washer fluid MAZDA MODEL PROTÉGÉ 2003 (in English) User Guide

8-5
Maintenance and Care
Scheduled Maintenance
Form No. 8Q94-EA-02G

Schedule 2
I
: Inspect and repair, clean, adjust, or replace if necessary.
(Oil-permeated air filter cannot be cleaned using the air-blow method.)
R
: Replace
L
: Lubricate
ENGINE
COOLING SYSTEM
FUEL SYSTEM
IGNITION SYSTEM
ELECTRICAL SYSTEM
CHASSIS and BODY
AIR CONDITIONER SYSTEM (if equipped)
*1 According to state and federal regulations, failure to perform maintenance on these items will not void your
emissions warranties. However, Mazda recommends that all maintenance services be performed at the
recommended time or mileage period to ensure long-term reliability
*2 If the vehicle is operated in cold districts { below -18 degrees C (0 degrees F) }, replace the timing belt at
96,000 km (60,000 miles).
Maintenance Interval
(Number of months or
kilometers (miles),
whichever comes first)Months 4 8 12 16 20 24 28 32 36 40 44 48
×1000 km 8 16 24 32 40 48 56 64 72 80 88 96
×1000 miles 5 10 15 20 25 30 35 40 45 50 55 60
Engine valve clearanceI
Engine timing belt
*2Inspect at 96,000 km (60,000 miles)
Replace every 168,000 km (105,000 miles)
Drive belts (tension) II
Engine oilPuerto RicoReplace every 5,000 km (3,000 miles) or 3 months
OthersRRRRRRRRRRRR
Engine oil filterRRRRRRRRRRRR
Cooling systemII
Engine coolantReplace at first 72,000 km (45,000 miles) or 36 months ;
after that, every 48,000 km (30,000 miles) or 24 months
Engine coolant levelIIIIIIIIIIII
Idle speedII
Air filter
I
*1R
I*1R
Fuel lines and hoses*1II
Hoses and tubes for emission*1I
Spark plugsRR
Function of all lightsIIIIIIIIIIII
Brake lines, hoses and connectionsII
Brake and clutch fluid level IIIIIIIIIIII
Disc brakesIIII
Drum brakesII
Tire inflation pressure and tire wearIIIIIIIIIIII
Steering operation and linkagesII
Power steering fluid levelIIIIIIIIIIII
Front suspension ball jointsII
Driveshaft dust bootsII
Bolts and nuts on chassis and bodyIIII
Exhaust system heat shieldsII
All locks and hingesLLLLLLLLLLLL
Washer fluid levelIIIIIIIIIIII
Refrigerant amountIIII
Compressor operationIIII
J39L_EA.book Page 5 Saturday, June 8, 2002 5:35 PM

8-6
Maintenance and Care
Form No. 8Q94-EA-02G
Owner Maintenance
The owner or a qualified service technician should make these vehicle inspections at the
indicated intervals to ensure safe and dependable operation.
Bring any problem to the attention of an Authorized Mazda Dealer or qualified service
technician as soon as possible.

When Refueling
•Brake and clutch fluid level (page 8-14)
•Engine coolant level (page 8-12)
•Engine oil level (page 8-9)
•Washer fluid level (page 8-18)

At Least Monthly
•Tire inflation pressures (page 8-25)

At Least Twice a Year (For Example, Every Spring and Fall)
•Automatic transaxle fluid level (page 8-16)
•Power steering fluid level (page 8-16)
You can do the following scheduled maintenance items if you have some mechanical
ability and a few basic tools and if you closely follow the directions in this manual.
•Air filter (page 8-19)
•Engine coolant (page 8-12)
•Engine oil (page 8-10)
Owner Maintenance Schedule
J39L_EA.book Page 6 Saturday, June 8, 2002 5:35 PM

8-8
Maintenance and Care
Owner Maintenance
Form No. 8Q94-EA-02G
Engine Compartment Overview
Automatic transaxle fluid-level dipstick (only for automatic transaxle)
Brake/Clutch fluid reservoir
Battery
Fuse block
Engine coolant reservoir
Air filter
Cooling system cap Engine oil dipstick Engine oil filter 1.6-liter engine
2.0-liter engineEngine oil-filler cap
Power steering
fluid reservoir
Windshield washer
fluid reservoir
Automatic transaxle fluid-level dipstick (only for automatic transaxle)
Brake/Clutch fluid reservoir
Battery
Fuse block
Engine coolant reservoir
Air filter Cooling system cap Engine oil filter Engine oil-filler cap
Engine oil dipstick
Power steering
fluid reservoir
Windshield washer
fluid reservoir
J39L_EA.book Page 8 Saturday, June 8, 2002 5:35 PM

8-18
Maintenance and Care
Owner Maintenance
Form No. 8Q94-EA-02G

Inspecting Washer Fluid Level
Inspect fluid level in the washer fluid
reservoir; add fluid if necessary.
The top of the float should be between
FULL and LOW.Use plain water if washer fluid is
unavailable.
But use only washer fluid in cold weather
to prevent it from freezing.
To inspect the washer fluid level in the
front reservoir, pull off the cap. Then,
holding your thumb over the hole in the
center of the cap, lift it straight up. There
should be fluid in the straw. Add fluid if
necessary.
Use plain water if washer fluid is
unavailable. But use only washer fluid in
cold weather to prevent it from freezing.
Washer Fluid
Substitute Washer Fluid:
Using radiator antifreeze as washer
fluid is dangerous. If sprayed on the
windshield, it will dirty the
windshield, affect your visibility, and
could result in an accident. Use only
windshield washer fluid or plain
water in the reservoir.
WARNING
Float
Sedan
Hatchback
J39L_EA.book Page 18 Saturday, June 8, 2002 5:35 PM

11-5
Index
Form No. 8Q94-EA-02G
P
Paint Damage ................................... 8-42
Parking Brake
..................................... 5-5
Parking in an Emergency
................... 7-2
Power Door Locks
............................. 3-8
Power Steering
................................. 5-18
Fluid
.......................................... 8-16
Power Windows
............................... 3-14
Push-Starting
.................................... 7-17
R
Rear Door Child Safety Locks ........... 3-8
Rear Seat
............................................ 2-5
Rear Window Defroster
................... 5-40
Rear Window Washer
...................... 5-40
Rear Window Wiper
........................ 5-40
Rearview Mirror
............................... 3-24
Recreational Towing
........................ 7-20
Rocking the Vehicle
........................... 4-7
Roof Rack
........................................ 3-21
S
Safety Defects, Reporting ................ 9-14
Seat Belt System
3-point type
............................... 2-14
Extender
.................................... 2-20
Pregnant women
....................... 2-12
Pretensioner and load limiting
.. 2-16
Rear-center lap/shoulder
........... 2-18
Seat belt precautions
................. 2-11
Warning beep
............................ 2-21
Warning light
............................ 2-21
Seats
Front seats
................................... 2-2
Rear seat
...................................... 2-5
Service Publications
......................... 9-14
Spare Tire and Tool Storage
.............. 7-3
S
Specifications ...................................10-4
Speedometer
.....................................5-24
SRS Air Bags
Air bag system description
........2-40
Supplemental restraint systems
precautions
................................2-36
Warning light
............................2-45
Starting the Engine
.............................5-3
Steering Wheel
.................................3-23
Horn
..........................................5-41
Storage Compartments
.....................6-39
Cargo securing loops
.................6-39
Center console
...........................6-39
Glove box
..................................6-39
Sunroof
.............................................3-19
Sunshade
...........................................3-20
Sunvisors
..........................................6-35
T
Tachometer .......................................5-25
Temporary Spare Tire
......................8-27
Tiedown
Hook
..........................................7-19
Tires
Flat tire
........................................7-3
Inflation pressure
.......................8-25
Replacement
..............................8-26
Rotation
.....................................8-26
Snow tires
....................................4-8
Spare tire and tool storage
...........7-3
Specifications
............................10-8
Tire chains
...................................4-9
Uniform tire quality grading
system (UTQGS)
.......................9-12
Tool
....................................................7-3
J39L_EA.book Page 5 Saturday, June 8, 2002 5:35 PM

11-6
Index
Form No. 8Q94-EA-02G
T
Towing
Description
............................... 7-18
Emergency towing
.................... 7-18
Hook
......................................... 7-19
Recreational towing
.................. 7-20
Trailer towing
........................... 4-11
Trailer Towing
................................. 4-11
Trip Meter
........................................ 5-24
Trunk Lid
......................................... 3-11
Trunk Light
...................................... 3-12
Trunk Release Handle
...................... 3-12
Turn and Lane-Change Signals
....... 5-37
V
Vanity Mirrors ................................. 6-35
Vehicle Information Labels
............. 10-2
W
Warning Lights ................................ 5-27
Air bag system
.......................... 5-32
Anti-lock brake system
(ABS)
........................................ 5-32
Automatic transaxle
.................. 5-33
Brake system
............................ 5-29
Charging system
....................... 5-30
Check engine
............................ 5-31
Door-ajar
................................... 5-33
Engine oil pressure
................... 5-31
Front seat belt pretensioner
system
....................................... 5-32
Low fuel
.................................... 5-33
Low washer fluid level
............. 5-33
Seat belt
.................................... 5-33
Warranty
............................................ 9-8
Washer Fluid
.................................... 8-18
Weights
............................................ 10-6
W
Wheel Replacement ......................... 8-27
Windows
Power windows
......................... 3-14
Windshield Washer
.......................... 5-39
Windshield Wipers
........................... 5-39
Blades replacement
................... 8-20
Winter Driving
................................... 4-8
J39L_EA.book Page 6 Saturday, June 8, 2002 5:35 PM