technical data MERCEDES-BENZ CL500 2006 C215 User Guide

406 Technical dataIdentification labels1Certification label
(on driver’s B pillar)2Vehicle Identification Number (VIN)
(below right rear passenger seat)3Engine number (engraved on engine)
4VIN, visible (lower edge of windshield)
5Vacuum line routing diagram label
6Emission control information label,
includes both federal and California
certification exhaust emission
standards
iWhen ordering parts, please specify
vehicle identification and engine num-
bers.

407 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
CL 500
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
CL 55 AMG The CL 55 AMG has two poly-V-belts (belt
one shown in purple/belt two shown in
black).1Idler pulley
2Automatic belt tensioner
3ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)
8Idler pulley
9Automatic belt tensioner
aSupercharger
CL 600 and CL 65 AMG
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
8Idler pulley
9Idler pulley

408 Technical dataEngineModel
CL 500 (215.375)
1
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
CL 55 AMG (215.374)
1
Engine
113
113
Mode of operation
4-stroke engine, gasoline injection
4-stroke engine, gasoline injection
No. of cylinders
8
8
Bore
3.82 in (97.00 mm)
3.82 in (97.00 mm)
Stroke
3.31 in (84.00 mm)
3.60 in (92.00 mm)
Total piston displacement
303.0 cu in (4966 cm
3)
331.8 cu in (5439 cm
3)
Compression ratio
10:1
9:1
Output acc. to SAE J 1349
302 hp/5600 rpm
2
(225 kW/5600 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
493 hp/6100 rpm
2
(368 kW/6100 rpm)
Maximum torque
acc. to SAE J 1349
339 lb-ft/2700 - 4250 rpm
(460 Nm/2700 - 4250 rpm)
516 lb-ft/2750–4000 rpm
(700 Nm/2750–4000 rpm)
Maximum engine speed
6000 rpm
6500 rpm
Firing order
1-5-4-2-6-3-7-8
1-5-4-2-6-3-7-8
Poly-V-belt
2380 mm
Belt one: 1289 mm
Belt two: 2462 mm

409 Technical data
Engine
Model
CL 600 (215.376)
1
CL 65 AMG (215.379)
1
Engine
275
275
Mode of operation
4-stroke engine, gasoline injection
4-stroke engine, gasoline injection
No. of cylinders
12
12
Bore
3.23 in (82.00 mm)
3.25 in (82.60 mm)
Stroke
3.43 in (87.00 mm)
3.66 in (93.00 mm)
Total piston displacement
336.4 cu in (5513 cm
3)
364.9 cu in (5980 cm
3)
Compression ratio
9:1
9:1
Output acc. to SAE J 1349
493 hp/5000 rpm
2
(368 kW/5000 rpm)
603 hp/4750 rpm
2
(450 kW/4750 rpm)
Maximum torque
acc. to SAE J 1349
590 lb-ft/1800–3500 rpm
(800 Nm/1800–3500 rpm)
738 lb-ft/2000 - 3000 rpm
(1000 Nm/2000 - 3000 rpm)
Maximum engine speed
5950 rpm
5950 rpm
Firing order
1-12-5-8-3-10-6-7-2-11-4-9
1-12-5-8-3-10-6-7-2-11-4-9
Poly-V-belt
2335 mm
2335 mm
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.2Premium fuel required. Performance may vary with fuel octane rating.

410 Technical dataRims and Tires
!
Only use tires which have been tested
and approved for your vehicle by
Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to pro-
vide best possible performance in con-
junction with the driving safety
systems on your vehicle such as ABS or
ESP
®. Tires specially developed for
your vehicle and tested and approved
by Mercedes-Benz can be identified by
finding the following on the tire’s side-
wall:


MO = M
ercedes-Benz O
riginal
equipment tires
AMG vehicles:
Does not apply to all approved tires
on AMG vehicles. For information
on tested and approved tires for
AMG vehicles, contact an autho-
rized Mercedes-Benz Center.
Using tires other than those approved
by Mercedes-Benz may result in dam-
age that is not covered by the
Mercedes-Benz Limited Warranty.!Using tires other than those approved
by Mercedes-Benz can have detrimen-
tal effects, such as

poor handling characteristics


increased noise


increased fuel consumption
Moreover, tires and rims not approved
by Mercedes-Benz may, under load,
exhibit dimensional variations and dif-
ferent tire deformation characteristics
that could cause them to come into
contact with the vehicle body or axle
parts. Damage to the tires or the vehi-
cle may be the result.
iFurther information on tires and rims is
available at any authorized
Mercedes-Benz Center. A placard with
the recommended tire inflation pres-
sures is located on the driver’s door
B-pillar (
page 286). Some vehicles
may have supplemental tire inflation
pressure information for driving at high
speeds (page 293) or for vehicle
loads less than the maximum loaded
vehicle condition (
page 299). If such
information is provided, it can be found
on the placard located on the inside of
the fuel filler flap. The tire inflation
pressure should be checked regularly
and should only be adjusted on cold
tires. Follow tire manufacturer’s main-
tenance recommendation included
with vehicle.

411 Technical data
Rims and Tires
iThe following pages also list the ap-
proved wheel rim and tire sizes for
equipping your vehicles with winter
tires. Winter tires are not available as
standard or optional factory equip-
ment, but can be purchased from an
authorized Mercedes-Benz Center.
Depending on vehicle model and the
standard or optional factory-equipped
wheel rim/tire configuration on your
vehicle (Appearance Package, Sport
Package etc.), equipping your vehicle
with winter tires approved for your ve-
hicle model may also require the pur-
chase of two or four wheel rims of the
recommended size for use with these
winter tires. See an authorized
Mercedes-Benz Center for more infor-
mation.

412 Technical dataRims and TiresSame size tires
CL 500 (without Sport Package*
[standard on U.S. vehicles] and
without Appearance Package*)
CL 600 (without Sport Package*
[standard on U.S. vehicles] and
without Appearance Package*)
CL 500, CL 600
(with Appearance Package*)
Rims (light alloy)
7.5 J x17 H2
8 J x18 H2
1
1For use with snow chains contact an authorized Mercedes-Benz Center.
8 J x18 H2
1
Wheel offset
1.81 in (46 mm)
1.73 in (44 mm)
1.73 in (44 mm)
Summer tires
2
2Radial-ply tires.
-
245/45 R18 96Y
1
245/45 R18 96Y
1
All-season tires
2
225/55 R17 97H M+S
-
-
Winter tires
2, 3
3For more information, see “Winter tires” (page 313).
225/55 R17 97H M+S.
245/45 R18 100V XL (Extra Load)
M+S.
1
or
245/45 R18 96H M+S.
1
245/45 R18 100V XL (Extra Load)
M+S.
1
or
245/45 R18 96H M+S.
1

413 Technical data
Rims and Tires
CL 500, CL 600 (with Appearance Package*)
CL 65 AMG
Rims (light alloy)
8 J x18 H2
1, 2
or
8.5J x18 EH2
3
1For use with winter tires only.2For use with snow chains contact an authorized Mercedes-Benz Center.3Must not be used with snow chains.
8.5 J x19 H2
1, 2
Wheel offset
1.73 in (44 mm)
1.73 in (44 mm)
Summer tires
4
4Radial-ply tires.
245/45 R18 100Y XL (Extra Load)
-
All-season tires
4
-
-
Winter tires
4, 5
5For more information, see “Winter tires” (page 313).
245/45 R18 100V XL (Extra Load) M+S.
2
or
245/45 R18 96H M+S.
2
245/40 R19 98V XL (Extra Load) M+S.
2

414 Technical dataRims and TiresMixed size tires
CL 500, CL 600
(with Sport Package*)
CL 55 AMG
CL 65 AMG
Front axle:
AMG light alloy rims
8.5 J x 18 EH2
2
8.5 J x 19 H2
2
8.5 J x 19 H2
2
Wheel offset
1.73 in (44 mm)
1.73 in (44 mm)
1.73 in (44 mm)
Summer tires
1
1Radial-ply tires.
245/45 R18 100Y XL (Extra
Load)
or
245/45 R18 96Y
245/40 ZR19 98Y XL (Extra
Load)
2
or
245/40 ZR19
2
245/40 ZR19 98Y XL (Extra
Load)
2
or
245/40 ZR19
2
Rear axle:
AMG light alloy rims
9 J x 18 EH2
2
9.5 J x 19 H2
2
9.5 J x 19 H2
2
Wheel offset
1.73 in (44 mm)
1.81 in (46 mm)
2.36 in (60 mm)
Summer tires
1
265/40 R18 101Y XL
(Extra Load)
2
or
265/40 R18 97Y
2
2Must not be used with snow chains.
275/35 ZR19 100Y XL
(Extra Load)
2
or
275/35 ZR19
2
275/35 ZR19 100Y XL
(Extra Load)
2
or
275/35 ZR19
2

415 Technical data
Rims and Tires
Spare wheel
CL 500 (without Sport Package*
[standard on U.S. vehicles] and
without Appearance Package*)
CL 600, CL 500 (with Sport Package*
[standard on U.S. vehicles] and with
Appearance Package*)
CL 55 AMG
CL 65 AMG
Rims (light alloy)
7.5Jx17H2
8Jx18H2
8Jx19 H2
Wheel offset
2.0 in (51 mm)
1.73 in (44 mm)
1.97 in (50 mm)
Summer tires
1
1Radial-ply tires.
-
245/45 ZR18 96Y
245/40 ZR19 98Y XL (Extra Load)
All-season tires
1
225/55 R17 97H M+S
-
-