charging MERCEDES-BENZ C320 2005 W203 Owner's Manual

Contents
Practical hints................................ 301
What to do if … .................................. 302
Lamps in instrument cluster ........ 302
Lamp in center console................ 308
Vehicle status messages in the
multifunction display .................... 309
Where will I find ...? ........................... 329
First aid kit ................................... 329
Vehicle tool kit ............................. 329
Minispare wheel
(except C 55 AMG)....................... 333
Collapsible tire
(C 55 AMG only)........................... 334
Spare wheel bolts ........................ 336
Unlocking/locking in an emergency .. 337
Unlocking the vehicle ................... 337
Locking the vehicle ...................... 338
Fuel filler flap ............................... 339
Manually unlocking the
transmission gear selector lever .. 340
Opening/closing in an emergency..... 341
Power tilt/sliding sunroof* .......... 341Replacing SmartKey batteries ............ 342
SmartKey ...................................... 343
Replacing bulbs .................................. 344
Bulbs ............................................. 344
Replacing bulbs for front lamps .... 347
Replacing bulbs for rear lamps ..... 351
Replacing wiper blades....................... 352
Removing wiper blades ................. 352
Installing wiper blades .................. 352
Flat tire ............................................... 353
Preparing the vehicle .................... 353
Mounting the spare wheel ............ 353
Battery................................................ 360
Disconnecting the battery............. 361
Removing the battery.................... 361
Charging and reinstalling
the battery .................................... 361
Reconnecting the battery.............. 362Jump starting...................................... 363
Towing the vehicle.............................. 365
Installing towing eye bolt .............. 368
Fuses.................................................. 369
Aids for changing fuses ................ 369
Main fuse box in passenger
compartment ................................ 370
Fuse box in engine
compartment ................................ 370
Fuse box in trunk .......................... 371

302 Practical hintsWhat to do if …Lamps in instrument clusterGeneral information:
If a bulb in the instrument cluster fails to
come on during the bulb self-check when switching on ignition, have it checked and
replaced if necessary.Problem
Possible cause
Suggested solution
-
The yellow ABS malfunction
indicator lamp comes on while
driving.
The ABS has detected a malfunction and has
switched off. The BAS and the ESP are also
switched off (see messages in display).
The brake system is still functioning normally
but without the ABS available.
If the ABS control unit is malfunctioning,
other systems such as the navigation
system* or the automatic transmission* may
also be malfunctioning.

Continue driving with added caution.
Wheels may lock during hard braking,
reducing steering capability.

Read and observe messages in the
display (
page 309).

Have the system checked at an autho-
rized Mercedes-Benz Center as soon
as possible.
Failure to follow these instructions
increases the risk of an accident.
The charging voltage has fallen below ten
volts. The ABS has switched off.
The battery might not be charged sufficiently.

Switch off electrical consumers that
are currently not needed, e.g. seat
heating*.

If necessary, have the generator
(alternator) and battery checked.
When the voltage is above this value
again, the ABS is operational again.

311 Practical hints
What to do if …
Display message
Possible cause
Possible solution
BAS
unavailable
See Operator’s Manual
The charging voltage has fallen below ten
volts. The BAS has switched off.
The battery might not be charged
sufficiently.
The brake system is still functioning
normally but without the BAS available.

Continue driving with added caution.

If necessary, have the generator and
battery checked.
When the voltage is above this value
again, the BAS is operational again.
malfunction.
Visit workshop.
The BAS has detected a malfunction and
switched off.

Continue driving with added caution.

Have the system checked at an
authorized Mercedes-Benz Center as
soon as possible.
Failure to follow these instructions
increases the risk of an accident.
Display malfunction.
Visit workshop.
The BAS or the BAS display is
malfunctioning.

Continue driving with added caution.

Have the system checked at an
authorized Mercedes-Benz Center as
soon as possible.
Failure to follow these instructions
increases the risk of an accident.

312 Practical hintsWhat to do if …Display message
Possible cause
Possible solution
ESP
unavailable
See Operator’s Manual
The ESP was deactivated because of a
malfunction or interrupted power supply.
The ABS might not be operational.
The brake system is still functioning
normally but without the ESP available.

Continue driving with added caution.

Visit an authorized Mercedes-Benz
Center as soon as possible.
Failure to follow these instructions
increases the risk of an accident.
If the yellow ESP warning lampv
flashes while driving and this message
appears, the electronic traction system
has switched off to prevent overheating
of the drive wheel brakes.
As soon as the brakes have cooled off, the
electronic traction system switches on
again.
The self-diagnosis has not been
completed yet.
The brake system is still functioning
normally but without the ESP available.
The display will clear after driving a short
distance at more than 12 mph (20 km/h).
The charging voltage has fallen below ten
volts. The ESP has switched off.
The battery might not be charged
sufficiently.

Continue driving with added caution.

If necessary, have the generator and
battery checked.
When the voltage is above this value
again, the ESP is operational again.

314 Practical hintsWhat to do if …Symbol messagesDisplay symbol
Display message
Possible cause
Possible solution
#
Battery Alternator
Visit workshop.
The battery is no longer charging.
Possible causes:

broken poly-V-belt


alternator malfunctioning

Stop immediately and check the
poly-V-belt.
If it is broken:

Do not continue to drive. Otherwise
the engine will overheat due to an
inoperative water pump which may
result in damage to the engine. Notify
an authorized Mercedes-Benz Center.
If it is intact:

Drive immediately to the nearest
authorized Mercedes-Benz Center.
Low voltage
Charge battery
The battery has insufficient voltage.

Start the engine (
page 46).
Low voltage
Switch off consumers
The battery has insufficient voltage.

Turn off unnecessary electrical
consumers.

361 Practical hints
Battery
1Negative terminal
2Positive terminal cover
Disconnecting the battery
Turn off the engine (
page 56).

Turn off all electrical consumers.

Remove SmartKey from starter switch.

Open the hood (
page 278).

Remove the filter box (
page 360).

Disconnect the battery negative lead
from negative terminal1.

Remove cover2 from the positive
terminal.

Disconnect the battery positive lead.
Removing the battery
Remove the screw-nuts securing the
battery.

Remove the battery bracket.

Take out the battery.
Charging and reinstalling the battery
Charge battery in accordance with the
instructions of the battery charger
manufacturer.

Reinstall the charged battery. Follow
the previously described steps in
reverse order.
Warning!
G
With a disconnected battery

you will no longer be able to turn the
SmartKey in the starter switch


the gear selector lever will remain
locked in positionP
Warning!
G
Never charge a battery while still installed in
the vehicle. Gases may escape during charg-
ing and cause explosions that may result in
paint damage, corrosion or personal injury.

408 Index
Starting with 47
Steering wheel gearshift control
(C 55 AMG only) 164
Transmission fluid 282
B
BabySmart
TM
Air bag deactivation system 70, 399
Compatible child seats 70, 399
Self-test 70
Backrest
Folding forward 238
Folding rearward 238
Backrest contour
Adjusting 104
Backrest side bolsters
Adjusting 104
Backrest tilt
Manual seat 36
Power seat* 38
Backup lamps
Messages in display 323
Replacing bulbs 345BAS 78, 399
Messages in display 311
Batteries, SmartKey
Changing 343
Check lamp 90
Checking 91
Battery discharged
Jump starting 363
Battery, vehicle 284, 360
Charging 361
Disconnecting 361
Reconnecting 362
Reinstalling 361
Removing 361
Bi-Xenon headlamps* 399
Bi-Xenon type*
Front lamp bulbs 349
Block heater (Canada only) 291
Blocking
Rear door window operation 75
Bolts
For spare wheel 336Brake Assist System see BAS
Brake fluid 390
Checking 277
Message in display 315
Brake lamp bulbs 345
Brake lamp, high mounted 345
Brake lamps
Messages in display 323
Brake pads
Message in display 315
Brakes 266
Warning lamp 25, 303
Break-in period 264
Bulbs, replacing 344
Additional turn signals 345
Backup lamps 345, 351
Brake lamps 345, 351
Fog lamp, rear 345, 351
Fog lamps, front 345
Front lamps 345
High beam flasher 345
High beam headlamps 345

410 IndexCharging
Vehicle battery 361
Checking
Brake fluid 277
Coolant level 277, 283
Engine oil level 277, 280
Tire inflation pressure 277
Vehicle lighting 277
Washer reservoir level 277
Child safety 67
Air bags 60
Infant and child restraint
systems 64, 67
LATCH-type child seat anchors 73
Child safety switch see
Blocking of rear door window operation
Child seat anchors see
LATCH-type child seat anchors
Cigarette lighter 246
Cleaning
Cloth upholstery 300
Cup holders 299
Gear selector lever 299Hard plastic trim items 299
Headlamps 168
Headliner and shelf below
rear window 299
Instrument cluster 298
Leather upholstery 299
Light alloy wheels 298
MB Tex upholstery 300
Plastic and rubber parts 300
Seat belts 299
Steering wheel 299
Upholstery 299
Windows 298
Windshield 52
Wiper blades 298
Wood trims 300
Climate control 174
Clock 25, 121, 137, 138
Closing
Cup holder, in rear seat armrest 245
Glove box 241
Hood 279Tilt/sliding sunroof* 227
Tilt/sliding sunroof*
in an emergency 341
Tilt/sliding sunroof*
with SmartKey 229
Trunk lid 94
Windows 223, 224
Windows with SmartKey 225
Cloth upholstery
Cleaning 300
Cockpit 22, 399
Cockpit Management and
Data System see COMAND*
Collapsible tire 383
Collapsible tire (C 55 AMG only) 334
Collapsible wheel chock 332
COMAND* 400
COMAND* see separate
operating instructions
Combination switch 113
High beam flasher 50
Turn signals 50
Windshield wipers 51