power steering MERCEDES-BENZ CL600 2006 C215 User Guide

259 Operation
Driving instructions
Driving instructions
Drive sensibly – save fuel
Fuel consumption, to a great extent, de-
pends on driving habits and operating con-
ditions.
To save fuel you should:

Keep tires at the recommended tire
inflation pressures.


Remove unnecessary loads.


Remove roof rack when not in use.


Allow engine to warm up under low
load use.


Avoid frequent acceleration and decel-
eration.


Have all maintenance work performed
at the intervals specified in the
Maintenance Booklet and as required
by the Maintenance System
(U.S. vehicles) or FSS (Canada vehi-
cles). Contact an authorized
Mercedes-Benz Center.Fuel consumption is also increased by driv-
ing in cold weather, in stop-and-go traffic,
on short trips, and in hilly area.
Drinking and driving
PedalsPower assistance
Warning!
G
Drinking and driving and/or taking drugs
and driving are very dangerous combina-
tions. Even a small amount of alcohol or
drugs can affect your reflexes, perceptions
and judgment.
The possibility of a serious or even fatal ac-
cident are greatly increased when you drink
or take drugs and drive.
Do not drink or take drugs and drive or allow
anyone to drive who has been drinking or
taking drugs.
Warning!
G
Keep driver’s foot area clear at all times. Ob-
jects stored in this area may impair pedal
movement.Warning!
G
With the engine not running, there is no
power assistance for the brake and steering
systems. In this case, it is important to keep
in mind that a considerably higher degree of
effort is necessary to brake and steer the ve-
hicle.

309 Operation
Tires and wheels
Tire and loading terminology
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
automatic transmission, power steering,
power brakes, power windows, power
seats, radio, and heater, to the extent that
these items are available as
factory-installed equipment (whether
installed or not).
Air pressure
The amount of air inside the tire pressing
outward on each square inch of the tire.
Air pressure is expressed in pounds per
square inch (psi), or kilopascal (kPa) or
bars.
Aspect ratio
Dimensional relationship between tire
section height and section width
expressed in percentage.Bar
Another metric unit for air pressure. There
are 14.5038 pounds per square inch (psi)
to 1 bar; there are 100 kilopascals (kPa)
to 1 bar.
Bead
The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the
rim.
Cold tire inflation pressure
Tire inflation pressure when your vehicle
has been sitting for at least 3 hours or driv-
en no more than 1 mile (1.6 km).
Curb weight
The weight of a motor vehicle with stan-
dard equipment including the maximum
capacity of fuel, oil, and coolant, and, if so
equipped, air conditioning and additional
optional equipment, but without passen-
gers and cargo.DOT (D
epartment o
f T
ransportation)
A tire branding symbol which denotes the
tire meets requirements of the
U.S. Department of Transportation.
GAWR (G
ross A
xle W
eight R
ating)
The GAWR is the maximum permissible
axle weight. The gross vehicle weight on
each axle must never exceed the GAWR for
the front and rear axle indicated on the
Certification label located on the driver’s
door B-pillar.
GVW (G
ross V
ehicle W
eight)
The GVW comprises the weight of the
vehicle including fuel, tools, spare wheel,
installed accessories, passengers and
cargo and, if applicable, trailer tongue
load. The GWV must never exceed the
GWVR indicated on the Certification label
located on the driver’s door B-pillar.

343 Practical hints
What to do if …?
Display
Possible cause/consequence
Possible solution
ESP
UNAVAILABLE
SEE OPERATORS
MANUAL
The ESP
® was deactivated because the
power supply has been interrupted.
The ABS is still operational.

Synchronize the ESP
®. With the vehicle sta-
tionary and the engine running, turn the
steering wheel completely to the left and
then to the right to synchronize the ESP
®.
If the ESP
® message does not go out:

Continue driving with added caution.

Have the system checked at an authorized
Mercedes-Benz Center as soon as possible.
Failure to follow these instructions increases the
risk of an accident.
!When synchronizing the ESP
®, make
sure you can turn the steering wheel in
both directions as far as it will go with-
out the wheel hitting any objects, e.g.
aroad curb.

397 Practical hints
Towing the vehicle
!
To be certain to avoid a possibility of
damage to the drivetrain, however, we
recommend the drive shaft be discon-
nected at the rear axle drive flange for
any towing beyond a short tow to a
nearby garage. Warning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the power sup-
ply or in the vehicle’s electrical system
as that will be necessary to adequately con-
trol the towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the SmartKey
is in starter switch position2.
If the SmartKey is left in starter switch posi-
tion 0 for an extended period of time, it can
no longer be turned in the switch. In this
case, the steering is locked. To unlock, re-
move SmartKey from starter switch and re-
insert.Warning!
G
With the engine not running, there is no
power assistance for the brake and steering
systems. In this case, it is important to keep
in mind that a considerably higher degree of
effort is necessary to brake and steer the ve-
hicle. Adapt your driving accordingly.iThe gear selector lever will remain
locked in positionP and the SmartKey
will not turn in the starter switch if the
battery is disconnected or discharged.
See information on the battery
(page 391) or on jump starting
(page 394).
iTo signal turns while being towed with
the hazard warning flasher in use, turn
SmartKey in starter switch to
position2 and activate the combina-
tion switch for the left or right turn sig-
nal in the usual manner – only the
selected turn signal will operate.
Upon canceling the turn signal, the haz-
ard warning flasher will operate again.

407 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
CL 500
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
CL 55 AMG The CL 55 AMG has two poly-V-belts (belt
one shown in purple/belt two shown in
black).1Idler pulley
2Automatic belt tensioner
3ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)
8Idler pulley
9Automatic belt tensioner
aSupercharger
CL 600 and CL 65 AMG
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
8Idler pulley
9Idler pulley

418 Technical dataFuels, coolants, lubricants, etc.CapacitiesVehicle components and their respective
lubricants must match. Therefore use only
products tested and approved by
Mercedes-Benz.Please refer to the Factory Approved
Service Products pamphlet, or inquire at
your Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
CL 500
CL 55 AMG
CL 600
CL 65 AMG
8.5 US qt (8.0 l)
8.0 US qt (7.5 l)
9.5 US qt (9.0 l)
11.0 US qt (10.5 l)
Approved engine oils
Automatic transmission
CL 500
CL 55 AMG
CL 600
CL 65 AMG
9.1 US qt (8.6 l)
9.1 US qt (8.6 l)
8.2 US qt (7.7 l)
8.2 US qt (7.7 l)
MB Automatic Transmission Fluid
Rear axle
CL 500
CL 55 AMG
CL 600
CL 65 AMG
1.7 US qt (1.6 l)
2.1 US qt (2.0 l)
2.1 US qt (2.0 l)
2.1 US qt (2.0 l)
Hypoid gear oil SAE 85 W 90
Hydraulic system for ABC
approx. 4.2 US qt (4.0 l)
MB Hydraulic Fluid
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid
(Pentosin CHF 11S)
Front wheel hubs
approx. 3.5 oz (100 g) each
High temperature roller bearing grease
Brake system
0.7 US qt (0.7 l)
MB Brake Fluid (DOT 4+)

428 Technical termsCAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.
Cold tire inflation pressure
(
page 309)
COMAND
(Cockpit M
anagement and D
ata
System)
Information and operating center for
vehicle sound and communications
systems, including the radio and navi-
gation system, as well as other optional
equipment (CD changer, telephone,
etc.).Control system
The control system is used to call up
vehicle information and to change
component settings. Information and
messages appear in the multifunction
display. The driver uses the buttons on
the multifunction steering wheel to
navigate through the system and to ad-
just settings.
Cruise control
Driving convenience system that auto-
matically maintains the vehicle speed
set by the driver.
Curb weight
(
page 309)
Distronic*
A driving convenience cruise control
system which helps the driver maintain
a pre-selected speed:


If there is no vehicle directly ahead,
the system operates in the same
way as conventional ->cruise con-
trol.


If a slower moving vehicle is ahead,
Distronic will reduce your vehicle
speed to the extent permitted by re-
duced throttle and up to 20% brak-
ing power to maintain the preset
minimum following distance.
DOT
(Department o
f Transportation)
(
page 309)
Engine number
The number set by the manufacturer
and placed on the cylinder block to
uniquely identify each engine pro-
duced.
Engine oil viscosity
Measurement for the inner friction (vis-
cosity) of the oil at different tempera-
tures. The higher the temperature an
oil can tolerate without becoming thin,
or the lower the temperature it can tol-
erate without becoming viscous, the
better the viscosity.

434 IndexAutomatic locking when driving 110
Automatic transmission 48, 165
Accelerator position 169
Driving tips 169
Emergency operation (Limp Home
Mode) 177
Gear ranges 170
Gear selector lever position 48, 165,
167
Gear shifting malfunctions 177
Kickdown 169
Kickdown, manual shift program
CL 55 AMG and CL 65 AMG 177
Manual (One-touch) gearshifting 172
Manual shift program CL 55 AMG and
CL 65 AMG 175
Shift program mode selector
switch 171
Starting the engine 48
Steering wheel gearshift control
CL 55 AMG and CL 65 AMG 173
Transmission fluid level 279
Warning sounds (vehicles with
KEYLESS-GO*) 59B
BabySmart
TM
Air bag deactivation system 74
Compatible child seats 427
Self-test 74
Backrest
Power seats 37
Power seats, Multicontour* 117
Backrest supports
Shoulder region (Multicontour
seats*) 117
Backup lamps
Replacing bulbs 379, 383
Bar 309
BAS 81, 427
Batteries, SmartKey
Checking battery condition 93
Replacing 376
Battery, SmartKey with KEYLESS-GO*
Checking battery condition 99
Replacing 377
Battery, Vehicle 281, 391
Charging 392
Disconnecting 392
Jump starting 394
Message in display 345Reconnecting 393
Reinstalling 392
Removing 392
Bead 309
Beverage holder see Cup holder
Bi-Xenon headlamps see Headlamps
Block heater (Canada only) 314
Brake Assist System see BAS
Brake fluid 420
Brake warning lamp 329
Checking 271
Message in display 346
Brake lamp
High mounted 379
Messages in display 354
Replacing bulbs 379
Brake pads
Message in display 346
Brakes 260
High-performance brake system
(CL 65 AMG only) 261
Warning lamp 329
Break-in the vehicle 258
Bulbs, replacing
Side marker lamps, front 382
Bulbs, replacing see Replacing bulbs

438 IndexEngine oil 274, 420
Adding 278
Additives 420
Changing 278, 420
Checking level 274
Consumption 274
Filler neck 278, 279
Messages in display 275, 276, 351
Recommended engine oils and oil
filter 420
Viscosity 428
ESP
®
82, 429
Messages in display 342
Warning lamp 332, 333
ETD 71, 429
Safety guidelines 66
Exterior rear view mirrors 43
Auto-dimming on the driver’s
side 178
Parking position 124, 180
Parking position for 164
Power folding 180
Storing parking position 124F
Filler neck, Engine oil 278, 279
First aid kit 369
Flat tire 386
Jacking up the vehicle 387
Lowering the vehicle 390
Mounting the spare wheel 386
Preparing the vehicle 386
Flexible Service System see FSS
Fluids
ABC fluid 279
Automatic transmission 279, 418
Brake fluid 272, 418, 420
Capacities 418
Engine coolant 280, 419, 422
Engine oil 418, 420
Hydraulic system for ABC 418
Power steering fluid 418
Windshield washer system and head-
lamp cleaning system 282, 419,
425
Fog lamps 128, 379
Messages in display 355, 357
Replacing bulbs 379, 383Front air bags 67
Front lamps see Headlamps
Front passenger front air bag 63, 67
Front passenger front air bag off indicator
lamp 74, 336
Front seat head restraints see Head re-
straints
FSS (Canada vehicles) 315, 429
Fuel 271, 419, 421
Additives 422
Capacities, Fuel tank 419
Consumption statistics after
start 151
Consumption statistics since last
reset 152
Filling the tank 270
Fuel filler flap and cap 270, 374
Fuel gauge 25, 331
Fuel reserve warning lamp 25, 331
Requirements, Octane rating 271,
419, 421
Technical data 419, 421
Fuel cap
Engine malfunction indicator
lamp 331
Message in display 360

444 Index
Hood 353
Instrument cluster 350
Lamp sensor 356
Lamps 354
License plate lamp 355
Low beam headlamps 356
Maintenance service indicator 315
Parking brake 345
Parking lamps 357
Power tilt/sliding sunroof 359
Reverse lamps 357
Seat belts 359
Selector lever 344
Side marker lamps 356
SmartKey 353
SmartKey with KEYLESS-GO* 353
Tail lamps 357
Tele Aid 359
Telephone* 360
Tires 361
Trunk 360
Turn signal lamps 358
Washer fluid 360
Multifunction steering wheel 138, 430
Button operation 138N
Navigation system
See separate COMAND operating in-
structions
Net, parcel 234
Neutral gear position, Automatic
transmission 48, 165, 167
New vehicle break-in 258
Night security illumination 160
Normal occupant weight 310
Number, vehicle identification (VIN) 406O
Occupant distribution 310
Occupant safety 62
Air bags 63
Children and air bags 64
Children in the vehicle 72
Fastening the seat belt 45
Front passenger front air bag off indica-
tor lamp 74
Infant and child restraint systems 72
LATCH-type child seat anchors 77
Seat belts 45, 66
Odometer 135
Oil see Engine oil
One-touch gearshifting 172
Operating safety 16
Ornamental moldings, cleaning 321
Outside temperature indicator 25, 136
Overdue maintenance service 316
Overhead control panel 29
Overspeed range, Engine 430