run flat MERCEDES-BENZ CLS63AMG 2007 W219 User Guide

418 Practical hintsFlat tire
Detach the electric air pump.

Stow electrical plug3 and air hose4
behind flap1 and place the air pump
back in the trunk.Lowering the vehicle

Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.
1-5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of 96 lb-ft
(130 Nm).

Before storing the jack in the trunk, it
should be fully collapsed.
Warning!
G
Follow recommend inflation pressures.
Do not overinflate tires. Overinflating tires
can result in sudden deflation (blowout)
because they are more likely to become
punctured or damaged by road debris,
potholes, etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.i
Vehicles with Advanced TPMS*:
Do not activate the tire inflation pressure moni-
tor (page 309) until a full size wheel/tire with
functioning sensor has been placed back into
service on the vehicle.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
96 lb-ft (130 Nm).i
Wrap the damaged wheel in the protective
film that comes with the spare wheel and put the
wheel in the trunk.
You can also place the damaged wheel down into
the spare wheel well. In this case, you must stow
the luggage bowl in the trunk.


419 Practical hints
Flat tire
MOExtended system*
The MOExtended system allows you to
continue driving your vehicle even if there
is a total loss of pressure in one or more
tires.
You may only use the MOExtended system
in conjunction with Tire Pressure Monitor-
ing System (U.S. vehicles), Run Flat Indica-
tor (Canada vehicles), or Advanced Tire
Pressure Monitoring System* (Canada
only).!
The maximum distance in emergency mode
depends on the vehicle’s load. It is 30 miles
(50 km) if the vehicle is partially loaded and
18 miles (30 km) if the vehicle is fully loaded.
The point at which the maximum driving distance
begins in emergency mode is when the warning
message appears in the multifunction display
indicating that there is a loss of tire inflation
pressure.
Do not exceed the maximum speed of 50 mph
(80 km/h).
Warning!
G
In emergency mode, your vehicle’s driving
characteristics are diminished in such situa-
tions as:

driving around curves


while braking


while accelerating rapidly
Therefore, your driving style must be adapt-
ed accordingly. Avoid abrupt steering and
driving maneuvers, as well as driving over
obstacles (road curbs, potholes, or off-road
areas). This is especially important if the
vehicle is heavily loaded.
The emergency driving distance that can be
achieved greatly depends on the demands
placed on the vehicle. Depending on speed,
load, driving maneuvers, road conditions,
outside temperature, etc., the distance can
be significantly shorter or, if the vehicle is
driven cautiously, somewhat longer.
Do not continue driving in emergency mode
if

you notice knocking sounds


the vehicle starts to shake


smoke develops and you smell rubber


ESP
® is intervening continuously


you notice tears on the tire sidewalls
After driving in emergency mode, you must
have the rims inspected by an authorized
Mercedes-Benz Center to check if they are
suitable for further use. The failed tire must
be replaced in any case.
i
When replacing individual or all tires on the
vehicle, make sure only matching tires marked
with “MOExtended” are mounted in the size
specified for your vehicle (
page 444).

425 Practical hints
Towing the vehicle
Towing the vehicle
Mercedes-Benz recommends that the
vehicle be transported with all wheels off
the ground using flatbed or appropriate
wheel lift/dolly equipment. This method is
preferable to other types of towing.
When circumstances do not permit the
recommended towing methods, the
vehicle may be towed with all wheels on
the ground or front wheels raised only so
far as necessary to have the vehicle moved
to a safe location where the recommended
towing methods can be employed.!
Do not tow-start the vehicle.
!
Use flatbed or wheel lift/dolly equipment
with SmartKey in starter switch turned to
position0.
Do not tow with sling-type equipment. Towing
with sling-type equipment over bumpy roads will
damage radiator and supports.
To prevent damage during transport, do not tie
down vehicle by its chassis or suspension parts.
Switch off the automatic central (
page 165)
locking.
Warning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the brake sys-
tem


there is a malfunction in the power sup-
ply or in the vehicle’s electrical system
as that will be necessary to adequately con-
trol the towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the SmartKey
is in starter switch position2.
If the SmartKey is left in the starter switch
position0 for an extended period of time, it
can no longer be turned in the switch. In this
case, the steering is locked. To unlock,
remove SmartKey from starter switch and
reinsert.
Warning!
G
With the engine not running, there is no
power assistance for the steering system. In
this case, it is important to keep in mind that
a considerably higher degree of effort is nec-
essary to steer the vehicle. Adapt your driv-
ing accordingly.!
If the vehicle is towed with the front axle
raised, the gear selector lever must be in
positionN and the engine must be shut off
(SmartKey in starter switch position0 or1).
Active braking action through the ESP
® may
otherwise seriously damage the brake system.
When towing the vehicle with all wheels on the
ground, the selector lever must be in positionN
and the SmartKey must be in starter switch
position2.
When towing the vehicle with all wheels on the
ground or the front axle raised, the vehicle may
be towed only for distances up to 30 miles
(50 km) and at a speed not to exceed 30 mph
(50 km/h).

429 Practical hintsFuses
Main fuse box in passenger compartment
1CoverOpening

Open the front passenger door.

Insert flat, blunt object as a lever in into
on the edge of cover1 at the position
indicated by the arrow.

Loosen cover1 from the dashboard
using lever.

Using your hands, pull cover1 in the
direction of the arrow and remove.
Closing

Hook cover1 into the opening at the
front.

Press cover1 back on until it engag-
es.
Fuse box in trunk
2Cover
3Catches
Turn catches3 counter-clockwise
and remove cover2.
!
Do not use sharp objects such as a screw
driver to open the fuse box cover1 in the dash-
board, as this could damage it.

438 Technical dataRims and tires!
Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:


MO = M
ercedes-Benz O
riginal equipment
tires
AMG vehicles:
Does not apply to all approved tires on AMG
vehicles. For information on tested and ap-
proved tires for AMG vehicles, contact an au-
thorized Mercedes-Benz Center.


MOE = M
ercedes-Benz O
riginal E
xtended
(tires with limited run-flat characteristics)
original equipment tires
Using tires other than those approved by
Mercedes-Benz may result in damage that is
not covered by the Mercedes-Benz Limited
Warranty.
i
For information on driving with MOExtended
tires, see “MOExtended system*” (
page 313).
!
Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as


poor handling characteristics


increased noise


increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the re-
sult.
i
Further information on tires and rims is
available at any authorized Mercedes-Benz
Center. A placard with the recommended tire in-
flation pressures is located on the driver’s door
B-pillar. Some vehicles may have supplemental
tire inflation pressure information for driving at
high speeds (
page 302) or for vehicle loads
less than the maximum loaded vehicle condition
(
page 302). If such information is provided, it
can be found on the placard located on the in-
side of the fuel filler flap. The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
i
The following pages also list the approved
wheel rim and tire sizes for equipping your vehi-
cles with winter tires. Winter tires are not avail-
able as standard or optional factory equipment,
but can be purchased from an authorized
Mercedes-Benz Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire config-
uration on your vehicle (Appearance Package,
AMG Sport Package etc.), equipping your vehicle
with winter tires approved for your vehicle model
may also require the purchase of two or four
wheel rims of the recommended size for use with
these winter tires. See an authorized
Mercedes-Benz Center for more information.

444 Technical dataRims and tiresMOExtended tires*Model
CLS 550
CLS 550 (AMG Sport Package*)
CLS 550
CLS 550 (AMG Sport Package*)
Front axle:Rims (light alloy)
8.5 J x 18 H2
8.5 J x 18 H2
Wheel offset
1.10 in (28 mm)
1.10 in (28 mm)
Summer tires
1,2
1Radial-ply tires.2Must be used in conjunction with Tire Pressure Monitoring System (U.S. vehicles), Run Flat Indicator (Canada vehicles), or
Advanced Tire Pressure Monitoring System* (Canada only).
245/40 R18 93Y MOExtended
–
Winter tires
1,2,3
3Not available as factory equipment.
–
245/40 R18 97V XL (Extra Load) M+S.MOExtended
Rear axle:Rims (light alloy)
9.5Jx18H2
8.5Jx18H2
Wheel offset
1.30 in (33 mm)
0.71 in (18 mm)
Summer tires
1,2,4
4Must not be used with snow chains.
275/35 R18 95Y MOExtended
–
Winter tires
1,2,3
–
245/40 R18 97V XL (Extra Load) M+S .MOExtended

467 Index
Lighting 128
Automatic headlamp mode 129
Combination switch 132
Daytime running lamp mode 130
Door entry lamps 137
Exterior lamp switch 128
Front fog lamps 131
High beams 132
Instrument cluster illumination 138
Interior 135
Locator lighting 131
Low beam 128
Manual headlamp mode 129
Night security illumination 131
Parking lamps 128
Rear fog lamp 131
Settings (control system) 161
Trunk lamp 137
Limp-home mode 184
Loading see Vehicle loading
Loading the vehicle 296Locator lighting 131, 162
Lock button (KEYLESS-GO*)
Door handle 62
Trunk lid 109
Locking the vehicle 59
In an emergency 397
Locking/Unlocking, SmartKey 36, 104
Locking/Unlocking, SmartKey with
KEYLESS-GO* 37
Loss of
Key, Mechanical 110
Key, SmartKey 110
Key, SmartKey with
KEYLESS-GO* 110
Loss of Service and Warranty Information
Booklet 433
Low beam headlamps 55
Replacing bulbs 408
Switching on 55
Lubricants 449
Lumbar support 121M
Main Dimensions 448
Maintenance 12
Calling up service indicator 331
Clearing service indicator
message 330
FSS PLUS (Canada vehicles) 330
Maintenance System 330
Resetting service indicator 331
Service indicator message 329
Service term exceeded 330
Manual headlamp mode 129
Manual shift program CLS 63 AMG 181
Deactivating 183
Maximum load rating, Tires 324
Maximum loaded vehicle weight 324
Maximum tire inflation pressure 324
Mechanical key 396
Memory functions 125
Menus see Control system menus
Microphone, Hands-free 31

471 Index
Refueling 283
Regular checks 285
Reminder, seat belts see Seat belts, Tell-
tale
Remote control see Key, SmartKey
Remote door unlock (Tele Aid) 262
Replacing bulbs
Additional turn signals 407
Brake lamps 407
Front lamps 407
Headlamps 405
High beam headlamps 408
High mounted brake lamp 407
License plate lamps 409
Low beam headlamps 408
Parking lamps 409
Side marker lamps 407
Tail lamps 409
Turn signal lamps 408
Reporting safety defects 18
Research octane number see RON
Reserve fuel
Message in display 378Reset button in the instrument
cluster 138, 155
Reset tool (Active head restraints) 401
Restraint system see Children in the vehi-
cle
Retaining hooks 243
Reverse gear position, Automatic
transmission 171, 173
Rims 324, 438
Roadside assistance 12
Button 260
RON 284
Roof rack* 239
Rotating tires 326
Rubber parts, cleaning 338
Run Flat Indicator* 304
S
Safety
Driving safety systems 91
Occupant 64
Reporting defects 18
Safety belts see Seat beltsSatellite radio* 151
Seat belt force limiter 81
Seat belts 78
Children in the vehicle 84
Cleaning 339
Fastening 48
Height adjustment 50
Proper use of 50, 79
Safety guidelines 68
Telltale 27, 348, 349
Warning lamp 348, 349
Seating capacity 297
Seats 41, 120
Adjusting 41
Easy entry/exit feature* 45
Heater* 123
Memory function 125
Multicontour seat* 122
Ventilation* 124
Securing cargo
Cargo tie-down rings 243
Selecting display 158

474 IndexTele Aid 257
Emergency calls 258
Information 261
Initiating an emergency call
manually 259
Messages in display 386
Remote door unlock 262
Roadside assistance 260
SOS button 259
Stolen vehicle Recovery services 263
System self-check 258
Telephone cradle
Changing 256
Telephone* 28, 254
Answering/ending a call 169
Changing mobile phone cradle 256
Compartment 244
Hands-free microphone 31
Inserting in cradle 255
Installing a different mobile phone
cradle 256
Messages in the display 389
Operation 168
Phone book 170
Redialing 170
Removing from cradle 256Temperature
Engine 54
Interior temperature 197
Outside temperature 158
Tether anchorage points, see Children in
the vehicle
Tie-down rings, Trunk 243
Tightening torque, Wheel bolts 418
Time
Setting 159
Synchronizing 159
TIN 325
Tire and Loading Information
Placard 296
Terminology 323
Tire inflation pressure
Checking 301
Placard on the fuel filler flap 297
Tire Pressure Monitoring System (TPMS),
(USA only)
Checking tire pressure
electronically 306
Tires
Advanced Tire Pressure Monitoring
System* (Advanced TPMS*) (Canada
only) 309Advanced TPMS* malfunction
telltale 351
Air pressure 301
Care and maintenance 294
Cleaning 295
Combination low tire pressure/TPMS
malfunction telltale, USA only 27
Direction of rotation, Spinning 295
Driving instructions 275
Important notes, Tire inflation
pressure 302
Inflation pressure 301, 302
Information placard 297
Inspection 294
Load rating 325
Low tire pressure telltale* (Canada
only) 27, 351
Messages in display 367, 388
MOExtended* 313, 419
Ply composition and material
used 325
Problems with
under-/overinflation 312
Retreads 293
Rims and tires 438
Rotation 326