lights MAZDA MODEL 3 5-DOOR 2005 Service Manual

Black plate (287,1)
5 Door
1. Remove the liftgate upper trim.
2. Disconnect the electrical connectorfrom the socket.
3. Turn the socket and bulb assembly counterclockwise and remove it.
4. Disconnect the bulb from the socket.
5. Install the new bulb in the reverse order of removal.
NOTE
To replace the bulb, contact an
Authorized Mazda Dealer.
License plate lights
1. Wrap a flathead screwdriver with a softcloth to prevent damage to the lens and
remove the lens by carefully prying on
the edge of the lens with a flathead
screwdriver.
2. Disconnect the bulb by pulling it out.
Edge
3. Install the new bulb in the reverse order of removal.
qReplacing Interior Light Bulbs
Overhead light/Map lights (Front)í
1. Wrap a flathead screwdriver with a soft
cloth to prevent damage to the trim and
gently insert it in the overhead light as
shown in the figure, and then remove
the overhead light unit.
Maintenance and Care
Owner Maintenance
8-45íSome models.
Mazda3_8T96-EA-04J_Edition3 Page287
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (289,1)
3. Disconnect the bulb by pulling it out.
4. Install the new bulb in the reverse orderof removal.
Fuses
Your vehicle's electrical system is
protected by fuses.
If any lights, accessories, or controls don't
work, inspect the appropriate circuit
protector. If a fuse has blown, the inside
element will be melted.
If the same fuse blows again, avoid using
that system and consult an Authorized
Mazda Dealer as soon as possible.
qFuse Replacement
Replacing the fuses on the front
passenger's side below the glove box
If the electrical system doesn't work, first
inspect fuses on the front passenger's side
below the glove box.
1. Turn off the ignition switch and other
switches.
2. Remove the cover.
Maintenance and Care
Owner Maintenance
8-47
Mazda3_8T96-EA-04J_Edition3 Page289
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (290,1)
3. Turn the knobs counterclockwise andlower the fuse block.
4. Locate the position of the suspected
fuse by using the chart inside the fuse
block cover.
5. Pull the fuse straight out with the fuse puller provided on the inside of the
engine compartment fuse block cover.
6. Inspect it and replace if it's blown.
Normal Blown
7. Push in a new fuse of the same
amperage rating, and make sure it fits
tightly. If it doesn't, have an Authorized
Mazda Dealer install it.
If you have no spare fuses, borrow one
of the same rating from a circuit not
essential to vehicle operation, such as
the MIRROR or CIGAR circuit.
CAUTION
Always replace a fuse with one of the
same rating. Otherwise you may
damage the electric system.
Replacing the fuses under the hood
If the headlights or other electrical
components don't work and the fuses in
the cabin are OK, inspect the fuse block
under the hood. If a fuse is blown, it must
be replaced. Follow these steps:
1. Turn off the ignition switch and all
other switches.
8-48
Maintenance and Care
Owner Maintenance
Mazda3_8T96-EA-04J_Edition3 Page290
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (292,1)
qFuse Panel Description
Fuse block (Engine compartment)
12 3
4 5 6
789
10
11
12
13 1415 16 17 18
19 20 21
22
23
24
25
26
27
28
29
30 31
32
33
34
35
36
DESCRIP-
TIONFUSERAT-ING PROTECTED
COMPONENT
1 FAN 40 A Cooling fan
2 P/ST 80 A EHPAS
3 BTN 40 A For protection of various
circuits
4 HEAD 40 A Headlights
5 PTC 80 A ―
6 GLOW 60 A ―
7 ABS 1 30 A ABS
í
8 ABS 2 20 A ABSí
9ENGINE30 A For protection of various
circuits
10―― ―
11 IG KEY 130 A Ignition switch
12 STARTER20 A Starter clutch
13 IG KEY 230 A Ignition switch
14―― ―
DESCRIP-
TIONFUSERAT-ING PROTECTED
COMPONENT
15 HEATER40 A Blower motor
16―― ―
17DEFOG 40 A Rear window defroster
18AUDIO 30 A Audio system
(BOSE Sound System-equip-
ped model)
19ABS IG 10 A ABSí
20FOG 15 A Fog lightsí
21HORN 15 A Horn
22―― ―
23 H/CLEAN20 A
―
24 F/PUMP15 A Fuel pump
25P/ST IG 10 A Power steering
26 A/C MAG10 A Air conditioner
27ALT 10 A ―
28―― ―
8-50
Maintenance and Care
íSome models.
Owner Maintenance
Mazda3_8T96-EA-04J_Edition3 Page292
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (293,1)
DESCRIP-TIONFUSERAT-ING PROTECTED
COMPONENT
29―― ―
30 ENG +B10 A PCM
31ROOM 15 A Interior lights
32 ENG BAR
410 A O2heater
33ENG BAR
310 A O2heater
34EGI INJ 10 A Injector
35ENG BAR
110 A Air flow sensor
36ENG BAR
210 A EGR control valve
Maintenance and Care
Owner Maintenance
8-51
Mazda3_8T96-EA-04J_Edition3 Page293
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (294,1)
Fuse block (Passenger's side)
37 38 39 4041 42
43 44 45 46
47 48 49 50 51
52 53 54 55 56 57 58
59 60 61 62 63 64
65 66 67 68 69 70
71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86
DESCRIP-
TIONFUSERAT-ING PROTECTED
COMPONENT
37 D/LOCK 215 A Power door lock
38―― ―
39 HEAD
HIGH L10 A Headlight high beams (LH)
40 HEAD
HIGH R10 A Headlight high beams (RH)
41―― ―
42―― ―
43CIGAR 15 A Lighter
44RADIO 7.5 A Audio system
45 MIRROR10 A Power control mirror
46TAIL R 7.5 A Taillight (RH), Parking lights
(RH) License plate lights
47OBD 10 AFor protection of various
circuits
48―― ―
49 TR/LOCK20 A
―
50 CPU PWR10 A Control unit
DESCRIP-
TIONFUSERAT-ING PROTECTED
COMPONENT
51 HAZARD15 A Turn signals, Hazard warning
flashers
52 SUN
ROOF20 A Moonroofí
53 WASHER20 A Front washer, Rear window
wiper and washer
54―― ―
55 P/WIND R30 A
―
56 P/WIND L30 A―
57 ALARM7.5 A ―
58M/DEF 7.5 A Mirror Defroster
59―― ―
60HEAD
LOW R15 A Headlight low beams (RH),
Headlight levelingí
61HEAD
LOW L15 A Headlight low beams (LH)
62―― ―
63―― ―
8-52
Maintenance and Care
íSome models.
Owner Maintenance
Mazda3_8T96-EA-04J_Edition3 Page294
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (295,1)
DESCRIP-TIONFUSERAT-ING PROTECTED
COMPONENT
64―― ―
65SAS 10 A Supplemental restraint system
66METER 10 A Instrument cluster,
Immobilizer system, Shift
lock system
67 IGNITION20 A ABSí, EHPAS
68WIPER 20 A Windshield wiper
69 ENGINE20 A
For protection of various
circuits
70IG SIG 10 A Auto wiperí
71SAS 2 7.5 A Supplemental restraint system
72―― ―
73―― ―
74SEAT
WARM20 A ―
75 D/LOCK 125 A Power door lock
76A/C 10 AAir conditioner, Heater
control unit
77 P/WIND L30 A Power window (LH)í
78 P/WIND R30 A Power window (RH)í
79BACK 10 A Reverse lights
80SUN
ROOF7.5 A Moonroofí
81TAIL L 7.5 A Taillights (LH), Parking lights
(LH)
82 ILLUMI7.5 A Illumination
83―― ―
84―― ―
85―― ―
86―― ―
Maintenance and Care
Owner Maintenance
8-53íSome models.
Mazda3_8T96-EA-04J_Edition3 Page295
Wednesday, May 11 2005 3:39 PM
Form No.8T96-EA-04J

Black plate (328,1)
2.3-liter engineItem Weight
Manual transaxle Automatic transaxle
GVWR (Gross Vehicle Weight Rating) 1,732 kg (3,818 lb) 1,760 kg (3,880 lb)
GAWR (Gross Axle Weight Rating) Front 928 kg (2,046 lb) 957 kg (2,110 lb)
Rear 804 kg (1,772 lb) 803 kg (1,770 lb)
5 Door
Item Weight
Manual transaxle Automatic transaxle
GVWR (Gross Vehicle Weight Rating) 1,743 kg (3,843 lb) 1,771 kg (3,904 lb)
GAWR (Gross Axle Weight Rating) Front 930 kg (2,050 lb) 960 kg (2,116 lb)
Rear 813 kg (1,793 lb) 811 kg (1,788 lb)
q
Air Conditioner
Gas complies with SAE J639 Maximum operating charge
HFC134a (R-134a) 0.5 kg (17.55 oz)
qLight Bulbs
Exterior light
Light bulb Category
Wattage ECE R SAE
Headlights High beam 60 HB3
―
Low beam Halogen 55 H7
―
Xenon fusion 35 D2S ―
Front turn signal lights/Side-marker lights 27/8 ―#1157NA
Fog lights
í55 H11 ―
Side turn signal lights*15 WY5W ―
High-mount brake light 18 W16W #921
Rear turn signal lights 21 W21W #7440
Brake lights/Taillights With Non-LED bulb 21/5 W21/5W #7443
With LED bulb
*24/0.8
――
Reverse light 21 W21W #7440
License plate light 5 W5W ―
*1 Bulb replacement is not possible because it is built into the unit. Replace the unit.
*2 Bulb replacement is not possible. The rear combination component must be replaced.
10-6íSome models.
Specifications
Mazda3_8T96-EA-04J_Edition3 Page328
Wednesday, May 11 2005 3:40 PM
Form No.8T96-EA-04J

Black plate (329,1)
Interior lightLight bulb Category
Wattage ECE R
Trunk light (Sedan)
5W5W
Luggage compartment light (Hatchback) ―
Overhead light/Map lights (Front)
íW5W
Overhead light (Rear) 10 ―
qTires
NOTE
The tires have been optimally matched with the chassis of your vehicle.
When replacing tires, Mazda recommends that you replace tires of the same type
originally fitted to your vehicle. For details, contact an Authorized Mazda Dealer.
Check the tire pressure label for tire size and inflation pressure. Refer to Tire Inflation
Pressure on page 8-32.
Standard tire Tire size Inflation pressure
Front Rear
195/65R15 91V 220 kPa (2.2 kgf/cm
2, 32 psi or lb/po2) 220 kPa (2.2 kgf/cm2, 32 psi or lb/po2)
P195/65R15 89H 230 kPa (2.3 kgf/cm2, 33 psi or lb/po2) 230 kPa (2.3 kgf/cm2, 33 psi or lb/po2)
205/55R16 91V
220 kPa (2.2 kgf/cm
2, 32 psi or lb/po2) 220 kPa (2.2 kgf/cm2, 32 psi or lb/po2)
P205/55R16 89H
205/50R17 89V
P205/50R17 88V
Temporary spare tire Tire size Inflation pressure
T115/70D15 420 kPa (4.2 kgf/cm
2or bar, 60 psi)
T125/70D16
q Fuses
Refer to the fuse rating on page 8-47.
Specifications
10-7íSome models.
Mazda3_8T96-EA-04J_Edition3 Page329
Wednesday, May 11 2005 3:40 PM
Form No.8T96-EA-04J

Black plate (332,1)
A
Add-On Non-Genuine Parts and
Accessories ....................................... 9-13
Air Bag Systems ............................... 2-38
Air Filter ............................................ 8-24
Antenna ............................................. 6-10
Anti-Lock Brake System (ABS) ......... 5-6Warning light ............................... 5-7
Appearance Care ............................... 8-54
Ashtray .............................................. 6-43
Audio System ................................... 6-10 Audio control switch .................. 6-34
Operating tips for audio
system ........................................ 6-10
Safety certification ..................... 6-37
Automatic Transaxle Driving tips ................................ 5-16
Fluid ........................................... 8-21
Manual shift mode ..................... 5-13
Shift-lock override ..................... 5-12
Shift-lock system ....................... 5-12
Transaxle ranges ......................... 5-11
B
BatteryEmergency starting .................... 7-14
Maintenance ............................... 8-29
Specifications ............................. 10-4
Beep Sounds
Ignition key reminder ................. 5-44
Beeps Lights-on reminder ..................... 5-44
Seat belt warning beep Sounds ... 5-44
Tire inflation pressure warning
beep ............................................ 5-44
Before Starting the Engine .................. 4-6 After getting in ............................. 4-6
Before getting in .......................... 4-6
B
Body Lubrication .............................. 8-24
Bottle Holder ..................................... 6-45
Brake/Clutch
Fluid ........................................... 8-20
Brakes Anti-lock brake system (ABS) ..... 5-6
Brakes assist ................................. 5-8
Foot brake .................................... 5-4
Parking brake ............................... 5-5
Warning light ............................... 5-6
Break-In Period ................................... 4-7
Bulb Replacement ............................. 8-37
C
Capacities .......................................... 10-5
Carbon Monoxide ............................... 4-5
Cargo Securing Loops ...................... 6-46
Cargo Sub-Compartment .................. 6-46
Catalytic Converter ............................. 4-3
Cell Phones ....................................... 9-14
Center Console .................................. 6-46
Child Restraint Child restraint precautions ......... 2-21
Installing child-restraint
systems ....................................... 2-25
LATCH child-restraint
systems ....................................... 2-33
Child Safety Locks for Rear Doors ..... 3-9
Cigarette Lighter ............................... 6-43
Climate Control System ...................... 6-2 Gas specifications ...................... 10-6
Clock ................................................. 6-42
Cruise Control ................................... 5-18
Cup Holder ........................................ 6-44
Customer Assistance ........................... 9-2
11-2
Index
Mazda3_8T96-EA-04J_Edition3 Page332
Wednesday, May 11 2005 3:40 PM
Form No.8T96-EA-04J