engine oil MERCEDES-BENZ CLK-CLASS 2000 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2000, Model line: CLK-CLASS, Model: MERCEDES-BENZ CLK-CLASS 2000Pages: 299, PDF Size: 7.58 MB
Page 273 of 299
Cleaning and care of the vehicle
Te ch n ica l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar careIndex Scratches, corrosive deposits, corrosion or damage due
to negligent or incorrect care cannot always be removed
or repaired with the car-care products recommended
here. In such cases it is best to seek aid at your
authorized Mercedes-Benz Center.
The following topics deal with the cleaning and care of
your vehicle and give important “how-to” information as
well as references to Mercedes-Benz approved car-care
products.
Additional information can be found in the booklet titled
“Vehicle Care Guide”.
Engine cleaning
Prior to cleaning the engine compartment make sure to
protect electrical components and connectors from the
intrusion of water and cleaning agents.
Corrosion protection, such as MB Anticorrosion Wax
should be applied to the engine compartment after
every engine cleaning. Before applying, all control
linkage bushings and joints should be lubricated. The
poly-V-belt and all pulleys should be protected from any
wax.Vehicle washing
Do not use hot water or wash your vehicle in direct
sunlight. Use only a mild car wash detergent, such as
Mercedes-Benz approved Car Shampoo.
Thoroughly spray the vehicle with a diffused jet of
water. Direct only a very weak spray towards the
ventilation intake. Use plenty of water and rinse the
sponge and chamois frequently.
Rinse with clear water and thoroughly wipe dry with a
chamois. Do not allow cleaning agents to dry on the
finish.
In the winter, thoroughly remove all traces of road salt
as soon as possible.
When washing the underbody, do not forget to clean the
inner sides of the wheels.
Plastic and rubber parts
Do not use oil or wax on these parts.
273
ProCarManuals.com
Page 277 of 299
Technical data
Spare parts service 278
Warranty coverage 278
Identification labels 279
Layout of poly-V-belt drive 280
Technical data 281
Fuels, coolants, lubricants etc. – capacities 284
Engine oils additives 285
Engine oil 285
Air conditioner refrigerant 285
Brake fluid 285
Premium unleaded gasoline 286
Fuel requirements 286
Gasoline additives 287
Coolants 287
Consumer information 289
Uniform tire quality grading 289
Index291
277
ProCarManuals.com
Page 284 of 299
Fuels, coolants, lubricants etc. - capacities
Te ch n ica l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Fuels, coolants, lubricants etc. – capacities
Vehicle components and their respective lubricants must match. Therefore use only brands tested and recommended
by us. Please refer to the Factory Approved Service Products pamphlet, or inquire at your Mercedes-Benz Center.
Capacity Fuels, coolants, lubricants etc.
Engine with oil filter 8.5 US qt (8.0 l) Recommended engine oils
Automatic transmission9.6US qt (9.1l) Automatic transmission fluid
Rear axle 1.4 US qt (1.3 l) Hypoid gear oil SAE 90, 85 W 90
Power steering
Accelerator control linkage Hydraulic fluidapprox. 1.1 US qt (1.0 l) MB Power steering fluid
Front wheel hubs approx. 2.1 oz (60 g) each High temperature roller bearing grease
Brake system approx. 0.5 US qt (0.5 l) MB Brake fluid (DOT 4)
Windshield/headlamp
washer systemapprox. 7.4 US qt (7.0 l) MB Windshield washer concentrate “S” 1
Cooling system approx. 11.7 US qt (11.1 l) MB Anticorrosion/antifreeze
Fuel tank including
a reserve ofapprox. 16.4 US gal (62.0 l)
approx. 2.1 US gal (8.0 l)Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96 RON/86 MON)
Air conditioner system R-134a refrigerant and special PAC lubricant (Never R-12)1 Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing. Follow suggested mixing ratios, see
Windshield/headlamp washer system on page238.
284
ProCarManuals.com
Page 285 of 299
Fuels, coolants, lubricants etc.
Te ch n ica l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index Engine oil additives
Do not blend oil additives with engine oil. They may be
harmful to the engine operation.
Damage or malfunctions resulting from blending oil
additives are not covered by the Mercedes-Benz Limited
War ra nt y.
Engine oils
Engine oils are specifically tested for their suitability in
our engines. Therefore, use only engine oils
recommended by Mercedes-Benz. Information on
recommended brands is available at your authorized
Mercedes-Benz Center.
Please follow Service Booklet recommendations for
scheduled oil changes. Failure to do so could result in
engine damage not covered by the Mercedes-Benz
Limited Warranty.Air conditioner refrigerant
R-134a (HFC) refrigerant and special PAG lubricating oil
is used in the air conditioner system.
Never use R-12 (CFC) or mineral-based lubricating oil,
otherwise damage to the system will occur.
Brake fluid
During vehicle operation, the boiling point of the brake
fluid is continuously reduced through the absorption of
moisture from the atmosphere. Under extremely hard
operating conditions, this moisture content can lead to
the formation of bubbles in the system thus reducing
the system’s efficiency.
The brake fluid must therefore be replaced every two
years, preferably in the spring.
It is recommended to use only brake fluid approved by
Mercedes-Benz. Your authorized Mercedes-Benz Center
will provide you with additional information.
285
ProCarManuals.com
Page 286 of 299
Fuels, coolants, lubricants etc.
Te ch n ica l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Premium unleaded gasoline
Caution!
To maintain the engine’s durability and performance,
premium unleaded gasoline must be used. If premium
unleaded is not available and low octane fuel is used,
follow these precautions:
•have the fuel tank filled only partially with unleaded
regular and fill up with premium unleaded as soon
as possible,
•avoid full throttle driving and abrupt acceleration,
•do not exceed an engine speed of 3000 rpm, if the
vehicle is loaded with a light load such as two
persons and no luggage,
•do not exceed 2/3 of maximum accelerator pedal
position, if the vehicle is fully loaded or operating in
mountainous terrain.Fuel requirements
Use only Premium unleaded meeting ASTM
standard D 439:
The octane number (posted at the pump) must be
91 min. It is an average of both the Research (R) octane
number and the Motor (M) octane number: (R+M)/2).
This is also known as ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates such as
Ethanol, IPA, IBA and TBA can be used provided the
ratio of any one of these oxygenates to gasoline does not
exceed 10%, MTBE not to exceed 15%.
The ratio of Methanol to gasoline must not exceed 3%
plus additional cosolvents.
Using mixtures of Ethanol and Methanol is not allowed.
Gasohol, which contains 10% Ethanol and 90% unleaded
gasoline, can be used.
These blends must also meet all other fuel requirements
such as resistance to spark knock, boiling range, vapor
pressure etc..
286
ProCarManuals.com
Page 287 of 299
Fuels, coolants, lubricants etc.
Te ch n ica l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index Gasoline additives
A major concern among engine manufacturers is carbon
build up caused by gasoline. Mercedes-Benz
recommends the use of only quality gasoline containing
additives that prevent the build up of carbon deposits.
After an extended period of using fuels without such
additives, carbon deposits can build up especially on the
intake valves and in the combustion area, leading to
engine performance problems such as:
•warm-up hesitation,
•unstable idle,
•knocking/pinging,
•misfire,
•power loss.
Do not blend other specific fuel additives with fuel.
They only result in unnecessary cost, and may be
harmful to the engine operation.
Damage or malfunctions resulting from poor fuel
quality or from blending specific fuel additives are not
covered by the Mercedes-Benz Limited Warranty.Coolants
The engine coolant is a mixture of water and
anticorrosion/antifreeze, which provides:
•corrosion protection,
•freeze protection,
•boiling protection (by increasing the boiling point).
The cooling system was filled at the factory with a
coolant providing freeze protection to approximately
-22°F (-30°C) and corrosion protection.
If the antifreeze mixture is effective to -22°F (-30°C), the
boiling point of the coolant in the pressurized cooling
system is reached at approximately 266°F (130°C).
The coolant solution must be used year round to provide
the necessary corrosion protection and increase in the
boil-over protection. You should have it replaced every
3years.
To provide the important corrosion protection, the
solution must be at least 45% anticorrosion/antifreeze
(equals a freeze protection to approx. - 22°F [-30°C]). If
you use a solution that is more than 55% anticorrosion/
antifreeze (freeze protection to approx. - 49°F [-45°C]),
287
ProCarManuals.com
Page 293 of 299
Checking engine oil level
Via engine oil level indicator.................................. 108Via oil dipstick ....................................................... 234
Cleaning and care of the vehicle ................................ 272COMAND, radio, telephone and two-way radio........... 162Combination switch ....................................................113Consumer information ............................................... 289Control and operation of radio transmitters ............... 162COOLANT (coolant level) - malfunction and
warning messages ..................................................219
COOLANT (coolant temperature) -
malfunction and warning messages ....................... 220
Coolant level
Adding...................................................................237Checking ............................................................... 236
Coolant temperature gauge.......................................... 82Coolants ....................................................................287
Anticorrosion/antifreeze quantity..........................287
Cruise control ............................................................193Cup holder
Center console, front..............................................149Rear bench armrest................................................149
DDeep water
Driving instructions ............................................... 191
DISPLAY DEFECTIVE (engine control unit) -
malfunction and warning messages ....................... 214
DISPLAY DEFECTIVE (several systems) -
malfunction and warning messages ....................... 214
Display illumination ..................................................... 81Doors............................................................................33Drinking and driving.................................................. 185Drive sensibly - save fuel ............................................ 184Driving instructions ................................................... 184
Brakes.................................................................... 185Pedals .................................................................... 185
Driving off.................................................................. 186EELEC. STABIL PROGR. -
malfunction and warning messages ....................... 226
Electronic main key ......................................................24
Changing batteries ................................................ 264Synchronizing remote control ................................ 266
293
ProCarManuals.com
Page 294 of 299
Electronic stability program (ESP)
Malfunction indicator lamp .................................... 211Warning lamp ......................................................... 211
Emergency tensioning retractor (ETR) .........................63Emergency unlocking in case of accident .....................37Emission control ........................................................ .165Engine compartment .................................................. 233ENGINE FAN - malfunction and
warning messages ..................................................218
Engine oil additives .....................................................285Engine oil consumption .............................................. .109Engine oil level
Checking .........................................................108, 234
ENGINE OIL LEVEL -
malfunction and warning messages ........................224
ENGINE OIL LEVEL NOT WHEN ENGINE ON
(measuring) - multifunction indicator ....................109
ENGINE OIL TEMP -
malfunction and warning messages ........................224
Engine oils ..................................................................285
Capacities..............................................................284
Enlarged cargo area ....................................................152
ESP (Electronic stability program).............................. 200
Control switch ....................................................... 201Synchronizing ....................................................... 201
Exterior lamp switch ................................................... 110Exterior lamps
Adjusting headlamp aim ........................................ 261Low and high beam ............................................... 258Parking lamps ....................................................... 258Replacing bulbs ..................................................... 256Side marker lamp, front ......................................... 260Standing lamps ..................................................... 258Taillamp assemblies............................................... 259Turn signal lamp.................................................... 258
FFirst aid kit ............................................................... 228Flexible service system (FSS) ..................................... 105Fuel filler flap
Manual release ...................................................... 268
Fuel requirements ...................................................... 286Fuels, coolants, lubricants etc. - Capacities ................ 284Fuses, electrical ......................................................... 231
294
ProCarManuals.com
Page 296 of 299
M
O
Maintenance .............................................................. 163Malfunction and indicator lamps in the
instrument cluster ................................................. 208
Malfunction and warning messages ............................ 213Malfunction message memory ................................... 100Manual operation of sliding/pop-up roof .................... 267Multicontour seat.........................................................52Multifunction display..................................................84
Engine oil level indicator .........................................88ESS (Flexible service system) ...................................88Setting the audio volume...................................... 104Trip and mainodometer...........................................88
Multifunction steering wheel........................................84NNavigation system - Multifunction display ....................97
On-board diagnostic system........................................ 208Operator's Manual.......................................................... 8Outside temperature indicator ..................................... .82Overhead control panel ................................................ .21PPanic button ................................................................. 32Parcel net in front passenger footwell ........................ 155Parking ...................................................................... 187Parking brake............................................................. 184PARKING BRAKE - malfunction and
warning messages ................................................ 218
Power assistance ........................................................ 185Power seats, front......................................................... 44
Backrest................................................................... 51
Power windows........................................................... 141
Express opening and closing ................................. 142Synchronizing........................................................ 142
Problems with your vehicle ......................................... 14Product information
.................................................... 7
296
ProCarManuals.com