door lock MAZDA MODEL MX-5 MIATA 2008 Service Manual

Black plate (105,1)
qDetachable Hardtop Precautions
WARNING
Sit in the seat with the seat belt
correctly fastened when the vehicle is
moving:
Standing in the vehicle, or sitting on
the deck or center console when the
vehicle is moving is a dangerous way
to ride. During a sudden maneuver or
collision you could be seriously
injured or even killed.
Always drive safely and observe the
speed limit: Rollover accidents on a hardtop
vehicle are dangerous. The hardtop is
not as strong as a regular steel roof.
Rollover accidents could dislodge or
crush the hardtop and cause serious
injuries or even death, just as with no
top or the convertible top.
Always keep your hands and fingers
away from the fastening mechanisms
when moving the hardtop: It is dangerous to place your hands
or fingers near the fastening
mechanisms. Your hands or fingers
could be caught and injured by the
mechanism.
lWhen removing or installing the
hardtop, make sure the operation is
performed by 2 adults.
lBefore removing or installing the
hardtop, be sure you are parked out of
traffic in a flat area near the location
your hardtop is to be stored.
lWhen removing the hardtop, make sure
objects inside the vehicle are not blown
away by wind.
lSecure all loose objects inside before
driving with the hardtop removed.
lDo not drive through an automatic car
wash as it could damage the hardtop.
lDo not remove or install the hardtop in
a strong wind as it could damage the
hardtop or cause an unexpected
accident.
lBefore removing the hardtop, remove
the antenna.
lRemoving the hardtop while it's wet
can cause water to drip into the
passenger compartment.
qRemoving the Detachable Hardtop
1. Park the vehicle on a level surface and
firmly set the parking brake.
2. Lower the side windows, then turn off the ignition.
3. Remove the antenna if it is installed. Refer to Antenna on page 6-9.
4. Push the unlock button and fully release the top latch.
Unlock button
Top latch
Knowing Your Mazda
Doors and Locks
3-45
MX-5_8X49-EA-07F_Edition5 Page105
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (106,1)
5. Remove the seat belts from the beltguides.
Belt guide
6. Slide the seats forward.
Refer to Seat Slide on page 2-2.
7. Fold the seatbacks forward. Refer to Seat Recline on page 2-2.
8. Pull the levers and fully release the side latches.
Side latch
Lever
9. After the side latches are fully released,
release the lever. 10. Lift the side latches while pulling the
lever. Make sure the hooks are fully
released.
Side
latch
Lever Hook
11. Disconnect the rear window defroster
cord connector from the plug on the
inside of the hardtop.
3-46
Knowing Your Mazda
Doors and Locks
MX-5_8X49-EA-07F_Edition5 Page106
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (107,1)
12. Slide the hardtop rearward whilepressing down on the rear deck
latches to unlock the latches.
Hardtop
Rear deck latch
13. Lift the hardtop straight off the bodyto prevent damage to the rear deck
latches and studs.
Hardtop
Rear deck stud
WARNING
Be careful of the windshield's edges
when getting into or out of the vehicle:
Not being careful of the windshield's
edges when getting into or out of the
vehicle is dangerous. The
windshield's edges could scratch and
cause injuries.
CAUTION
ØBe careful not to strike the body
with any of the protruding
hardtop latches.
Ø Use extreme care when carrying
the hardtop to prevent scratching
or other damage to it.
NOTE
Points to remember when storing the
detachable hardtop.
lDo not place the hardtop on a hard surface,
such as concrete or asphalt. Place it on a
cushioning material, such as an old
blanket.
lBe sure the top and side latches are locked.lDo not lean the hardtop against a wall or
stand it in an unstable way.
lStore the hardtop in a dry clean area, and
cover it with a soft material, such as an old
blanket.
14. Return the belt guides and the seatbacks to their original positions.
15. Disconnect the hardtop rear window defroster coupler (A) from the coupler
(B), and remove the convertible top
rear window defroster coupler (C)
from its holder (D).
(A)
(B)
(C)
(D)
Knowing Your Mazda
Doors and Locks
3-47
MX-5_8X49-EA-07F_Edition5 Page107
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (108,1)
16. Connect the convertible top's rearwindow defroster coupler (C) to the
coupler (B).
(C)
(B)
qInstalling the Detachable Hardtop
CAUTION
Do not attempt to install the hardtop
with the convertible top also up.
Lower the convertible top before
installing the hardtop, otherwise
damage will occur to the convertible
top.
NOTE
lBe sure to place the convertible top latches
in the locked position.
lConfirm that the rear window defroster
coupler is disconnected. Also make sure the
convertible top is completely lowered
before installing the hardtop.
1. Park the vehicle on a level surface and firmly set the parking brake.
2. Lower the side windows, then turn off the ignition.
3. Remove the antenna if it is installed. Refer to Antenna on page 6-9. 4. Remove the seat belts from the belt
guides.
Belt guide
5. Slide the seats forward.
Refer to Seat Slide on page 2-2.
6. Fold the seatbacks forward. Refer to Seat Recline on page 2-2.
7. Connect the rear window defroster coupler.
3-48
Knowing Your Mazda
Doors and Locks
MX-5_8X49-EA-07F_Edition5 Page108
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (109,1)
NOTE
Connect the convertible top's rear window
defroster coupler into the holder so that it does
not rattle.
8. Make sure the top latch and the sidelatches on the hardtop are unlocked.
Top latch
assembly
Side latch
assembly
9. Align the rear deck latches with therear deck studs and set the hardtop
squarely onto the body.
Hardtop
Rear deck stud
10. Slide the hardtop forward while pressing down on the rear deck
latches to lock the latches, and then
verify that they are secure by
attempting to lift the rear of the
hardtop.
Hardtop
Rear deck latch
Knowing Your Mazda
Doors and Locks
3-49
MX-5_8X49-EA-07F_Edition5 Page109
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (110,1)
CAUTION
ØBe careful not to strike the body
with any of the protruding
hardtop latches.
Ø The rear defogger grid and the
defogger cord could be damaged
when removing or installing the
hardtop. Make sure the rear
defogger grid isn't folded and the
defogger cord isn't caught
between the vehicle's body and the
hardtop.
11. Make sure the striker for the top latch is securely engaged with the anchor
before pushing the top latch lever.
Rotate the lever of the top latch with
the palm of your hand until the top
latch is locked.
Striker
Anchor
12. Pull the levers and fully release theside latches.
Side latch
Lever
13. Make sure the hooks are engaged.
Lift the side latches with the palm of
your hand until the latches are locked.
Side
latch
Hook
CAUTION
After installation, verify that all
latches are secure. Operating the
vehicle with unlocked latches may
cause hardtop damage or loss.
14. Set the belt guides and the seats back to their original positions.
3-50
Knowing Your Mazda
Doors and Locks
MX-5_8X49-EA-07F_Edition5 Page110
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (111,1)
15. Connect the rear window defrostercord connector to the plug on the
inside of the hardtop.
NOTE
If the hardtop rattles even when all latches are
secure, drive slowly and contact an Authorized
Mazda Dealer for inspection.
qDetachable Hardtop Appearance
Care
Refer to Hardtop Maintenance (page
8-55) for information on detachable
hardtop appearance care.
Knowing Your Mazda
Doors and Locks
3-51
MX-5_8X49-EA-07F_Edition5 Page111
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (112,1)
Convertible Top (Power Retractable Hardtop)í
The power retractable hardtop opens/closes electrically by operating switches in the
vehicle. When opening/closing the hardtop, the hardtop, deck and window glass operate
together. The hardtop is stored in the storage area under the deck.
Top latch assembly
Close switchOpen switchDeck
Indicator light
Hardtop
3-52
Knowing Your Mazda
íSome models.
Doors and Locks
MX-5_8X49-EA-07F_Edition5 Page112
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (113,1)
qPower Retractable Hardtop Precautions
WARNING
Always confirm that there are no people around the vehicle before operating the
hardtop:
If the hardtop were to operate unexpectedly, it could result in an accident and
serious injury from someone getting caught in the mechanism.
Always drive safely and observe the speed limit: Rollover accidents on a hardtop vehicle are dangerous. The hardtop is not as strong
as a regular steel roof. Rollover accidents could dislodge or crush the hardtop and
cause serious injuries or even death, just as with no top.
Sit in the seat with the seat belt correctly fastened when the vehicle is moving: Standing in the vehicle, or sitting on the deck or center console when the vehicle is
moving is a dangerous way to ride. During a sudden maneuver or collision you could
be seriously injured or even killed.
Always keep your hands and fingers away from the fastening mechanisms when
moving the hardtop: It is dangerous to place your hands or fingers near the fastening mechanisms. Your
hands or fingers could be caught and injured by the mechanism.
CAUTION
ØDo not drive with the hardtop partially opened; this could damage the hardtop or
cause an unexpected accident.
Ø Children should not be allowed to play with the open/close switch.
Ø Do not place objects or cargo around the deck, rear glass, or the hardtop storage
area.
Even small objects may interfere and cause damage.
Ø Remove leaves that accumulate on and around the hardtop. If the leaves are not
removed, they may block the water drainage outlets.
Ø Before opening the hardtop, make sure the rear window defogger switch
(Defroster) is turned off. Otherwise the heat generated from the defogger could
damage the hardtop and the internal material.
Ø When opening/closing the hardtop, verify that there is no obstruction above the
hardtop (about 1.5 m from the ground) so as not to damage the hardtop or the
obstruction.
Ø When opening/closing the hardtop, do not apply any load to the hardtop or the
deck. The opening/closing mechanism of the hardtop may be damaged.
lOpen/close the hardtop with the vehicle parked on level ground in a safe place where the
vehicle does not obstruct traffic. If the hardtop is opened/closed on a slope or bump, the
opening/closing mechanism of the hardtop may be damaged.
Knowing Your Mazda
Doors and Locks
3-53
MX-5_8X49-EA-07F_Edition5 Page113
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F

Black plate (114,1)
lBefore opening or closing the hardtop, stop in a safe place off the right-of-way and park
on a level surface.
lWhen opening the hardtop, make sure objects inside the vehicle are not blown away by
the wind.
lSecure all loose objects inside before driving with the hardtop down.lTo help prevent burglary or vandalism and to ensure that the passenger compartment
stays dry, close the hardtop securely and lock both doors when leaving the vehicle.
lDo not drive through an automatic car wash as it may damage the hardtop.lDo not open or close the hardtop when the temperature is below 5 °C (41 °F) as it this
will damage the hardtop material.
lOpening the hardtop while it is wet can also cause water to drip into the passenger
compartment.
lDo not open or close the hardtop in a strong wind as it could damage the hardtop.
qOperation Indicator Light
When illuminated
This notifies the driver that the hardtop is
only partially open.
When flashing
This indicates that the hardtop is being
open/closed. (During button operation)
When not illuminated
This indicates that the hardtop is open/
closed fully.
NOTE
If the operation indicator light flashes quickly,
there may be a system malfunction. Consult an
Authorized Mazda Dealer.
qOperation Conditions
If the following conditions have been
satisfied, the hardtop can be opened/
closed.
lThe vehicle is parked on a level surface
off the right-of-way and the parking
brake is firmly set.
lThe ignition switch is in the ON
position.
lPut a vehicle with an automatic
transmission in Park (P) or Neutral (N),
a manual transmission in Neutral.
lThe trunk lid is closed.
NOTE
If the power retractable hardtop cannot be
closed even after the operation conditions are
all met, have it checked at an Authorized
Mazda Dealer.
The hardtop can be closed manually as an
emergency measure.
Refer to The Power Retractable Hardtop Does
not Close on page 3-58.
3-54
Knowing Your Mazda
Doors and Locks
MX-5_8X49-EA-07F_Edition5 Page114
Thursday, February 21 2008 12:50 AM
Form No.8X49-EA-07F