check engine MERCEDES-BENZ CL600 2005 C215 Owner's Guide

348 Practical hintsWhat to do if …?Display
Possible cause
Possible solution
:
USA only:ADD 1.0 QT. OIL
AT FILLING STATIONCanada only:ADD 1.0 LITER OIL
AT FILLING STATION
The engine oil level is too low.

Add engine oil (
page 278) and check
the engine oil level (page 275).
ENGINE OIL LEVEL
STOP, ENGINE OFF
There is no oil in the engine.
There is a danger of engine damage.
Carefully bring the vehicle to a halt as
soon as possible.

Turn off the engine.

Add engine oil (
page 278) and check
the engine oil level (page 275).
ENGINE OIL LEVEL
REDUCE OIL LEVEL
You have added too much engine oil.
There is a risk of damaging the engine or
the catalytic converter.

Have excess oil siphoned or drained off.
Observe all legal requirements with re-
spect to its disposal.

349 Practical hints
What to do if …?
When the message
ADD 1.0 QT. OIL AT
FILLING STATION (Canada:
1 Liter
) ap-
pears while the engine is running and at
operating temperature, the engine oil level
has dropped to approximately the mini-
mum level.When this occurs, the warning will first
come on intermittently and then stay on if
the oil level drops further.
Visually check for oil leaks. If no obvious oil
leaks are noted, drive to the nearest ser-
vice station where the engine oil should be
topped to the required level with an ap-
proved oil specified in the Factory Ap-
proved Service Products pamphlet.
Display
Possible cause
Possible solution
:
ENGINE OIL
VISIT WORKSHOP
It may be that there is water in the engine
oil.

Have the engine oil level checked
(page 275).
ENGINE OIL LEVEL
VISIT WORKSHOP
The engine oil has dropped to a critical
level.

Check the engine oil level (
page 275)
and add engine oil as required
(
page 278).

If you must add engine oil frequently,
have the engine checked for possible
leaks.
OIL SENSOR MALFUNCT.
VISIT WORKSHOP
The measuring system is malfunctioning.

Have the measuring system checked by
an authorized Mercedes-Benz Center.
!The engine oil level warnings should
not be ignored. Extended driving with
the symbol displayed could result in
serious engine damage that is not
covered by the Mercedes-Benz Limited
Warranty.

350 Practical hintsWhat to do if …?Display
Possible cause
Possible solution
_
ENTRY POSITION
DO NOT DRIVE
Seat, exterior mirrors and steering wheel
have not yet moved to their preset driving
positions.

Wait until the seat, exterior mirrors and
steering wheel have moved to their driv-
ing positions.
The message will disappear.
Y

HOOD OPEN
You are driving with the hood open.

Close the hood (
page 274).
I
REMOVE KEY
You have forgotten to remove the
SmartKey.

Remove the SmartKey from the ignition.
REPLACE KEY
DRIVE TO WORKSHOP
The SmartKey is malfunctioning.

Visit an authorized Mercedes-Benz Cen-
ter as soon as possible.
AUTOMATIC LIGHT ON
REMOVE KEY
SmartKey in starter switch position 1
or2.

Remove the SmartKey from the starter
switch.
KEY
CHECK BATTERY
The battery in the SmartKey with KEY-
LESS-GO* is discharged.

Replace the battery (
page 371).
KEY
NOT RECOGNIZED
SmartKey with KEYLESS-GO* is not rec-
ognized while the engine is running be-
cause

the SmartKey is not in the vehicle


there is strong radio-frequency inter-
ference

Stop the vehicle as soon as it is safe to do
so.

Search for the SmartKey.
Otherwise the vehicle cannot be centrally
locked nor can the engine be started again
after it has been stopped.

386 Practical hintsBattery
The battery is located in the trunk under
the right hand wheel well cover panel.
1Battery cover
2Locking knob
Rotate and loosen locking button2
approx. one-half turn.

Remove battery cover1.
Warning!
G
Failure to follow these instructions can re-
sult in severe injury or death.
Never lean over batteries while connecting,
you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.Warning!
G
Do not place metal objects on the battery as
this could result in a short circuit.
Use leak-proof battery only to avoid the risk
of acid burns in the event of an accident.
!Never loosen or detach battery termi-
nal clamps while the engine is running
or the SmartKey is in the starter switch.
Otherwise the alternator and other
electronic components could be se-
verely damaged.
Have the battery checked regularly by
an authorized Mercedes-Benz Center.
Refer to Maintenance Booklet for main-
tenance intervals or contact your au-
thorized Mercedes-Benz Center for
further information.Warning!
G
With a disconnected battery

you will no longer be able to turn the
SmartKey in the starter switch and
pressing the KEYLESS-GO* start/stop
button (
page 35) on the gear selector
lever will have no effect


the gear selector lever will remain
locked in positionP

389 Practical hints
Jump starting
Jump starting
If the battery is discharged, the engine can
be started with jumper cables and the bat-
tery of another vehicle. Observe the follow-
ing:

Jump starting should only be performed
when the engine and catalytic convert-
er are cold.


Do not start the engine if the battery is
frozen. Let the battery thaw out first.


Only use 12 volt battery to jump start
your vehicle. Jump starting with a more
powerful battery could damage the ve-
hicle’s electrical system, which will not
be covered by the Mercedes-Benz Lim-
ited Warranty.


Only use jumper cables with sufficient
cross-section and insulated terminal
clamps.


Always make sure that the jumper ca-
bles are not on or near pulleys, fans or
other parts that move when an engine
is started or running.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
Attempting to jump start a frozen battery
can result in it exploding, causing personal
injury.
Read all instructions before proceeding.
!Avoid repeated and lengthy starting at-
tempts.
Do not attempt to start the engine us-
ing a battery quick charge unit.
If engine does not run after several un-
successful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter and
may present a fire risk.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.!Do not tow-start the vehicle.

390 Practical hintsJump startingThe battery is located on the right side of
the trunk under the battery cover
(page 386).

Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the trunk lid.

Remove battery cover.

Remove red cover from positive
terminal 1. 1Positive terminal of discharged battery
2Negative terminal of discharged bat-
tery
3Positive terminal of charged battery
4Negative terminal of charged battery

Connect positive terminals 1 and3
of the batteries with the jumper cable.
Clamp cable to charged battery3
first.

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminals2 and4
of the batteries with the jumper cable.
Clamp cable to charged battery4
first.

Start the engine of the disabled vehi-
cle.
Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
negative terminals2 and4 and then
from positive terminals1 and3.
You can now turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 281).
!Never invert the terminal connections.

416 Technical dataFuels, coolants, lubricants, etc.Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze [equivalent to freeze
protection to approx. –22°F (–30°C)]. If
you use a solution that is more than 55%
anticorrosion/antifreeze [freeze protec-
tion to approx. –49°F (–45°C)], the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure the mixture is
in accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult an authorized Mercedes-Benz Center.Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorrosion/
antifreeze coolant will result in a signifi-
cantly shortened service life.)
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze Agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to an authorized Mercedes-Benz
Center for service.

427 Index
AUDIO menu 141
Selecting CD track 143
Selecting MP3-CD track 143
Selecting radio station 142
Selecting satellite radio* station 142
Audio system
CD mode 144
Auto-dimming for rear view mirror 178
Automatic central locking
Activating/deactivating (control
system) 161
Automatic climate control 184
Air recirculation mode 190
Defrosting 190
Rear window defroster 193
Setting the temperature 187
Automatic headlamp mode 126
Automatic lighting control
Activating 130
Deactivating 131
Automatic locking when driving 110
Automatic shift program
Automatic transmission 171Automatic transmission 165
Accelerator position 172
Automatic shift program 171
Emergency operation (Limp Home
Mode) 177
Fluid level 279
Gear ranges 168
Gear selector lever position 165, 169
Gear shifting malfunctions 177
Kickdown 172
Kickdown, manual shift program CL 55
AMG and CL 65 AMG 176
Manual shift program CL 55 AMG and
CL 65 AMG 175
Manual shifting 167
One-touch gearshifting 167
Starting the engine 48
Steering wheel gearshift control CL 55
AMG and CL 65 AMG 173
Transmission fluid 279
Auxiliary fuse box 395B
BabySmartTM
Air bag deactivation system 74
Compatible child seats 74, 419
Self-test 74
BabySmartTM air bag deactivation
system 419
Backrest supports
Lumbar region 118
Shoulder region 117
Backup lamps 374, 378
Bulbs 374
Bar 309
BAS 81, 419
Messages in display 339
Batteries, SmartKey
Check lamp 93
Replacing 371
Battery discharged
Jump starting 389
Battery, SmartKey
Checking the batteries 93

429 Index
Central locking
Automatic 110
From inside 111
Switch 111
Switching on/off (control
system) 161
Unlocking from inside 111
Central locking switch 111
Change of address or ownership 12
Changing
Key setting 162
Vehicle level 222
Changing CDs 144
Charcoal filter 192
Activating 192
Deactivating 192
Charging
Vehicle battery 387
CHECK ENGINE malfunction indicator
lamp 328, 329Checking
Coolant level 279
Oil level 272, 274
Oil level via control system 275
Tire inflate pressure 272
Vehicle lighting 272
Checking the batteries
SmartKey 93
Child safety 72
Air bags 64
Infant and child restraint systems 68,
72
LATCH child seat mounts 77
Child safety switch see Blocking of rear
window operation 78
Cigarette lighter 239Cleaning
Cup holder 322
Distronic* system sensor cover 320
Gear selector lever 322
Hard plastic trim items 322
Headlamps 178
Headliner and shelf below rear
window 322
Instrument cluster 322
Leather upholstery 323
Light alloy wheels 322
Nubuck leather upholstery 323
Parktronic* system sensor 320
Plastic and rubber parts 323
Seat belts 322
Steering wheel 322
Upholstery 323
Windows 321
Windshield 55
Wiper blades 320
Wood trims 323
Cleaning tires 285

434 IndexEngine cleaning 319
Engine compartment 273
Fuse box in 396
Hood 273
Engine malfunction indicator lamp 25,
328, 329
Engine number 400, 421
Engine oil 274
Adding 278
Additives 413
Checking level 274
Consumption 274
Display messages 348
Filler neck 278, 279
Messages in display 276, 348
Viscosity 421
Engine oil level see Oil level 272
Entry position
Messages in display 350
ESP 82, 421
Switching off 83
Switching on 84
Synchronizing 340
Warning lamp 330, 331ETD 421
Safety guidelines 66
ETD (Emergency tensioning device) 71
Exterior lamp switch 125
Exterior rear view mirror
Auto-dimming on the driver’s
side 178
Exterior rear view mirrors
Adjusting 43
Folding electrically 180
Parking position for 164
F
Fahrenheit (°F)
Setting temperature units 156
Fastening the seat belts 45
Fine adjustment
Cruise control 207
Distronic* 214First aid kit 365
Flat tire 381
Lowering the vehicle 384
Mounting the Spare wheel 381
Preparing the vehicle 381
Flexible Service System (FSS) 315
Flexible Service System see FSS
Fog lamp, rear 128, 374
Replacing bulb 378
Fog lamps
Replacing bulbs 374
Fog lamps, front
Messages in display 352
Switching on 128
Folding electrically
Exterior rear view mirrors
180
Front air bags 67