stop start LEXUS SC300 1991 Service Manual PDF

56
POWER SOURCE
AM2 AM1
ACC
IG 1
IG 2
321 6 411
ST1
1B
2
1J 5
1J 6
1J 3
1J 8 1K
13
1K 4
1J
4
1B
4
1J
7 I24
I33
I11 P
N 2
3
IE1
16
IJ16
3421314 59 7
116
W
WB
B
B
B±R
B±W B±W
W±L
B
B±O P±L B
B
B
W±L R
W±R
W±R
B
W±R Y
W±L
W±R
W
W±R
B±Y
B±W P±L
B±O
B±W
B±W
B±W
B±WW
B±R
15A ECU±B
15A STOP
30A POWER
30A DOOR
TAILLIGHT
RELAY 15A TAIL
7. 5A PANEL BATTERY
15A ECU±IG
7. 5A ENGINE
20A W IPER
10A GAUGE 20A TURN
10A HEATER
7. 5A ST
7. 5A IGN 15A CIG
7. 5A RADIO NO. 2
40A
IGSW
NEUTRAL
START SW
TO ENGINE AND ECT ECUTO CRUISE CONTROL ECU
TO ABS ACTUATOR RELAY,
ABS MOTOR RELAY AND
TRACTION BRAKE
ACTUATOR RELAYTO ALTERNATOR º Bº
IGNITION SW
FUSE BLOCK
TO TRACTION MOTOR RELAY100A AM1
60A ABS NO. 1
30A INJ
120A ALT 30A AM2
30A ABS NO. 2 60A MAIN
F9
N1
I15
5
1 3
2
2
6
3 4 1
5
1 2IJ2
8 B
B±W
B
B
(
M/T )
(
M/T )
C23
CLUTCH START SW
(
A/T )
WhereEverybodyKnowsYourName

154
POWER SEAT (w/ DRIVING POSITION MEMORY)
PRND 2 L146578 9
GR
R±B
L
G±W G
W
A/T INDICATOR SW
[NEUTRAL START SW AND BACK±UP LIGHT SW]
N1
IT1
12
1I
10 1H 12
1C
10 1H
1
A
6
STOP A
15
P
A
3 RCL+
A
10 RCL±
B
16 SSRS
B
14 SSRR
B
6 PVCC
B
5 SSFV
B
15 SSRV
2
3 13
1265
2 13 2
13
M
B28
B26 B27
BU1
7
Ba16
Ba1
8 1 2
IJ1
10
GR
V V
V
BR±B
BR±B BR±B
BR±B
BR±B
BR±BLG
V
Y±R Y±B
V
V±W
LG±R V
Y±G V
BR±B
G±W G±W G±W W
Y
GR
GR
Y
Y
VV LG±R
Y±G
V±W
Y±B
Y±R LG
FROM POWER SOURCE SYSTEM
(
SEE PAGE 56 )
15A
STOP 10A
GAUGE
STOP LIGHT
SW
POWER SEAT ECU
(FOR DRIVE R' S SEA T )
SLIDE
POSITION
SENSOR
( FOR
DRIVE R' S SEA T )POWER SEAT MOTOR
(
FOR DRIVER' S SEAT
RECLINING MOTOR
CONTROL ) FRONT
VERTICAL
POSITION
SENSOR
RE AR
VEATICAL
POSITION
SENSOR
S20
P16 F19 R19
P10 , P 1 1
S12
AB
B261
B
( M/T )
PARKING
BRAKE SW
P
3 (
A/T )
BR±B
WhereEverybodyKnowsYourName

159
RETURN OPERATION
WHEN THE SEAT BACK IS RAISED UP FROM THE WALK±IN POSITION AND RETURNED TO THE UPRIGHT LOCK POSITION,
RECLINING LIMIT SWITCH NO. 1 OPERATES AND A SIGNAL IS INPUT TO TERMINAL RRSW OF THE POWER SEAT ECU " TERMINAL
SLD± " TERMINAL 2 OF POWER SEAT MOTOR (FOR PASSENGER'S SEAT SLIDE CONTROL) " MOTOR " TERMINAL 1 " TERMINAL
SLD+ OF ECU " TERMINAL GND " GROUND . THIS CAUSES THE SEAT TO SLIDE BACK TO A POSITION 120 MM FROM THE MOST
REAR POSITION, COMPLETING RETURN OPERATION. HOWEVER, IF THE SEAT IS POSITIONED WITHIN 120 MM OF THE MOST REAR
POSITION, RETURN OPERATION DOES NOT OCCUR, THUS MAINTAINING SUFFICIENT SPACE FOR THE REAR SEAT PASSENGER.
D10 DOOR LOCK MOTOR, DOOR UNLOCK DETECTION SW AND DOOR OPEN DETECTION SW LH
3±6 : CLOSED WITH FRONT LH DOOR OPEN
N 1 A/T INDICATOR SW [NEUTRAL START SW]
9±1 : CLOSED WITH SHIFT LEVER AT ªPº POSITION
P10(A), P11(B) POWER SEAT ECU (FOR DRIVER'S SEAT)
(A) 6±GROUND : APPROX. 12 VOLTS WITH STOP LIGHT SW ON
(B) 7±GROUND : ALWAYS APPROX. 12 VOLTS
(A) 7±GROUND : APPROX. 12 VOLTS WITH IGNITION SW ON
(A) 15±GROUND : APPROX. 12 VOLTS WITH IGNITION SW ON AND SHIFT LEVER AT ªPº RANGE
(A) 2±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT FRONT SLIDE OPERATION
(A) 9±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT REAR SLIDE OPERATION
(A) 4±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT FRONT VERTICAL UP OPERATION
(A) 11±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT FRONT VERTICAL DOWN OPERATION
(A) 13±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT REAR VERTICAL UP OPERATION
(A) 12±GROUND : APPROX. 12 VOLTS WITH DRIVER'S SEAT AT REAR VERTICAL DOWN OPERATION
(B) 18±GROUND : ALWAYS CONTINUITY
(A) 5, (A) 14±GROUND : ALWAYS APPROX. 12 VOLTS
(A) 1, (A) 8±GROUND : ALWAYS CONTINUITY
P 8 POWER SEAT CONTROL SW (FOR DRIVER'S SEAT)
4±14 : CLOSED WITH DRIVER'S SEAT AT FRONT RECLINING OPERATION
3±14 : CLOSED WITH DRIVER'S SEAT AT REAR RECLINING OPERATION
1±14 : CLOSED WITH DRIVER'S SEAT AT FRONT SLIDE OPERATION
2±14 : CLOSED WITH DRIVER'S SEAT AT REAR SLIDE OPERATION
5±14 : CLOSED WITH DRIVER'S SEAT AT FRONT VERTICAL UP OPERATION
6±14 : CLOSED WITH DRIVER'S SEAT AT FRONT VERTICAL DOWN OPERATION
9±14 : CLOSED WITH DRIVER'S SEAT AT REAR VERTICAL UP OPERATION
8±14 : CLOSED WITH DRIVER'S SEAT AT REAR VERTICAL DOWN OPERATION
P12 POWER SEAT ECU (FOR PASSENGER'S SEAT)
1±GROUND : ALWAYS APPROX. 12 VOLTS
8±GROUND : ALWAYS APPROX. 12 VOLTS
7±GROUND : APPROX. 12 VOLTS WITH PASSENGER'S SEAT AT FRONT SLIDE OPERATION
17±GROUND : APPROX. 12 VOLTS WITH PASSENGER'S SEAT AT REAR SLIDE OPERATION
S12 STOP LIGHT SW
2±1 : CLOSED WITH STOP LIGHT SW ON
SERVICE HINTS
WhereEverybodyKnowsYourName

167
4. AUTO RETURN OPERATION
WHEN THE STEERING IS IN ªAUTO AWAYº CONDITION AND THE IGNITION KEY IS INSERTED INTO THE IGNITION KEY CYLINDER
(UNLOCK WARNING SW ON), A SIGNAL IS INPUT TO TERMINAL UWSW OF TILT AND POWER TELESCOPIC ECU.
AS A RESULT, THE TILT AND POWER TELESCOPIC ECU OPERATES AND THE CURRENT TO TERMINAL +B OF TILT AND POWER
TELESCOPIC ECU FLOWS FROM TERMINAL TEM± OF TILT AND POWER TELESCOPIC ECU "TERMINAL 4 OF COMB. SW "
TERMINAL 1 OF TELESCOPIC CONTROL MOTOR "TERMINAL 2 " TERMINAL 1 OF COMB. SW " TERMINAL TEM+ OF TILT AND
POWER TELESCOPIC ECU " TERMINAL GND2 "GROUND , AND AT THE SAME TIME, CURRENT FLOWS FROM TERMINAL TIM± OF
TILT AND POWER TELESCOPIC ECU "TERMINAL 10 OF COMB. SW "TERMINAL 1 OF TILT CONTROL MOTOR "TERMINAL 2 "
TERMINAL 1 OF COMB. SW "TERMINAL TIM+ OF TILT AND POWER TELESCOPIC ECU "TERMINAL GND2 "GROUND , CAUSING
BOTH THE TILT CONTROL MOTOR AND TELESCOPIC CONTROL MOTOR TO ROTATE. THE MOTORS CONTINUE TO ROTATE UNTIL
THE SIGNALS INPUT FROM THE TILT POSITION SENSOR TO TERMINAL TIS OF TILT AND POWER TELESCOPIC ECU AND FROM THE
TELESCOPIC POSITION SENSOR TERMINAL TES OF TILT AND POWER TELESCOPIC ECU (SIGNALS INFORMING THE ECU OF THE
CURRENT POSITION OF THE STEERING) MATCH THE POSITION MEMORIZED BY THE ECU PRIOR TO AUTO AWAY OPERATION.
IN THIS WAY, THE STEERING POSITION IS AUTOMATICALLY RETURNED TO THE ORIGINAL POSITION.
WHEN THE IGNITION SW IS TURNED FROM OFF TO ON OR THE SHIFT LEVER IS SHIFTED TO A POSITION OTHER THAN P OR N,
AUTO OPERATION IS STOPPED.
C15 TILT AND POWER TELESCOPIC UNIT [COMB. SW]
4±6 : APPROX. 160
WITH TELESCOPIC LONG OPERATION
: APPROX. 360
WITH TILT UP OPERATION
: APPROX. 790
WITH TELESCOPIC SHORT OPERATION
: APPROX. 2.0K
WITH TILT DOWN OPERATION
8±7 : CONTINUITY WITH AUTO SW OFF
8±4 : APPROX. 5K

T 7 (D) TELESCOPIC POSITION SENSOR
6±3 : APPROX. 5K

D10 DOOR LOCK MOTOR, DOOR UNLOCK DETECTION SW AND DOOR OPEN DETECTION SW LH
3±6GROUND :CLOSED WITH FRONT DOOR LH OPEN
D12 DRIVING POSITION MEMORY AND RETURN SW
2±3 : CLOSED WITH DRIVING POSITION MEMORY SW (NO. 1) ON
1±3 : CLOSED WITH DRIVING POSITION MEMORY SW (NO. 2) ON
4±3 : CLOSED WITH DRIVING POSITION MEMORY SW (SET) ON
I15 UNLOCK WARNING SW [IGNITION SW]
9±10: CLOSED WITH IGNITION KEY IN CYLINDER
N 1 A/T INDICATOR SW [NEUTRAL START SW]
9±1 : CLOSED WITH SHIFT LEVER AT P POSITION
T10, T11 TILT AND POWER TELESCOPIC ECU
(A) 4±GROUND : ALWAYS APPROX. 12 VOLTS
(A) 1±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
(B) 18±GROUND : ALWAYS APPROX. 12 VOLTS
(A) 6±GROUND : APPROX. 12 VOLTS WITH IGNITION SW ON AND SHIFT LEVER AT ªPº RANGE
(B) 10±GROUND : CONTINUITY WITH IGNITION KEY IN CYLINDER
(A) 7±GROUND : ALWAYS CONTINUITY
(B) 8±GROUND : ALWAYS CONTINUITY
(B) 2±GROUND : CONTINUITY WITH FRONT DOOR LH OPEN
(B) 3±GROUND : CONTINUITY WITH DRIVING POSITION MEMORY SW (NO. 1) ON
(B) 12±GROUND : CONTINUITY WITH DRIVING POSITION MEMORY SW (NO. 2) ON
(B) 11±GROUND : CONTINUITY WITH DRIVING POSITION MEMORY SW (SET) ON
(A) 10±GROUND : APPROX. 12 VOLTS WITH TILT UP OPERATION
(A) 3±GROUND : APPROX. 12 VOLTS WITH TILT DOWN OPERATION
(A) 2±GROUND : APPROX. 12 VOLTS WITH TELESCOPIC SHORT OPERATION
(A) 11±GROUND : APPROX. 12 VOLTS WITH TELESCOPIC LONG OPERATION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
C1728N 127T 732
D1030P 329T10B29
D1230P1127T11A29
I1529R 732
SERVICE HINTS
WhereEverybodyKnowsYourName