oil MERCEDES-BENZ CLS63AMG 2007 W219 Owner's Guide

449 Technical data
Fuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.
Capacities
Vehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercedes-Benz.
Please refer to the Factory Approved
Service Products pamphlet (USA only), or
inquire at an authorized Mercedes-Benz
Center.
Warning!
G
Comply with all valid regulations with re-
spect to handling, storing and disposing of
service fluids. Otherwise you could endan-
ger persons or the environment.
Keep service fluids out of the reach of chil-
dren.
For health reasons, you should prevent ser-
vice fluids from coming into direct contact
with your skin or clothing.
If a service fluid is swallowed, contact a phy-
sician immediately.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
CLS 550
9.0 US qt (8.5 l)
Approved engine oils
Engine with oil filter including
oil cooler
CLS 63 AMG
9.3 US qt (8.8 l)
Approved engine oils
Automatic transmission
CLS 550
9.7 US qt (9.2 l)
MB Automatic Transmission Fluid
CLS 63 AMG
9.0 US qt (8.5 l)
Rear axle
CLS 550
1.37 US qt (1.3 l)
Hypoid gear oil SAE 85 W 90
CLS 63 AMG
1.27 US qt (1.2 l)

450 Technical dataFuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Power steering
CLS 550
approx. 1.0 US qt (0.9 l)
MB Power Steering Fluid (Pentosin CHF 11S
or, depending on vehicle production date,
Chevron Texaco PSF 9109)
1
1For detailed information, please refer to the Factory Approved Service Products pamphlet (USA only) or contact an authorized Mercedes-Benz Center.
CLS 63 AMG
approx. 1.3 US qt (1.2 l)
Front wheel hubs
CLS 550
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
CLS 63 AMG
approx. 3.2 oz (90 g) each
Brake system
All models
0.63 US qt (0.6 l)
MB Brake Fluid (DOT 4+)
Cooling system
CLS 550
11.9 US qt (11.3 l)
MB 325.0 Anticorrosion/Antifreeze
CLS 63 AMG
12.5 US qt (11.8 l)
Fuel tank
All models
21.12 US gal (80.0 l)
Premium unleaded gasoline
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)
including a reserve of
CLS 550
2.38 US gal (9.0 l)
CLS 63 AMG
3.7 US gal (14.0 l)
Air conditioning system
All models
R-134a refrigerant and special PAG lubricant
oil (never R-12)
Windshield washer system
All models
4.8 US qt (4.5 l)
MB Windshield Washer Concentrate
2
2Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing or MB Windshield Washer Concentrate “MB SummerFit” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 456).Windshield washer and head-
lamp cleaning* system
All models
6.9 US qt (6.5 l)

451 Technical data
Fuels, coolants, lubricants etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance Sys-
tem (U.S. vehicles) or FSS PLUS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory Ap-
proved Service Products pamphlet (USA
only), or contact an authorized
Mercedes-Benz Center.
Engine oil additivesAir conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system.
Brake fluid
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will pro-
vide you with additional information.
!
Using engine oils and oil filters of specifica-
tion other than those expressly required for the
Maintenance System (U.S. vehicles) or
FSS PLUS (Canada vehicles), or changing of oil
and oil filter at change intervals longer than
those called for by the Maintenance System
(U.S. vehicles) or FSS PLUS (Canada vehicles)
will result in engine or emission control system
damage not covered by the Mercedes-Benz Lim-
ited Warranty.Please follow Maintenance System (U.S. vehi-
cles) or FSS PLUS (Canada vehicles) recommen-
dations for scheduled oil changes. Failure to do
so could result in engine or emission control sys-
tem damage not covered by the Mercedes-Benz
Limited Warranty.
!
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from blending
oil additives are not covered by the
Mercedes-Benz Limited Warranty.
!
Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the system
will occur.
Warning!
G
During vehicle operation, the boiling point of
the brake fluid is continuously reduced
through the absorption of moisture from the
atmosphere. Under extremely strenuous op-
erating conditions, this moisture content
can lead to the formation of bubbles in the
system, thus reducing the system’s efficien-
cy.
Therefore, the brake fluid must be replaced
regularly. Refer to your vehicle’s Mainte-
nance Booklet for replacement interval.

452 Technical dataFuels, coolants, lubricants etc.Premium unleaded gasoline
Fuel requirements
Only use premium unleaded fuel:
The octane number (posted at the pump)
m u s t b e 9 1 m i n . I t i s a n a v e r a g e o f b o t h t h e
Research Octane Number (RON) and the
Motor Octane Number (MON):
(RON+MON)/2. This is also known as the
ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not exceed
10%; MTBE must not exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional cosolvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains 10%
ethanol and 90% unleaded gasoline, can be
used.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.
Warning!
G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious per-
sonal injury.
Never allow sparks, flame or smoking mate-
rials near gasoline!
Turn off the engine before refueling.
Whenever you are around gasoline, avoid in-
haling fumes and skin or clothing contact,
extinguish all smoking materials.
Direct skin contact with fuels and the inha-
lation of fuel vapors can damage your
health.
!
To maintain the engine’s durability and per-
formance, premium unleaded gasoline must be
used. If premium unleaded gasoline is not avail-
able and low octane fuel is used, follow these
precautions:


Have the fuel tank only partially filled with
unleaded regular gasoline and fill up with
premium unleaded gasoline as soon as pos-
sible.


Avoid full throttle driving and abrupt acceler-
ation


Do not exceed an engine speed of 3000 rpm
if the vehicle is loaded with a light load such
as two persons and no luggage.


Do not exceed
2/3 of maximum accelerator
pedal position if the vehicle is fully loaded or
operating in mountainous terrain.

453 Technical data
Fuels, coolants, lubricants etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build-up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to
engine performance problems such as:

Warm-up hesitation


Unstable idle


Knocking/pinging


Misfire


Power lossIn areas where carbon deposits may be
encountered due to lack of availability of
gasolines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to Factory
Approved Service Products Pamphlet (USA
only) or contact an authorized
Mercedes-Benz Center for a listing of ap-
proved product(s). Follow directions on
product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary costs and
may be harmful to the engine operation.
Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
!
Damage or malfunction resulting from poor
fuel quality or from blending additional fuel addi-
tives other than those tested and approved by us
for use on Mercedes-Benz vehicles listed in the
Factory Approved Service Products pamphlet
are not covered by the Mercedes-Benz Limited
Warranty.
For a listing of approved products, refer to the
Factory Approved Service Products pamphlet
(USA only) or contact an authorized
Mercedes-Benz Center.
!
Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz Lim-
ited Warranty.

454 Technical dataFuels, coolants, lubricants etc.If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for re-
placement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.For information on other Mercedes-Benz
approved products of equal specification,
refer to the Factory Approved Service
Products pamphlet (USA only) or contact
an authorized Mercedes-Benz Center.
To provide important corrosion protection,
the solution must be at least 50% anticor-
rosion/antifreeze (equivalent to freeze
protection to approximately -35°F
[-30°C]). If you use a solution that is more
than 55% anticorrosion/antifreeze (freeze
protection to approximately -49°F
[-45°C]), the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and
MB 325.0 Anticorrosion/Antifreeze
should be used to bring it up to the proper
level (have cooling system checked for
signs of leakage). Please make sure the
mixture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult an authorized Mercedes-Benz Center.

462 IndexEmergency Tensioning Device see ETD
Emergency, In case of
Batteries, Jump starting 423
First aid kit 391
Flat tire, changing 412
Fuses 428
Hazard warning flasher 134
Instrument cluster, indicator
lamps 342
Roadside Assistance 12
Towing the vehicle 342
Emission control 281
Information label 435
System warranties 10
Vacuum line routing diagram
label 435
Engine 437
Belt layout 436
Block heater* (Canada only) 328
Break-in recommendations 270
Cleaning 334
Compartment 286
Malfunction indicator lamp 345, 346,
373Maximum engine speed 437
Number 434, 435
Starting 51
Starting with KEYLESS-GO* 52
Tachometer 27
Technical data 437
Turning off with KEYLESS-GO* 61
Turning off with the SmartKey 61
Engine compartment
Hood 286
Engine coolant see Coolant 290
Engine oil 287, 449
Adding 289
Additives 451
Changing 451
Checking level 288
Consumption 287
Filler neck 289
Messages in display 377
Oil dipstick 288
Recommended engine oils and oil
filters 451ESP
®
94
Messages in display 358, 372
Warning lamp 343
ETD
Safety guidelines 68
Exterior lamp switch 128
Exterior rear view mirrors 47
Parking position 166, 187
Exterior view 22
F
Factory settings
Resetting 155
SmartKey with KEYLESS-GO* 108
Filler neck, Engine oil 289
First aid kit 391
Flat tire 412
Collapsible tire 415, 416
Jacking up the vehicle 414
Lowering the vehicle 418
Mounting the spare wheel 412, 415
Preparing the vehicle 412
Spare wheel 412

463 Index
Flexible Service System see FSS PLUS
Floormats 253
Fluids
Automatic transmission fluid 449
Brake fluid 450
Capacities 449
Engine coolant 450
Engine oil 449
Power steering fluid 450
Windshield washer and headlamp
cleaning system 450
Fog lamp, rear 131
Fog lamps 131
Messages in display 380, 381, 382,
383, 384
Fog lamps, front
Corner-illuminating* 132
Switching on 131
Front air bags 69
Front lamps see Headlamps
Front passenger front air bag
Messages in display 353
Front passenger front air bag off indicator
lamp 70, 75Front seat head restraints see Head re-
straints
FSS PLUS (Canada vehicles) 330
Fuel
Additives 453
Capacities, Fuel tank 450
Filler flap and cap 283
Filling the tank 283
Fuel reserve warning lamp 348
Premium unleaded gasoline 284
Requirements
Gasoline additives 453
Premium unleaded gasoline 452
Fuel consumption statistics
Since last reset 167
Since start 167
Fuel filler flap 283
Locking/unlocking 283
Opening 283
Fuel tank
Capacity 283
Filler flap 283
Fuels, coolants, lubricants etc. 449
Fuse box in trunk 429Fuses 428
Aids for replacing fuses 428
Fuse box (main) in passenger
compartment 429
Fuse box in trunk 429
Fuse chart 428
Fuse extractor 428
Replacing 428
Spare fuses 428
G
Garage door opener 263
Gasoline see Fuel
GAWR 323
Gear range
Automatic transmission 176
Limiting 176
Shifting into optimal 179, 181
Gear selector lever 171
Cleaning 339
Gearshift pattern 171
Lock 51
Position 172, 173
Shifting procedure 172
Unlocking in an emergency 398

468 IndexMinispare wheel see Spare wheel 391
Mirrors
Adjusting 46
Auto-dimming 185
Exterior rear view mirror 47
Exterior rear view mirror parking
positions 166, 187
Interior rear view mirror 47
Storing exterior mirror parking
position 127
Mobile phone see Telephone*
MOE tires* see MOExtended system*
MOExtended system* 313, 419
MOExtended tires* 313, 444
MON 284
MP3
Selecting track 152
Multicontour seat* 122
Multifunction display 141
Changing settings see Control system
menus and Control system
submenus 141
Selecting language 157Multifunction display messages
ABS 358, 372
Airmatic DC 389, 390
Brake fluid 372
Brake pads 371
Check engine 345, 346
Coolant 373, 374, 375
Cruise control 359
Distronic* 359
Door 370
Engine oil 377
ESP
®
358, 361, 372
Fog lamps 380, 381, 382, 383, 384
Hood 370
Light sensor 383
Parking brake 372
Parking lamps 382
PRE-SAFE®
358, 366
Reserve fuel 378
SmartKey with KEYLESS-GO* 378,
379, 380
SRS 386
Taillamps 384, 385Tele Aid 386
Telephone* 389
Tires 388
Trunk 370
Turn signals 385
Windshield washer fluid 389
Multifunction steering wheel 28, 142
Button operation 142
N
NAV* menu (Control system) 152
Navigation system see separate COMAND
operating instructions
Net, parcel 246
Neutral gear position, Automatic
transmission 171, 173
Night security illumination 131
Normal occupant weight 324
Number, Vehicle Identification (VIN) 434

469 Index
O
Occupant Classification System see OCS
Occupant distribution 324
Occupant safety 64
Air bags 66
Children and air bags 67
Children in the vehicle 84
Fastening the seat belt 48
Front passenger front air bag off indica-
tor lamp 75
Infant and child restraint systems 84
LATCH type child seat anchors 88
OCS 71
Seat belts 48, 68
OCS 71
Self-test 76
Odometer 27
Oil
Consumption 287
Oil see Engine oil
One-touch gearshifting
Gear selector lever 178
Steering wheel gearshift
control* 179Operating safety 16
Ornamental moldings, cleaning 335
Outside temperature see Displays
Overdue maintenance service 329
Overhead control panel 31
P
Paintwork, Cleaning 334
Panic alarm 90
Parcel net
Front passenger footwell 246
Parking 59
On hills 59
Over things that burn, Potential
consequences 59
Parking brake 53, 59
Message in display 372
Parking lamps 405
Replacing bulbs 409
Parking position
Exterior rear view mirrors 127, 166
Gear position 51
Parktronic system (Parking assist)* see
Parktronic*Parktronic* 235
Activating/deactivating 238
Cleaning system sensors 336
Malfunctioning 238
Minimum distance 236
Range 235
System sensors 336
Warning indicators 25, 237
Warning sounds 238
Parts service 432
PASS AIR BAG OFF indicator lamp see
Front passenger front air bag off indica-
tor lamp
Passenger compartment
Interior lighting 135
Interior rear view mirror 47
Main fuse box 429
Parcel net in the front passenger
footwell 246
Passenger safety see Occupant safety
Pedals 271
Phone see Telephone*
Plastic parts, cleaning 338