engine coolant MAZDA MODEL 2 2017 (in English) Owner's Manual

6–30
Maintenance and Care
Owner Maintenance
The coolant should be at full in the
radiator and between the F or FULL and
L marks on the coolant reservoir when the
engine is cool.
SKYACTIV-G 1.3 and SKYACTIV-G
1.5


Cooling system cap Coolant reservoir
Cooling fan

SKYACTIV-D 1.5


Cooling system cap Coolant reservoir
Cooling fan

If it is at or near L, add enough coolant to
the coolant reservoir to provide freezing
and corrosion protection and to bring the
level to F or FULL.
Securely tighten the coolant reservoir tank
cap after adding coolant.
CAUTION
  Radiator coolant will damage paint.  Rinse it off quickly if spilled. 

 Use only soft (demineralised) water
in the coolant mixture. Water that
contains minerals will cut down on
the coolant's effectiveness.
  Do not add only water. Always add a
proper coolant mixture.
  The engine has aluminium parts and
must be protected by an ethylene-
glycol-based coolant to prevent
corrosion and freezing.
  DO NOT USE coolants Containing
Alcohol, methanol, Borate or
Silicate.
 These coolants could damage the
cooling system.
  DO NOT MIX alcohol or methanol
with the coolant. This could damage
the cooling system.
  Do not use a solution that contains
more than 60% antifreeze.
 This would reduce effectiveness.  
 If the “FL22” mark is shown on or
near the cooling system cap, use
of FL-22 is recommended when
replacing engine coolant. Using
engine coolant other than FL-22 may
cause serious damage to the engine
and cooling system.

6–72
Maintenance and Care
Appearance Care
Plastic Part Maintenance
 












 When cleaning the plastic lenses of
the lights, do not use petrol, paraf¿ n,
recti¿ ed spirit, paint, thinner, highly
acidic detergents, or strongly alkaline
detergents. Otherwise, these chemical
agents can discolour or damage the
surfaces resulting in a signi¿ cant loss
in functionality. If plastic parts become
inadvertently exposed to any of these
chemical agents, À ush with water
immediately.
 


 If plastic parts such as the bumpers
become inadvertently exposed to
chemical agents or À uids such as petrol,
oil, engine coolant, or battery À uid, it
could cause discolouration, staining,
or paint peeling. Wipe off any such
chemical agents or À uids using a soft
cloth immediately.
 


 High water temperature and high water
pressure car washers are available
depending on the type of high pressure
car washer device. If the car washer
nozzle is put too close to the vehicle or
aimed at one area for an extended period
of time, it could deform plastic parts or
damage the paint.
 


 Do not use wax containing compounds
(polish). Otherwise, it could result in
paint damage.
 In addition, do not use an electrical or
air tool to apply wax. Otherwise, the
frictional heat generated could result
in deformation of plastic parts or paint
damage.

Interior Care
WARNING
Do not spray water into the vehicle
cabin:
Spraying water into the vehicle cabin
is dangerous as electrical devices such
as the audio and switches could get wet
resulting in a malfunction or vehicle
¿ re.
NOTE

 Do not wipe the interior using
alcohol, chlorine bleach, or organic
solvents such as thinner, benzene,
and petrol. Otherwise, it may cause
discolouration or stains.
  Rubbing hard with a stiff brush or
cloth may cause damage.
If the vehicle interior becomes soiled
by any of the following, wipe it off
immediately using a soft cloth.
Leaving it uncleaned could cause
discolouration, stains, cracks, or peeling
of the coating, and it will make it hard to
wipe off later.
 


 Beverage or fragrance



 Grease or oil



 Soiling

7–29
If Trouble Arises
Overheating
O v e r h e a t i n g
If the high engine coolant temperature
warning light turns on, the vehicle loses
power, or you hear a loud knocking or
pinging noise, the engine is probably too
hot.
WARNING
Pull over to a safe location, then
switch the ignition off and make sure
the fan is not running before
attempting to work near the cooling
fan:
Working near the cooling fan when it
is running is dangerous. The fan could
continue running inde¿ nitely even if
the engine has stopped and the engine
compartment temperature is high. You
could be hit by the fan and seriously
injured.

Do not remove either
cooling system cap when the engine
and radiator are hot:
When the engine and radiator are hot,
scalding coolant and steam may shoot
out under pressure and cause serious
injury.

Open the bonnet ONLY after steam is
no longer escaping from the engine:
Steam from an overheated engine is
dangerous. The escaping steam could
seriously burn you.
If the high engine coolant temperature
warning light turns on:


1. Drive safely to the side of the road and
park off the right-of-way.
2. Put a vehicle with an automatic
transaxle in park (P), a manual
transaxle in neutral.
3. Apply the parking brake.
4. Turn off the air conditioner.
5. Check whether coolant or steam is
escaping from the engine compartment.

If steam is coming from the engine
compartment:
Do not go near the front of the vehicle.
Stop the engine.
Wait until the steam dissipates, then
open the bonnet and start the engine.

If neither coolant nor steam is
escaping:
Open the bonnet and idle the engine
until it cools.
CAUTION
If the cooling fan does not operate
while the engine is running, the engine
temperature will increase. Stop the
engine and call an expert repairer,
we recommend an Authorised Mazda
Repairer.
6. Make sure the cooling fan is operating,
then turn off the engine after the
temperature has decreased.
7. When cool, check the coolant level.
If it is low, look for coolant leaks from
the radiator and hoses.

7–30
If Trouble Arises
Overheating
If you ¿ nd a leak or other damage, or if
coolant is still leaking:
Stop the engine and call an expert repairer,
we recommend an Authorised Mazda
Repairer.
SKYACTIV-G 1.3 and SKYACTIV-G
1.5

Cooling system cap Coolant reservoir
Cooling fan

SKYACTIV-D 1.5

Cooling system cap Coolant reservoir
Cooling fan

If you ¿ nd no problems, the engine is
cool, and no leaks are obvious:
Carefully add coolant as required (page
6-29 ).
CAUTION
If the engine continues to overheat or
frequently overheats, have the cooling
system inspected. The engine could
be seriously damaged unless repairs
are made. Consult an expert repairer,
we recommend an Authorised Mazda
Repairer.

7–37
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
Signal Warning


Engine Oil Warning
Light This warning light indicates low engine oil pressure.
CAUTION
Do not run the engine if the oil pressure is low. Otherwise, it could result in
extensive engine damage.
If the light illuminates or the warning indication is displayed while driving:
1. Drive to the side of the road and park off the right-of-way on level ground.
2. Turn off the engine and wait 5 minutes for the oil to drain back into the sump.
3. Inspect the engine oil level 6-28 . If it's low, add the appropriate amount of engine
oil while being careful not to over¿ ll.
CAUTION
Do not run the engine if the oil level is low. Otherwise, it could result in extensive
engine damage.
4. Start the engine and check the warning light.

If the light remains illuminated even though the oil level is normal or after adding oil,
stop the engine immediately and have your vehicle towed to an expert repairer, we
recommend an Authorised Mazda Repairer.


(Red)
High Engine Coolant
Temperature Warning
Light
The light À ashes when the engine coolant temperature is extremely high, and
illuminates when the engine coolant temperature increases further.
Handling Procedure
Flashing light
Drive slowly to reduce engine load until you can ¿ nd a safe place to stop the vehicle
and wait for the engine to cool down.
Illuminated light
This indicates the possibility of overheating. Park the vehicle in a safe place
immediately and stop the engine.
Refer to Overheating 7-29 .
CAUTION
Do not drive the vehicle with the high engine coolant temperature warning light
illuminated. Otherwise, it could result in damage to the engine.

7–48
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
*Some models.
Message Indicated on Display *
If a message is displayed in the centre display (Type B audio), take appropriate action (in a
calm manner) according to the displayed message.


(Display example)

Stop Vehicle in Safe Place Immediately
If the following messages are displayed in the centre display (Type B audio), a vehicle
system may be malfunctioning. Stop the vehicle in a safe place and contact an Authorised
Mazda Repairer.

Display Indicated Condition

Displays if the engine coolant temperature has increased
excessively.

Displays if the charging system has a malfunction.

9–6
Speci¿ cations
Speci¿ cations
Lubricant Quality
Engine oil *1 Europe Except Europe
SKYACTIV-G 1.3,
SKYACTIV-G 1.5 Recommended Oils *2 Oil Quality
Mazda Original Oil Supra 0W-20
API SG/SH/SJ/SL/SM/SN or
ILSAC GF-II/GF-III/GF-IV/GF-V Mazda Original Oil Ultra 5W-30
Alternative Oil Quality
*3
API SL/SM/SN or
ACEA A3/A5 0W-20
5W-30
SKYACTIV-D 1.5 Recommended Oils
*2 Oil Quality
Mazda Original Oil Supra DPF 0W-30
ACEA C3
0W-30 / 5W-30 Mazda Original Oil Ultra DPF 5W-30
Alternative Oil Quality
*3
ACEA C3 0W-30
5W-30
*1 Refer to the recommended SAE viscosity numbers on page 6-23 .
*2 Mazda Original Oils are specially designed/tested for the respective engine. For optimum performance we
recommend to use Mazda Original Oils at all times.
*3 If you are unable to ¿ nd a Mazda Original Oil, alternative oils meeting the listed speci¿ cation may also be used.

Do not use oils which do not meet the above speci¿ cation or requirements. Use of
unsuitable oil may lead to engine damage which is not covered by the Mazda Warranty.

Lubricant Classi¿ cation
Coolant FL-22 type
Manual transaxle oil API Service GL-4
SAE 75W-80
Automatic transaxle
À uid Mazda Original Oil ATF-FZ
Brake/Clutch À uid SAE J1703 or FMVSS116 DOT-3 or DOT-4
*1
* 1 (Except European models)
Use FMVSS116 DOT-4 brake À uid for vehicles equipped with the SKYACTIV-D 1.5 engine and drum type rear
brakes.

9–7
Speci¿ cations
Speci¿ cations
Capacities

(Approximate Quantities)
Item Capacity
Engine oil SKYACTIV-G 1.3,
SKYACTIV-G 1.5 With oil ¿ lter replacement 4.2 L (4.4 US qt, 3.7 Imp qt)
Without oil ¿ lter replacement 3.9 L (4.1 US qt, 3.4 Imp qt)
SKYACTIV-D 1.5 With oil ¿ lter replacement 5.1 L (5.4 US qt, 4.5 Imp qt)
Without oil ¿ lter replacement 4.7 L (5.0 US qt, 4.1 Imp qt)
Coolant SKYACTIV-G 1.3 5.2 L (5.5 US qt, 4.6 Imp qt)
SKYACTIV-G 1.5 Manual
transaxle Europe Left-hand drive model 5.4 L (5.7 US qt, 4.8 Imp qt)
Right-hand drive model 5.0 L (5.3 US qt, 4.4 Imp qt)
Russia 5.4 L (5.7 US qt, 4.8 Imp qt)
Israel 5.0 L (5.3 US qt, 4.4 Imp qt)
Except
above
Left-hand drive model *1 5.0 L (5.3 US qt, 4.4 Imp qt)/
5.4 L (5.7 US qt, 4.8 Imp qt)
Right-
hand
drive
model With heater 5.0 L (5.3 US qt, 4.4 Imp qt)
Without
heater 4.5 L (4.8 US qt, 4.0 Imp qt)
Automatic
transaxle Europe Left-hand drive model 5.6 L (5.9 US qt, 4.9 Imp qt)
Right-hand drive model 5.2 L (5.5 US qt, 4.6 Imp qt)
Russia 5.6 L (5.9 US qt, 4.9 Imp qt)
Israel, Saudi Arabia 5.2 L (5.5 US qt, 4.6 Imp qt)
Except
above
Left-hand drive model *1 5.2 L (5.5 US qt, 4.6 Imp qt)/
5.6 L (5.9 US qt, 4.9 Imp qt)
Right-
hand
drive
model With heater 5.2 L (5.5 US qt, 4.6 Imp qt)
Without
heater 4.7 L (5.0 US qt, 4.1 Imp qt)
SKYACTIV-D 1.5 For engine Europe 6.6 L (7.0 US qt, 5.8 Imp qt)
Except
above Left-hand drive model 6.7 L (7.1 US qt, 5.9 Imp qt)
Right-hand drive model 6.8 L (7.2 US qt, 6.0 Imp qt)
For water-cooled charge air cooler 2.0 L (2.1 US qt, 1.8 Imp qt)
Manual
transaxle
oil SKYACTIV-G 1.5 1.59 L (1.68 US qt, 1.40 Imp qt)
SKYACTIV-D 1.5 1.64 L (1.73 US qt, 1.44 Imp qt)
Automatic
transaxle
À uid SKYACTIV-G 1.3, SKYACTIV-G 1.5 7.2 L (7.6 US qt, 6.3 Imp qt)
SKYACTIV-D 1.5 7.8 L (8.2 US qt, 6.9 Imp qt)
Fuel tank 44.0 L (11.6 US gal, 9.68 Imp gal)
Check oil and À uid levels with dipsticks or reservoir gauges. *1 The engine coolant amount varies depending on the speci¿ cation.

10–4
Index
Distance Recognition Support System
(DRSS) .............................................. 4-124
Indication on display ................... 4-125
Door Locks .......................................... 3-11
Driver Attention Alert (DAA) ........... 4-127
Drive selection .................................... 4-99
Driving In Flooded Area ..................... 3-54
Driving Tips
Automatic transaxle ...................... 4-60
Driving in À ooded area.................. 3-54
Floor mat ....................................... 3-50
Hazardous driving ......................... 3-49
Rocking the vehicle ....................... 3-51
Running-in..................................... 3-48
Saving fuel and protection of the
environment................................... 3-48
Turbocharged vehicles
(SKYACTIV-D 1.5) ...................... 3-55
Winter driving ............................... 3-51
Dynamic Stability Control (DSC) ....... 4-88
DSC OFF Indicator Light.............. 4-89
DSC OFF Switch........................... 4-89
TCS/DSC Indicator Light ............. 4-88
E
Effectiveness Display .......................... 4-98
Electronic steering lock warning beep 7-52
Emergency Starting
Push-Starting ................................. 7-27
Running Out of Fuel
(SKYACTIV-D 1.5) ...................... 7-28
Starting a Flooded Engine
(SKYACTIV-G 1.3 and SKYACTIV-G
1.5) ................................................ 7-27
Emergency Stop Signal System .......... 4-84
Emergency Towing
Towing Description ....................... 7-31
Towing/Tiedown Hooks ................ 7-32
Emission Control System
(SKYACTIV-D 1.5) ............................ 3-29
Emission Control System (SKYACTIV-G
1.3, SKYACTIV-G 1.5) ....................... 3-28 Ending Display .................................... 4-98
Engine
Bonnet release ............................... 6-19
Coolant .......................................... 6-29
Engine Compartment Overview .... 6-21
Exhaust gas.................................... 3-30
Oil .................................................. 6-23
Starting ............................................ 4-5
Essential information ............................ 6-2
Exhaust Gas ........................................ 3-30
Exterior Care ....................................... 6-66
Aluminium Wheel Maintenance ... 6-71
Bright-Metal Maintenance ............ 6-70
Cavity Protection ........................... 6-70
Maintaining the Finish .................. 6-68
Paint Damage Touch-up ................ 6-70
Plastic Part Maintenance ............... 6-72
Undercoating ................................. 6-71
F
Flasher
Hazard warning ............................. 4-80
Headlights ..................................... 4-61
Flat Tyre ................................................ 7-3
Mounting the Spare Tyre ............... 7-21
Removing a Flat Tyre .................... 7-17
Floor Mat ............................................ 3-50
Fluid
Brake/Clutch ................................. 6-31
Washer ........................................... 6-32
Fluids
Classi¿ cation ................................... 9-6
Fog Lights ........................................... 4-69
Front .............................................. 4-69
Rear ............................................... 4-70
Foot Brake ........................................... 4-81
Forward Sensing Camera (FSC) ....... 4-170
Front Seat .............................................. 2-5

10–6
Index
Ignition
Switch .............................................. 4-4
Ignition not switched off (STOP) warning
beep ..................................................... 7-51
Illuminated Entry System ................. 5-158
Immobilizer System ............................ 3-42
Indicator Lights ................................... 4-41
Glow plug ...................................... 4-45
Low engine coolant temperature ... 4-44
Wrench .......................................... 4-44
Inspecting Brake/Clutch Fluid Level ... 6-31
Inspecting Coolant Level .................... 6-29
Inspecting Engine Oil Level ............... 6-28
Inspecting Washer Fluid Level............ 6-32
Instrument Cluster ............................... 4-24
Instrument Panel Illumination ............. 4-30
Interior Care ........................................ 6-72
Active driving display
maintenance................................... 6-74
Cleaning the window interiors ...... 6-75
Instrument panel top maintenance ... 6-74
Leather upholstery maintenance ... 6-73
Panel maintenance ......................... 6-75
Plastic part maintenance ................ 6-74
Seat belt maintenance .................... 6-73
Upholstery maintenance ................ 6-73
Vinyl upholstery maintenance ....... 6-73
Interior Lights ................................... 5-156
Boot Light ................................... 5-156
Luggage Compartment Light ...... 5-156
Map Lights .................................. 5-156
Overhead Lights .......................... 5-156
J
Jack ....................................................... 7-6
Jump-Starting ...................................... 7-24
K
Key Suspend Function .......................... 3-8
Key left-in-luggage compartment warning
beep (With the advanced keyless
function) .............................................. 7-52
Key left-in-vehicle warning beep (With the
advanced keyless function) ................. 7-52
Keyless Entry System ........................... 3-3
Key removed from vehicle warning
beep ..................................................... 7-51
Keys ...................................................... 3-2
Key suspend function ...................... 3-8
Transmitter ...................................... 3-4
L
Label Information ................................. 9-2
Lane-Change Signals .......................... 4-72
Lane Departure Warning System
(LDWS) ............................................. 4-111
LDWS OFF switch ...................... 4-114
Lane Departure Warning sound .......... 7-53
Laser Sensor ...................................... 4-179
Leaving Home Light ........................... 4-67
Liftgate ................................................ 3-21
When liftgate/boot lid cannot be
opened ........................................... 7-55
Liftgate/Boot Lid
Luggage compartment ................... 3-24
Light Bulbs
Replacement .................................. 6-48
Speci¿ cations .................................. 9-9
Lighting Control.................................. 4-61
Lights-on reminder .............................. 7-50
Lubricant Quality .................................. 9-6
Luggage Compartment Light ............ 5-156