *
Positive Crankcase Ventilation
(PCV) System
•
Oil filler cap
• PCV valve or orifice
Other Parts Used in
Systems Listed
•
Data link connector (8/80)
• Hoses, clamps, fittings, tubing
and mounting hardware
• Malfunction indicator
light and bulb (8/80)
• Pulleys, belts and idlers
• Sealing gaskets and devices
• Sensors, solenoids,
switches and valves
Your Warranties in Detail
FEDERAL EMISSION CONTROL WARRANTY
WARRANTY
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
*Warranted until first required maintenance under terms of the California Emission Control Warranty.

28
The California Air Resources Board
(CARB) and Lexus are pleased to
explain the emission control system
warranty for your 2015 vehicle. In
California, new motor vehicles must
be designed, built and equipped to
meet the state’s stringent anti-smog
standards. CARB regulations require
that Lexus must warrant the emission
control system on your vehicle for
the time periods indicated on the
next page, provided there has been
no abuse, neglect or improper
maintenance of your vehicle.
Your emission control system may
include parts such as the fuel
injection system, ignition system,
catalytic converter and engine
computer. Also included may be
hoses, belts, connectors and other
emissions-related assemblies.
Where a warrantable condition exists,
Lexus will repair your vehicle at no
cost to you, including diagnosis, parts
and labor.
YOUR WARRANTY
RIGHTS AND
OBLIGATIONS
Your Warranties in Detail
CALIFORNIA EMISSION CONTROL WARRANTY
WARRANTY
Vehicles equipped with a
California Certified Emission
Control System that are regis-
tered and operated in California
or any state that adopts California
emission warranty provisions
are covered by this warranty.
Connecticut, Delaware, Maine,
Maryland, Massachusetts, New
Jersey, Oregon, Pennsyl vania,
Rhode Island, Vermont and
Washington are the other states
to which this warranty currently
applies. Vehicles covered by this
war ranty are also covered by
the Federal Emission Control
Warranty (see page 22).

55
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
72 Months or 60,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Replace spark plugs1
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires2
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Required under the terms of the Emission Control Warranty.
2Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

57
SCHEDULED MAINTENANCE LOG
Scheduled Maintenance Log
90 Months or 75,000 Miles
❑ Inspect and adjust all fluid levels
❑ Replace Smart Key battery
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Drive belt
__ Engine coolant (see page 69)
Note: If 0W-20 oil was not used at last oil change, or if you drive primarily under certain special operating
conditions, you should also replace the engine oil with 0W-20 oil and replace the oil filter. See page 44 for
conditions that apply. Some conditions require additional maintenance. See below.
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect engine air filter
❑ Tighten nuts and bolts on chassis __ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Wiper blades
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________
MAINTENANCE

59
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
108 Months or 90,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Engine coolant (see page 69)
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

61
SCHEDULED MAINTENANCE LOG
Scheduled Maintenance Log
126 Months or 105,000 Miles
❑ Inspect and adjust all fluid levels
❑ Replace Smart Key battery
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Drive belt
__ Exhaust pipes and mountings
Note: If 0W-20 oil was not used at last oil change, or if you drive primarily under certain special operating
conditions, you should also replace the engine oil with 0W-20 oil and replace the oil filter. See page 44 for
conditions that apply. Some conditions require additional maintenance. See below.
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect engine air filter
❑ Tighten nuts and bolts on chassis __ Front differential oil (AWD)
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Wiper blades
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________
MAINTENANCE

63
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
144 Months or 120,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace Smart Key battery
❑ Replace spark plugs1
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires2
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1Required under the terms of the Emission Control Warranty.
2 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

65
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
162 Months or 135,000 Miles
❑ Inspect and adjust all fluid levels
❑ Replace Smart Key battery
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Drive belt
__ Exhaust pipes and mountings
Note: If 0W-20 oil was not used at last oil change, or if you drive primarily under certain special operating
conditions, you should also replace the engine oil with 0W-20 oil and replace the oil filter. See page 44 for
conditions that apply. Some conditions require additional maintenance. See below.
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Inspect engine air filter
❑ Tighten nuts and bolts on chassis __ Front differential oil (AWD)
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Wiper blades
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

67
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
180 Months or 150,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace engine coolant (see page 69)
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________