MERCEDES-BENZ CLS550 2007 W219 Owner's Manual

450 Technical dataFuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Power steering
CLS 550
approx. 1.0 US qt (0.9 l)
MB Power Steering Fluid (Pentosin CHF 11S
or, depending on vehicle production date,
Chevron Texaco PSF 9109)
1
1For detailed information, please refer to the Factory Approved Service Products pamphlet (USA only) or contact an authorized Mercedes-Benz Center.
CLS 63 AMG
approx. 1.3 US qt (1.2 l)
Front wheel hubs
CLS 550
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
CLS 63 AMG
approx. 3.2 oz (90 g) each
Brake system
All models
0.63 US qt (0.6 l)
MB Brake Fluid (DOT 4+)
Cooling system
CLS 550
11.9 US qt (11.3 l)
MB 325.0 Anticorrosion/Antifreeze
CLS 63 AMG
12.5 US qt (11.8 l)
Fuel tank
All models
21.12 US gal (80.0 l)
Premium unleaded gasoline
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)
including a reserve of
CLS 550
2.38 US gal (9.0 l)
CLS 63 AMG
3.7 US gal (14.0 l)
Air conditioning system
All models
R-134a refrigerant and special PAG lubricant
oil (never R-12)
Windshield washer system
All models
4.8 US qt (4.5 l)
MB Windshield Washer Concentrate
2
2Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing or MB Windshield Washer Concentrate “MB SummerFit” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 456).Windshield washer and head-
lamp cleaning* system
All models
6.9 US qt (6.5 l)

451 Technical data
Fuels, coolants, lubricants etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance Sys-
tem (U.S. vehicles) or FSS PLUS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory Ap-
proved Service Products pamphlet (USA
only), or contact an authorized
Mercedes-Benz Center.
Engine oil additivesAir conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system.
Brake fluid
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will pro-
vide you with additional information.
!
Using engine oils and oil filters of specifica-
tion other than those expressly required for the
Maintenance System (U.S. vehicles) or
FSS PLUS (Canada vehicles), or changing of oil
and oil filter at change intervals longer than
those called for by the Maintenance System
(U.S. vehicles) or FSS PLUS (Canada vehicles)
will result in engine or emission control system
damage not covered by the Mercedes-Benz Lim-
ited Warranty.Please follow Maintenance System (U.S. vehi-
cles) or FSS PLUS (Canada vehicles) recommen-
dations for scheduled oil changes. Failure to do
so could result in engine or emission control sys-
tem damage not covered by the Mercedes-Benz
Limited Warranty.
!
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from blending
oil additives are not covered by the
Mercedes-Benz Limited Warranty.
!
Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the system
will occur.
Warning!
G
During vehicle operation, the boiling point of
the brake fluid is continuously reduced
through the absorption of moisture from the
atmosphere. Under extremely strenuous op-
erating conditions, this moisture content
can lead to the formation of bubbles in the
system, thus reducing the system’s efficien-
cy.
Therefore, the brake fluid must be replaced
regularly. Refer to your vehicle’s Mainte-
nance Booklet for replacement interval.

452 Technical dataFuels, coolants, lubricants etc.Premium unleaded gasoline
Fuel requirements
Only use premium unleaded fuel:
The octane number (posted at the pump)
m u s t b e 9 1 m i n . I t i s a n a v e r a g e o f b o t h t h e
Research Octane Number (RON) and the
Motor Octane Number (MON):
(RON+MON)/2. This is also known as the
ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not exceed
10%; MTBE must not exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional cosolvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains 10%
ethanol and 90% unleaded gasoline, can be
used.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.
Warning!
G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious per-
sonal injury.
Never allow sparks, flame or smoking mate-
rials near gasoline!
Turn off the engine before refueling.
Whenever you are around gasoline, avoid in-
haling fumes and skin or clothing contact,
extinguish all smoking materials.
Direct skin contact with fuels and the inha-
lation of fuel vapors can damage your
health.
!
To maintain the engine’s durability and per-
formance, premium unleaded gasoline must be
used. If premium unleaded gasoline is not avail-
able and low octane fuel is used, follow these
precautions:


Have the fuel tank only partially filled with
unleaded regular gasoline and fill up with
premium unleaded gasoline as soon as pos-
sible.


Avoid full throttle driving and abrupt acceler-
ation


Do not exceed an engine speed of 3000 rpm
if the vehicle is loaded with a light load such
as two persons and no luggage.


Do not exceed
2/3 of maximum accelerator
pedal position if the vehicle is fully loaded or
operating in mountainous terrain.

453 Technical data
Fuels, coolants, lubricants etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build-up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to
engine performance problems such as:

Warm-up hesitation


Unstable idle


Knocking/pinging


Misfire


Power lossIn areas where carbon deposits may be
encountered due to lack of availability of
gasolines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to Factory
Approved Service Products Pamphlet (USA
only) or contact an authorized
Mercedes-Benz Center for a listing of ap-
proved product(s). Follow directions on
product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary costs and
may be harmful to the engine operation.
Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
!
Damage or malfunction resulting from poor
fuel quality or from blending additional fuel addi-
tives other than those tested and approved by us
for use on Mercedes-Benz vehicles listed in the
Factory Approved Service Products pamphlet
are not covered by the Mercedes-Benz Limited
Warranty.
For a listing of approved products, refer to the
Factory Approved Service Products pamphlet
(USA only) or contact an authorized
Mercedes-Benz Center.
!
Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz Lim-
ited Warranty.

454 Technical dataFuels, coolants, lubricants etc.If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for re-
placement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.For information on other Mercedes-Benz
approved products of equal specification,
refer to the Factory Approved Service
Products pamphlet (USA only) or contact
an authorized Mercedes-Benz Center.
To provide important corrosion protection,
the solution must be at least 50% anticor-
rosion/antifreeze (equivalent to freeze
protection to approximately -35°F
[-30°C]). If you use a solution that is more
than 55% anticorrosion/antifreeze (freeze
protection to approximately -49°F
[-45°C]), the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and
MB 325.0 Anticorrosion/Antifreeze
should be used to bring it up to the proper
level (have cooling system checked for
signs of leakage). Please make sure the
mixture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult an authorized Mercedes-Benz Center.

455 Technical data
Fuels, coolants, lubricants etc.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum parts. Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.
Therefore, the following product is strongly
recommended for use in your vehicle:
MB 325.0 Anticorrosion/Antifreeze agent.Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantityModel
Approx. freeze protection-35°F (-37°C)
-49°F (-45°C)
CLS 550
6.0 US qt (5.7 l)
6.6 US qt (6.2 l)
CLS 63 AMG
6.2 US qt (5.9 l)
6.9 US qt (6.5 l)

456 Technical dataFuels, coolants, lubricants etc.Windshield washer system and head-lamp cleaning system*
Both the windshield washer and headlamp
cleaning system* are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approximately 6.9 US qt. (6.5 l).

Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed windshield washer sol-
vent/antifreeze, depending on ambient
temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and water:


1 part “MB SummerFit” to 100 parts
water
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] water).
For temperatures below freezing point use
MB Windshield Washer Concentrate
“MB SummerFit” and commercially avail-
able premixed windshield washer
solvent/antifreeze:


1 part “MB SummerFit” to 100 parts
solvent
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] solvent).
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You can be seriously burned.

457 Index
A
ABS 91
Indicator lamp 342
Messages in display 358, 372
Accelerator position, automatic
transmission 175
Accessory weight 323
Accident 58
Active Bi-Xenon headlamps see Head-
lamps
Active head restraints 83
resetting 401
Adaptive Damping System 231
Adjusting 41
ADS 231
Air bags 66
Children 67
Front, Driver 69
Front, Passenger 69
Knee bag 70
Safety guidelines 68
Side impact 70
Window curtain 70Air conditioning refrigerant 451
Air conditioning system see Climate con-
trol system 203
Air conditioning, Cooling 194, 203
Air distribution 197
Air pressure 323
Air pressure see Tire inflation pressure
Air pump, electric 417
Air recirculation mode 200
Air vents 191
Air volume 198
Airmatic DC (Dual Control) 231
Message in display 389, 390
Suspension tuning 231
Vehicle level control 231
Alarm
Audible alarm and flashing exterior
lamps (Panic alarm) 90
Canceling 100
Visual 99
Alarm system see Anti-theft systems
Alignment bolt (vehicle tool kit) 393, 415AMG menu 147
Lap analysis 150
Overall analysis 150
RACETIMER 148
Vehicle supply voltage 148
Anticorrosion/antifreeze 455
Antilock Brake System see ABS
Anti-theft systems 99
Anti-theft alarm system 99
Immobilizer 99
Aquaplaning see Hydroplaning
Ashtrays 249
Aspect ratio 323
AUDIO menu 150
Audio search function 165
Audio system
CD mode 151
Selecting radio station 151
Selecting satellite radio station* 151
Auto-dimming, Rear view mirrors 185
Automatic central locking, Control
system 165

458 IndexAutomatic climate control (4-zone) 190
Air recirculation mode 200
Deactivating 195
Rear window defroster 189
Setting the temperature 197
Automatic headlamp mode 129
Automatic lighting control, Interior
lighting 135
Automatic locking when driving 165
Automatic shift program 177
Automatic transmission
Accelerator position 175
Automatic shift program 177
Emergency operation (limp-home
mode) 184
Gear ranges 176
Gear selector lever 171
Gear selector lever control one-touch
gearshifting 178
Gear selector lever positions 173
Gear shifting malfunctions 184
Kickdown 175
Kickdown, manual shift program
CLS 63 AMG 183Manual shift program
CLS 63 AMG 181
Program mode selector switch 177
Shifting procedure 172
Starting the engine 51
Steering wheel gearshift control
one-touch gearshifting* 179
Auxiliary bulbs 404
Messages in display 381
B
BabySmart
TM
Airbag deactivation system 76
Self-test 77
Backrest
Seat 42
Seat, multicontour* 122
Backup lamps see Reverse lamps
Bar 323
BAS 92
Batteries, SmartKey
Checking battery condition 110
Replacing 402
Batteries, SmartKey with KEYLESS-GO*
Checking battery condition 110
Replacing 402Batteries, vehicle 420
Charging 422
Disconnecting 421
Jump starting 423
Messages in display 370, 371
Reconnecting 422
Reinstalling 422
Removing 421
Bead 323
Beverage holder see Cup holders
Bi-Xenon headlamps see
Headlamps 128
Block heater* (Canada only) 328
Brake fluid
Checking 285
Brake lamps
Cleaning lenses 336
Replacing bulbs 406
Brake pads
Message in display 371
Brakes
High-performance brake system
(CLS 63 AMG only) 274
Warning lamp 344
Break-in period 270
Bulbs, replacing see Replacing bulbs

459 Index
C
California retail buyers and lessees, impor-
tant notice for 11
Can holder see Cup holders
Capacities and recommended
fuels/lubricants 449
Cargo tie-down rings 243
Carpets, cleaning 339
Catalytic converter 281
CD player 151
Center console
Lower part 30
PASS AIR BAG OFF indicator
lamp 353
Upper part 29
Central locking
Automatic 118
Locking/unlocking from inside 118
Switching on/off (control
system) 165
Central locking switch 118
Certification label 300
Checking tire pressure electronically with
the Advanced Tire Pressure Monitoring
System* (Advanced TPMS*), (Canada
only) 309Checking tire pressure electronically with
the Tire Pressure Monitoring System
(TPMS), (USA only) 306
Children in the vehicle 84
Air bags 67
Indicator lamp, front passenger front
air bag 76
Infant and child restraint systems 84
LATCH-type child seat anchors 88
Override switch for rear passenger
compartment 89
Cigarette lighter 250
Climate control system
Air conditioning refrigerant 451
Air conditioning, Cooling 203
Air distribution 197
Air recirculation mode 200
Air volume 198
Automatic mode 196
Control panel, Rear 204
Deactivating system 196
Front defroster 199
Maximum cooling MAX COOL 200
Rear climate control 204
Residual engine heat (REST) 203Clock 27, 159
Setting time 159
Cockpit 24
Cold tire inflation pressure 323
Collapsible tire
Inflating 416
Collapsible wheel chock 395
COMAND see separate operating instruc-
tions
Combination filter with pollutant-sensitive
air-recirculation mode 202
Combination switch 55, 132
Control system 141
Functions 145
Multifunction display 141
Multifunction steering wheel 142
Resetting to factory default 155
Control system menus 144, 145
AUDIO 150
Distronic* 153
NAV* 152
Settings 154
Standard display 147
TEL* 168
Trip computer 167
Vehicle status message memory 153