window MAZDA 323 1989 Factory Repair Manual

PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION TABLE
Following items may be done at any time prior to delivery to your customer.
INSPECT and ADJUST, if necessary, the following items to
the specifications:
0 Glass, exterior bright metal and paint for damage
Cl Wheel lug nuts, and locks (if equipped)
88-118 N.m (9-12 m-kg, 65-87 ft-lb)
q All weatherstrips for damage or detachment
0 Operation of hood release and lock
0 Operation of trunk lid, rear hatch, and fuel lid opener
Cl With trunk open, check for spare jack, tire, tools, and
fasteners securing these items in place.
Cl Door operation and alignment
Cl Headlight aim
INSTALL the following parts:
Cl Wheel caps or rings (if equipped)
q Outside rearview mirror(s)
1 UNDER HOOD-ENGINE OFF )
INSPECT and ADJUST, if necessary, the following items to
the specifications:
0 Fuel, coolant and hydraulic lines, fittings, connections and
components for leaks
Cl Engine oil level
0 Power steering fluid level
0 Brake and clutch master cylinder fluid level
El Windshield washer reservoir fluid level
Cl Radiator coolant level
Cl Tightness of battery terminals
Cl Manual transaxle oil level
riizmiq
INSTALL the following parts:
Cl Rubber stopper for inside rearview mirror
CHECK operation of the following items:
0 Seat controls (sliding and reclining) and head restraint
Cl Folding rear seat
0 Door locks, including childproof door locks (if equipped)
Seat belts and warning system
Cl Ignition switch and steering lock
0 Inhibitor switch (ATX only)
U Starter interlock switch (clutch pedal, MTX only)
Cl All lights, including warning and indicator lamps
Cl Sound warning system
Cl Horn, wipers and washers (front and rear, if equipped)
0 Audio system (if equipped) 0 Cigarette lighter and clock
0 Sunroof (if equipped)
II Remote control outside rearview mirrors (if equipped)
Cl Power windows (if equipped)
q Heater, defroster and air conditioner at various mode
selections (if equipped)
CHECK the following items:
Cl Presence of spare fuse
0 Upholstery and interior finish
CHECK and ADJUST, if necessary, the following items:
0 Pedal height and free play of brake and clutch pedal
Pedal height mm (in) Free play mm (in)
0 Parking brake
5-7 notches/98 N (10 kg, 22lb)
UNDER HOOD-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
q Automatic transaxle fluid level
[I
CHECK the following items:
Cl Underside fuel, coolant and hydraulic lines, fittings, con-
nections and components for leaks
0 Tires for cuts or bruises
0 Steering linkage, suspension, exhaust system and all un-
derside hardware for looseness or damage
[I
CHECK the following items:
0 Brake operation
0 Clutch operation
Cl Steering control
Cl Operation of gauges
q Squeaks, rattles or unusual noise
Cl Emergency locking retractors
0 Cruise control system (if equipped)
1 AFTER ROAD TEST (
CHECK for necessary owner information materials.
Following items must be done just before the delivery to your customer.
q Load test battery and charge if necessary
1 Volts 1 0 Install fuses for accessories
i.. _
0 Adjust tire pressure to the specification
Load test result cl Remove seat and floor mat protective covers
(Refer to door label) 0 Vacuum and clean interior of vehicle
0 Clean outside of vehicle q Inspect installation of option parts with invoice
23UOAX-002
A-2

F OUTLINE
A comparison of the new and previous models is as follows.
Engine Control Unit Terminal Relation Ship Chart
Connected to
Headlight switch Terminal
Connected to Terminal
New Previous New Previou
1H IU
Water thermosensor 2E 2Q
Diagnosis connector
(TEN terminal) / II 1 IK 1 1 Throttle sensor
Rear window defroster switch
I I 21 2K
Ground (California)
Main relay (Canada)
A/C relay
Vehicle speed sensor
P/S pressure switch
A/C switch
Blower control switch 1K 2H
IL 1J
1M --
1N 1P
10 IQ
1P 1s Distributor
(G-signal) [DOHC]
Intake air thermosensor
Solenoid valve
(Purge control)
Ground (Injector)
Ground (Output)
Ground (CPU) 2J 2G
2K 2P
20 2x
___
Stoplight switch 1Q 10
Ground (Input)
1 I I 1 ! 3D ! 2D
Cruise control main switch
1 lS / - II8cRalnardega,y
Throttle sensor
(Idle switch)
Distributor
(Ne-signal) 1T 1N
2A 2E
2B 20
2C 2N Solenoid valve
(VICS)
--.-- I_-
Solenoid valve
(Pressure regulator) [BP] 31 2s
-- -_
3M 2T
Airflow meter
Oxygen sensor
-
Fan switch 1 2D 1 IR 1 1 lniector (Nos. 2, 4) I 3v I 2v
23UOFX-01 I
F-l 4

F OUTLINE
COMPONENT DESCRIPTIONS
Component
Air cleaner
Airflow meter
Mr valve
Atmospheric pressure
Sensor
Catalytic converter Function Remark
Filters air entering throttle body
Detects amount of intake air; sends signal to intake air thermosensor and fuel pump
ECU switch included
Supplies bypass air into dynamic chamber
l Engine speed increased to shorten
when engine is cold warm-up period
l Thermowax type l Installed in dynamic chamber
Detects atmospheric pressure; sends signal Built in ECU
to ECU
Reduces HC, CO, and NOx by chemical Monolith type
reaction Charcoal canister
Stores fuel tank fumes while engine stopped Check valve
Controls pressure in fuel tank Two-way type Circuit opening relay
Voltage for fuel pump while engine running Clutch switch (MTX)
Detects clutch condition; sends signal to Switch OFF when clutch pedal released
ECU Diagnosis connector
Concentrated service connector 25pin (located near left suspension mount-
Concentrated terminals: ing block)
1. EGI self-diagnostic terminal
2. EC-AT self-diagnostic terminal
3. Test terminal
4. Fuel pump check terminal
5. Cooling fan check terminal
6. Engine rpm output terminal Dynamic chamber
Interconnects all cylinders Engine control unit (ECU) Detects the following:
1. A/C operation 1. A/C switch
2. Air/fuel ratio (Oxygen concentration) 2. Oxygen sensor
3. ATF thermosensor
4. Atmospheric pressure 4. Atmospheric pressure sensor
5. Braking signal 5. Stoplight switch (MTX)
6. Cranking signal 6. Ignition switch (START Position)
7. DRL (Daytime Running Light) operation 7. DRL relay (Canada)
8. E/L operation 8. Blower motor switch, cooling fan relay,
headlight switch, and rear window
defroster switch
9. Engine coolant temperature 9. Water thermosensor
10. Engine speed 10. Distributor (Ne-signal)
11. Ignition ON signal 11. Ignition switch
12. In-gear condition 12. Neutral and clutch switches (MTX)
13. Inhibitor switch (ATX) 13. N range, D range, S range, L range
switch
14. Intake air amount 14. Airflow meter
15. Intake air temperature 15. Intake air thermosensor
(In airflow meter)
16. No.1 piston TDC of compression
17. P/S operation
18. Shift solenoid (ATX)
19. Test signal (Ignition timing, idle speed,
Malfunction code No.)
20. Throttle valve fully closed/fully open
condition 16. Distributor (G-signal) DOHC)
17. P/S pressure switch
18. 1-2, 2-3, 3-4, Lockup solenoid
19. Diagnosis connector
(TEN terminal)
20. Throttle sensor (MTX)
21. Throttle valve opening angle
22. Turbine sensor 21. Throttle sensor (ATX) .__r
F-10

SELF-DIAGNOSIS FUNCTION F
SWITCH MONITOR FUNCTION
Individual switches can be inspected by the SST (Self-Diagnosis checker).
Note
l The TEN terminal of the diagnosis connector must be grounded and the ignition switch ON
(engine stopped).
l If either of the switches remain activated, the monitor lamp will be illuminated.
ECU
NEUTRAL SWITCH (MTX)
CLUTCH SWITCH (MTX)
=d-’ 1
BATTERY
INHIBITOR SWITCH (ATX)
STOPLIGHT SWITCH (MTX)
HEADLIGHT SWITCH MONITER LAMP
REAR WINDOW (SELF-DIAGNOSIS CHECKER)
DEFROSTER SWITCH
AIC SWITCH
BLOWER SWITCH
THROTTLE SENSOR asp-
- _
COOLING FAN SWITCH
03UOFX
Switch
Clutch switch
Neutral switch (MW
(M-W Self-Diagnosis Checker (Monitor lamp)
Light ON Light OFF Pedal released Pedal depressed
In gear Neutral Remark In gear
Clutch pedal released
Inhibitor switch
(ATX) L, S, D or R range
N or P range -
Throttle sensor Pedal depressed (Not fully) Pedal released/fully depressed -
Stoplight switch
Pedal depressed Pedal released -
Headlight switch
ON
OFF Headlights/parking lights: ON
Blower switch
ON
OFF Blower switch at 2nd or
above position
AIC switch
ON OFF Fan speed control at 1st po-
sition
Rear window defroster
switch ON
OFF -
Water thermoswitch Fan operating Fan not operating -
23UOFX-084
F-l 05

SELF-DIAGNOSIS FUNCTION
Headlight switch
Turn headlight switch ON
Check that monitor lamp illuminates
YES
Headlight switch OK
Turn headlight switch OFF NO
PC: l Headlight switch malfunction v Section T
*Open circuit in wire harness
from headlight switch to ECU
l ECU terminal 1 U (MTX) 1 H
(ATX) voltage incorrect CT page F-152
l ECU malfunction
23UOFX-087
Rear window defroster switch
Turn rear window defroster switch ON
Check that monitor lamp illuminates
YES
Rear defroster switch OK
Turn rear window defroster switch OFF NO
_ PC: *Rear window defroster switch
malfunction c7 Section T
*Open circuit in wire harness
from rear window defroster
switch to ECU
l ECU terminal 1 T (MTX) 1 J (ATX)
voltage incorrect
u page F-152
l ECU malfunction
23UOFX-088
Inhibitor switch (ATX)
Shift transaxle into L, S, D, or P range
Check that monitor lamp illuminates
YES
Inhibitor switch OK
Shift into P or N range PC: l Inhibitor switch malfunction
*Open or short circuit in related
23UOFX-089
F-l 07

F CONTROL SYSTEM
VB: Battery voltage
erminal Input Output Connection to Test condition Corrsct voltage Remark
1M - - - - - -
IN 0 Throttle sensor Accelerator pedal released ov Ignition switch
(Idle switch)
Accelerator pedal depressed
VB ON
10 0
1P 0 Stoplight switch
P/S pressure
switch Brake pedal released
Brake pedal depressed
Ignition switch ON
P/S ON at idle
P/S OFF at idle ov
-
VEi
Va
ov
VS -
10 0 A/C switch A/C switch ON
A/C switch OFF Below 23 Ignition switch
VS ON and blower
motor ON
1R 0
IS 0 Fan switch
Blower control
switch Fan operating (Engine coolant tempera-
ture over 97% (207OF) or diagnosis con-
nector terminal TFA grounded)
Fan not operating (Idle)
Blower control switch OFF or 1st position
Blower control switch 2nd or higher po-
sition ov
-
V0
Ve ignition switch
ov ON
IT 0 Rear window
defroster switch Rear window defroster switch OFF
Rear window defroster switch ON ov
VB
Ignition switch ON
1u 0
iv 0 Headlight switch
Neutral/Clutch
switches Headlights ON
Headlights OFF
Neutral position or clutch pedal
depressed
Others V0
-
ov
ov
VB -
1 I lr----t
r-i
ul r
2Y 2w 2u 2s 20 20 2M 2K 21 2G 2E 2’3 2A 1lJ 1s IQ 10 1M 1K 11 1G 1E 1~ 1A
22 2x 2v 2T 2R 2P 2N 2L 2J 34 2t= 2D 28 Ii/ fT 1R 1p IN 1L 1J 1H 1F 1D 18
F-l 52

CONTROL SYSTEM F
Ve: Battery voltage
Incorrect voltage
1, -
Always below l.OV
Always Ve
Always below I.OV (Stoplight OK)
Always below l.OV
Always
VB
Always below 25V (Blower fan OK)
Always
VB (Blower fan OK)
Always below 1 .OV
(Electrical cooling fan OK)
Always below 1 .OV (Blower fan OK)
Always
VB (Blower fan OK)
Always below
1 .ov
Always below l.OV Illumination lamp
ON when rear
window defroster
switch ON
Illumination lamp
never ON
(Headlights OK)
Always below l.OV
Always Ve Possible cause
-
l Throttle sensor misadjustment (Refer to page F-169)
l Short circuit in wiring from throttle sensor to ECU terminal 1N l ECU malfunction
l Throttle sensor misadjustment (Refer to page F-169) l Open circuit in wiring from throttle sensor to ECU terminal IN l Open circuit in wiring from throttle sensor to ECU terminal 2D
l Open circuit in wiring from stoplight switch to ECU terminal 10
l P/S pressure switch malfunction (Refer to page F-173) l Short circuit in wiring from P/S pressure switch to ECU terminal 1P l ECU malfunction
l P/S pressure switch malfunction (Refer to page F-173) l Open circuit in wiring from P/S pressure switch to ECU terminal 1P l Open circuit in wiring from P/S pressure switch to ground
l A/C switch malfunction (Refer to page U-55) l Short circuit in wiring from A/C switch to ECU terminal 10 l Poor connection at ECU connector l ECU malfunction
l A/C switch malfunction (Refer to page U-55) l Open circuit in wiring from A/C switch to ECU terminal 1Q l Open circuit in wirina from A/C switch to blower control switch
l Open or short circuit in wiring from fan relay to ECU terminal 1R l ECU malfunction
l Short circuit in wiring from blower control switch to ECU terminal 1s l Poor connection at ECU connector l ECU malfunction
l Open circuit in wiring from blower control switch to ECU terminal IS
I
l Open or short circuit in wiring from rear window defroster switch to ECU
terminal 1 T
l Open circuit in wiring from ignition switch to rear window defroster switch l Rear window defroster switch malfunction (Refer to page T-21)
l Open or short circuit in wiring from headlight relay to ECU terminal 1U
(Refer to page F-152)
l Neutral switch malfunction (Refer to page F-173) l Clutch switch malfunction (Refer to page F-172) l Short circuit in wirino from ECU terminal IV to neutral or clutch switch
l Neutral switch malfunction (Refer to page F-173) l Clutch switch malfunction (Refer to page F-172) l Open circuit in wiring from ECU terminal 1V to neutral or clutch switch l Poor connection at ECU connector
23UOFX-136
F-l 53

F CONTROL SYSTEM
Terminal voltage (ATX)
VB: Battery voltage
erminal Input Output
Connection to Test condition Correct voltage Remark
IA - -
Battery Constant --- Va For backup
16 0 Main relay
lgnrtion switch OFF ov
(FUEL INJ relay) -
ON Vs
IC 0 Ignition switch While cranking Approx. 1 OV
(START) -
Ignition switch ON
ov
_
ID 0 Self-Diagnosis Test switch at “SELF-TEST” With Self-
Checker Lamp illuminated for 3 sec. after ignition 4.5-5.5v Diagnosis Check-
(Monitor lamp) switch OFF-ON er and System
Lamp not illuminated after 3 sec.
VB Selector
Test switch at “02 MONITOR” at idle
Monitor lamp illuminated 4.5-5.5v
Test switch at
“02 MONITOR” at idle
Monitor lamp not illuminated VB
1E 0 Malfunction indica- Lamp illuminated for 3 sec. after ignition
Below 2.5V With System
tor lamp (MIL) switch OFF+ON Selector test
Lamp not illuminated after 3
sec. VS switch at
“SELF-TEST”
Lamp illuminated Below 2.5V
Lamp not illuminated VR
IF 0 Self-Diagnosis Buzzer sounded for 3 sec. after ignition
Below 2.5V
l With Self-
Checker switch OFF+ON Diagnosis
(Code Number)
Buzzer not sounded after 3 sec.
VB Checker and
Buzzer sounded Below 2.5V System Selector
l With System
Buzzer not sounded
VB Selector test
switch at
“SELF-TEST”
IG 0 Igniter Ignition switch ON ov
-
Idle Approx. 0.2V
1H 0 Headlight switch Headlrghts ON VB
-
Headlights OFF Below 1 .OV
II
0 Diagnosis System Selector test switch at Ignition switch
connector
“02 MONITOR” VE
ON
(TEN terminal)
System Selector test switch at
“SELF-TEST” ov
1J 0 Rear window
defroster switch Rear window defroster switch OFF
Rear window defroster switch ON ov
VB
Ignition switch
- ON
1K 0 Ground (California) Constant ov
Main relay Ignition switch ON VB -
I
3 J
IJ- J-1
u- Fl
IJ -‘--l. r
3~ lawlau13SI3Q13013M]3K131 13Gl3EI3C (3A 20]2M;2KI21 (2Gl2E12C)2A ltJ~LS~lo)l01~~1~ II IIG~IE( 1CIlA
32 13x I3v 13~13~l3~13N13~13~13~13~I 3~ 138 ~P)~N)L?L~~J(~H(~F~~D~z!B iv ~IT~IR~IP IN~IL 1 J IIHIIFI ID~IS
F-l 58

CONTROL SYSTEM F
VB: Battery voltage
Incorrect voltage Possible cause
Always OV l ROOM 10A fuse burned l Open circuit in wiring from ROOM 10A fuse to ECU terminal 1A
Always OV
l Main relay malfunction (Refer to page F-171) l Open or short circuit in wiring from main relay to ECU terminal 1B
Always OV (Starter turns)
l Open or short circuit in wiring from or inhibitor switch (ATX) to ECU termi-
nal 1C
Always OV
Always Ve
Always 4.5~5.5U
l Main relay (FUEL INJ relay) malfunction (Refer to page F-171) l Open circuit in wiring from main relay to diagnosis connector terminal +B l Open or short circuit in wiring from diagnosis connector terminal MEN to
ECU terminal 1D
l Poor connection at ECU connector l ECU malfunction
l ECU malfunction
Always below
25v
Always Va MIL always ON
MIL never ON
l Short circuit in wiring from combination meter to ECU terminal 1E l ECU malfunction
l Open circuit in wiring from combination meter to ECU terminal 1E
l Poor connection at ECU connector l ECU malfunction
Always below
2.5V
Always VB No display on Self- * Main relay (FUEL INJ relay) malfunction (Refer to page F-171)
Diagnosis Checker
l Open circuit in wiring from main relay to diagnosis connector terminal +B
“88” displayed and
l Open or short circuit in wiring from diagnosis connector terminal FEN to
buzzer sounds con- ECU terminal 1F
tinuously
l Poor connection at ECU connector l ECU malfunction
Always OV
l Short circuit in wiring from igniter to ECU terminal 1G
Always below 1 .OV (Headlights OK)
l Open or short circuit in wiring from headlight relay to ECU terminal 1H
(Refer to page F-171)
Always OV
Always VB
Always OV Illumination lamp
ON when rear
window defroster
switch ON
Illumination lamp
never ON
Approx. 5V (California)
Always OV (Canada)
l Short circuit in wiring from diagnosis connector terminal TEN to ECU termi-
nal II
l Open circuit in wiring from diagnosis connector terminal TEN to ECU termi-
nal II
l Open circuit in wiring from diagnosis connector terminal GND to ground
l Open or short circuit in wiring from rear window defroster switch to ECU
terminal 1 J
l Open circuit in wiring from ignition switch to rear window defroster switch l Rear window defroster switch malfunction (Refer to page T-21)
l Open circuit in wiring from ECU terminal 1K to ground
l Short circuit in wiring from ECU terminal 1K to main relay (FUEL INJ relay)
23UOFX-14: 2
f-1 59

S
BODY
INDEX ........................................................ 2
HOOD ........................................................
COMPONENTS ........................................ t
FRONT FENDER PANEL .............................. ;I
COMPONENTS ........................................ S- ::
FRONT DOOR ............................................. S- 8
COMPONENTS ........................................ S- 8
FRONT SIDE WINDOW REGULATOR AND
GLASS ..................................................... s- 10
COMPONENTS ........................................ s- 10
FRONT DOOR LOCK AND OPENER .............. S- 13
COMPONENTS ........................................ s- 13
REAR DOOR ............................................... s- 15
COMPONENTS ........................................ s- 15
REAR SIDE WINDOW REGULATOR AND
GLASS ..................................................... s- 17
COMPONENTS ........................................ s- 17
REAR DOOR LOCK AND OPENER ...........
.-. ...
S- 19
COMPONENTS ........................................ s- 19
REAR HATCH ............................................. s- 20
COMPONENTS ........................................ s- 20
REAR HATCH LOCK AND OPENER.. .............
S- 22
COMPONENTS ........................................ s- 22
POWER DOOR LOCK SYSTEM.. ................... S- 23
STRUCTURAL VIEW .................................. S- 23
TROUBLESHOOTING GUIDE ...................... S- 24
DOOR LOCK SWITCH ............................... S- 28
DOOR LOCK CONTROL ............................ S- 26
DOOR LOCK TIMER AND RELAY ............... S- 26
POWER WINDOW SYSTEM .......................... S- 27
STRUCTURAL VIEW .................................. S- 27
TROUBLESHOOTING GUIDE.. .................... S- 28
MAIN POWER WINDOW SWITCH.. .............. S- 31
POWER WINDOW SUB-SWITCH.. ................ S- 32
POWER WINDOW MOTOR ......................... S- 32
TRUNK LID .................................................
s- 33
COMPONENTS ........................................ s- 33
TRUNK LID LOCK AND OPENER.. ................ S- 35
COMPONENTS ........................................ s- 35
FUEL FILLER LID AND OPENER ................... S- 37
COMPONENTS ........................................ s- 37
FRONT BUMPER ......................................... s- 39
COMPONENTS ........................................ s- 39
REAR BUMPER ........................................... s- 40
COMPONENTS ........................................ s- 40
REAR SPOILER ........................................... s- 41
COMPONENTS ........................................ s- 41
MOLDING, PROTECTOR, GARNISH .............. S- 42
UPPER WINDSHIELD MOLDING,
A-PILLAR GARNISH ................................ S- 42
REAR WINDOW MOLDING (PROTEGE) ........ S- 43
REAR WINDOW MOLDING (HATCHBACK) ... S- 44
ROOF MOLDING ...................................... S- 46
BELTLINE MOLDING ................................ S- 48
SIDE PROTECTOR.. .................................. S- 49
RADIATOR GRILLE, LOWER GRILLE
MOLDING ................................................. s- 51
COMPONENTS ........................................ S- 51
REAR FINISHER.. ........................................
S- 52
COMPONENTS ........................................ S- 52
COWL GRILLE ............................................ s- 53
COMPONENTS ........................................ s- 53
EXTRACTOR CHAMBER ..............................
COMPONENTS ........................................ g-
- ;; OUTSIDE MIRROR ....................................... s- 54
TROUBLESHOOTING GUIDE.. .................... S- 54
POWER OUTSIDE MIRROR SWITCH ............ S- 55
POWER OUTSIDE MIRROR.. ...................... S- 56
COMPONENTS ........................................ s- 66
WINDSHIELD .............................................. S- 58
PREPARATION ......................................... S- 58
COMPONENTS ........................................ S- 58
QUARTER WINDOW GLASS ......................... S- 62
COMPONENTS .................. ..T ................... S- 82
REAR WINDOW GLASS ............................... S- 63
PREPARATION ......................................... S- 63
COMPONENTS ........................................ S- 63
WINDSHIELD WIPER AND WASHER ............. S- 87
TROUBLESHOOTING GUIDE.. .................... S- 67
WIPER MOTOR ........................................ s- 70
WASHER MOTOR ..................................... s- 71
WINDSHIELD WIPER AND WASHER
SWITCH ................................................ s- 71
COMPONENTS ........................................ S- 72
REAR WIPER AND WASHER ........................ S- 74
TROUBLESHOOTING GUIDE.. .................... S- 74
REAR WIPER MOTOR ............................... s- 77
REAR WASHER MOTOR ............................ s- 77
REAR WIPER AND WASHER SWITCH.. ........ S- 77
COMPONENTS ........................................ S- 78
SLIDING SUNROOF ..................................... S- 80
TROUBLESHOOTING GUIDE.. .................... S- 80
MOTOR ASSEMBLY .................................. S- 81
SUNROOF RELAY .................................... S- 82
SUNROOF SWITCH
(OVERHEAD CONSOLE) .......................... S- 82
COMPONENTS ........................................ S- 83
HEADLINER ................................................ S- 89
COMPONENTS ........................................ S- 89
DASHBOARD .............................................. s- 94
COMPONENTS ........................................ s- 94
TRIM .......................................................... s- 97
COMPONENTS ........................................ s- 97
FLOORMAT ................................................ s- 99
COMPONENTS ........................................ s- 99
SEAT BELT ................................................ S-l 00
COMPONENTS ........................................ S-l 00
SEAT BELT .............................................. S-l 02
BUCKLE SWITCH ..................................... s-102
PASSIVE SHOULDER BELT SYSTEM.. .......... S-103
STRUCTURAL VIEW .................................. s-103
TROUBLESHOOTING GUIDE.. .................... S-104
PASSIVE SHOULDER BELT MOTOR.. .......... S-106
DOOR CATCH SWITCH ............................. S-l 07
LIMIT SWITCH (FRONT/REAR)
WARNING SWITCH ....................................................... z-:X;
-
SPEED SENSOR ....................................... s-i 07
COMPONENTS ........................................ S-l 08
SEAT ......................................................... s-110
COMPONENTS ........................................ s-110
SEAT ASSEMBLY ..................................... S-l 13
UNDERBODY DIMENSIONS .............. ..: ......... S-116
PROJECTED DIMENSIONS (PROTEGE) ........ S-116
PROJECTED DIMENSIONS (HATCHBACK). .. S-117
STRAIGHT-LINE DIMENSIONS (PROTEGE). .. S-118
STRAIGHT-LINE DIMENSIONS
(HATCHBACK) ........................................ s-119
23UOSX.001