warning LINCOLN TOWN CAR 2007 Service Manual
[x] Cancel search | Manufacturer: LINCOLN, Model Year: 2007, Model line: TOWN CAR, Model: LINCOLN TOWN CAR 2007Pages: 328, PDF Size: 4.51 MB
Page 297 of 328
gasoline. “Premium” unleaded gasoline is not recommended because it
may cause these problems to become more pronounced. If the problems
persist, see your authorized dealer.
FFV engine (if equipped)
Your FFV will operate well on ordinary “Regular” unleaded gasoline, but
only the highest quality fuel ethanol will provide the same level of
protection and performance. To identify if your vehicle is an FFV, check
your VIN or the label on the inside of your fuel filler door. When
checking the VIN, look for the engine type identifier (8th character). If
your vehicle is an FFV, then the character will be labeled as a “2”.
If you operate your vehicle 50% or more of the time on ethanol, you
should follow a different maintenance schedule. In addition to this it is
also recommended to fill the fuel tank with regular unleaded gasoline
once every 3,000 miles (4,828 km). Seescheduled maintenance
informationfor more information.
If you are experiencing a rough or rolling idle after start-up with the
outside temperature above 80° F (27° C), the idle should improve within
10 to 30 seconds. If the problems persist below this temperature, see
your authorized dealer.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from OFF to ON several times after
refueling to allow the fuel system to pump the fuel from the tank to
the engine. On restarting, cranking time will take a few seconds longer
than normal.
•Normally, adding one gallon of fuel is enough to restart the engine. If
the vehicle is out of fuel and on a steep grade, more than one gallon
may be required.
•The
indicator may come on. For more information on the “check
engine” or the “service engine soon” indicator, refer toWarning lights
and chimesin theInstrument Clusterchapter.
ESSENTIALS OF GOOD FUEL ECONOMY
Measuring techniques
Your best source of information about actual fuel economy is you, the
driver. You must gather information as accurately and consistently as
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
297
Page 301 of 328
expected on the vehicle under optimum conditions. Your fuel economy
may vary depending upon the method of operation and conditions.
EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Do not park, idle, or drive your vehicle in dry grass or other dry
ground cover. The emission system heats up the engine
compartment and exhaust system, which can start a fire.
Illumination of the
indicator, charging system warning light or the
temperature warning light, fluid leaks, strange odors, smoke or loss of
engine power could indicate that the emission control system is not
working properly.
Exhaust leaks may result in entry of harmful and potentially
lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
301
Page 302 of 328
it from working. Information about your vehicle’s emission system is on
the Vehicle Emission Control Information Decal located on or near the
engine. This decal identifies engine displacement and gives some tune up
specifications.
Please consult yourWarranty Guidefor complete emission warranty
information.
On board diagnostics (OBD-II)
Your vehicle is equipped with a computer that monitors the engine’s
emission control system. This system is commonly known as the On
Board Diagnostics System (OBD-II). This OBD-II system protects the
environment by ensuring that your vehicle continues to meet
government emission standards. The OBD-II system also assists your
authorized dealer in properly servicing your vehicle. When the
indicator illuminates, the OBD-II system has detected a malfunction.
Temporary malfunctions may cause the
indicator to illuminate.
Examples are:
1. The vehicle has run out of fuel—the engine may misfire or run poorly.
2. Poor fuel quality or water in the fuel.
3. The fuel cap may not have been securely tightened. SeeFuel filler
capin this chapter.
These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel and/or properly tightening the fuel cap. After three
driving cycles without these or any other temporary malfunctions
present, the
indicator should turn off—A driving cycle consists of a
cold engine startup followed by mixed city/highway driving. No additional
vehicle service is required.
If the
indicator remains on, have your vehicle serviced at the first
available opportunity.
Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If the
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
302
Page 304 of 328
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your authorized dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic during hot
weather or pulling a trailer, the vehicle should be turned off for about 30
minutes to allow fluid to cool before checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated area for normal operating temperature or ambient
temperature.
M
AX
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
304
Page 317 of 328
A
Accessory delay ........................112
Air cleaner filter ...............306–307
Air suspension ...........................231
description ..............................231
Airbag supplemental restraint
system ................................175, 184
and child safety seats ............177
description ......................175, 184
disposal ....................................186
driver airbag ....................177, 185
indicator light .................184, 186
operation .........................177, 185
passenger airbag .............177, 185
side airbag ...............................184
Antifreeze
(see Engine coolant) ................285
Anti-lock brake system
(see Brakes) ..............................227
Anti-theft system ..............149, 153
arming the system ..................153
disarming a triggered system 154
Audio system
(see Radio) ......................15, 18, 24
Automatic transmission
driving an automatic
overdrive .................................233
fluid, adding ............................304
fluid, checking ........................304
fluid, refill capacities ..............309
fluid, specification ..................309
Auxiliary power point ...............110
Axle
lubricant specifications ..........309
refill capacities ........................309
traction lok ..............................231
B
Battery .......................................283acid, treating emergencies .....283
jumping a disabled battery ....255
maintenance-free ....................283
replacement, specifications ...307
servicing ..................................283
BeltMinder...............................171
Brakes ........................................227
anti-lock ...................................227
anti-lock brake system (ABS)
warning light ...........................227
fluid, checking and adding ....304
fluid, specifications .................309
lubricant specifications ..........309
shift interlock ..........................231
Bulbs ..........................................101
C
Capacities for refilling fluids ....309
Cell phone use ..............................7
Changing a tire .........................248
Child safety restraints ..............187
child safety belts ....................187
Child safety seats ......................191
attaching with tether straps ..195
in front seat ............................192
in rear seat ..............................192
Cleaning your vehicle
engine compartment ..............271
instrument panel ....................272
interior .....................................273
plastic parts ............................271
washing ....................................269
waxing .....................................270
wheels ......................................270
wiper blades ............................272
Climate control (see Air
conditioning or Heating) ............93
Clock ..........................................110
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Index
317
Page 318 of 328
Compass, electronic
set zone adjustment ...............130
Console
rear ..................................111, 118
Controls
power seat ...............................156
steering column ......................117
Coolant
checking and adding ..............285
refill capacities ................289, 309
specifications ..........................309
Cruise control
(see Speed control) ..................114
Customer Assistance ................239
Ford Extended Service
Plan ..........................................265
Getting assistance outside the
U.S. and Canada .....................266
Getting roadside assistance ...239
Getting the service you
need .........................................261
Ordering additional owner’s
literature .................................267
Utilizing the
Mediation/Arbitration
Program ...................................265
D
Daytime running lamps
(see Lamps) ................................98
Defrost
rear window ..............................96
Dipstick
automatic transmission
fluid ..........................................304
engine oil .................................280
Driving under special
conditions ..................................235
through water .........................238E
Electronic message center .......124
Emergencies, roadside
jump-starting ..........................255
Emergency Flashers .................241
Emission control system ..........301
Engine ........................................312
cleaning ...................................271
coolant .....................................285
fail-safe cooling .......................290
idle speed control ...................283
lubrication specifications .......309
refill capacities ........................309
service points ..........................278
starting after a collision .........241
Engine block heater .................226
Engine oil ..................................280
change oil soon warning,
message center .......................280
checking and adding ..............280
dipstick ....................................280
filter, specifications ........282, 307
recommendations ...................282
refill capacities ........................309
specifications ..........................309
Exhaust fumes ..........................226
F
Fail safe cooling ........................290
Flexible Fuel Vehicle (FFV) ....291
Floor mats .................................134
Fluid capacities .........................309
Foglamps .....................................98
Fuel ............................................291
calculating fuel
economy ..........................126, 297
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Index
318
Page 320 of 328
bulb replacement
specifications chart ................102
daytime running light ...............98
fog lamps ...................................98
headlamps .................................97
headlamps, flash to pass ..........98
instrument panel, dimming .....99
interior lamps .................101–103
replacing bulbs .......................103
Lane change indicator
(see Turn signal) ......................101
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........227
Load limits .................................213
Locks
childproof ................................140
doors ........................................138
Lubricant specifications ...........309
Lug nuts ....................................255
Lumbar support, seats .............156
M
Message center .........................124
english/metric button .............129
system check button ..............128
warning messages ...................132
Mirrors .......................................113
automatic dimming rearview
mirror ......................................113
fold away .................................114
heated ......................................114
programmable memory ..........144
side view mirrors (power) .....113
Moon roof ..................................119
Motorcraft parts ........274, 291, 307
N
Navigation system .......................30cd functions ..............................47
destination mode ......................71
DVD location .............................91
map mode .................................51
quick start .................................32
radio functions ..........................39
O
Octane rating ............................296
Oil (see Engine oil) ..................280
P
Parking brake ............................228
Parts (see Motorcraft parts) ....307
Passenger Occupant
Classification Sensor .................162
Pedals (see Power adjustable
foot pedals) ...............................114
Power adjustable foot pedals ...114
Power distribution box
(see Fuses) ...............................245
Power door locks ......................138
Power mirrors ...........................113
Power point ...............................110
Power steering ..........................230
fluid, checking and adding ....303
fluid, refill capacity ................309
Power trunk ......................135–136
Power Windows .........................111
R
Radio ................................15, 18, 24
Rear window defroster ...............96
Relays ........................................242
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Index
320
Page 321 of 328
Remote entry system ...............142
illuminated entry ....................147
locking/unlocking doors .........143
opening the trunk ...................143
panic alarm .............................144
replacement/additional
transmitters .............................146
replacing the batteries ...........145
Reverse sensing system ...........235
Roadside assistance ..................239
S
Safety Belt Maintenance ..........169
Safety belts (see Safety
restraints) ..................160, 164–169
Safety Canopy ...........................184
Safety defects, reporting ..........267
Safety restraints ........160, 164–169
BeltMinder............................171
extension assembly ................169
for adults .........................165–168
for children .............................187
lap belt ....................................166
Occupant Classification
Sensor ......................................162
safety belt maintenance .........169
warning light and chime ........170
Safety seats for children ..........191
Safety Compliance
Certification Label ....................313
Seat belts
(see Safety restraints) .............160
Seats ..........................................155
child safety seats ....................191
easy access/easyout feature ..159
memory seat ...................144, 160SecuriLock passive anti-theft
system ........................................149
Servicing your vehicle ..............276
Spark plugs,
specifications .....................307, 312
Specification chart,
lubricants ...................................309
Speed control ............................114
Starting a flex fuel vehicle .......225
Starting your vehicle ........223–225
jump starting ..........................255
Steering
speed sensitive .......................230
Steering wheel
controls ....................................117
tilting .......................................109
T
Tilt steering wheel ....................109
Tires ...........................199–200, 248
alignment ................................206
care ..........................................203
changing ..........................248, 251
checking the pressure ............203
inflating ...................................201
label .........................................212
replacing ..................................205
rotating ....................................207
safety practices .......................206
sidewall information ...............208
snow tires and chains ............212
spare tire .........................249–250
terminology .............................200
tire grades ...............................200
treadwear ........................199, 204
Towing .......................................219
recreational towing .................222
trailer towing ..........................219
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Index
321
Page 322 of 328
wrecker ....................................260
Traction control ........................229
Traction-lok rear axle ...............231
Transmission .............................231
brake-shift interlock (BSI) ....231
fluid, checking and adding
(automatic) .............................304
fluid, refill capacities ..............309
lubricant specifications ..........309
Trunk .........................................140
remote release ................136, 143
Turn signal ................................101
V
Vehicle Identification Number
(VIN) ..........................................313Vehicle loading
..........................213
Ventilating your vehicle
...........226
W
Warning lights (see Lights)
.......10
Water, Driving through
.............238
Windows
power
.......................................111
Windshield washer fluid and
wipers
........................................108
replacing wiper blades
...........280
Wrecker towing
.........................260
2007 Town Car(tow)
Owners Guide (post-2002-fmt)
USA(fus)
Index
322