technical data MERCEDES-BENZ CLS500 2008 W219 User Guide

433 Technical data
Warranty coverage
Warranty coverage
Your vehicle is covered under the terms of
the warranties printed in the Service and
Warranty Information Booklet. Your
authorized Mercedes-Benz Center will ex-
change or repair any defective parts origi-
nally installed in the vehicle in accordance
with the terms of the following warranties:

New Car Limited Warranty

Emission System Warranty

Emission Performance Warranty

California, Maine, Massachusetts, and
Vermont Emission Control System
WarrantyReplacement parts and accessories are
covered by the Mercedes-Benz Parts and
Accessories Warranties, copies of which
are available at any authorized
Mercedes-Benz Center.Loss of Service and Warranty
Information Booklet
Should you lose your Service and Warranty
Information Booklet, have your authorized
Mercedes-Benz Center arrange for a re-
placement. It will be mailed to you.

434 Technical data
Identification labels
1Certification label (includes Paintwork
code)
The V
ehicle Identification Number (VIN)
can be found in the following locations:

on the certification label

embossed underneath a cover in the
center armrest

on the lower edge of the windshield
Example certification label (U.S. vehicles)
2VIN
3Paintwork code
Example certification label
(Canada vehicles)
2VIN
3Paintwork code
iData shown on certification label are for il-
lustration purposes only. These data are specific
to each vehicle and may vary from data shown in
the illustration. Refer to certification label on ve-
hicle for actual data specific to your vehicle.

435 Technical data
Identification labels
1Cover
2VIN3Emission control information label, in-
cludes both federal and California cer-
tification exhaust emission standards
4VIN (lower edge of windshield)
5Engine number (engraved on engine)
iWhen ordering parts, please specify vehicle
identification and engine numbers.

436 Technical data
Layout of poly-V-belt drive
CLS 550
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)CLS 63 AMG
1Idler pulley
2Idler pulley
3Idler pulley
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

437 Technical data
Engine
Engine
ModelCLS 550 (219.372)1
1The quoted data apply only to the standard vehicle. Contact an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equip-
ment.
CLS 63 AMG (219.377)1
Engine273156
Mode of operation4-stroke engine, gasoline injection4-stroke engine, gasoline injection
No. of cylinders88
Bore3.86 in (98.00 mm)4.02 in (102.20 mm)
Stroke3.56 in (90.50 mm)3.72 in (94.60 mm)
Total piston displacement333.3 cu in (5461 cm3)378.8 cu in (6 208 cm3)
Compression ratio10.7:111.3:1
Output acc. to SAE J 1349382 hp/6 000 rpm2
(285 kW/6 000 rpm)
507 hp/6 800 rpm2
(378 kW/6 800 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
Maximum torque acc. to SAE J 1349391lb-ft/2800rpm - 4800rpm
(530 Nm/2 800 rpm - 4 800 rpm)465 lb-ft/5 200 rpm
(630 Nm/5 200 rpm)
Maximum engine speed6 500 rpm7 200 rpm
Firing order1-5-4-2-6-3-7-81-5-4-2-6-3-7-8
Poly-V-belt2 404 mm2360 mm

438 Technical data
Rims and tires
!Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires

MOE = Mercedes-Benz Original Extended
(tires with limited run-flat characteristics)
original equipment tires
Using tires other than those approved by
Mercedes-Benz may result in damage that is
not covered by the Mercedes-Benz Limited
Warranty.
iFor information on driving with MOExtended
tires, see “MOExtended system*” (
page 313).
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the re-
sult.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz
Center. A placard with the recommended tire in-
flation pressures is located on the driver’s door
B-pillar. Some vehicles may have supplemental
tire inflation pressure information for driving at
high speeds (
page 302) or for vehicle loads
less than the maximum loaded vehicle condition
(
page 302). If such information is provided, it
can be found on the placard located on the in-
side of the fuel filler flap. The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your vehi-
cles with winter tires. Winter tires are not avail-
able as standard or optional factory equipment,
but can be purchased from an authorized
Mercedes-Benz Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire config-
uration on your vehicle (Appearance Package,
AMG Sport Package etc.), equipping your vehicle
with winter tires approved for your vehicle model
may also require the purchase of two or four
wheel rims of the recommended size for use with
these winter tires. See an authorized
Mercedes-Benz Center for more information.

439 Technical data
Rims and tires
Same size tires
ModelCLS 550
Rims (light alloy)8.5 J x 18 H2
Wheel offset (front axle)1.38 in (28 mm)
Wheel offset (rear axle)0.71 in (18 mm)
Summer tires1
1Radial-ply tires
-
Winter tires1,2
2Not available as factory equipment.
245/40 R18 97V XL (Extra Load) M+S.
!Winter tires on rims with different wheel
offset front vs. rear cannot be rotated.

440 Technical data
Rims and tires
ModelCLS 550 (AMG Sport Package*)CLS 63 AMG
Rims (light alloy)8.5Jx18H28.5 J x 18 H2
Wheel offset0.98 in (25 mm)0.98 in (25 mm)
Summer tires1
1Radial-ply tires
– –
Winter tires1,2
2Not available as factory equipment.
245/40 R18 97V XL (Extra Load) M+S.245/40 R18 97V XL (Extra Load) M+S.
ModelCLS 63 AMG (Performance Package*)
Rims (light alloy)8.5Jx19H2
Wheel offset0.98 in (25 mm)
Summer tires1
1Radial-ply tires
–
Winter tires1,2,3
2Not available as factory equipment.3Maximum permissible vehicle speed of 137 mph (220 km/h).
245/35 R19 93V XL (Extra Load) M+S.

441 Technical data
Rims and tires
Mixed size tires
ModelCLS 550CLS 550 (AMG Sport Package*)
Front axle:
Rims (light alloy)8.5Jx18H28.5Jx18H2
Wheel offset1.10 in (28 mm)0.98 in (25 mm)
Summer tires1
1Radial-ply tires
245/40 R18 93Y255/40 ZR18 95Y
or
255/40 ZR18 99Y XL (Extra Load)
All-season tires1245/40 R18 93V M+S –
Rear axle:
Rims (light alloy)9.5Jx18H29.5Jx18H2
Wheel offset1.30 in (33 mm)1.10 in (28 mm)
Summer tires1,2
2Must not be used with snow chains.
275/35 R18 95Y285/35 ZR18 97Y
or
285/35 ZR18 101Y XL (Extra Load)
All-season tires1,2275/35 R18 95V M+S –

442 Technical data
Rims and tires
ModelCLS 63 AMGCLS 63 AMG*
Front axle:
Rims (light alloy)8.5 J x 18 H28.5 J x 19 H2
Wheel offset0.98 in (25 mm)0.98 in (25 mm)
Summer tires1
1Radial-ply tires
255/40 ZR18 99Y XL (Extra Load)255/35 ZR19 96Y XL (Extra Load)
Winter tires – –
Rear axle:
Rims (light alloy)9.5 J x 18 H29.5Jx19H2
Wheel offset1.10 in (28 mm)1.10 in (28 mm)
Summer tires1,2
2Must not be used with snow chains.
285/35 ZR18 101Y XL (Extra Load)285/30 ZR19 98Y XL (Extra Load)
Winter tires – –