snow chains MERCEDES-BENZ C240 2002 W203 Owner's Manual

4 Contents
DrivingControl and operation of
radio transmitters .....................232
The first 1 000 miles
(1 500 km) .................................233
Maintenance ...................................233
Tele Aid ...........................................234
Catalytic converter ........................244
Emission control ............................245
Starter switch .................................246
Starting and turning off
the engine ..................................248
Manual transmission ....................249
Automatic transmission ............... 251
Parking brake .................................260
Driving instructions ...................... 261
Drive sensibly – Save Fuel ........ 261
Drinking and driving ................. 261
Pedals ........................................... 261
Power assistance ........................262
Brakes ..........................................262
Driving off ...................................263
Parking ........................................264Tires ............................................. 265
Snow chains ............................... 267
Winter driving
instructions ................................ 268
Deep water .................................. 270
Passenger compartment ............271
Traveling abroad .........................271
Cruise control ................................ 272
Brake assist system (BAS) ............ 275
Antilock brake system
(ABS) ...........................................276
Electronic stability program
(ESP) ........................................... 278
What you should know
at the gas station ...................... 282
Check regularly and
before a long trip ...................... 284
Instrument cluster displayMalfunction and indicator lamps
in the instrument cluster ........ 286
On-board diagnostic system ........ 286
Check engine malfunction
indicator lamp ............................ 286Brake warning lamp ..................288
Supplemental restraint
system (SRS) indicator lamp ....289
Fuel reserve warning .................290
ABS malfunction
indicator lamp ............................. 291
Electronic stability program
(ESP) — warning lamp ...............292
Seat belt nonusage
warning lamp ............................292
Malfunction and
indicator lamp in
the center console .....................292
AIRBAG OFF indicator lamp .....292
Malfunction and
warning messages in the
multifunction display ...............293
DISPLAY DEFECTIVE ................295
BATTERY / ALTERNATOR ........296
ANTILOCK BRAKE SYSTEM ....297
BRAKE ASSIST ...........................297
BRAKE PAD WEAR ....................298
BRAKE FLUID .............................298
PARKING BRAKE .......................299
OM_203.book Seite 4 Donnerstag, 31. Mai 2001 11:57 11

231 Contents - Driving
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index
DrivingControl and operation of
radio transmitters .....................232
The first 1 000 miles
(1 500 km) .................................233
Maintenance ...................................233
Tele Aid ...........................................234
Catalytic converter ........................244
Emission control ............................245
Starter switch .................................246
Starting and turning off
the engine ..................................248
Manual transmission ....................249
Automatic transmission ............... 251
Parking brake .................................260Driving instructions ...................... 261
Drive sensibly – Save Fuel ....... 261
Drinking and driving ................ 261
Pedals .......................................... 261
Power assistance ........................ 262
Brakes .......................................... 262
Driving off ................................... 263
Parking ........................................ 264
Tires ............................................. 265
Snow chains ............................... 267
Winter driving
instructions ................................ 268
Deep water .................................. 270
Passenger compartment ............271
Traveling abroad .........................271Cruise control .................................272
Brake assist system (BAS) ............275
Antilock brake system
(ABS) ........................................... 276
Electronic stability program
(ESP) ...........................................278
What you should know
at the gas station .......................282
Check regularly and
before a long trip ......................284
OM_203.book Seite 231 Donnerstag, 31. Mai 2001 11:57 11

267 Driving instructions
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index Tire speed rating
Vehicles without Sport Package:
Your vehicle is factory equipped with “H”-rated tires,
which have a speed rating of 130 mph (210 km / h).
An electronic speed limiter prevents your vehicle from
exceeding the speed rating.Snow chains
Use only snow chains that are tested and recommended
by Mercedes-Benz. Your authorized Mercedes-Benz
Center will be glad to advise you on this subject.
Chains should only be used on the rear wheels. Follow
the manufacturer’s mounting instructions.
Snow chains should only be driven on snow covered
roads at speeds not to exceed 30 mph (50 km / h).
Remove chains as soon as possible when driving on
roads without snow.
When driving with snow chains, press the ESP control
switch to OFF, refer to page 280.
Wa r n i n g !
Even when permitted by law, never operate a
vehicle at speeds greater than the maximum speed
rating of the tires.Exceeding the maximum speed for which tires are
rated can lead to sudden tire failure causing loss of
vehicle control and resulting in personal injury
and possible death.
OM_203.book Seite 267 Donnerstag, 31. Mai 2001 11:57 11

269 Driving instructions
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index Winter driving
Have your vehicle winterized at your authorized
Mercedes-Benz Center before the onset of winter.
•Change the engine oil if the engine contains an oil
which is not approved for winter operation. For
viscosity (SAE / CCMC class) and filling quantity,
seepage383.
•Check engine coolant anticorrosion / antifreeze
concentration.
•Additive for the windshield washer and headlamp
cleaning system: Add MB Concentrate “S” to a
premixed windshield washer solvent / antifreeze
which is formulated for below freezing
temperatures, see page 323.
•Test battery: Battery capacity drops with decreasing
ambient temperature. A well charged battery helps
to ensure that the engine can be started, even at low
ambient temperatures.
•Tires: We recommend M+S rated radial-ply tires on
all four wheels for the winter season. Observe
permissible maximum speed for M+S rated
radial-ply tires and the legal speed limit.Note:
In winter operation, the maximum effectiveness of the
antilock brake system (ABS) and electronic stability
program (ESP) can only be achieved with M+S rated
radial-ply tires and / or snow chains recommended by
Mercedes-Benz. Snow chains maximize performance.
OM_203.book Seite 269 Donnerstag, 31. Mai 2001 11:57 11

279 Driving systems
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index Notes:
The yellow ESP warning lampv in the speedometer
dial comes on with the electronic key in starter switch
position 2. It should go out with the engine running.
If the ESP warning message is displayed, a malfunction
has been detected in the system. Only partial engine
output will be available.
Have the ESP checked at your authorized
Mercedes-Benz Center as soon as possible.
For ESP warning message, see page 292.
With the ABS malfunctioning, the ESP is also switched
off.
Driving the vehicle with varied size tires will cause the
wheels to rotate at different speeds, therefore the ESP
may activate (yellow ESP warning lamp in speedometer
d ial com es on ). For t his reas on, all wheels, in cludin g t he
spare wheel, must have the same tire size.When testing the parking brake on a brake test
dynamometer, the engine must be shut off. Otherwise,
the ESP will immediately be engaged and will apply the
rear wheel brakes.
In winter operation, the maximum effectiveness of the
ESP is only achieved with Mercedes-Benz recommended
M+S rated radial-ply tires and / or snow chains.
Synchronizing ESP
If the power supply was interrupted (battery
disconnected or empty), the ESP warning message may
be displayed with the engine running.
Turn steering wheel completely to the left and then to
the right. The ESP warning message should go out.
OM_203.book Seite 279 Donnerstag, 31. Mai 2001 11:57 11

378 Technical data
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Rims — Tires
Model C 240 (203.061)C 320 (203.064)C 240 (Canada only)C 32 AMG (203.065)
Rims (light alloy)
Wheel offset:7J x 16 H2
1.46 in (37 mm)7J x 16 H2
1.46 in (37 mm)(steel rims) 7J x 16 H2
1. 4 6 i n ( 3 7 m m )Front axle: 71/2Jx17H2
Rear axle: 8
1/2Jx17H2
Front axle: 1.46 in (37 mm)
Rear axle: 1.34 in (34 mm)
All season tires:
Radial-ply tires 205/55 R16 91 H 205/55 R16 91 H 205/55 R 16 91 H –
Summer tires:
Radial-ply tires – – – Front axle: 225/45 R 17 91 Y3
Rear axle: 245/40 R 17 91 Y2,
4
Winter tires:
Radial-ply tires 205/55 R16 91 H
M+S205/55 R16 91 H
M+S205/55 R 16 91 H
M+S–
Spare wheel
Rim (steel rim)
Wheel offset:7J x 16 H2
1.46 in (37 mm)7J x 16 H2
1.46 in (37 mm)7J x 16 H2
1. 4 6 i n ( 3 7 m m )–
–
All season tires:
Radial-ply tires 205/55 R16 91 H 205/55 R16 91 H 205/55 R16 91 H –
2 Must not be used with snow chains. 3 Also permissible: 225/45 ZR 17 91 Y. 4 Also permissible: 245/40 ZR 17 91 Y2.
OM_203.book Seite 378 Donnerstag, 31. Mai 2001 11:57 11