LINCOLN NAVIGATOR 2011 Owners Manual

EXCEPTIONS
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
Normal vehicle axle maintenance
❑Rear axles and power take-off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design
axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is re-
quired or the axle assembly has been submerged in water. The axle and PTO lubricant should be changed anytime the axle
and PTO have been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open
throttle for extended periods above 45 mph (72 km/h), non-synthetic rear axle lubricants should be replaced every
3,000 miles (4,800 km) or 3 months, whichever occurs first. The 3,000 mile (4,800 km) lubricant change interval may
be waived if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part
number F1TZ-19580-B or equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-
Lok rear axles (refer to
Maintenance product and specificationsin theMaintenance and Specificationschapter for details).
The axle lubricant should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑Replace rear axle lubricant every 100,000 miles (160,000 km). Rear axle lubricant change may be waived if the axle
was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or
equivalent. Add four ounces (118 mL) of additive friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of
Traction-Lok rear axles. The axle lubricant should be changed anytime the axle has been submerged in water.
E–450 and F–450/550 axle maintenance
❑Replace rear axle lubricant every 100,000 miles (160,000 km) under normal driving conditions on all E–450 and
F–450/550 applications. For E–450 and F–450/550 vehicles operated at or near maximum Gross Vehicle Weights, the
rear axle lubricant should be replaced every 50,000 miles (80,000 km). In addition, this 50,000 mile (80,000 km)
schedule should be observed when the vehicles are operated under the Special Operating Conditions.
California fuel filter replacement
❑If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this main-
tenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life.
Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified inter-
vals and to record all vehicle service.
Class A Motorhome
❑Every two years - Change brake fluid
Scheduled Maintenance Guide
361
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

COOLANT CHANGE RECORD
Hot climate oil change intervals
❑If operating conditions are normal and you drive your Ford, Lincoln or Mercury vehicle under typical, everyday conditions
andyou are using an API performance category oil of SL or later (for example SM, etc.) then you can follow the
7,500 mile (12,000 km) normal service oil change intervals schedule. Vehicles operating in the Middle East, North Africa,
Sub-Saharan Africa or locations with similar climates must follow the oil change interval of 3,000 mile (5,000 km) if the
owner is using oils defined by the American Petroleum Institute (API) performance category of API SK or earlier (for ex-
ample SJ, etc.).
Engine air filter & cabin air filter replacement
❑Engine air filter and cabin air filter life is dependent on exposure to dusty and dirty conditions. Vehicles operated in these
conditions will require frequent inspection and replacement of the engine air filter and cabin air filter.
Engine coolant
❑Initial change – 6 years or 105,000 miles (168,000 km) (whichever comes first).❑After initial change - every 3 years or 45,000 miles (72,000 km).
Scheduled Maintenance Guide
362
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Engine coolant change log
DEALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DATE:MILEAGE:
Scheduled Maintenance Guide
363
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

A
ABS (see Brakes) .....................224
Accessory delay ..........................74
AdvanceTrac ..............................226
Air cleaner filter ...............325, 330
Air suspension ...........................232
description ..............................232
Airbag supplemental
restraint system ........152, 156, 158
and child safety seats ............154
description ..............152, 156, 158
disposal ....................................161
driver airbag ............154, 157, 159
indicator light .................156, 161
operation .................154, 157, 159
passenger airbag .....154, 157, 159
side airbag ...............................156
Antifreeze
(see Engine coolant) ................305
Anti-lock brake system
(see Brakes) ..............................224
Anti-theft system ..............114, 118
arming the system ..................118
disarming a triggered
system .....................................119
Audio system (see Radio) .........30
Automatic transmission
driving an automatic
overdrive .................................235
fluid, adding ............................325
fluid, checking ........................325
fluid, refill capacities ..............331
fluid, specification ..................331
Auxiliary input jack
(Line in) ......................................36
Auxiliary power point .................71Axle
lubricant specifications ..........331
refill capacities ........................331
B
Battery .......................................303
acid, treating emergencies .....303
jumping a disabled
battery .....................................274
maintenance-free ....................303
replacement, specifications ...330
servicing ..................................303
Belt-Minder.............................148
Booster seats .............................177
Brakes ........................................223
anti-lock ...................................224
anti-lock brake system
(ABS) warning light ...............224
fluid, checking and adding ....324
fluid, refill capacities ..............331
fluid, specifications .................331
lubricant specifications ..........331
parking ....................................225
shift interlock ..........................233
Bulbs ............................................60
C
Capacities for refilling fluids ....331
Car2UHome Automation
System .........................................84
Cargo cover .................................95
Cargo management system ........95
Cell phone use ..............................9
Changing a tire .........................264
Child safety seats ......................166
in front seat ............................167
in rear seat ..............................167
Index
364
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

LATCH .....................................170
recommendations ...................164
Child safety seats - booster
seats ...........................................177
Cleaning your vehicle
engine compartment ..............289
instrument panel ....................290
interior .............................291–292
plastic parts ............................289
washing ....................................287
waxing .....................................288
wheels ......................................288
wiper blades ............................290
Clock ............................................71
Compass, electronic
set zone adjustment .................25
Console ........................................70
overhead ..............................69–70
Controls
power seat ...............................123
steering column ........................82
Coolant
checking and adding ..............305
refill capacities ................308, 331
specifications ..........................331
Cruise control
(see Speed control) ....................80
Customer Assistance ................253
Ford Extended Service
Plan ..................................340, 343
Getting assistance outside
the U.S. and Canada ..............283
Getting roadside assistance ...253
Getting the service you
need .........................................279
Ordering additional owner’s
literature .................................285Utilizing the
Mediation/Arbitration
Program ...................................283
D
Daytime running lamps
(see Lamps) ................................56
Dipstick
automatic transmission
fluid ..........................................325
engine oil .................................300
Driving under special
conditions ..................237, 247, 250
sand .........................................249
snow and ice ...........................251
through water .................249, 252
E
Electronic message center .........20
Emergencies, roadside
jump-starting ..........................274
running out of fuel .........273, 316
Emission control system ..........321
Engine ................................334–335
cleaning ...................................289
coolant .....................................305
fail-safe cooling .......................309
idle speed control ...................303
lubrication specifications .......331
refill capacities ........................331
service points ..........................297
starting after a collision .........255
Engine block heater .................221
Engine oil ..................................300
checking and adding ..............300
dipstick ....................................300
filter, specifications ........302, 330
recommendations ...................302
Index
365
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

refill capacities ........................331
specifications ..........................331
Event data recording ....................7
Exhaust fumes ..........................221
F
Fail safe cooling ........................309
Fleet MyKey programming ........98
Flexible Fuel Vehicle (FFV) ....311
Floor mats ...................................90
Fluid capacities .........................331
Fog lamps ....................................55
Four-Wheel Drive vehicles .......243
control trac .............................244
description ..............................244
driving off road .......................245
indicator light .........................244
preparing to drive your
vehicle .....................................233
Fuel ............................................311
calculating fuel
economy ............................22, 318
cap ...........................................314
capacity ...................................331
choosing the right fuel ...........315
detergent in fuel .....................316
filler funnel .............................316
filling your vehicle
with
fuel ...........................311, 314, 318
filter, specifications ........311, 330
fuel pump shut-off switch .....255
improving fuel economy ........318
octane rating ...........315, 334–335
quality ......................................316
running out of fuel .........273, 316
safety information relating
to automotive fuels ................311Fuel - flex fuel vehicle
(FFV) .................................311, 315
Fuses ..................................256–257
G
Garage door opener ....................84
Gas cap (see Fuel cap) ............314
Gas mileage
(see Fuel economy) .................318
Gauges .........................................18
H
Hazard flashers .........................254
Headlamps ...................................55
aiming ........................................57
autolamp system .......................55
bulb specifications ....................60
daytime running lights .............56
flash to pass ..............................56
high beam .................................56
turning on and off ....................55
Hood ..........................................296
I
Ignition .......................217, 334–335
Illuminated visor mirror .............68
Infant seats
(see Safety seats) .....................166
Inspection/maintenance (I/M)
testing ........................................323
Instrument panel
cleaning ...................................290
cluster ........................................12
Index
366
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

J
Jack ............................................264
positioning ...............................264
storage .....................................264
Jump-starting your vehicle ......274
K
Keyless entry system
autolock ...................................103
keypad .....................................113
locking and unlocking
doors ........................................114
programming entry code .......113
Keys .....................................97, 116
positions of the ignition .........217
L
Lamps
autolamp system .......................55
bulb replacement
specifications chart ..................60
daytime running light ...............56
fog lamps ...................................55
headlamps .................................55
headlamps, flash to pass ..........56
interior lamps ...............58–59, 61
replacing bulbs .........................64
LATCH anchors .........................170
Liftgate ................................90, 109
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........224
Load limits .................................202
Loading instructions .................209
Locks
autolock ...................................103
childproof ................................107
doors ........................................103Lubricant specifications ...........331
Lug nuts ....................................272
Lumbar support, seats .............123
M
Message center ...........................20
english/metric button ...............25
system check button ................25
warning messages .....................26
Mirrors ...................................75–76
automatic dimming rearview
mirror ........................................75
fold away ...................................76
heated ........................................77
programmable memory ..........110
signal .........................................77
Moon roof ....................................83
Motorcraftparts ..............294, 330
MyKey ..........................................98
N
Navigation system .......................47
O
Octane rating ............................315
Oil (see Engine oil) ..................300
P
Parental MyKey
programming ...............................98
Parking brake ............................225
Parts
(see Motorcraftparts) ...........330
Pedals (see Power adjustable
foot pedals) .................................78
Index
367
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Power adjustable foot pedals .....78
Power deployable running
boards ..........................................78
Power distribution box
(see Fuses) .......................257, 260
Power door locks ......................103
Power liftgate ..............................90
Power mirrors .............................76
Power point .................................71
Power steering ..........................231
fluid, checking and adding ....324
fluid, refill capacity ................331
fluid, specifications .................331
Power Windows ...........................73
Preparing to drive your
vehicle ........................................233
R
Radio ............................................30
Rear heated seats .....................135
Rear-view camera system .........241
Recommendations for
attaching safety restraints for
children ......................................164
Relays ........................................256
Remote entry system .......107–108
illuminated entry ....................112
locking/unlocking
doors ................................108–109
opening the trunk ...................109
panic alarm .............................110
replacement/additional
transmitters .............................111
replacing the batteries ...........111
Reverse sensing system ...........238Roadside assistance ..................253
Roll stability control .................226
S
Safety Belt Maintenance ..........180
Safety belts
(see Safety restraints) ....138, 140,
142–143, 145
Safety Canopy ...................156, 158
Safety defects, reporting ..........286
Safety restraints ...............138, 140,
142–143, 145
Belt-Minder...........................148
extension assembly ................147
for adults .........................142–143
for children .............................162
safety belt maintenance .........180
warning light and chime ........147
Safety restraints - LATCH
anchors ......................................170
Safety seats for children ..........166
Safety Compliance
Certification Label ....................335
Satellite Radio Information ........44
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............348
What Maintenance Schedule
Should You Follow? ................346
Seats ..........................................120
child safety seats ....................166
cleaning ...................................293
climate control ........................127
heated ......................................135
memory seat ...................110, 125
Index
368
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

SecuriCode keyless entry
system ........................................113
SecuriLock passive anti-theft
system ........................................114
Servicing your vehicle ..............295
Snowplowing .................................6
SOS Post Crash Alert ...............161
Spark plugs, specifications ......330,
334–335
Special notice
utility-type vehicles ....................6
Specification chart,
lubricants ...................................331
Speed control ..............................80
Stability system .........................226
Starting a flex fuel vehicle .......220
Starting your vehicle ........217–220
jump starting ..........................274
Steering wheel
controls ......................................82
tilting .........................................67
SYNC..........................................47
T
Third-row power fold seat .......137
Tire Pressure Monitoring
System (TPMS)
Driving .....................................249
Tires, Wheels and Loading ....198
Warning Displays ................12, 26
Tires ...........................183–185, 264
alignment ................................192
care ..........................................188
changing ..........................264, 268
checking the pressure ............188
inflating ...................................186label .........................................197
replacing ..................................190
rotating ....................................192
safety practices .......................191
sidewall information ...............193
snow tires and chains ............202
spare tire .................................264
terminology .............................185
tire grades ...............................184
treadwear ........................184, 188
Towing .......................................210
recreational towing .................216
trailer towing ..........................210
wrecker ....................................277
Transmission .............................235
brake-shift interlock (BSI) ....233
fluid, checking and adding
(automatic) .............................325
fluid, refill capacities ..............331
lubricant specifications ..........331
Turn signal ..................................58
U
Universal garage door opener ....84
USB port ......................................38
V
Vehicle Identification Number
(VIN) ..........................................336
Vehicle loading ..........................202
Ventilating your vehicle ...........221
W
Warning lights (see Lights) .......12
Washer fluid ..............................298
Water, Driving through .............252
Index
369
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Windows
power .........................................73
rear wiper/washer .....................67
Windshield washer fluid and
wipers ..........................................65checking and adding fluid
.....298
liftgate reservoir
.....................298
replacing wiper blades
...........299
Wrecker towing
.........................277
Index
370
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)