check engine MERCEDES-BENZ C240 4MATIC 2004 W203 Owner's Guide
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2004, Model line: C240 4MATIC, Model: MERCEDES-BENZ C240 4MATIC 2004 W203Pages: 400, PDF Size: 5.04 MB
Page 352 of 400
352 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, only
use engine oils approved by
Mercedes-Benz. Information on approved
engine oils is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Center.Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air
conditioning system.Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of
bubbles in the system, thus reducing the
system’s efficiency.
Therefore, the brake fluid must be
replaced every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will
provide you with additional information.
!Always check the oil filler cap
(page 255) for important information
pertaining to the engine oil needing to
meet a specific Mercedes-Benz specifi-
cation (e.g. MB 229.5). If such informa-
tion is printed on the oil filler cap, only
use an engine oil from the list of ap-
proved engine oils in the Factory Ap-
proved Service Products pamphlet that
meets the specification indicated on
the oil filler cap.
Using engine oils of other specification
may cause the FSS to incorrectly deter-
mine the next service interval and will
result in engine damage not covered by
the Mercedes-Benz Limited Warranty.
Page 356 of 400
356 Technical dataFuels, coolants, lubricants, etc.Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which
provides:
Corrosion protection
Freeze protection
Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and
corrosion protection.
If the antifreeze mixture is effective
to -22°F (-30°C), the boiling point of the
coolant in the pressurized cooling system
is reached at approx. 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over
protection. Refer to Service Booklet for
replacement interval.
Coolant system design and coolant used
stipulate the replacement interval. The
replacement interval published in the
Service Booklet is only applicable
if MB 325.0 anticorrosion/antifreeze
solution or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products
pamphlet) are used to renew the coolant
concentration or bring it back up to the
proper level.
To provide important corrosion protection,
the solution must be at least 45%
anticorrosion/antifreeze [equivalent to
freeze protection to approx. -22°F
(-30°C)]. If you use a solution that is more than 55%
anticorrosion/antifreeze [freeze
protection to approx. -49°F (-45°C)], the
engine temperature will increase due to
the lower heat transfer capability of the
solution. Therefore, do not use more than
this amount of anticorrosion/antifreeze.
If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure the mixture is
in accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality,
consult your authorized Mercedes-Benz
Center.
Page 357 of 400
357 Technical data
Fuels, coolants, lubricants, etc.
Anticorrosion/antifreeze
Your vehicle contains a number of
aluminum parts. The use of aluminum
components in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifi-
cally formulated to protect the aluminum
parts.Failure to use such anticorrosion/anti-
freeze coolant will result in a significantly
shortened service life.
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0
Anticorrosion/Antifreeze Agent.Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantityModel
Approx. freeze protection–35°F (–37°C)
–49°F (–45°C)
C230KompressorSport
3.0 US qt (2.8 l)
3.3 US qt (3.1 l)
C 240/C 320 (all models)
3.4 US qt (3.2 l)
3.8 US qt (3.6 l)
C32AMG
3.4 US qt (3.2 l)
3.8 US qt (3.6 l)
Page 372 of 400
372 IndexCenter console 25
Lower part 26
PASS. AIRBAG OFF
indicator lamp 279
Upper part 25
Centigrade
Setting temperature units 127
Central locking
Automatic 90
From inside 91
Switch 91
Switching on/off
(control system) 133
Unlocking from inside 91
Central locking switch 91
Certification label 338
Changing
Batteries (SmartKey) 307
CDs 189
Key setting 133
Charcoal filter 169Charging
Vehicle battery 324
CHECK ENGINE
malfunction indicator lamp 276
Checking
Brake fluid 251
Coolant level 251, 257
Engine oil level 251, 254
Tire inflation pressure 251
Vehicle lighting 251
Child safety 63
Airbags 56
Infant and child restraint
systems 60, 63
LATCH-type child seat anchors 69
Child safety switch see
Blocking of rear door window operation
Child seat anchors
see LATCH-type child seat anchors
Cigarette lighter 221Cleaning
Cloth upholstery 272
Cup holder 271
Gear selector lever 271
Hard plastic trim items 271
Headlamps 148
Headliner and shelf below
rear window 271
Instrument cluster 270
Leather upholstery 271
Light alloy wheels 270
MB Tex upholstery 272
Plastic and rubber parts 272
Seat belts 271
Steering wheel 271
Upholstery 271
Windows 270
Windshield 48
Wiper blades 270
Wood trims 272
Page 374 of 400
374 IndexCoolant 257, 356
Adding 257
Anticorrosion/antifreeze
quantity 356
Capacities 350
Checking level 257
Messages in display 287–289
Temperature 248
Temperature display 110
Coolant level
Checking 257
Cruise control 206, 362
Canceling 207
Driving downhill 207
Driving uphill 207
Fine adjustment 208
Message in display 290
Setting current speed 207
Setting speeds 208
Cruise control lever 206
Cruising range, fuel 355Cup holder
Cleaning 271
In front of seat armrest 217
In rear seat armrest 218
Customer Assistance Center see CAC
D
Daytime running lamp mode 104
Setting 129
Deactivating
Air conditioning (cooling)
Automatic climate control* 170
Climate control 160
Air recirculation mode
Automatic climate control* 168
Climate control 159
Alarm 79
Anti-theft alarm system* 79
Automatic climate control* 163
Central locking (control system) 133
Climate control 155
Climate control system 159Cruise control 207
Defrosting
Automatic climate control* 167
Climate control 158
Engine with the SmartKey 52
ESP 75
Exterior lamps 103
Exterior lamps delayed shut-off 131
Front fog lamps 131
Hazard warning flasher 106
Headlamps 51
Interior lighting delayed shut-off 132
Rapid seat heating* 98
Rear window defroster 153
Seat heating* 98
Tow-away alarm* 80
Deep water see Standing water
Defogging
Windshield
Automatic climate control* 166
Climate control 157
Page 376 of 400
376 IndexE
Easy-entry/exit feature* 92
Activating 134
Interrupting movement 92, 134
Electrical fuses 332
Electrical system
Technical data 346
Electronic Stability Program see ESP
Emergency call system* 223
Emergency calls
Initiating an emergency call 226
Telephone* 198
With Tele Aid* 224
Emergency operation
(Limp Home Mode) 147
Emergency operations
Closing sliding/pop-up roof* 309
Locking the vehicle 306
Opening sliding/pop-up roof* 309
Releasing trunk lid from inside 88
Remote door unlock 230
Unlocking the vehicle 305Emergency Tensioning Device see ETD
Emission control 247
Emission control label 338
Ending
A call (telephone*) 139
Engine
Compartment 252
Starting with
automatic transmission* 44
Starting with
manual transmission 43
Starting with the SmartKey
Automatic transmission* 44
Manual transmission 43
Technical data 340
Turning off with the SmartKey 52
Engine cleaning 269
Engine compartment 252
Fuse box in 333
Hood 252
Engine malfunction
indicator lamp 23, 276Engine number 338, 362
Engine oil 253, 352
Adding 255
Additives 352
Checking level 251, 254
Consumption 253
Display messages 254, 291–292
Filler neck
C 230 Kompressor Sport 256
C 240, C 320, and C 32 AMG 256
Messages in display 254, 291–292
Viscosity 362
Engine oil level
Checking 251, 254
ESP 23, 74, 362
Four wheel electronic
traction system with ESP 77
Messages in display 282–283
Switching off 75
Switching on 76
Synchronizing 282
Warning lamp 277
Page 381 of 400
381 Index
K
Key dependency memory
Settings 135
Key positions in starter switch 31
Key, mechanical 305
Key, SmartKey
Battery check lamp 83
Checking the batteries 84
Factory setting 83
Global locking 83
Global unlocking 83
Loss of 85
Messages in display 293
Positions in starter switch 31
Remote control 82
Restoring to factory setting 83
Selective setting 83
Starting the engine
Automatic transmission* 44
Manual transmission 43
Turning off the engine 52Unlocking the trunk lid 84
Unlocking with 30
Kickdown 147, 363
Kilometers/miles in speedometer 128
Km/h or mph in speedometer 128
L
Labels, identification 338
Lamp bulbs, exterior 310
Lamps, exterior
Front 310
Light sensor 294
Messages in display 293–296
Rear 311
Lamps, indicator and warning
ABS 274
Battery (SmartKey) 83
Brakes 275
CHECK ENGINE 276
Engine diagnostics 276, 278
ESP 277
Fuel reserve 278Instrument cluster 274–278
PASS. AIRBAG OFF 59, 279
Seat belts 278
SRS 55, 278
Turn signals 23
Language
Multifunction display 128
Setting 128
LATCH-type child seat anchors 69
Folding back 69
Layout of poly-V-belt drive 339
Leather upholstery
Cleaning 271
License plate lamps
Messages in display 294
Replacing bulbs 311, 315
Light alloy wheels
Cleaning 270
Technical data 343
Light sensor 294
Lighter see Cigarette lighter
Page 393 of 400
393 Index
Technical data
Air conditioning refrigerant 352
Brake fluid 352
Coolant 350
Coolants 356
Electrical system 346
Engine oil additives 352
Engine oils 352
Flexible fuel vehicles 354
Fuel requirements 353
Fuels 350
Gasoline additives 354
Lubricants 349
Main dimensions 347
Premium unleaded gasoline 353
Rims and tires 342
Weights 348
Windshield washer 351
Windshield washer and headlamp
cleaning* system 351, 358Tele Aid* 223
Emergency calls 224
Information 227
Initiating an emergency call
manually 226
Message in display 299
Remote door unlock 230
Roadside assistance 226
SOS button 226
Stolen vehicle tracking services 230
System self-check 224
Tele Aid System 223, 365
Upgrade signals 229
Telematics* 365
Telephone* 24, 222
Answering a call 139
Dialing a number from
the phone book 140
Emergency call 198
Ending a call 139
Hands-free microphone 27Loading phone book 140
Message in display 299
Operation 138, 193
Redialing 140
Signal strength 139
Temperature
Display mode 127
Grades of tires 360
Setting interior temperature
Automatic climate control* 165
Climate control 156
Setting units in display 127
Tires 262
Tightening torque
(Wheel bolts) 321, 365
Tilt
Head restraint
Manual seat 34
Power seat* 36
Time
Setting hours 126
Setting minutes 126
Page 394 of 400
394 IndexTime display
Setting 127
Tire inflation pressure
Checking 251, 261
Tire speed rating 243, 365
Tire traction 243
Tires 260, 342
Consumer information 359
Direction of rotation 261
Driving instructions 242
Retreads 260
Rims and tires 342
Service life 261
Temperature 262
Temperature grades 360
Tread depth 263
Wear pattern 262
Winter 263
Tools 300Tow-away alarm* 25, 79
Arming 80
Disarming 80
Disarming for transport 80
Towing eye bolt (vehicle tool kit)
Installing 331
Towing the vehicle 328
Tracking services
For stolen vehicle 230
Traction 147, 359, 365
Transmission gear selector lever
Unlocking manually 308
Transmission see
Automatic* or Manual transmission
Tread depth (tires) 263
Tread Wear 359
Trip computer 136
Trip odometer
Resetting 111Trunk
Auxiliary fuse box 334
Closing the lid 87
Lamp 108
Opening 84
Opening from inside vehicle 87
Separately locking 89
Separately unlocking 90
Trunk lid emergency release 88
Trunk lid
Closing 87
Emergency release 88
Message in display 299
Turn signal lamps
Replacing bulbs 310, 311
Turn signals 47
Additional in mirrors 310
Cleaning lenses 269
Front bulbs 310, 312, 314
Indicator lamps 23
Rear bulbs 311, 315
Turning off
Engine 52