warning MERCEDES-BENZ CLK430 2002 C208 Workshop Manual

253 Engine compartment
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index Checking engine oil level
1Oil dipstick
2Oil filler cap
To check the engine oil level, park vehicle on level
ground, with engine at normal operational temperature.
Check engine oil level approximately 5 minutes after
stopping the engine, allowing for the oil to return to the
oil pan.Wipe oil dipstick clean prior to checking the engine oil
level. Fully insert dipstick in tube, and remove after
three seconds to obtain accurate reading.
Oil level must be between the
lower (min) and upper (max) mark of
the dipstick.
Fill quantity between upper and lower dipstick marking
level is approximately 2.0 US qt (2.0 l).
Do not overfill the engine.
Excessive oil must be drained
or siphoned. It could cause damage to engine and
catalytic converter not covered by the Mercedes-Benz
Limited Warranty.
See malfunction and warning messages on page 232 if
an engine oil level display appears on the multifunction
display when the engine is running.
Note:
See page 114 for engine oil level indicator.
Mercedes-Benz
Mercedes-Benz
2
1
J_C208_II.book Seite 253 Donnerstag, 31. Mai 2001 10:13 10

262 Tires, Wheels
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index
Changing wheelsMove vehicle to a level area which is a safe distance
from the roadway.
1. Set parking brake and turn on hazard warning
flasher.
2. Move selector lever to position “P” and turn off
engine.
3. Prevent vehicle from rolling away by blocking
wheels with wheel chocks (not supplied with
vehicle) or sizable wood block or stone. When
changing a wheel on a hill, place chocks on the
downhill side blocking both wheels of the other
axle. On a level road, place one chock in front of and
one behind the wheel that is diagonally opposite to
the wheel being changed.
Wa r n i n g !
The jack is designed exclusively for jacking up the
vehicle at the jack tubes built into either side of the
vehicle. To help avoid personal injury, use the jack
only to lift the vehicle during a wheel change.
Never get beneath the vehicle while it is supported
by t he j ack . Keep han ds a nd feet away from t he a rea
under the lifted vehicle. Always firmly set parking
brake and block wheels before raising vehicle with
jack.Do n ot d is engage parki n g brake w hil e t he vehi c le i s
raised. Be certain that the jack is always vertical
when in use, especially on hills. Always try to use
the jack on level surface. Be sure that the jack arm
is fully inserted in the jack tube. Always lower the
vehicle onto sufficient capacity jackstands before
working under the vehicle.
J_C208_II.book Seite 262 Donnerstag, 31. Mai 2001 10:13 10

271 Jump starting
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index Proceed as follows:
1. Position the vehicle with the charged battery so that
the jumper cables will reach, but never let the
vehicles touch. Make sure the jumper cables do not
have loose or missing insulation.
2. On both vehicles:
•Turn off engine and all lights and accessories,
except hazard warning flashers or work lights.
•Apply parking brake and shift selector lever to
position “P”.
Important!
3. Clamp one end of the first jumper cable to the
positive (+) under hood terminal of the discharged
battery and the other end to the positive (+) terminal
of the charged battery. Make sure the cable clamps
do not touch any other metal parts.
4. Clamp one end of the second jumper cable to the
grounded negative (–) terminal of the charged
battery and the final connection to the negative (–)
terminal (2) of the discharged battery.Important!
5. Start engine of the vehicle with the charged battery
and run at high idle. Make sure the cables are not
on or near pulleys, fans, or other parts that move
when the engine is started. Allow the discharged
battery to charge for a few minutes. Start engine of
the disabled vehicle in the usual manner.
6. After the engine has started, remove jumper cables
by exactly reversing the above installation
sequence, starting with the last connection made
first. When removing each clamp, make sure that it
does not touch any other metal while the other end
is still attached.
Notes:
If engine does not run after several unsuccessful
starting attempts, have it checked at the nearest
authorized Mercedes-Benz Center.
Excessive unburned fuel may damage the catalytic
converter.
J_C208_II.book Seite 271 Donnerstag, 31. Mai 2001 10:13 10

273 Towing
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index We recommend that the vehicle be transported using
flat bed equipment. This method is preferable to other
types of towing.
The vehicle may be towed with all wheels on the ground
and the selector lever in position “N” for distances up to
30 miles (50 km) and at a speed not to exceed 30 mph
(50 km/h). The electronic key must be in steering lock
position 2.
To be certain to avoid a possibility of damage to the
transmission, however, we recommend the drive shaft
be disconnected at the rear axle drive flange for any
towing beyond a short tow to a nearby garage.
Do not tow with sling-type equipment. Towing with
sling-type equipment over bumpy roads will damage
radiator and supports.
Use wheel lift, dolly, or flat bed equipment, with
electronic key in steering lock turned to position 0.Note:
To signal turns while being towed with hazard warning
flasher in use, turn electronic key in steering lock to
position 2 and activate combination switch for left or
right turn signal in usual manner – only the selected
turn signal will operate.
Upon canceling the turn signal, the hazard warning
flasher will operate again.
Caution!
If the vehicle is towed with the front axle raised, the
engine must be shut off (electronic key in steering lock
position 0 or 1). Otherwise, the ESP will immediately be
engaged an d will app ly t he r ear wheel b rakes . Swi tch o f f
the tow-away alarm (see page 44) as well as the ESP (see
page 220).
Wa r n i n g !
With the engine not running, there is no power
assistance for the braking and steering systems. In
this case, it is important to keep in mind that a
considerably higher degree of effort is necessary to
brake and steer the vehicle.
J_C208_II.book Seite 273 Donnerstag, 31. Mai 2001 10:13 10

313 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Index
AABS (Antilock brake system) ....................................... 216
Malfunction indicator lamp ..................................... 229
ABS-SYSTEM - malfunction
and warning messages ............................................ 235
Adjusting headlamp aim ...............................................280
Adjusting telescoping steering column ........................ 79
Air conditioner refrigerant ........................................... 307
Air distribution .............................................................. 126
Air volume ...................................................................... 126
Airbag deactivation system ............................................ 65
Airbag OFF indicator lamp ........................................... 231
Airbags .............................................................................. 68
Alarm system ............................................................. 43, 44
Anticorrosion/antifreeze ....................210, 255, 305, 309
Antiglare night position ................................................. 80
Antilock brake system (ABS) ....................................... 216
Malfunction indicator lamp ..................................... 229
Antitheft alarm system ................................................... 43
Aquaplaning ...................................................................207Ashtray
Center console, front ................................................ 157
Rear seats ................................................................... 158
Audio system
Anti-theft system ....................................................... 131
Button and soft key operation ................................. 132
Cassette mode ............................................................ 137
CD changer ................................................................. 141
CD mode ..................................................................... 140
Operating and display elements ............................. 130
Operating safety ........................................................129
Operation .................................................................... 133
Operation — audio and telephone ........................... 129
Radio mode ................................................................ 135
Telephone operation ................................................. 144
Audio systems ................................................................... 95
Cassette player ............................................................ 97
CD player ......................................................................96
Radio .............................................................................95
Automatic central locking .............................................. 36
Automatic climate control ............................................ 122
Air distribution .......................................................... 126
Air recirculation ........................................................127
Air volume ..................................................................126
J_C208_II.book Seite 313 Donnerstag, 31. Mai 2001 10:13 10

314 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Basic setting .............................................................. 124
Defogging windows .................................................. 125
Defrosting ................................................................... 125
Display and controls ................................................. 124
Dust filter ................................................................... 128
Economy ..................................................................... 125
Rear window defroster ............................................. 126
Residual engine heat utilization (REST) ............... 127
Special settings ......................................................... 125
Automatic transmission ............................................... 193
Emergency Operation .............................................. 201
Fluid level ...................................................................254
Program mode selector switch ............................... 200
Selector lever position .............................................. 196
Transmission selector lever,
manually unlocking ............................................. 274
BBabySmart
TM airbag deactivation system ..................... 65
Self-test ......................................................................... 66
Backrest, front seat .......................................................... 54
BAS (Brake assist system) ............................................ 214
Malfunction indicator lamp ..................................... 229Battery ............................................................................ 268
Battery recycling ...................................................... 269
BATTERY/ALTERNATOR -
malfunction and warning messages ..................... 234
Block heater .................................................................... 211
BRAKE ASSIST - malfunction
and warning messages ............................................ 235
Brake assist system (BAS) ............................................ 214
Malfunction indicator lamp .................................... 229
Brake fluid .................................................... 204, 227, 307
Capacity ..................................................................... 305
BRAKE FLUID - malfunction
and warning messages ............................................ 236
BRAKE LINING WEAR - malfunction
and warning messages ............................................ 236
Brake pad wear .............................................................. 236
Brake warning lamp ..................................................... 227
Brake fluid low ......................................................... 227
Brakes .................................................... 202, 204, 214, 219
Bulbs
See Replacing bulbs ................................................. 275
J_C208_II.book Seite 314 Donnerstag, 31. Mai 2001 10:13 10

315 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
CCapacities
Fuels, coolants, lubricants etc. ............................... 305
Cargo area ....................................................................... 160
Loading instructions ................................................ 162
Cargo tie-down rings ..................................................... 163
Catalytic converter ........................................................ 178
CD changer
See Audio system ...................................................... 141
Cellular telephone ......................................................... 165
Center console .................................................................. 20
Central locking switch .................................................... 35
Central locking system ................................................... 27
Automatic central locking ......................................... 36
Choosing global or selective mode ........................... 30
Electronic key .............................................................. 25
Locking and unlocking .............................................. 29
Mechanical keys .......................................................... 32
Remote control ............................................................ 27
Changing wheels ...........................................................262
CHECK ENGINE malfunction indicator lamp ............ 226
Check regularly and before a long trip ......................224
Checking engine oil level
Via engine oil level indicator ...................................114
Via oil dipstick ...........................................................253Child restraint .............................................. 50, 58, 64, 76
Child seat
See Infant and child restraint systems .................... 76
Cleaning and care of the vehicle ................................ 292
COMAND, radio and telephone ................................... 176
Combination switch ....................................................... 119
Consumer information .................................................. 311
Control and operation of radio transmitters .............. 176
COOLANT (coolant level) - malfunction
and warning messages ............................................ 238
Coolant level
Adding coolant .......................................................... 255
Checking .................................................................... 254
COOLANT TEMP. (coolant temperature) -
malfunction and warning messages ..................... 239
Coolant temperature gauge ............................................88
Coolants .......................................................................... 309
Anticorrosion/antifreeze quantity ........................ 309
Cruise control ................................................................. 212
Cup holder
Center console, front ................................................ 155
Rear bench armrest ................................................... 156
J_C208_II.book Seite 315 Donnerstag, 31. Mai 2001 10:13 10

316 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
DDaytime running lamps .................................................117
Deep water
Driving instructions ................................................. 210
DISPLAY DEFECTIVE (engine control unit) -
malfunction and warning messages ......................233
DISPLAY DEFECTIVE (several systems) -
malfunction and warning messages ......................233
Display illumination ........................................................ 87
Doors .................................................................................. 33
Drinking and driving ....................................................203
Drive sensibly - save fuel ..............................................203
Driving instructions ......................................................203
Driving off .......................................................................205EELEC. STABIL. PROGR. - malfunction
and warning messages ............................................ 243
Electronic key ................................................................... 25
Changing batteries ................................................... 283
Electronic main key
Synchronizing remote control ................................ 285Electronic stability program (ESP) .....................209, 273
Control switch .......................................................... 220
Malfunction and warning message ....................... 243
Malfunction indicator lamp .................................... 229
Synchronizing ........................................................... 219
Warning lamp ........................................................... 229
Emergency call
See Tele Aid ............................................................... 181
Emergency tensioning retractor (ETR) .........................67
Emergency trunk lid release button ....................... 41, 42
Emergency unlocking in case of accident ...................36
Emission control ............................................................ 179
Emission control label .................................................. 300
Engine compartment ..................................................... 251
ENGINE FAN - malfunction and
warning messages ................................................... 237
Engine malfunction
CHECK ENGINE malfunction indicator lamp ...... 226
Engine oil additives ...................................................... 307
Engine oil consumption ................................................ 115
Engine oil level
Checking ............................................................ 114, 253
Warning ..................................................................... 242
ENGINE OIL LEVEL - malfunction
and warning messages ............................................ 242
J_C208_II.book Seite 316 Donnerstag, 31. Mai 2001 10:13 10

317 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex Engine oil level indicator ...............................................114
ENGINE OIL LEVEL NOT WHEN ENGINE ON
(measuring) - multifunction indicator ....................115
Engine oils ...................................................................... 307
Capacities ...................................................................305
Enlarged cargo area ....................................................... 160
ESP (Electronic stability program) ............ 209, 218, 273
Control switch ...........................................................220
Malfunction and warning message ........................ 243
Malfunction indicator lamp ..................................... 229
Synchronizing ........................................................... 219
Warning lamp ............................................................229
Express opening and closing
See Power windows .................................................. 148
Exterior lamp malfunction
and warning message ..............................................240
Exterior lamp switch ......................................................116
Exterior lamps ................................................................ 275
Adjusting headlamp aim .......................................... 280
Fog lamps ....................................................................116
Headlamps ...................... 116, 240, 241, 276, 280, 294
Low and high beam .......................................... 119, 277
Parking lamps ................................................... 116, 277Replacing bulbs ........................................................ 275
Side marker lamp, front .......................................... 279
Standing lamps ..................................................116, 277
Taillamp assemblies ................................................ 278
Turn signal lamp ...............................................119, 277
FFirst aid kit ..................................................................... 248
Flat tire
See Changing wheels .............................................. 262
Flexible service system (FSS) .......................................111
Fuel
Gasoline additives .................................................... 309
Premium unleaded gasoline ..................222, 306, 308
Fuel cap placement warning ....................................... 228
Fuel filler flap
Manual release ......................................................... 287
Fuel requirements ........................................................ 308
Fuel reserve warning .................................................... 228
Fuels, coolants, lubricants etc. - capacities .............. 305
Fuses, electrical ............................................................. 249
J_C208_II.book Seite 317 Donnerstag, 31. Mai 2001 10:13 10

318 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
GGarage door opener ....................................................... 166
Gasoline
Additives .................................................................... 309
Fuel requirements ....................................................308
Premium unleaded ................................................... 308
General notes on the central locking system .............. 26
Global locking
See Central locking system ....................................... 29
Glove box ......................................................................... 154HHazard warning flasher switch ................................... 121
Head restraints
Front ............................................................................. 51
Rear ............................................................................... 52
Removal ........................................................................ 51
Headlamp cleaning system ...........................................118
Headlights ........................................................................116
Heated seats ..................................................................... 56
High beams
See Combination switch ...........................................119
Hood ................................................................................. 251
IIdentification labels ...................................................... 299
Illuminated vanity mirrors ........................................... 153
Indicator lamps in the instrument cluster ...................86
Individual settings ......................................................... 108
Infant and child restraint systems ................................ 76
Installation ................................................................... 78
Information call
See Tele Aid ............................................................... 185
Instrument cluster ........................................................... 84
Activating .....................................................................87
Indicator lamps ............................................................ 86
Instrument lamps ............................................................. 87
Instruments and controls ............................................... 18
Interior
General notes ............................................................. 153
Interior lighting .............................................................. 151JJump starting ................................................................. 270
J_C208_II.book Seite 318 Donnerstag, 31. Mai 2001 10:13 10