ignition Lexus GX460 2012 Workshop Manual

606
4-3. Do-it-yourself maintenance
GX460_U.S.A. (OM60J00U)
CAUTION
The engine compartment contains many mechanisms and fluids that may move sud-
denly, become hot, or become electrically energized. To avoid death or serious injury,
observe the following precautions:
■When working on the engine compartment
●Keep hands, clothing, and tools away from the moving fan and engine drive belt.
●Be careful not to touch the engine, radiator, exhaust manifold, etc. right after driv-
ing as they may be hot. Oil and other fluids may also be hot.
●Do not leave anything that may burn easily, such as paper or rags, in the engine
compartment.
●Do not smoke, cause sparks or expose an open flame to fuel or the battery. Fuel
and battery fumes are flammable.
●Be extremely cautious when working on the battery. It contains poisonous and
corrosive sulfuric acid.
■When working near the electric cooling fans or radiator grille:
Be sure the “ENGINE START STOP” switch is off.
With the “ENGINE START STOP” switch in IGNITION ON mode, the electric
cooling fans may automatically start to run if the air conditioning is on and/or the
coolant temperature is high. (→P. 6 1 8 )
■Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from getting
in your eyes.

614
4-3. Do-it-yourself maintenance
GX460_U.S.A. (OM60J00U)
■After changing the engine oil (U.S.A. only)
The engine oil maintenance data should be reset. Perform the following proce-
dures:Press the Menu switch ( →P. 212) to change the multi-information display
to blank.
Turn the “ENGINE START STOP” switch off.
While pressing the ODO/TRIP button ( →P. 195), turn the “ENGINE
START STOP” switch to IGNITION ON mode.
Continue to press and hold the button for more than 7 seconds after the
“ENGINE START STOP” switch is turned to IGNITION ON mode.
STEP1
STEP2
STEP3
STEP4
The message shown in the illustration will
appear on the display. After 5 seconds, the
system reset will be completed.

651
4-3. Do-it-yourself maintenance
4
Maintenance and care
GX460_U.S.A. (OM60J00U)
6SUB BATT30 ATo w i n g
7IG220 AInjector, ignition, meter
8HORN10 AHorn
9EFI25 AEFI ECU, A/F heater relay, fuel pump
relay, EFI NO.2
10A/F20 AA/F SSR
11FUEL OPN 10 AFuel lid opener
12S/HTR RR20 ARear seat heater
13FOLD SEAT LH30 AFolding seat (left)
14FOLD SEAT RH30 AFolding seat (right)
15TOW I N G TA I L30 ATo w i n g
16A/C COMP10 AAir conditioning system
17STRG HTR 10 ASteering heater
18CDS FAN20 ACondenser fan
19STOP10 A
Stop lights, high mount stop light, stop
light switch, VSC ECU, towing, Smart
access system with push button start
20AIR SUS NO.27. 5 AAIR SUS ECU
21H-LP RH-HI15 AHeadlight high beam (right)
22H-LP LH-HI15 AHeadlight high beam (left)
FuseAmpereCircuit

652
4-3. Do-it-yourself maintenance
GX460_U.S.A. (OM60J00U)
23HTR50 AAir conditioning system
24WIP WSH RR30 ARear window wipers and washer
25H-LP CLN30 AHeadlight cleaner
26ST30 ASTARTER MTR
27H-LP HI25 ADIM relay, headlights, daytime run-
ning light system
28ALT-S7. 5 AALT
29TURN & HAZ15 A
Front turn signal light, rear turn signal
light, side turn signal light, meter turn
signal light
30D/ L N O.125 ADoor lock motor, glass hatch opener
31ETCS10 AEFI ECU
32FUEL PMP15 AFPC
33TOW I N G30 ATo w i n g
34ALT140 A
Air conditioning system, AIR SUS,
headlight cleaner, towing, folding seat,
STOP, rear window defogger, MIR
HTR, CDS FAN, RR FOG, DEICER,
MG-CLT, RR SEAT HTR, STRG HTR,
J/B, INV, RR WIP, RR WSH
35P/ I - B80 AInjector, ignition, meter, EFI, A/F
heater, horn
FuseAmpereCircuit

654
4-3. Do-it-yourself maintenance
GX460_U.S.A. (OM60J00U)
50ECU-B10 A
BODY ECU, meter, heater, steering
sensor, wireless remote control, seat
position memory, tilt and telescopic
steering, multi display, Smart access
system with push button start, folding
seat, cool box, DSS#2 ECU, steering
switch, D-module switch, overhead
module
51WSH FR NO.27. 5 ADSS#1 ECU
52H-LP RH-LO15 AHeadlight low beam (right), headlight
leveling system
53H-LP LH-LO15 AHeadlight low beam (left), headlight
leveling system
54INJ10 ACoil, injector, ignition, noise filter
55EFI NO.210 A
O2 SSR, AFM, ACIS VSV, AI
COMB, KEY OFF PUMP, EYP VSV,
EGR VALVE, CANISTER VSV, AI
VSV RLY, AI PUMP HTR RLY
56WIP FR NO.27. 5 ADSS#1 ECU
57WSH RR15 ARear window washer
58SPARESpare fuse
59SPARESpare fuse
60SPARESpare fuse
FuseAmpereCircuit

5
When trouble arises
681
5-1. Essential information
GX460_U.S.A. (OM60J00U)
■Before emergency towingThe “ENGINE START STOP” switch must be in the ACCESSORY mode
(engine off) or IGNITION ON mode (engine running).
Put the four-wheel drive control switch in H4. (The center differential is
unlocked.)
Put the vehicle height in the N mode and press height control switch to
turn off the rear height control air suspension.
Shift the shift lever in N.
Release the parking brake.
CAUTION
■Caution while towing
●Use extreme caution when towing the vehicle.
Avoid sudden starts or erratic driving maneuvers which place excessive stress on
the emergency towing eyelets and the cables or chains. Always be cautious of the
surroundings and other vehicles while towing.
●Do not turn the “ENGINE START STOP” switch off.
Doing so will lock the steering wheel an d prevent operation, possibly causing an
accident and resulting in death or serious injury.
●If the engine is not running, the power assist for the brakes and steering will not
function, making steering and braking more difficult.
STEP1
STEP2
STEP3
STEP4
STEP5

5
When trouble arises
693
5-2. Steps to take in an emergency
GX460_U.S.A. (OM60J00U)
*1: Open door warning buzzer:
The open door warning buzzer sounds to alert one or more of the doors is not
fully closed (with the vehicle having reached a speed of 3 mph [5 km/h]).
( → P. 7 0 4 )
*2: Driver’s and front passenger’s seat belt reminder buzzer:
The driver’s and front passenger’s seat belts reminder buzzer sounds to alert
the driver and front passenger that his/her seat belt is not fastened. Once the
“ENGINE START STOP” switch is turned to IGNITION ON mode, the buzzer
sounds for 4 to 8 seconds. If the vehicle reaches a speed of 12 mph (20 km/h),
the buzzer sounds intermittently for 10 seconds. Then, if the seat belt is still
unfastened, the buzzer will sound in a different tone for 20 more seconds.
Warning lightWarning light/DetailsCorrection procedure
Master warning light
A buzzer sounds and the
warning light comes on and
flashes to indicate that the
master warning system has
detected a malfunction.
→ P. 7 0 0
Tire pressure warning light
When the light comes on:
Low tire inflation pressure.Adjust the tire inflation pres-
sure.
When the light comes on after
blinking for 1 minute:
Malfunction in the tire pres-
sure warning system.
Have the system checked by
your Lexus dealer.

757
6-1. Specifications
6
Vehicle specifications
GX460_U.S.A. (OM60J00U)
Cooling system
Ignition system
Capacity
(reference)
With rear
heater16.3 qt. (15.4 L, 13.6 Imp.qt.)
Without rear
heater14.5 qt. (13.7 L, 12.1 Imp.qt.)
Coolant type
Use either of the following:• “Toyota Super Long Life Coolant”
• A similar high-quality ethylene glycol-
based non-silicate, non-amine, non-nitrite,
and non-borate coolant with long-life
hybrid organic acid technology
Do not use plain water alone.
Spark plug
MakeDENSO SK20HR11
Gap0.043 in. (1.1 mm)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.

823
Alphabetical index
GX460_U.S.A. (OM60J00U)
Electronic keyIf the electronic key does not
operate properly ............................ 739
Emergency, in case of
If the electronic key does not operate properly ............................ 739
If the engine will not start ............... 735
If the shift lever cannot be shifted from P.................................... 737
If the vehicle has discharged
battery.................................................... 741
If the warning buzzer sounds..... 688
If the warning light turns on ......... 688
If the warning message is
displayed ............................................ 700
If you have a flat tire .......................... 721
If you lose your keys ........................ 738
If you think something is
wrong...................................................683
If your vehicle becomes stuck .....747
If your vehicle has to be stopped in an emergency ......... 749
If your vehicle needs to be towed ....................................................677
If your vehicle overheats.................744
Emergency flashers
Switch ...................................................... 676 Engine
Accessory mode..................................179
Compartment..................................... 609
Engine switch .........................................179
Hood ....................................................... 608
How to start the engine ....................179
Identification number .......................753
If the engine will not start................735
Ignition switch ........................................179
Overheating ......................................... 744
Engine compartment cover .............. 610
Engine coolant Capacity ................................................. 757
Checking ................................................ 616
Preparing and checking before winter ................................... 366
Engine coolant temperature gauge....................................................... 195
Engine immobilizer system..................115
Engine oil Capacity .................................................755
Checking .................................................. 611
Preparing and checking before winter ................................... 366
Engine oil maintenance data............. 613
Engine switch ...........................................179
Engine switch light................................. 519
Event data recorder ........................... 685E
*: For vehicles with a navigation system, refer to the “Navigation System Owner’s Manual”.

825
Alphabetical index
GX460_U.S.A. (OM60J00U)
Hill-start assist control ....................... 336
Hood ......................................................... 608
HooksCargo ......................................................558
Cargo hooks .......................................559
Coat .........................................................555
Horn............................................................. 194
I/M test ..................................................... 602
Identification Engine ..................................................... 753
Vehicle.................................................... 753
Ignition switch .......................................... 179
Ignition switch light Ignition switch light .............................519
Illuminated entry system ....................522
Indicator lights .........................................198
Initialization
Items to initialize .................................802
Inside door handle light ....................... 519
Inside rear view mirror.......................... 95
Instrument cluster light control ........ 196
Interior lights Interior lights ..........................................519
Switch ........................................................ 521
Wattage ................................................. 763
Intuitive parking assist .........................266 Jack
Vehicle-equipped jack ..................... 721
Jack handle................................................721
Keyless entry ................................................. 47
Keys
Electronic key ......................................... 26
Engine switch .......................................... 29
If you lose your keys .........................738
If the electronic key does not operate properly ............................ 739
Key number plate ................................. 26
Keyless entry ........................................... 47
Keys ............................................................. 26
Mechanical key ...................................... 26
Wireless remote control key .......... 47
Kinetic Dynamic Suspension System (KDSS) ................................... 336
Lane Departure Alert ......................... 275
LDA ............................................................ 275
License plate lights Replacing light bulbs ........................ 672
Light bulbs
Replacing ...............................................662
Wattage.................................................. 763
I
J
K
L
*: For vehicles with a navigation system, refer to the “Navigation System Owner’s Manual”.