coolant temperature MERCEDES-BENZ CLS63AMG 2007 W219 User Guide

375 Practical hints
What to do if …
Display symbol
Display messages
Possible cause/consequence
Possible solution
Z
Coolant
Stop, turn engine off
The poly-V-belt could be broken.

Stop the vehicle in a safe location and immediately
turn off the engine.

Check the poly-V-belt.
If it is broken:

Do not continue to drive. Otherwise the engine will
overheat due to an inoperative water pump which
may result in damage to the engine. Notify an au-
thorized Mercedes-Benz Center.
If it is intact:

Do not continue to drive the vehicle with this mes-
sage displayed. Doing so could result in serious en-
gine damage that is not covered by the
Mercedes-Benz Warranty.

Observe the coolant temperature indicator in the
instrument cluster (
page 26).

Drive immediately to the nearest authorized
Mercedes-Benz Center.

376 Practical hintsWhat to do if …Display symbol
Display messages
Possible cause/consequence
Possible solution
Z
The cooling fan for the coolant is
malfunctioning.

Observe the coolant temperature indicator in the
instrument cluster (
page 26).
If the coolant temperature is under 120°C, you may
continue driving to an authorized Mercedes-Benz
Center.

Avoid placing heavy loads on the engine (e.g. by
driving uphill) as well as stop-and-go traffic.

Have the fan replaced as soon as possible.
±
Display malfunction
Visit workshop
Certain electronic systems are
unable to relay information to
the control system. The follow-
ing systems may have failed:

Coolant temperature display


Tachometer


Cruise control display

Have the electronic systems checked by an autho-
rized Mercedes-Benz Center.
Engine
Service
There may be a malfunction in:

the fuel injection system


the ignition system


the exhaust system

Have the engine checked as soon as possible by an
authorized Mercedes-Benz Center.

450 Technical dataFuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Power steering
CLS 550
approx. 1.0 US qt (0.9 l)
MB Power Steering Fluid (Pentosin CHF 11S
or, depending on vehicle production date,
Chevron Texaco PSF 9109)
1
1For detailed information, please refer to the Factory Approved Service Products pamphlet (USA only) or contact an authorized Mercedes-Benz Center.
CLS 63 AMG
approx. 1.3 US qt (1.2 l)
Front wheel hubs
CLS 550
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
CLS 63 AMG
approx. 3.2 oz (90 g) each
Brake system
All models
0.63 US qt (0.6 l)
MB Brake Fluid (DOT 4+)
Cooling system
CLS 550
11.9 US qt (11.3 l)
MB 325.0 Anticorrosion/Antifreeze
CLS 63 AMG
12.5 US qt (11.8 l)
Fuel tank
All models
21.12 US gal (80.0 l)
Premium unleaded gasoline
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)
including a reserve of
CLS 550
2.38 US gal (9.0 l)
CLS 63 AMG
3.7 US gal (14.0 l)
Air conditioning system
All models
R-134a refrigerant and special PAG lubricant
oil (never R-12)
Windshield washer system
All models
4.8 US qt (4.5 l)
MB Windshield Washer Concentrate
2
2Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing or MB Windshield Washer Concentrate “MB SummerFit” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 456).Windshield washer and head-
lamp cleaning* system
All models
6.9 US qt (6.5 l)

454 Technical dataFuels, coolants, lubricants etc.If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for re-
placement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.For information on other Mercedes-Benz
approved products of equal specification,
refer to the Factory Approved Service
Products pamphlet (USA only) or contact
an authorized Mercedes-Benz Center.
To provide important corrosion protection,
the solution must be at least 50% anticor-
rosion/antifreeze (equivalent to freeze
protection to approximately -35°F
[-30°C]). If you use a solution that is more
than 55% anticorrosion/antifreeze (freeze
protection to approximately -49°F
[-45°C]), the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and
MB 325.0 Anticorrosion/Antifreeze
should be used to bring it up to the proper
level (have cooling system checked for
signs of leakage). Please make sure the
mixture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult an authorized Mercedes-Benz Center.

456 Technical dataFuels, coolants, lubricants etc.Windshield washer system and head-lamp cleaning system*
Both the windshield washer and headlamp
cleaning system* are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approximately 6.9 US qt. (6.5 l).

Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed windshield washer sol-
vent/antifreeze, depending on ambient
temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and water:


1 part “MB SummerFit” to 100 parts
water
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] water).
For temperatures below freezing point use
MB Windshield Washer Concentrate
“MB SummerFit” and commercially avail-
able premixed windshield washer
solvent/antifreeze:


1 part “MB SummerFit” to 100 parts
solvent
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gallon [4.0 l] solvent).
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You can be seriously burned.

460 IndexControl system submenus
Convenience 165
Instrument cluster 157
Lighting 161
Time/Date 159
Vehicle 164
Convenience submenu 165
Activating easy-entry/exit
feature* 166
Setting parking position for exterior
rear view mirror 166
Coolant
Checking level 290
Messages in display 373, 374, 375
Temperature 282
Temperature indicator 139
Warning lamp 347
Corner-illuminating front fog lamps* 132
Cruise control 215
Canceling 217
Driving downhill 216
Driving uphill 216
Fine adjustment 218
Lever 224
Saving current speed 216
Setting speed 216Cruise control lever 215, 224
Cup holders 247
Curb weight 323
D
Date display, setting 160, 161
Daytime running lamp mode 130
Setting 161
Deceleration
With Distronic* 222
Deep water see Standing water
Defogging windshield 199
Defrosting
Front 199
Rear window 189
Delayed shut-off
Exterior lamps 163
Interior lighting 164
Department of Transportation see DOT
Dialing
A number (telephone) 170
Difficulties
While driving 58
With starting 52
Digital clock see Clock
Digital speedometer 147Dimensions, vehicle 448
Direction of rotation (tires) 295
Displays
Digital speedometer 147
Distronic* 221
Maintenance service indicator
message 329
Messages in display 356
Multifunction display 141
Outside temperature 141, 158
Selecting 158
Symbol messages 370
Text messages 358
Vehicle status message memory 153
Vehicle system settings, Control
system 154
Distance
Decreasing in Distronic* 227
Increasing in Distronic* 227
Warning function 227
Distance to empty (range)
Trip computer 167

465 Index
I
Identification labels 434
Identification Number, Vehicle (VIN) 435
Ignition 38, 40
Immobilizer 99
Indicator lamps see Lamps, indicator and
warning
Infant and child restraint systems see Chil-
dren in the vehicle
Inflation pressure see
Tires, Inflation pressure 301
Information button (Tele Aid) 261
Inside door handle 111
Installing
Wiper blades 411
Instrument cluster 26, 138
Coolant temperature indicator 139
Illumination brightness 138
Lamps 342
Messages in the multifunction
display 356
Multifunction display 141
Outside temperature indicator 140Instrument lighting see Instrument cluster,
Illumination brightness 138
Instrument panel see Instrument
cluster 138
Instruments and controls see
Cockpit 138
Interior lighting 135
Delayed shut-off 164
Interior rear view mirror 47, 185
Auto dimming 185
Interior storage space see Storage com-
partments
J
Jack 394
Jacking up the vehicle 414
Jump starting 423
K
Key, Mechanical 396
Loss of 110Key, SmartKey
Battery check lamp 105
Checking batteries 110
Factory setting 103
Global locking 104, 105
Global unlocking 104
Locking/unlocking 102, 105
Loss of 110
Messages in display 378
Opening and closing the power
tilt/sliding sunroof 210
Opening and closing the
windows 210
Remote control 102
Replacing batteries 402
Restoring to factory setting 105
Selective setting 104
Starter switch positions 38
Starting the engine 51, 52
Turning off the engine 60