fuel MERCEDES-BENZ CLK350 2007 A209 Workshop Manual

474 Technical data
Fuels, coolants, lubricants, etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory Ap-
proved Service Products pamphlet, or
contact an authorized Mercedes-Benz
Center.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.
Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air
conditioning system.
Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the
system will occur.
!Using engine oils and oil filters of specifica-
tion other than those expressly required for the
Maintenance System (U.S. vehicles. Canada ve-
hicles, depending on vehicle production date) or
FSS (Canada vehicles, depending on vehicle pro-
duction date), or changing of oil and oil filter at
change intervals longer than those called for by
the Maintenance System (U.S. vehicles. Canada
vehicles, depending on vehicle production date)
or FSS (Canada vehicles, depending on vehicle
production date) will result in engine or emission
control system damage not covered by the
Mercedes-Benz Limited Warranty. Please follow Maintenance System
(U.S. vehicles. Canada vehicles, depending on
vehicle production date) or FSS (Canada vehi-
cles, depending on vehicle production date)
recommendations for scheduled oil changes.
Failure to do so will result in engine or emission
control system damage not covered by the
Mercedes-Benz Limited Warranty.

475 Technical data
Fuels, coolants, lubricants, etc.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere.
Only brake fluid approved by
Mercedes-Benz is recommended. An
authorized Mercedes-Benz Center will
provide you with additional information.Premium unleaded gasoline
Warning!G
Under extremely strenuous operating condi-
tions, this moisture content can lead to the
formation of bubbles in the system, thus re-
ducing the system’s efficiency.
Therefore, the brake fluid must be replaced
regularly. Refer to your vehicle's Mainte-
nance Booklet for replacement interval.
Warning!G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious per-
sonal injury.
Never allow sparks, flame or smoking mate-
rials near gasoline!
Turn off the engine before refueling
Whenever you are around gasoline, avoid in-
haling fumes and skin or clothing contact,
extinguish all smoking materials.
Direct skin contact with fuels and the inha-
lation of fuel vapors can be damaging to
your health.
!To maintain the engine’s durability and per-
formance, premium unleaded gasoline must be
used. If premium unleaded is not available and
low octane fuel is used, follow these precau-
tions:

Have the fuel tank only partially filled with
unleaded regular and fill up with premium
unleaded as soon as possible.

Avoid full throttle driving and abrupt acceler-
ation.

Do not exceed an engine speed of 3 000 rpm
if the vehicle is loaded with a light load such
as two persons and no luggage.

Do not exceed 2/3 of maximum accelerator
pedal position if the vehicle is fully loaded or
operating in mountainous terrain.

476 Technical data
Fuels, coolants, lubricants, etc.
Fuel requirements
Only use premium unleaded fuel:

The octane number (posted at the
pump) must be 91 min. It is an average
of both the Research (R) octane num-
ber and the Motor (M) octane number:
(R+M) / 2). This is also known as the
ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not exceed
10%; MTBE not to exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional cosolvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains 10%
ethanol and 90% unleaded gasoline, can be
used.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build-up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to en-
gine performance problems such as:

Warm-up hesitation

Unstable idle

Knocking/pinging

Misfire

Power loss
In areas where carbon deposits may be en-
countered due to lack of availability of gas-
olines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on Mercedes-Benz vehicles. Refer to Factory
Approved Service Products pamphlet for a
listing of approved product(s). Follow di-
rections on product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary cost and
may be harmful to the engine operation.
Damage or malfunction resulting from
poor fuel quality or from blending addition-
al fuel additives other than those tested
and approved by us for use on
Mercedes-Benz vehicles listed in the
Factory Approved Service Products pam-
phlet are not covered by the
Mercedes-Benz Limited Warranty.

477 Technical data
Fuels, coolants, lubricants, etc.
Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which
provides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and
corrosion protection.
If the antifreeze mixture is effective
to -22°F (-30°C), the boiling point of the
coolant in the pressurized cooling system
is reached at approx. 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Maintenance Booklet for
replacement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see Facto-
ry Approved Service Products pamphlet)
are used to renew the coolant concentra-
tion or bring it back up to the proper level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. -22°F [-30°C]). If you
use a solution that is more than 55% anti-
corrosion/antifreeze (freeze protection to
approx. -49°F [-45°C]), the engine temper-
ature will increase due to the lower heat transfer capability of the solution. There-
fore, do not use more than this amount of
anticorrosion/antifreeze.
If the coolant level is low, water and MB
Anticorrosion /Antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
Please make sure the mixture is in accor-
dance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality,
consult an authorized Mercedes-Benz
Center.
!Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz
Limited Warranty

478 Technical data
Fuels, coolants, lubricants, etc.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to an authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantity
ModelApprox. freeze protection
–35°F (–37°C)–49°F (–45°C)
CLK 3503.9 US qt (3.7 l)4.3 US qt (4.1 l)
CLK 5504.9 US qt (4.6 l)5.3 US qt (5.1 l)
CLK 63 AMG5.8 US qt (5.5 l)6.3 US qt (6.0 l)

479 Technical data
Fuels, coolants, lubricants, etc.
Windshield washer system and
headlamp cleaning system*
Both the windshield washer and headlamp
cleaning system are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx. 6.4 US qt (6.0 l).
Refill the reservoir with MB Windshield
Washer Concentrate “MB SummerFit”
and water (or concentrate and com-
mercially available premixed wind-
shield washer solvent / antifreeze,
depending on ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and water:

1 part “MB SummerFit” to 100 parts
water
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] water)
For temperatures below freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and commercially avail-
able premixed windshield washer
solvent / antifreeze:

1 part “MB SummerFit” to 100 parts
solvent
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] solvent)
Warning!G
Washer solvent/antifreeze is highly flam-
mable. Do not spill washer
solvent/antifreeze on hot engine parts, be-
cause it may ignite and burn. You could be
seriously burned.

483 Index
C
California retail buyers and lessees,
Important notice for 11
Call priority (Tele Aid) 292
Can holder see Cup holder
Capacities and
recommended fuels/lubricants 472
Cargo area see Trunk
Carpets, cleaning 363
Catalytic converter 310
CD changer* 227
MP3 228
CD player 227
Control system 150
Center console 29
Lower part 30
Upper part 29
Central locking
Automatic 117, 164
Locking/unlocking from inside 118
Central locking switch 118
Certification label 462
Certification label, examples 462
Charcoal filter 207Children in the vehicle 82
Air bags 82
Blocking rear
side window operation 86
Front passenger front
air bag off indicator lamp 74
Infant and
child restraint systems 75, 82
LATCH-type child seat anchors 85
Occupant Classification System
(OCS) 71
Cigarette lighter 282
Climate control see
Climate control system
Climate control system
Air conditioning refrigerant 474
Air conditioning, Cooling 196, 208
Air distribution 192, 203
Air recirculation mode 194, 205
Air vents 197, 210
Air volume 192, 193, 204
Charcoal filter 207
Control panel,
Automatic climate control 199Control panel, Climate control 189
Deactivating/Reactivating 191, 201
Defogging 204
Defrosting 204
Defrosting, Rear window 187
Front defroster 193
MAXCOOL 205
Residual engine heat
and ventilation* (REST*) 209
Temperature 192, 202
Clock 27, 138, 158
Setting time 158
Cockpit 24
Cold tire inflation pressure 347
Collapsible wheel chock 404, 407
COMAND* see separate
COMAND operating instructions
Combination switch 54, 130
Control system 139
Functions 143
Multifunction display 139
Multifunction steering wheel 140
Resetting to factory default 153

487 Index
Front lamps see Headlamps
Front passenger front air bag 65, 69
Messages in display 382–385
Front passenger front
air bag off indicator lamp 29, 74, 376
FSS (Canada vehicles) 353
Fuel 313, 472
Additives 476
Automatic transmission fluid 472
Brake fluid 473
Capacities 472
Capacities, Fuel tank 473
Engine coolant 473
Engine oil 472
Filling the tank 312
Fuel display 27
Fuel filler flap and cap 312
Fuel filler flap and cap, Multifunction
display messages 393
Fuel reserve warning lamp 373
Power steering fluid 473
Premium unleaded
gasoline 313, 473, 475
Requirements, Octane rating 476
Technical data 472Fuel cap
Message in display 370
Fuel consumption statistics
From start 165
Resetting 166
Since last reset 166
Fuel filler flap 312
Locking/unlocking 312
Opening 312
Fuel reserve warning lamp 27
Fuel tank
Capacity 473
Filler flap 312
Message in display 395
Fuel, Premium unleaded
gasoline 313, 475, 476
Fuels, coolants, lubricants etc.
Capacities 472
Fuses 456
Fuse box (main)
in passenger compartment 457
Fuse box
in engine compartment 457
Fuse box
in trunk 458
Replacing 456G
Garage door opener 31, 293
Gasoline see Fuel
GAWR 347
Gear range
Automatic transmission 175
Limiting 175
Shifting into optimal 178, 180
Gear selector lever 30, 50, 170
Cleaning 363
Gearshift pattern 170
Lock 51
Message in display 386
Position 171, 172
Position indicator 27, 139
Shifting procedure 171
Unlocking in an emergency 412
Gear selector lever one-touch gearshifting
Automatic transmission 177
Global locking/unlocking see
Key, SmartKey or KEYLESS-GO*
Glove box 25, 276
Gloves 404
Good visibility 184
Gross Axle Weight Rating see GAWR
Gross Vehicle Weight Rating see GVWR

490 Index
KEYLESS-GO* 101
Batteries in SmartKey 107
Battery check lamp, SmartKey 105
Factory setting 104, 106
Ignition 38
Important notes 103
Lock button 62
Locking/unlocking 35, 62, 101
Locking/unlocking,
Global setting 104, 105
Locking/unlocking,
Global with lock button
on trunk lid 106
Locking/unlocking,
Selective setting 105, 106
Loss of key 107
Messages in display 395, 396
Remote control 101
Start/stop button 37
Starting the engine 51
Turning off the engine 60
Unlocking/opening trunk lid 107
Kickdown 174
Kilopascal 348L
Labels 462
Certification 462
Emission control information 463
Vacuum line routing diagram 463
Lamp sensor see Light sensor
Lamps, exterior 427
Light sensor 396
Messages in display 397–400
Lamps, indicator and warning
ABS 27, 366
Battery (SmartKey) 100, 105
Brakes 27, 368
Center console 376–377
CHECK ENGINE 369, 370
Coolant 371
Coolant temperature 27, 137
Distance warning 27
Engine diagnostics 369, 370
Engine malfunction 27, 369, 370
ESP
®27, 372
Fog lamps 130
Front passenger front air bag off 69
Front passenger front
air bag off indicator lamp 376
Fuel reserve 27, 373High beam headlamp 27
Instrument cluster 366–375
Low beam headlamp 27
Parktronic system*
(CLK 63 AMG (USA),
Canada all vehicles)
warning indicators 269
Roll bar 373
Seat belt telltale 27, 78
SRS 27, 65, 375
Turn signals 27
Language, Setting 156
LATCH-type child seat anchors see
Children in the vehicle
License plate lamps
Messages in display 398
Replacing bulbs 428, 433
Light alloy wheels, cleaning 362
Light sensor
Messages in display 396
Lighter see Cigarette lighter
Lighting, Exterior and interior 126
Limp-home mode 183
Loading
Ski sack* (Canada only) 271
Loading see Vehicle loading

492 Index
Multifunction display messages 378
ABS 380
Battery 388
Brake fluid 389
Brake pads 389
Check engine 390
Coolant 390–392
Engine 390
Engine coolant 390–392
ESP
®380
Fog lamps 397
Front passenger
front air bag 382–385
Fuel cap 393
Fuel reserve tank 395
Gear selector lever 386
Headlamps 397–400
Key, SmartKey 395
KEYLESS-GO* 395
Lamps 397
Lamps, exterior 397–400
License plate lamp 398
Light sensor 396
Parking brake 389
Parking lamps 398
Roll bars 386Soft top 402
SRS 401
Steering gear oil 402
Tele Aid 401
Telephone* 403
Turn signals 397
Windshield washer fluid 403
Multifunction steering wheel 28, 140
Button operation 140
N
Navigation system* 151
See separate
COMAND* operating instructions
Net, Parcel 277
Neutral gear position,
Automatic transmission 170, 172
New vehicle break-in 300
Night security illumination 129
Normal occupant weight 348
Number, paintwork code 462
Number, vehicle identification
(VIN) 462, 463O
Occupant Classification System see OCS
Occupant distribution 348
Occupant safety 64
Active head restraints 80
Air bags 65
Children and air bags 82
Children in the vehicle 82
ETD 79
Fastening the seat belts 47
Front air bags 69
Front passenger front
air bag off indicator lamp 74, 376
Head-thorax air bags 70
Infant and child restraint systems 82
LATCH-type child seat anchors 85
OCS 71
Rear side-impact air bags* 70
Roll bars 81
Safety guidelines,
Seat belts, Air bag, ETD 67
Seat belts 47, 75
SRS 64