run flat MERCEDES-BENZ E-CLASS COUPE 2009 User Guide

If
ap ressure of 1. 8bar is not reached
after fiv eminutes:
X Switch off and disconnect th eelectric air
pump and driv ethe vehicle forwards or
backwards approximately 10 m.
This distributes th eTIREFI Tmoree venly.
X Pump up th etyrea gain. G
Ris
kofa ccident
If ap ressur eof1.8bar is no tachieve dafter
fiv em inutes, th etyreist oobadly damaged.
Do no tdrivea ny further. Consult aqualified
specialist worksho pwhichh as th enecessary
specialist knowledge and tools to carry out
th ew ork required .Mercedes-Ben zrecom-
mends that you use aMercedes-Ben zService
Centr efor this purpose. In particular, work
relevan ttosafety or on safety-related sys-
tems must be carried out at aqualified spe-
cialist workshop.
When atyrep ressure of at leas t1.8bar
is reached:
X Press on/off switch 0088on th eelectric air
pump to 0.
The electric air pump is switched off.
X Remove th eTIREFI Tkit from th ewheel.
! Afte ruse, exces sTIREFI Tmay run out of
th ef ille rhose. This may caus estains.
Therefore, plac ethe fille rhoseint heplastic
whic hcontai nedt he TIREFI Tkit.
X Stow away th eTIREFI Tkit,t he electric air
pump and th ewarning triangle.
X Pul lawa yimm ediately.
X Stop after driving for approximately ten
minute sand check th etyrep ressur ewith
th ee lectric air pump. G
Ris
kofa ccident
If th etyrep ressur eisnowlower than 1. 3bar,
th et yreist oobadly damaged. Do no tdrive
any further. Consult aqualified specialist
worksho pwhichh as th enecessary specialist
knowledge and tools to carry out th ework required
.Mercedes-Ben zrecommends that
you use aMercedes-Ben zServic eCentr efor
this purpose. In particular, work relevan tto
safety or on safety-related systems must be
carried out at aqualified specialist workshop.
X If th etyrep ressur eisstill at least 1. 3bar,
correct it (see fuel fille rflap for values).
To increase th etyrep ressure: switch on
th ee lectric air pump.
To reduce th etyrep ressure: open pres-
sure release screw 0071on pressure
gauge 0072.
X Drive to th eneares tworksho pand have the
tyr ec hanged there.
X Hav ethe TIREFI Tkit replace dassoonas
possible at aqualified specialist workshop,
e.g. at aMercedes-Ben zServic eCentre. G
Ris
kofa ccident
Do no texcee dt he maximum spee dof
80 km/h.
The "max .80km/h" label must be affixe din
th ed river' sfieldofv ision.
The vehicle's handlin gcharacteristic smay be
affected. H
Environmental note
Hav ethe used TIREFI Tkit disposed of profes-
sionally, e.g. at aMercedes-Ben zService
Centre.
X Hav ethe TIREFI Tkit replace devery four
years at aqualified specialist workshop,
e.g. aMercedes-Ben zServic eCentre. 266
Flat tyrePractical advice
207_AKB
;2;3,en-GB
mkalafa ,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 266

Versio
n2 X
Pull connector 0088with cable and ai rpump
hose 0086outoft he housing.
X Screw ai rpum phose 0086onto flange 0087of
TIREFIT sealant fille rbottle 0046.
X Place TIREFIT sealant fille rbottle 0046 head
downwards into recess 0047of the electric
ai rp um p. X
Remove the cap from valve 006Eon the faulty
tyre.
X Screw fille rhose 006Fonto valve 006E.
X Insert connector 0088into the socke tofthe
cigarette lighter* (Y page 173) or into a
12 Vp ower socke t(Ypage 174) in your
vehicle.
X Vehicles withou tKEYLESS GO*:turn the
key to position 2(Y page 65) in the ignition
lock.
X Vehicles with KEYLES SGO*: press the
Start/Sto pbutton twice (position
2 (Y page 66)). X
Press on/of fswitch 008Aon the electri cair
pump to I.
The electri cairpump is switched on. The
tyr eisi nflated.
i First, TIREFIT is pumpe dinto the tyre. The
pressure can briefl yrisetoa round 5bar.
Do no tswitcho ff the electric pump dur-
in gt his phase.
X Let the electri cpum prun for fiv eminutes.
The tyr eshoul dthen have apressure of at
leas t1.8 bar.
! Do not operate the electri cairpump for
longer tha neight minutes at atime without
ab reak. It ma yotherwise overheat.
The ai rpum pcan be operated agai nonce
it ha scooled down.
If ap ressure of 1.8 bar is no treached
afte rfivem inutes:
X Switch off and disconnect the electri cair
pump and drive the vehicl eforwards or
backwards approximatel y10m.
Thi sd istributes the TIREFIT more evenly.
X Remove TIREFIT sealant fille rbottle 0046
from the electri cpum p.
X Pump up the tyr eagain. G
Ris
kofa ccident
If ap ressure of 1.8 ba risnot achieved after
fiv em inutes, the tyr eistoo badl ydam aged.
Do not drive any further .Consult aquali fied
specialist workshop which ha sthe necessary
specialist knowledge and tool stocarry out
the work required .Mercedes-Benz recom-
mend stha tyou useaM ercedes-Benz Service
Centre for thi spurpose. In particular, work
relevant to safety or on safety-relate dsys-
tems must be carrie doutataq uali fied spe-
cialist workshop. Flat tyre
267Practical advice
*optional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 267 Z

When
atyre pressure of at leas t1.8 bar
is reached:
X Press on/off switch 008Aon the electric air
pump to 0.
The electric air pump is switched off.
X Remove the TIREFIT kit from the wheel.
! After use,e xcess TIREFIT may run out of
the filler hose. This may caus estains.
Therefore, place the filler hose in the plastic
which contained the TIREFIT kit.
X Stow away the TIREFIT kit, the electric air
pump and the warning triangle.
X Pull away immediately.
X Stop after driving for approximately ten
minutes and check the tyre pressure with
the electric air pump. G
Risk of accident
If the tyre pressure is now lower than 1.3 bar,
the tyre is too badly damaged. Do not drive
any further. Consult aqualified specialist
worksho pwhich has the necessary specialist
knowledge and tools to carry out the work
required .Mercedes-Benz recommends that
you use aMercedes-Benz Service Centre for
this purpose. In particular, work relevant to
safety or on safety-related systems must be
carrie dout at aqualified specialist workshop. X
If the tyre pressure is still at least 1.3 bar,
correct it (see fuel filler flap for values).
To increase the tyre pressure: switch on
the electric air pump. To reduce the tyre pressure:
press pres-
sure release button 0070next to pressure
gauge 0071.
X Drive to the neares tworksho pand have the
tyre changed there.
X Have the TIREFIT kit replaced as soon as
possible at aqualified specialist workshop,
e.g. at aMercedes-Benz Service Centre. G
Risk of accident
Do not exceed the maximu mspee dof
80 km/h.
The "max. 80 km/h" label must be affixe din
the driver's fiel dofvision.
The vehicle's handling characteristics may be
affected. H
Environmental note
Have the use dTIREFIT kit disposed of profes-
sionally ,e.g. at aMercedes-Benz Service
Centre.
X Have the TIREFIT kit replaced every four
years at aqualified specialist workshop,
e.g. aMercedes-Benz Service Centre. Changing
awheel and fitting the
spare wheel* G
Risk of accident
The whee ldimensions and tyre size of the
"Minispare" emergency spare wheel* may dif-
fer from those of the damaged wheel.
You rvehicle's handling characteristics will
change when a"Minispare" emergency spare
wheel* is fitted. Adapt you rstyle of driving
accordingly.
The "Minispare" emergency spare wheel*
may only be use dfor as hort time. Do not
exceed the maximu mspee dof80k m/h and
do not deactivate ESP ®
.
Never drive the vehicl ewith more than one
"Minispare" emergency spare wheel* fitted. 268
Flat tyrePractical advice
*o
ptional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 268

X
Place the emergenc yspare wheel ontot he
centring pin and push it on. X
Tighten the wheel bolts until they are fin-
ger-tight.
X Unscrew the centring pin.
X Tighten the last wheel bolt until it is finger-
tight.
Lowering the vehicle X
Lower the vehicle. To do this, turn the crank
of the jack anti-clockwise until the vehicle
is once again standin gfirmly on the ground.
X Place the jack to one side. X
Tighten the wheel bolts evenly in across-
wise patter ninthe sequence indica-
ted (0046 to0086). The tightening torque is
130 Nm. G
Risk of accident
Have the tightening torque checked immedi-
ately after awheel is changed. The wheels
could work loose if they are not tightened to
at orque of 130 Nm.
X Turn the jack back to its initial position and
store it together with the rest of the vehicle
tool kit in the stowage well under the boot
floor.
Vehicles with the "Minispare" emergency
spare wheel*:
X Transport the faulty wheel in the boot.
i When you are driving with the "Minispare"
emergenc yspare wheel* fitted, the tyre
pressure loss warning system* cannot
function reliably. MOExtended run-flat system*
The MOExtended run-flat system may only be
used in conjunction with the activated tyre
pressure loss warning system.
! The maximum permissible distanc ewhich
can be driven in run-flat mode depends on
the load in the vehicle. It is 80 km if the
vehicle is partially laden and 30 km if fully
laden. 272
Flat tyrePractical advice
*o
ptional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 272

The maximum permissible distanc
ewhich
can be driven in run-flat mode is counted
from the moment the tyre pressure loss
warning appears in the multifunction dis-
play.
You must not exceed amaximum speed of
80 km/h. G
Risk of accident
The handling characteristics of your vehicle
deteriorate in run-flat mode, for example:
R when cornering
R when braking
R when acceleratin grapidly
Adapt your driving style accordingly and avoid
sudden changes in direction and sudden
acceleration ,aswell as driving over obstacles
(i.e. kerbs, potholes), and driving off-road.
This is particularly the case when the vehicle
is heavily laden.
The maximum permissible distanc ethat can
be driven in run-flat mode depends to alarge
exten tonthe loads placed on the vehicle. It
can be shorter due to high speeds, aheavy
load, sudden acceleration and/or manoeu-
vring, the road surface condition, outside tem-
perature, etc.,orf urther,ifyou drive carefully
and conservatively.
Do not continue to drive in run-flat mode if:
R you hear banging noises.
R the vehicle start stoshake.
R you see smoke and smell rubber.
R ESP ®
is intervening constantly.
R there are tears in the sidewalls of the tyre.
After driving in run-flat mode, you must have
the wheel(s) checked for damage at aquali-
fied specialist workshop which has the nec-
essary specialist knowledge and tools to carry
out the work required. The faulty tyre must be
replaced in every case.
Mercedes-Benz recommends that you use a
Mercedes-Benz Servic eCentre for this pur-
pose. In particular, work relevant to safety or on safety-related systems must be carried out
at
aq ualified specialist workshop.
Vehicles with MOExtended tyres*: when
replacing one or all tyres, make sure that you
only use tyres marked MOExtended and of
the specified size for the vehicle. Battery
Notes on the vehicle battery
In order for the battery to achieve the maxi-
mum possible service life, it must alway sbe
sufficiently charged.
Have the battery charge checked more fre-
quently if you use the vehicle mainly for short
trips or if you leave it standin gidle for a
lengthy period.
To prevent damage from corrosion, only
replace the battery with one that has acentral
ventilation cover.
Consult aMercedes-Benz Servic eCentre if
you wish to leave your vehicle parked up for
al ong period of time. G
Risk of injury
Comply with safety precautions and take pro-
tective measures when handling batteries. Risk of explosion
Fire, naked flames and
smokin
gare prohibited
when handling the battery.
Avoid creatin gsparks. Battery acid is caustic.
Avoid contact with the skin,
eyes or clothing.
Wear suitable protective
clothing, in particular
gloves, an apron and
aface
mask.
Immediately rinse acid
splashes off with clean Battery
273Practical advice
*optional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 273 Z

speciallya
dapted for use with the control
systems, such as ABS or ESP ®
,a nd are
marked as follows:
R MO =Mercedes-Benz Original
R MOE =Mercedes-Benz Original Exten-
ded* (tyres with run-flat characteristics)
If you use other tyres, Mercedes-Benz can-
not accept any responsibility for damage
which may occur. Information aboutt yres
can be obtained from any Mercedes-Benz
Service Centre.
! If you fit tyres other than those tested and
recommended by Mercedes-Benz,c harac-
teristics such as handling, noise levels and
fuel consumption, etc. may be adversely
affected. In addition, when driving with a
load, tyre dimensional variations could
cause the tyres to come into contact with
the bodywork and axle components. This
could result in damage to the tyres or the
vehicle.
i Further information aboutt yres and
wheels can be obtained from any
Mercedes-Benz Service Centre. i
You will find atable of tyre pressures on
the inside of your vehicle's fuel filler flap.
You will find further information aboutt yre
pressures in the "Operation" section
(Y page 186).
i Notes on vehicle tyres:
Always
R fit tyres of the same size on agiven axle
(left/right)
R fit the same type of tyres on your vehicle
at ag iven time (summer tyres, winter
tyres, MOExtended tyres)
i Vehicles with the MOExtended run-flat
system are not equipped with the TIREFIT
kit. 63
Therefore, it is recommended that you
additionally equip your vehicle with the
TIREFIT kit* when fitting tyres that do not
feature run-flat properties, e.g. winter
tyres.
i ATIREFIT kit is available from any quali-
fied specialist workshop, e.g. aMercedes-
Benz Service Centre. Tyres of the same dimensions
i BA: Both axles Coupé and Cabriolet
E2
00 CGI
BlueEFFICIENCY /
E2 20 CDI
BlueEFFICIENCY E2
50 CGI
BlueEFFICIENCY /
E2 50 CDI
BlueEFFICIENCY 16" BA Summer tyres
205/55R
16 91V64 205/55R
16 91W64 Winter tyres
205/55R
16 91H M+S 004D 205/55 R16 91H M+S
004D
Wheels
7.0J
x16H2ET38 7.0J
x16H2ET38 63
Only for certai ncountries.
64 Not with sports package code 950/952, sports suspensio ncode 486 or dynamic handling package code
483. Tyres and wheels
297Technical data
*optional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 297 Z

Coupé
E2
00 CGI
BlueEFFICIENCY /
E2 50 CGI
BlueEFFICIENCY /
E3 50 /
E3 50 CGI
BlueEFFICIENCY /
E2 20 CDI
BlueEFFICIENCY /
E2 50 CDI
BlueEFFICIENCY /
E3 50 CDI
BlueEFFICIENCY E5
00 17" BA Summer tyres
235/45 R17 94W –
Summer tyres
65 235/45 R17 94W
MOExtended –
Light-alloy
wheels
7.5J
x17H2ET45 –
17" BA Winter tyres
235/45 R17 94H
M+S 004D 235/45 R17 94H
M+S
004D Winter tyres
65, 66 235/45 R17 94
HM+S
MOExtended 004D 235/45 R17 94
HM+S
MOExtended 004D Light-alloy
wheels
7.5J
x17H2ET45 7.5J
x17H2ET45 18" BA Winter tyres
235/40 R18 95
HXL
M+S 004D 235/40 R18 95
HXL
M+S 004D Light-alloy
wheels
8.0J
x18H2ET45 8.0J
x18H2ET45 65
Tyres with run-flat characteristics and only in conjunction with an activated tyr epressure loss warning or
tyr ep ressure monitor*.
66 Winter tyres for retrofitting .Onlyc ertain tyr ebrands are approved. As kyour Mercedes-Ben zServic eCentre
for mor einformation. Tyres and wheels
299Technical data
*optional
207_AKB
;2;3,en-GB
mkalafa, Version:2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 299 Z

Cabriolet
E2
00 CGI
BlueEFFICIENCY /
E2 50 CGI
BlueEFFICIENCY /
E3 50 /
E3 50 CGI
BlueEFFICIENCY /
E2 20 CDI
BlueEFFICIENCY /
E2 50 CDI
BlueEFFICIENCY /
E3 50 CDI
BlueEFFICIENCY E5
00 17" BA Summer tyres
235/45 R17 94W
64 –
Summer tyres
65 235/45 R17 94W
64
MOExtended –
Light-alloy wheels
7.5J
x17H2ET45 –
17" BA Winter tyres
235/45 R17 94H
M+S
004D 235/45 R17 94H
M+S
004D Winter tyres
65, 66 235/45 R17 94
HM+S
MOExtended 004D 235/45 R17 94
HM+S
MOExtended 004D Light-alloy wheels
7.5J
x17H2ET45 7.5J
x17H2ET45 18" BA Winter tyres
235/40 R18 95
HXL
M+S 004D 235/40 R18 95
HXL
M+S 004D Light-alloy wheels
8.0J
x18H2ET45 8.0J
x18H2ET45 64
Not with sports package cod e950/952 ,sports suspension cod e486 or dynamic handlin gpackage code
483.
65 Tyres with run-flat characteristics and only in conjunction with an activated tyr epressure loss warning or
tyr ep ressure monitor*.
66 Winter tyres for retrofitting .Onlyc ertain tyr ebrands are approved. As kyour Mercedes-Ben zServic eCentre
for mor einformation. 300
Tyres and wheelsTechnical data
*o
ptional
207_AKB
;2;3,en-GB
mkalafa, Version:2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 300

E2
50 CGI
BlueEFFICIENCY 69
/
E3 5069
/
E3 50 CGI
BlueEFFICIENCY 69
/
E2 50 CDI
BlueEFFICIENCY 69
/
E3 50 CDI
BlueEFFICIENCY 69 E5
00 18" FA Summer tyres
235/40 R18 91Y 235/40 R18 91Y
Light-alloy wheels
8.0J
x18H2ET45 8.0J
x18H2ET45 RA
Summer tyres
68 255/35 R18 94
YXL 255/35 R18 94
YXL Light-alloy wheels
8.5J
x18H2ET49 8.5J
x18H2ET49 Spar
ewheel*
Your vehicle may be equipped with TIREFIT, a"Minispare" emergency spare wheel* ,depending
on th ecountry, th eengine and th ewheels fitted.
! The spare wheel* must be inflate dtothemaximum tyr epressure give ninthetabl eon
th ei nside of th efuel filler flap.
i Vehicles featurin gthe MOExtended run-flat system* are no tequipped with th eTIREFIT
kit .Itist herefore recommended to additionally equip your vehicle with th eTIREFI Tkit when
fittin gtyres that do no tfeature run-flat properties, e.g .winter tyres.
i ATIREFI Tkit is available from any qualifie dspecialist workshop ,e.g.aM ercedes-Benz
Servic eCentre. "Minispare" emergency spare wheel*
70 E2
50 CGI BlueEFFICIENCY /
E2 50 CDI BlueEFFICIENCY E3
50 /
E3 50 CGI BlueEFFICIENCY /
E3 50 CDI BlueEFFICIENCY /
E5 00 16" Tyres
T1
35/90 R16 102M –
Tyre pressure
4.
2b ar –
Wheels
3.5B
x16H2ET20 –
69
Only in combinatio nwith sports package cod e950/952 ,sports suspension cod e486 or dynamic handling
package cod e483.
68 Use of snow chains not permitted.
70 Use of snow chains not permitted. 302
Tyres and wheelsTechnical data
*o
ptional
207_AKB
;2;3,en-GB
mkalafa, Version:2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 302