Bulbs LINCOLN TOWN CAR 2003 Owners Manual

BULBS
Replacing exterior bulbs
Check the operation of all the bulbs frequently.
Using the right bulbs
Replacement bulbs are specified in the chart below. Headlamp bulbs
must be marked with an authorized“D.O.T.”for North America and an
“E”for Europe to assure lamp performance, light brightness and pattern
and safe visibility. The correct bulbs will not damage the lamp assembly
or void the lamp assembly warranty and will provide quality bulb burn
time.
Function Trade Number
Headlamp (Hi beam) 9005
Headlamp (Lo beam)* H7
Park and turn lamp (front) 3457 AK
Sidemarker (front) 168
Backup lamp 3156 K
Stop, tail, turn and sidemarker lamp (rear) 3157 K
Cornering lamp 3156 K
License plate lamp 168
High-mount brakelamp - Stop** 20 (LEDS)
High-mount brakelamp - Backup Aid** 6 (LEDS)
Luggage compartment lamp 212-2
Map lamp 578
Visor vanity lamp 168
Door courtesy lamp 904
Glove compartment 194
All replacement bulbs are clear in color except where noted.
To replace all instrument panel lights - see your dealer.
* For vehicles with HID lamps, see your dealer for service.
**When replacing the center high mount stop lamp, see your dealer for
replacement bulbs.
Replacing the interior bulbs
Check the operation of all bulbs frequently.
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Lights
79

Replacing headlamp bulbs
To remove the headlamp bulb:
1. Make sure headlamp switch is in
OFF position.
2. Remove the protective bulb cover
by loosening and removing the five
screws.
3. Rotate the light bulb socket
counter clockwise and pull it
straight out from the assembly.
4. Remove the old bulb from the
lamp assembly by pulling it straight
out of the bulb socket.
Handle a halogen headlamp bulb carefully and keep out of
children’s reach. Grasp the bulb only by its plastic base and do
not touch the glass. The oil from your hand could cause the bulb to
break the next time the headlamps are operated.
5. To complete installation, follow the removal procedure in reverse
order.
Note:To ensure a good seal, attach the bulb cap and partially tighten
the screws. Check to ensure the gasket is fully centered. Finish
tightening the screws in a criss-cross pattern (upper-left, lower right
etc.)
Replacing HID headlamp bulbs (if equipped)
The low beam headlamps on your vehicle use a“high intensity discharge”
source. These lamps operate at a high voltage. When the bulb is burned
out, the bulb and starter capsule assembly must be replaced by your
dealer or a qualified technician.
Replacing front parking lamp/turn signal bulbs
The park/turn lamp bulbs can be replaced with out removing the
headlamp assembly.
1. Make sure headlamp switch is in OFF position, then open the hood.
2. Remove the protective bulb cover by removing the three retaining
bolts.
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Lights
80

3. Rotate the bulb socket
counterclockwise and remove from
lamp assembly.
4. Carefully pull bulb straight out of
the socket and push in the new bulb
until it snaps, locking it into
position.
5. To complete installation, follow
the removal procedure in reverse
order.
Replacing tail lamp/brake/turn lamp bulbs
The tail lamp, the brake lamp and the turn signal lamp bulbs are located
in the tail lamp assembly. Follow the same steps to replace either bulb.
1. Make sure headlamp switch is in
OFF position, then open the trunk
and carefully pull the carpet away to
expose the plastic retainer.
2. Remove plastic retainer to expose
the lamp assembly hardware.
3. Remove three nut and washer
assemblies and the lamp assembly
from the vehicle.
4. Remove the bulb socket by
rotating it counterclockwise, then
pulling it out of the lamp assembly.
5. Pull the bulb from the socket and
push in the new bulb.
6. Install the bulb socket into the
lamp assembly by rotating it
clockwise.
7. Install the lamp assembly on the
vehicle with three nut and washer
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Lights
81

assemblies ensuring the washers on the nuts are flush with the body to
prevent water from entering the trunk.
8. Install the plastic retainer and carefully push the carpet back in to
place.
Replacing license plate lamp bulbs
1. Make sure headlamp switch is in
OFF position, then remove two
screws, grommets and the license
plate lamp assembly from the trunk
lid.
2. Carefully pull the bulb from the
socket and push in the new bulb.
3. Install the lamp assembly on
trunk lid with two grommets,
ensuring the grommets are pushed
all the way in to the trunk lid and secure with two screws.
Replacing backup lamp bulbs
1. Make sure headlamp switch is in
OFF position, then open trunk and
remove bulb socket from the trunk
lid by turning counterclockwise.
2. Pull the bulb straight out of the
socket and push in the new bulb.
3. Install the bulb socket in trunk lid
by turning clockwise.
Replacing high-mount brakelamp bulbs
To change the high-mount brake
lamp assembly:
1. Make sure headlamp switch is in
OFF position, then pry the light
assembly away from its housing to
disengage it from the retaining clips.
2. Remove the light assembly from
the headliner.
3. Disconnect the light assembly wiring and replace the light assembly.
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Lights
82

A
Accessory delay ..........................97
Air bag supplemental
restraint system ........147–148, 152
and child safety seats ............149
description ......................148, 152
disposal ....................................154
driver air bag ..................150, 153
indicator light .................151, 154
operation .........................150, 153
passenger air bag ...........150, 153
side air bag ..............................152
Air cleaner filter .......250–251, 255
Air suspension ...........................173
description ..............................173
Antifreeze
(see Engine coolant) ................231
Anti-lock brake system
(see Brakes) ..............................170
Anti-theft system ......................126
Audio system (see Radio) .........17
Automatic transmission
driving an automatic
overdrive .................................175
fluid, adding ............................248
fluid, checking ........................248
fluid, refill capacities ..............256
fluid, specification ..................259
Auxiliary power point .................96
Axle
lubricant specifications ..257, 259
refill capacities ........................256
traction lok ..............................177
B
Battery .......................................229
acid, treating emergencies .....229jumping a disabled battery ....199
maintenance-free ....................229
replacement, specifications ...255
servicing ..................................229
BeltMinder .................................142
Brakes ........................................170
anti-lock ...................................170
anti-lock brake system
(ABS) warning light ...............170
fluid, checking and adding ....247
fluid, refill capacities ..............256
fluid, specifications .........257, 259
lubricant
specifications ..................257, 259
shift interlock ..........................174
Bulbs ............................................79
C
Capacities for refilling fluids ....256
CD changer .................................21
CD-single premium .....................17
Cell phone use ..........................104
Certification Label ....................261
Changing a tire .........................194
Child safety restraints ..............155
child safety belts ....................155
Child safety seats ......................158
attaching with tether straps ..162
in front seat ............................159
in rear seat ..............................159
Cleaning your vehicle
engine compartment ..............216
instrument panel ....................218
interior .............................218–219
plastic parts ............................217
safety belts ..............................220
washing ....................................215
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
266

recommendations ...................228
refill capacities ........................256
specifications ..................257, 259
Exhaust fumes ..........................169
F
Fail safe cooling ........................235
Floor mats .................................112
Fluid capacities .........................256
Foglamps .....................................75
Fuel ............................................237
calculating fuel
economy ....................89, 106, 241
cap ...........................................239
capacity ...................................256
choosing the right fuel ...........240
comparisons with EPA fuel
economy estimates .................244
detergent in fuel .....................241
filling your vehicle
with fuel ..................237, 239, 241
filter, specifications ........241, 255
fuel filler door override ..........110
fuel filler door release ............110
fuel pump shut-off switch .....186
improving fuel economy ........241
octane rating ...................240, 259
quality ......................................240
running out of fuel .................241
safety information relating
to automotive fuels ................237
Fuses ..................................187–188
G
Gas cap (see Fuel cap) ............239
Gas mileage
(see Fuel economy) .................241
Gauges .........................................15GAWR (Gross Axle
Weight Rating) ..........................180
definition .................................180
driving with a heavy load ......180
location ....................................180
GVWR (Gross Vehicle
Weight Rating) ..........................180
calculating ...............................180
definition .................................180
driving with a heavy load ......180
location ....................................180
H
Hazard flashers .........................186
Head restraints .........................128
Headlamps ...................................74
aiming ........................................76
autolamp system .......................74
bulb specifications ....................79
daytime running lights .............75
flash to pass ..............................76
high beam .................................75
replacing bulbs .........................80
turning on and off ....................74
HomeLink universal
transceiver (see
Garage door opener) ..................90
Hood ..........................................223
I
Ignition ...............................166, 259
Infant seats
(see Safety seats) .....................158
Inspection/maintenance
(I/M) testing ..............................246
Instrument panel
cleaning ...................................218
cluster ........................................10
lighting up panel and interior .76
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
268

J
Jack ............................................194
positioning ...............................194
storage .....................................194
Jump-starting your vehicle ......199
K
Keyless entry system ...............121
Keys
positions of the ignition .........166
L
Lamps
autolamp system .......................74
bulb replacement
specifications chart ..................79
cargo lamps ...............................76
daytime running light ...............75
fog lamps ...................................75
headlamps .................................74
headlamps, flash to pass ..........76
instrument panel, dimming .....76
interior lamps .....................78–79
replacing bulbs ...................79–82
Lane change indicator
(see Turn signal) ........................78
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........170
speed control ..........................102
Load limits .................................180
GAWR ......................................180
GVWR ......................................180
trailer towing ..........................180
Locks
childproof ................................114
doors ........................................113
Lubricant specifications ...257, 259
Lumbar support, seats .............129M
Message center .........................104
english/metric button .............108
reset button ............................105
warning messages .....................93
Mirrors ...................................85, 98
automatic dimming
rearview mirror .........................98
fold away ...................................99
heated ........................................99
programmable memory ..........120
side view mirrors (power) .......98
Moon roof ..................................103
Motorcraft parts ................241, 255
N
Navigation system .......................24
cd functions ..............................37
destination mode ......................50
map mode .................................41
quick start .................................26
radio functions ..........................30
O
Octane rating ............................240
Oil (see Engine oil) ..................225
P
Parking brake ............................171
Parts (see Motorcraft parts) ....255
Passenger Occupant
Classification Sensor .................134
Pedals (see Power adjustable
foot pedals) .................................99
Power adjustable foot pedals .....99
2003 Town Car(tow)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
269