power steering fluid MAZDA 323 1992 Workshop Manual Suplement

A PRE-DELIVERY INSPECTION TABLE
PRE-DELIVERY INSPECTION TABLE
[EXTERlORI
INSPECT and ADJUST, of necessary. the followlng Items to
specrfrcatron:
0 Glass, exterior bright metal and paint for damage
0 Wheel lug nuts
0 Tire pressures
0 All weatherstrips for damage or detachment
0 Operation of bonnet release and look
0 Operation of trunk Ild, hatch and fuel lbd opener
(of equipped)
0 Door operation and alignment
0 Headtrght aiming
INSTALL the foltowrng parts
0 Wheel caps or rrngs (if equipped)
0 Outsrde mirror(s)
1 UNDER BONNET-ENGINE OFF j
INSPECT and ADJUST. If necessary, the following items to
specrflcatlon.
0 Fuel, coolant and hydraulic tines, fittings, connectlons and
components for leaks
0 Engine 011 level
0 Power steering fluid level (of equipped)
0 Brake master cylinder fluky levels
0 Clutch master cylinder fturcl levels (If equipped)
0 Wtndshreld washer reservojr flurd level
0 Radiator coolant level and specrfic gravity
0 Tightness of water hose clamps
0 Tightness of battery terminals, electrolyte level and specific
gravity
0 Manual transaxle oil level
0 Drive belt(s) tension
Cl Carburetor lrnkage (choke control, wrde open throttle posi-
tion. etc ) (carburetor model only)
q Accelerator cable and linkage for free movement
0 Headlight cleaner and flurd level (if equipped)
BLEED air from fuel line (diesel engrne only)
CLEAN the spark plugs (except for diesel engine)
piEi6F]
INSTALL the following parts
0 Rubber stopper for rnsrde rear view mirror (if equjpped)
0 Fuse for accessories
CHECK the operation of the following items.
0 Seat controls (sliding and reclining) and head rest
0 Seat belts and warning system
Cl Ign&on switch and steering lock
0 Power window (if equipped)
D Door tacks including child proof door locks
Cl Inhibitor switch (ATX only)
Cl All Ikghts rncluding warning and Indicator lbghts
0 Ignition key reminder buzzer (If equipped)
A-Z
0 Horn, wbpers and washers (front and rear, If equipped)
0 Antenna (tf equipped)
0 Cigarette Ibghter and clock (if equipped)
0 Remote control outside mirror (if equrpped)
0 Heater, defogger and air conditioner at various mode selec-
tions (if equlppedj
0 Sunroof (If equipped)
CHECK the following items
0 Presence of spare fuse
0 Upholstery and Interior finish
CHECK and ADJUST, If necessary, the followjng items:
IJ Operation and fit of windows
0 Pedal height and free play of brake and clutch pedal
0 Parking brake UNDER BONNET-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Operation of Idle-up system for air condbtroner or power steer-
ing (if equrpped)
0 Automatic transaxle flurd levet
0 tnltial ignrtlon timing (except disel engine)
0 Idle speed
0 Operation of throttle positron. sensor (EGI engrne)
0 Operation of cold start device and glow plug warning light
(diesel engine only)
0 Operation of dash pbt (EGI.engine)
fTiGGJ
CHECK the following items.
0 Underside fuel, coolant and hydraulic Irnes, ftttlngs, connec-
tions and components for leaks
0 Trres for cuts or brurses
0 Steering Itnkage, suspensron, exhaust system and all under-
side hardware for .looseness or damage 1 ROAD TEST j
CHECK the following items
0 8rake operation
0 Clutch operation
0 Steering control
!ZI Operation of meters and gauges
Cl Squeaks, rattles or unusual noises
Cl Engine general performance
0 Emergency locking retractors 1 AFTER ROAD TEST ]
REMOVE the seat and floor mat protective covers
CHECK for the necessary owner information materials, took
and spare tire
m vehicle
93EOAX-002
-- MAIN Char3 t: In
A: PC R: F!t T: Ti! Emis! The ed : to t!

SCHEDULED MAINTENANCE SERVICES A
SCHEDULED MAINTENANCE SERVICES
MAINTENANCE TABLE
Chafi symbols:
1 : Inspect: Visual examination and/or functional measurement of system’s operation or
performance , A: Adjust: Examination resulting in adjustment or replacement
n
R: Replace or change
T: Tighten
REMARKS
After 80,000 km or 48 months, continue to follow the described maintenance at the recommended intervals.
As for * marked items in this maintenance chart, note the following points.
+ 1 Major service interval at 12 months/20,000 km (12,000 miles).
Lubrication service based on distance only 10,000 km (6,000 miles) not time.
l 2 Adjust or inspect alternator and water pump drive belt, and power steering and air conditioner drive belt
if equipped.
‘3 Replacement of the timing belt is required at every 100,000 km (60,000 mile). Failure to replace the tim-
ing bett may result in damage to the engine.
‘4 tf the vehicle is operated under any of the following conditions, it is suggested that the engine oil and
oil filter be changed more often than the recommended intervals.
a) Driving in dusty conditions. I
:
b) Extended periods of idling or low speed operation. i
i!
c) Driving for a prolonged periods in cold temperatures or regularly driving onty short distances.
*5 If the vehicle is operated in very dusty or sandy areas, inspect and, if necessary, replace more often
than at usual recommended intervals.
l 6 This IS a full function check of all electrical systems, i.e, atl
ltghts. washers (including condition of blades)
electric windows, sunroof, horn etc.
‘7 Replace every two years. $1
‘I
If there has been continuous hard driving, mountain
drivtng, or if the brakes are used extensively or the
vehicle is operated in extremely humid climates, the brake fluid should be changed annually.
Emission Control and Related Systems
The ignition and fuel systems are vitally important to the proper operation of the-emission control and relat-
ed system, as well as for efficient engine operation. It is strongly recommended that all servicing related
to these systems be done by your Authorised Mazda Dealer.
13EOAX-302 -4
I!
A-3

N OUTLJNE
UUTLJNE
OUTLINE Of CONSTRUCTION
l EncJine speed sensing power steering (ESPS) is standard equipment for all models. The construction and
operation are basically the same as for previous models.
l The lock-to-lock specification of the steering wheel is reduced from 2.76 to 2.51.
13EONX-302
SPECIFICATIONS
hem Specifications
Steermg wheel Outer diameter mm {in] 370 { 14.57)
Lock-to-lock turns :i-‘~~:~.~~~~~~:~~;~~~~ :;‘:.. .‘:I .:::::.::~::::,:.:::.i: ,,,,.,:, :‘,:,,.:,: .,: I. . ..- :.~6:.n.:::;,:~~:~~~~~~~.~::~,:~:.: :: :
” .: ‘-.: .:.:::~:‘::.‘.::‘:‘:.I;:.‘,.: >.. .: :” 3 :. ,;:.+..i<.I. ‘_ : ; t:
. . ..: :: ::.:. .:::. ::r .;
. . . . . . . . . .y : :.: ,. .: ,_ : ., :
Me Collapsible
Steering shaft and joint Joint type
Tilt stroke
J 2-cross joint
mm {in] 30 11.18)
Type Rack-and-pinion
I
Steering gear Gear ratio
Rack stroke mm [in] 00 (infinite)
121 f4.761
Capacity
Power steertng fluid 1 (US qt Imp qt) 018 (0.85, 0.701
We ATF DexrorPlI or M-ID
,
Shaded area rndicates new specrfcatlon. t3EONX-303
N-2

PARTS INDEX
PARTS NAME PAGE
PARTS NAME PAGE
I KNOCK CONTROL UNIT...................30
KNOCK SENSOR.........................30 .82
.82
.82
.82
.82
.32
.26
.72
a LICENSE PLATE LIGHT...............48.5 0
B MAIN RELAY(FUEL INJ)
............... ..2 8
1 NEUTRAL SWITCH.......................3 2
$3 OIL PRESSURE SWITCH..................3 8
OXYGEN SENSOR........................2 8
J PANEL LIGHT CONTROL..................7 0
PARKING BRAKE SWITCH.................3 8
POSITION LIGHT....................44,5 0
POWER DDOR LOCK SWITCH...............7 6
POWER DDOR LOCK TIMER UNIT...........7 6
POWER DOOR LOCK ACTUATOR.............7 6
POWER OUTSIDE MIRROR MOTOR...........7 0
POWER OUTSIDE MIRROR SWITCH..........7 8
POWER STEERING PRESSURE SWITCH.......3 2
POWER WINDOW MAIN SWITCH.............7 4
POWER WINDOW MOTOR...................7 4
e
1 BACK-UP LIGHT SWITCH.................60
BACK-UP LIGHT....
BLOWER MOTOR.....:::::::::::::::::::’
.E
BLOWER SWITCH........................62
BRAKE FLUID SWITCH...................38
POWER WINDOW SWITCH..................74
J D REAR FOG LIGHT RELAY.
REAR FOG LIGHT SWITCH
REAR FOG LIGHT.......
REAR SPEAKER......... ................
................ zz
................
52
................
................ E
................ 42
............... .
..: 2
.Riik+‘::::::::..6 4
SWITCH.........6 4
................
................ :z
................ 62
............. 44, 48
I CIGARETTE LIGHTER..
CIRCUIT OPENING REL
CLUTCH SWITCH...
COMBINATION SWITCH:
CONDENSER.......
COOLING FAN MOTOR::
COOLING FAN RELAY..
COURTESY LAMP.....,
CPU................ . .64
/ii’::::::::::::::..2 8
..................
... 44, 46, 48, 50, 52, %
..................
.................. 2:
..................
.................. 2:
............... 42, 66
B DIAGNOSIS CONNECTOR.....
DIGITAL CLOCK...........
n-rnnc ............
............ E
............
............ %
............
............ ZE
TURN LIGHT....
WASHER MOTOR.. REAR
REAR
REAR
REAR
REAR
REAR
REAR
REAR
-ih .ER
-ER
RESISTOR ASSEMBLY..
RUNNING LIGHT RELAY
il SEAT WARMER...........
SEAT WARMER REALY.....
SEAT WARMER SWITCH....
SHORT CONNECTOR.......
SLIDING SUNROOF MOTOR.
SLIDING SUNROOF RELAY.
SLIDING SUNROOF SWITCH
SLIDING SUNROOF.......
SOLENOID RESISTOR.....
SOLENOID VALVES
PRC HIGH TEMP........
PRC LOW TEMP.........
PURGE CONTROL........
WASTEGATE............
SPEED SENSOR..........
SPOT LAMP.............
STARTER...............
STOPLIGHT CHECKER..... ........
........
........
........
........
........
........
........
........ ....... 84
.......
....... ::
.......
.... 66.2
.......
.... 66, Ei
.......
....... ........
........
........
........
........
........
........
........
........
........
.
. . . . . . z:
. . .
. . . . zoo
. 1 .
. . . . E
. . . .
56, ::
. . 56, 58
. . 56, 58
“J.“LJL................. DISTRIBUTOR ............
DOOR SPEAKER ........... .
DOOR SWITCH........: .... 8
3 ENGINE CONTROL UNIT............ ,28, 30. 32
3 FLASHER UNIT...
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT SIDE TURN
FRONT TURN LIGH
FUEL METER.....
FUEL PUMP REALY
FUEL PUMP UNIT.
FUEL PUMP......
-. -- ............
............ 22 .
. . RiiA‘i 1
SWITCH
i&ii 1 ............ 52
............ .
............ 22
.....................
..................... %
.....................
..................... %
..................... 28 -
tust ....................
B
G SENSOR ................
13 HAZARD SWITCH............
HEADLIGHT CLEANER MOTOR..
HEADLIGHT CLEANER SWITCH.
HEADLIGHT LEVELING ACTUAT
HEADLIGHT LEVELING SWITCH
HEADLIGHT RELAY..........
ENI- IGHT. . . . . .
HORN RELAY...............
HORN SWITCH.............. ...
40, 46, 52, 64
: ........... 82
............ 54
........... .
..: ii
&::::::::..4 6
HORN..................I 1
HYDRAULIC UNIT ..........
01 IC REGURATOR ............
IG KEY CYLINDER LAMP ....
IGNITER .................
IGNITION COIL ...........
ILLUMINATION LAMP .......
AUDIO SYSTEM ...........
BLOWER SWITCH .......... ............
46
............ 44
......... 44, 46
............
............ E
............
............ E
...........
........... 2:
...........
........... 2
...........
........... 5:
...........
........... 5:
...........
........... 5::
...........
........... 5:
..........
.%
;ci:::::::.;;
........... CIGARETTE LIGHTER: ;.I:;::
FRONT FOG LIGHT SWITCH...
HAZARD SWITCH...........
HEADLIGHT CLEANER SWITCH:
HEADLIGHT LEVELING SWITCH
INSTRUMENT CLUSTER.......
REAR FOG LIGHT SWITCH....
REAR WINDOW DEFROSTER SW1
SEAT WARMER SWITCH.......
INDICATOR LAMP...........
...........
........... 33:: ...........
30 STOPLIGHT SWITCH ......
STOPLIGHT .............
0 TAChOMETER...........................3 8
TAILLIGHT.........................48,5 0
TEMP METER...........................3 8
THROTTLE SENSOR......................3 2
TRANSFER PUMP........................2 8
TRUNK COMPARTMENT LAMP SWITCH........6 8
TRUNK COMPARTMENT LAMP...............6 8
TURN SWITCH..........................5 4
q WARNING LAMP.........................3 8
WASHER LEVEL SENSOR..................3 8
WATER THERMOSENSOR................30,3 8
WATER THERMOSWITCH................... 6
WINDSHIELD WASHER MOTOR..............4 0
WINDSHIELD WASHER SWITCH.............4 0
WINDSHIELD WIPER MOTOR...............4 0
WINDSHIELD WIPER SWITCH..............4 0 INJECTOR..........:;.:::::
INJECTOR RESISTOR .........
INSTRUMENT CLUSTER .....
INTERIOR LAMP..........:::
ISC VALVE .................
. . . . . , . . . . .
. . . . . . . . . . . iz:
,..........
30