ECU MERCEDES-BENZ CLK55AMG COUPE 2005 C209 Repair Manual

393 Practical hints
Where will I find...?
Minispare wheel (except CLK 55 AMG)
The Minispare wheel is located in the
storage compartment underneath the
trunk floor.
Removing the Minispare wheel
Lift up trunk floor cover and engage
trunk floor handle in upper edge of
trunk.

Loosen the retaining screw in the mid-
dle of storage well casing by turning it
counterclockwise (
page 389).

Remove the storage well casing
(page 389).1Vehicle tool kit
2Arrow
3Minispare wheel
4Vehicle tool kit storage well casing

Remove vehicle tool kit storage well
casing4.

Remove Minispare wheel3.Storing the Minispare wheel

Place Minispare wheel3 in wheel
well.

Place vehicle tool kit storage well
casing4 over the Minispare wheel.
Make sure arrow2 on vehicle tool kit
storage well casing4 points in the
direction of travel.

Place storage well casing (
page 389)
over vehicle tool kit storage well
casing4 and turn the retaining screw
(
page 389) clockwise as far it will go
to secure the Minispare wheel.
iArrow2 on vehicle tool kit storage
well casing4 must point in the
direction of travel. Otherwise you
cannot place the storage well casing
(page 389) on top and secure the
Minispare wheel with the retaining
screw (
page 389).

395 Practical hints
Where will I find...?

Loosen retaining screw3 by turning it
counterclockwise.

Remove collapsible tire1.
Storing the collapsible tire
If you wish to store the collapsible tire after
use, carry out the following steps.
Otherwise the collapsible tire will not fit
the storage compartment.

Unscrew the valve cap from the valve
of the collapsible tire.

Take the valve extractor from the
vehicle tool kit (
page 391).

Unscrew the valve insert from the valve
and allow the air to escape.

Screw the valve insert back into the
valve.

Screw the valve cap back on the valve.

Pull the protective wrap provided with
the vehicle tool kit over the collapsible
tire.

Store the collapsible tire and the valve
extractor in the storage compartment
underneath the trunk floor.

Pierce the protective wrap with
retaining screw3.

Secure the collapsible tire by turning
retaining screw3clockwise.
!Make sure the collapsible tire is dry
when storing it.
iIt may take a few minutes for the col-
lapsible tire to deflate completely.
!To prevent damage, always disengage
trunk floor handle from upper edge of
trunk and lower trunk floor before
closing the trunk lid.Warning!
G
The dimensions of the collapsible tire are
different from those of the road wheels. As
a result, the vehicle handling characteristics
change when driving with a collapsible tire
mounted.
The collapsible tire should only be used tem-
porarily, and should be replaced with a reg-
ular road wheel as quickly as possible.

420 Practical hintsBatteryThe battery is located in the engine
compartment on the right hand side.
1Clamps
Removing filter box:
Release clamps1.

Remove filter box.
Installing filter box:

Insert filter box properly.

Secure it with clamps1.
Warning!
G
Failure to follow these instructions can re-
sult in severe injury or death.
Observe all safety instructions and
precautions when handling automotive
batteries (
page 314).
Never lean over batteries while connecting,
you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
!Never loosen or detach battery termi-
nal clamps while the engine is running
or the SmartKey is in the starter switch.
Otherwise the alternator and other
electronic components could be se-
verely damaged.
Have the battery checked regularly by
an authorized Mercedes-Benz Center.
Refer to Maintenance Booklet for
maintenance intervals or contact an
authorized Mercedes-Benz Center for
further information.Warning!
G
Do not place metal objects on the battery as
this could result in a short circuit.
Use leak-proof battery only to avoid the risk
of acid burns in the event of an accident.

421 Practical hints
Battery
1Negative terminal
2Positive terminal cover
Disconnecting the battery
Turn off the engine (
page 46).

Turn off all electrical consumers.

Remove SmartKey from starter switch.
Vehicles with KEYLESS-GO*:
Press the start / stop button until
the engine shuts off.

Open the driver’s door.

Open the hood (
page 308).

Remove the filter box (
page 420).

Disconnect the battery negative lead
from negative terminal1.

Remove cover2 from the positive ter-
minal.

Disconnect the battery positive lead.
Removing the battery
Remove the screw securing the
battery.

Remove the battery support and
bracket.

Take out the battery.
Warning!
G
With a disconnected battery

you will no longer be able to turn the
SmartKey in the starter switch and
pressing the KEYLESS-GO* start/stop
button on the gear selector lever will
have no effect


the gear selector lever will remain
locked in positionP

422 Practical hintsBatteryCharging and reinstalling battery
Charge battery in accordance with the
instructions of the battery charger
manufacturer.

Reinstall the charged battery. Follow
the previously described steps in
reverse order.
Reconnecting the battery
Turn off all electrical consumers.

Remove SmartKey from starter switch.
Vehicles with KEYLESS-GO*:
Press the start / stop button until
the engine shuts off.

Open the driver’s door.

Connect the battery positive lead and
fasten its cover 2.

Connect the battery negative lead.

Reinstall the filter box (
page 420).Batteries contain materials that can harm
the environment if disposed of improperly.
Large 12-volt storage batteries contain
lead. Recycling of batteries is the preferred
method of disposal. Many states require
sellers of batteries to accept old batteries
for recycling.
Warning!
G
Never charge a battery while still installed in
the vehicle. Gases may escape during charg-
ing and cause explosions that may result in
paint damage, corrosion or personal injury.
!NEVER invert the terminal connections!!The battery, its filler caps and the vent
tube must always be securely installed
when the vehicle is in operation.
iThe following procedures must be car-
ried out following any interruption of
battery power (e.g. due to reconnect-
ing):

Set the clock (
page 151) (vehi-
cles with COMAND*: see COMAND
operator’s manual).


Resynchronize the side windows
(page 250).


Resynchronize the tilt/sliding
sunroof* (
page 254).

432 Practical hintsFusesClosing fuse box
Make sure that the sealing rubber is
properly positioned.

Press fuse box cover4 down and
secure with clamps5.
Installing cover

Insert cover1 sideways into
retainer3.

Twist screws2 90° clockwise.
Fuse box in trunk
The fuse box is located in the trunk behind
the left-hand trim panel.
1Trim
2Spare extractor
3CoverOpening fuse box

Pull off trim1.

Remove cover3.
Closing fuse box

Place cover3 back on.

Press trim1 back into place.

474 Index
Maintenance service indicator 344
Parktronic system*
warning indicators 262
Seat belts 359
SRS 61, 359
Turn signals 25
Language
Multifunction display 150
Setting 150
LATCH child seat anchors 80
Folding back 81
Folding out 81
Layout of poly-V-belt drive 437
Leather upholstery
Cleaning 352
License plate lamps
Messages in display 383
Replacing bulbs 405, 410
Light alloy wheels
Cleaning 351
Technical data 440
Light sensor 383
Lighter see Cigarette lighterLighting 124
Automatic headlamp mode 125
Combination switch 129
Cornering fog lamps* 130
Daytime running lamp mode 126
Door entry lamps 133
Exterior lamp switch 124
Front fog lamps 128
High beam flasher 129
High beams 129
Instrument cluster illumination 134
Interior 132
Locator lighting 127
Low beam 124
Manual headlamp mode 125
Night security illumination 127
Parking lamps 124
Rear fog lamp 128
Settings (control system) 154
Limiting the gear range 168
Limp Home Mode 177
Line of fall 457Loading 264
Cargo tie-down rings 271
Instructions 269
Roof rack 264
Ski sack* 264
Split rear bench seat 267
Loading terminology 338
Loading the vehicle 319
Locator lighting 127
Setting 156
Lock buttons 457
Door handle (KEYLESS-GO*) 58
Locking 55, 94
Fuel filler flap 305
Global with KEYLESS-GO* 101
Global, SmartKey 96
The vehicle with KEYLESS-GO* 103
Vehicle in an emergency 398
Loss of Service and
Warranty Information Booklet 435
Loss of SmartKey 98
Loss of SmartKey
with KEYLESS-GO* 105

477 Index
Parking brake 374
SmartKey with KEYLESS-GO* 381
Steering gear oil level 387
Sunroof* 388
Symbol messages 373–388
Tele Aid 386
Telephone* 388
Text messages 364–372
Trunk 388
Washer fluid 388
Multifunction
steering wheel 26, 138, 458
Buttons 138N
Navigation system
Operating 144
See separate COMAND*
operating instructions
Night security illumination 127
Normal occupant weight 339
Nubuck leather upholstery (CLK 55 AMG)
Cleaning 352
O
Occupant Classification System see OCS
Occupant distribution 339
Occupant safety 60
Air bags 61
Children and air bags 62
Children in the vehicle 70
Fastening the seat belts 43
Front passenger front
air bag off indicator lamp 77, 360
Infant and child restraint systems 70
LATCH child seat anchors 80
OCS 73
Seat belts 43, 64OCS 73, 458
Self-test 78
Odometer, main 25
Oil
Adding 312
Checking level 310
Consumption 309
Filler cap 312
Filler neck 312
Viscosity 456
Oil level
Checking 307
One-touch gearshifting 167
Canceling gear range limit 167
Downshifting 167
Upshifting 167

482 IndexS
Safety
Occupant 60
Safety belts see Seat belts
Safety defects
Reporting 18
Safety systems
Driving 84
Seat belt force limiter 69
Seat belts 67
Cleaning 352
Fastening 43
Proper use of 45, 68
Safety guidelines 64
Warning lamp 359
Seat cushion depth
Adjusting 118
Seat heating* 119
Switching off 119
Switching on 119
Seat ventilation* 120
Switching off 120
Switching on 120
Seating capacity 321Seats 112
Adjusting 37
Easy entry/exit feature 112
Multicontour seat* 118
Seat heating* 119
Seat ventilation* 120
Split rear bench seat 267
Securing cargo
Cargo tie-down rings 271
Selecting
Automatic time change
(Daylight Saving Time
(DST) summer/winter) 153
Display 150
Selecting display 151
Self-test
OCS 78
Tele Aid 280
Service
Parts service 434
Service (maintenance) 344
Service and Warranty Booklet
Loss of 435
Service and warranty information 10
Service life (tires) 317Service System see
Maintenance service system
Setting
Convenience functions 148, 158
Cruise control 256
Date (day) 153
Date (month) 153
Date (year) 154
Daytime running lamp mode 155
Higher speed in cruise control 258
Hours (clock) 152
Individual vehicle settings 146
Interior lighting
delayed switch-off 157
Key-dependent memory 160
Lamps and lighting
(control system) 154
Language, multifunction display 150
Locator lighting 156
Lower speed in cruise control 258
Miles/kilometers
in speedometer 149
Minutes (clock) 152
Parking position for
exterior rear view mirrors 160
Slower speed in cruise control 258