washer fluid MERCEDES-BENZ C230 KOMPRESSOR SPORT 2004 W203 Owner's Manual

ContentsOperation......................................... 237
The first 1 000 miles (1 500 km) ......... 238
Driving instructions ............................ 239
Drive sensibly – save fuel ............. 239
Drinking and driving ..................... 239
Pedals .......................................... 239
Power assistance ......................... 239
Brakes .......................................... 240
Driving off..................................... 241
Parking ......................................... 241
Tires ............................................. 242
Hydroplaning ................................ 242
Tire traction .................................. 243
Tire speed rating .......................... 243
Winter driving instructions ........... 244
Standing water ............................. 245
Passenger compartment .............. 246
Driving abroad .............................. 246
Control and operation of radio
transmitters.................................. 246
Catalytic converter ....................... 247
Emission control........................... 247
Coolant temperature .................... 248At the gas station .............................. 249
Refueling ...................................... 249
Check regularly and before
a long trip ..................................... 251
Engine compartment ......................... 252
Hood ............................................ 252
Engine oil ..................................... 253
Transmission fluid level ................ 256
Coolant level ................................ 257
Battery ......................................... 258
Windshield washer system and
headlamp cleaning system* ......... 259
Tires and wheels ................................ 260
Important guidelines .................... 260
Life of tire..................................... 261
Direction of rotation ..................... 261
Checking tire inflation pressure ... 261
Rotating wheels ........................... 262Winter driving .................................... 263
Winter tires .................................. 263
Block heater (Canada only) .......... 264
Snow chains................................. 264
Maintenance...................................... 265
Clearing the service indicator ...... 265
Service term exceeded ................ 265
Calling up the service indicator .... 266
Resetting the service indicator .... 266
Vehicle care....................................... 267
Cleaning and care of the vehicle .. 267

ContentsTechnical data.................................. 335
Spare parts service ............................ 336
Warranty coverage ............................. 337
Loss of Service and Warranty
Information Booklet...................... 337
Identification labels............................ 338
Layout of poly-V-belt drive ................. 339
C 230 Kompressor Sport.............. 339
C 240/C 320 (all models) ............ 339
C 32 AMG..................................... 339
Engine ................................................ 340
Rims and Tires ................................... 342
Same size tires ............................. 343
Mixed size tires ............................ 344
Minispare wheel ........................... 345
Electrical system................................ 346
Main dimensions................................ 347
Weights .............................................. 348Fuels, coolants, lubricants, etc. ......... 349
Capacities .................................... 349
Engine oils.................................... 352
Engine oil additives ...................... 352
Air conditioning refrigerant .......... 352
Brake fluid .................................... 352
Premium unleaded gasoline ......... 353
Fuel requirements ........................ 353
Gasoline additives ........................ 354
Flexible Fuel Vehicles ................... 354
Coolants....................................... 356
Windshield washer and headlamp
cleaning* system ......................... 358
Consumer information ....................... 359
Uniform tire quality grading ......... 359
Technical terms............................... 361Index................................................. 367

48 Getting startedDrivingSwitching on windshield wipers
Turn the combination switch to the
desired position depending on the
intensity of the rain.
0Windshield wipers off
IIntermittent wiping
IINormal wiper speed
IIIFast wiper speedSingle wipe

Press combination switch briefly in
direction of arrow1.
The windshield wipers wipe one time
without washer fluid.
Wiping with windshield washer fluid

Push combination switch in direction of
arrow1 past the resistance point.
The windshield wipers operate with
washer fluid.
For information on filling up the washer
reservoir, see “Windshield washer system
and headlamp cleaning system*”
(
page 259).
iVehicles without rain sensor*:
Fast wiper speedIII goes to settingII
when the vehicle is standing still.
Vehicles with rain sensor*:
Intermittent wiping interval is depen-
dent on wetness of windshield. Wiping
will not occur with a front door open.
!Vehicles with rain sensor*:
Do not leave windshield wipers in inter-
mittent setting when the vehicle is tak-
en to an automatic car wash or during
windshield cleaning. Wipers will oper-
ate in the presence of water sprayed on
the windshield, and wipers may be
damaged as a result.
The switch should not be left in inter-
mittent setting as the wipers will wipe
the windshield once every time the en-
gine is started. Dust that accumulates
on the windshield might scratch the
glass and/or damage the wiper blades
when wiping occurs on a dry wind-
shield.

251 Operation
At the gas station
Check regularly and before a long trip
1Coolant level
For more information on coolant, see
“Coolant level” (
page 257).
2Brake fluid (fuse box cover removed)
Removing fuse box cover
(
page 333).
3Windshield washer and headlamp
cleaning system*
For more information on filling up the
washer reservoir, see “Windshield
washer system and headlamp cleaning
system*” (
page 259).Engine oil level
For more information on engine oil level,
see “Engine oil” (
page 253).
Opening hood (
page 252).
Vehicle lighting
Check function and cleanliness. For more
information on replacing light bulbs, see
“Replacing bulbs” (page 310).
Exterior lamp switch (page 102).
Tire inflation pressure
More information on tire inflation pressure
(
page 261).
!If you find that the brake fluid in the
brake fluid reservoir has fallen to the
minimum mark or below, have the
brake system checked for brake pad
thickness and leaks immediately.
Notify an authorized Mercedes-Benz
Center immediately. Do not add brake
fluid as this will not solve the problem.
For more information, see “Practical
hints” (
page 275).

259 Operation
Engine compartment
Windshield washer system and headlamp cleaning system*
The windshield washer reservoir is located
in the engine compartment.
1Washer fluid reservoir
Fluid for the windshield washer system and
the headlamp cleaning system* is supplied
from the windshield washer reservoir. It
has a capacity of:

3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system*


6.4 US qt (6.0 l) in vehicles with
headlamp cleaning system*During all seasons, add MB Windshield
Washer Concentrate “S” to water. Premix
the windshield washer fluid in a suitable
container.

Refill the reservoir with MB Windshield
Washer Concentrate and water (or
commercially available premixed
windshield washer solvent/antifreeze,
depending on ambient temperatures).
Always use washer solvent/antifreeze
where temperatures may fall below the
freezing point. Failure to do so could
result in damage to the washer
system/reservoir.For more information, see “Windshield
washer and headlamp cleaning* system”
(
page 358).
!Only use washer fluid which is suitable
for plastic lenses. Improper washer
fluid can damage the plastic lenses of
the headlamps.
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You could be seriously burned.

299 Practical hints
What to do if …
Display symbol
Display message
Possible cause
Possible solution
K
CLOSE
SUNROOF!
You have opened the driver’s door with
the SmartKey removed from the starter
switch and the sliding/pop-up roof open.

Close the sliding/pop-up roof
(page 203).
J
CLOSE
SUNROOF!
You have opened the driver’s door with
the SmartKey removed from the starter
switch and the sliding/pop-up roof open.

Close the sliding/pop-up roof
(page 203).
L
TELE AID
DRIVE TO WORKSHOP!
One or more main functions of the Tele
Aid system* are malfunctioning.

Have the Tele Aid system* checked by
an authorized Mercedes-Benz Center.
ì
FUNCTION
NOT AVAILABLE!
This display appears if buttonì
orí on the multifunction steering
wheel is pressed and the vehicle is not
equipped with a telephone*.
Ê
TRUNK OPEN!
This message will appear whenever the
trunk lid is open.

Close the trunk lid.
W
WASHER FLUID
CHECK LEVEL!
The fluid level has dropped to
about
1/3of total reservoir capacity.

Add washer fluid (
page 259).

358 Technical dataFuels, coolants, lubricants, etc.Windshield washer and headlamp cleaning* system
Both the windshield and headlamp washer
systems are supplied from the windshield
washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx.:

3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system*


6.4 US qt (6.0 l) in vehicles with
headlamp cleaning system*

Refill the reservoir with MB Windshield
Washer Concentrate “S” and water
(or concentrate and commercially
available premixed windshield washer
solvent/antifreeze, depending on
ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing, use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
[40 ml “S” to 1 gallon (4.0 liters) water]
For temperatures below freezing, use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent/antifreeze:


1 part “S” to 100 parts solvent
[40 ml “S” to 1 gallon (4.0 liters) solvent]
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You could be seriously burned.

379 Index
Gear selector lever 23, 44
Cleaning 271
Lock 44
Position (Automatic
transmission*) 23, 142, 145
Gearshift lever 43
Global
Locking 83
Unlocking 83
Global Positioning System see GPS
Glove box 21, 216
Closing 216
Opening 216
Good visibility 148
GPS 362
GPS see COMAND*
H
Halogen-type
Front lamp bulbs 312
Hands-free microphone 27
Hard plastic trim items
Cleaning 271Hazard warning flasher 106
Switching off 106
Switching on 106
Head restraints
Front seats
Manual seat 34, 93
Power seat* 35, 94
Rear seats 94
Headlamp cleaning system* 259
Headlamp shut-off delay see Delayed
shut-off, exterior lamps
Headlamps
Automatic control 103
Bi-Xenon* 361
Bi-Xenon* type
Replacing bulbs 313
Cleaning 269
Cleaning system* 148, 259, 358
Halogen-type
Replacing bulbs 312
Refilling washer fluid 259
Switching off 51
Switching on 46
Washer fluid 358Headliner and shelf below rear window
Cleaning 271
Heated seats* 98
Height adjustment
Front seat head restraints
Manual seat 34
Power seat* 35
Rear seat head restraints 94
Seat belts 42
Steering wheel
Adjustment, electrical* 37
Adjustment, manual 37
High beam flasher 47, 106
High beam headlamps
Messages in display 294
Replacing bulbs 310, 312
Switching on 106
High beam headlamps xenon type*
Replacing bulbs 313
High mounted brake lamp 311

384 IndexMultifunction display messages
ABS 284
BAS 281
Battery, vehicle 285
Brake fluid 286
Brake pads 286
Coolant 287–289
Cruise control 290
Display 290
Doors 290
Engine oil 291–292
ESP 282–283
Fuel cap 293
Fuel reserve tank 293
Hood 293
Key, SmartKey 293
Lamps, exterior 293–296
Oil 291–292
Parking brake 286
Restraint system 297Seat belts 297
Sliding/pop-up roof* 299
SRS 297
Steering column not
properly locked 298
Steering gear oil level 298
Tele Aid* 299
Telephone* 299
Trunk lid 299
Windshield washer fluid 299
Multifunction steering
wheel 24, 114, 363
Buttons 114
N
Navigation system*
Operating 121
See separate COMAND*
operating instructions
Night security illumination 104
Setting 131O
Occupant safety 54
Airbags 55
Children and airbags 56
Children in the vehicle 63
Fastening the seat belt 40
Infant and child restraint systems 63
LATCH-type child seat anchors 69
Seat belts 40, 58
Odometer, main 23
Oil level see Engine oil level
Oil see Engine oil
One-touch gearshifting 143
Canceling gear range limit 143
Downshifting 143
Upshifting 143
Opening
Ashtray, center console 220
Ashtray, rear seat 221
Cup holder, in front of
seat armrest 217

393 Index
Technical data
Air conditioning refrigerant 352
Brake fluid 352
Coolant 350
Coolants 356
Electrical system 346
Engine oil additives 352
Engine oils 352
Flexible fuel vehicles 354
Fuel requirements 353
Fuels 350
Gasoline additives 354
Lubricants 349
Main dimensions 347
Premium unleaded gasoline 353
Rims and tires 342
Weights 348
Windshield washer 351
Windshield washer and headlamp
cleaning* system 351, 358Tele Aid* 223
Emergency calls 224
Information 227
Initiating an emergency call
manually 226
Message in display 299
Remote door unlock 230
Roadside assistance 226
SOS button 226
Stolen vehicle tracking services 230
System self-check 224
Tele Aid System 223, 365
Upgrade signals 229
Telematics* 365
Telephone* 24, 222
Answering a call 139
Dialing a number from
the phone book 140
Emergency call 198
Ending a call 139
Hands-free microphone 27Loading phone book 140
Message in display 299
Operation 138, 193
Redialing 140
Signal strength 139
Temperature
Display mode 127
Grades of tires 360
Setting interior temperature
Automatic climate control* 165
Climate control 156
Setting units in display 127
Tires 262
Tightening torque
(Wheel bolts) 321, 365
Tilt
Head restraint
Manual seat 34
Power seat* 36
Time
Setting hours 126
Setting minutes 126