ad blue MERCEDES-BENZ E320 BLUETEC 2007 W211 Owner's Manual

E 320 BLUETEC
E 350
E 350 4MATIC
E 550
E 550 4MATIC
E63AMG

ContentsReplacing bulbs ................................. 443
Bulbs ............................................ 443
Replacing bulbs for front lamps.... 446
Replacing bulbs for rear lamps ..... 448
Replacing wiper blades ...................... 450
Placing wiper arms in vertical
position ........................................ 450
Removing wiper blades ................ 451
Installing wiper blades.................. 451
Flat tire .............................................. 452
Preparing the vehicle.................... 452
Mounting the spare wheel ............ 452
Bleeding the fuel system
(diesel engine only) ............................ 459
Battery ............................................... 460
Disconnecting the battery ............ 461
Removing the battery ................... 462
Charging and reinstalling the
battery.......................................... 462
Reconnecting the battery ............. 463
Jump starting ..................................... 464
Towing the vehicle ............................. 466
Installing towing eye bolt.............. 468Fuses ................................................. 469
Fuse box in passenger
compartment ............................... 470
Fuse box in trunk ......................... 470
Technical data................................. 473
Parts service ...................................... 474
Warranty coverage............................. 475
Loss of Service and Warranty
Information Booklet ..................... 475
Identification labels ........................... 476
Layout of poly-V-belt drive ................. 478
E 320 BLUETEC ............................ 478
E 350 / E 550 ............................... 478
E 63 AMG ..................................... 478
Engine................................................ 479
Rims and tires.................................... 481
Same size tires ............................. 482
Mixed size tires ............................ 485
Spare wheel ................................. 487
Electrical system ............................... 488
Main dimensions and weights............ 489
Main dimensions .......................... 489
Weights ........................................ 490Fuels, coolants, lubricants etc. .......... 491
Capacities .................................... 491
Engine oils ................................... 495
Engine oil additives ...................... 495
Air conditioning refrigerant .......... 495
Brake fluid.................................... 495
Premium unleaded gasoline
(gasoline engine).......................... 496
Fuel requirements ........................ 496
Gasoline additives
(gasoline engine).......................... 497
Coolants ...................................... 498
Windshield washer system and
headlamp cleaning system*......... 500
Index................................................. 501

133 Controls in detailSeats
Switching seat heating on
Switch on the ignition (
page 37).

Press switch1.
Three red indicator lamps on the switch
come on.

Continue pressing switch1 until de-
sired seat heating level is reached.
Switching seat heating off

Press switch1 repeatedly until all in-
dicator lamps go out.
Seat ventilation*
The blue indicator lamps on the switch
show the ventilation level selected.1Seat ventilation switch

Switch on the ignition (
page 37).Switching seat ventilation on

Press button1 repeatedly until the
desired ventilation level is set.
One or more blue indicator lamps on
the switch show the selected ventila-
tion level.
Switching seat ventilation off

Press button1 repeatedly until all in-
dicator lamps go out.
i
If one or more of the lamps on the seat heat-
ing switch are flashing, there is insufficient volt-
age available since too many electrical
consumers are turned on. The seat heating
switches off automatically.
The seat heating will switch back on again auto-
matically as soon as sufficient voltage is avail-
able.
Level3
Three indicator lamps on
(highest level).
2
Two indicator lamps on.
1
One indicator lamp on
(lowest level).
off
No indicator lamp on.
i
The seat ventilation for the driver’s seat can
be activated using summer opening feature
(
page 239).
i
If one or more of the lamps on the seat ven-
tilation switch are flashing, there is insufficient
voltage available since too many electrical con-
sumers are turned on. The seat ventilation
switches off automatically.
The seat ventilation will switch back on again au-
tomatically as soon as sufficient voltage is avail-
able.

204 Controls in detailDual-zone automatic climate control(only available on E 320 BLUETEC,
E 350, E 350 4MATIC)

329 Operation
Engine compartment
Adding engine oil
E 350/E 550 (E 320 BLUETEC similar)
E63AMG
Unscrew filler cap1 from filler neck.

Add engine oil as required. Be careful
not to overfill with oil.Be careful not to spill any oil when adding.
Avoid environmental damage caused by oil
entering the ground or water.

Screw filler cap1 back on filler neck.
For more information on engine oil, see the
“Technical data” section (
page 491) and
(
page 495).
Transmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Center
check the transmission.
!
Only use approved engine oils and oil filters
required for vehicles with Maintenance System
(U.S. vehicles) or FSS PLUS (Canada vehicles).
For a listing of approved engine oils and oil fil-
ters, refer to the Factory Approved Service
Products pamphlet (USA only) in your vehicle
literature portfolio, or contact an authorized
Mercedes-Benz Center.
Using engine oils and oil filters of specification
other than those expressly required for the Main-
tenance System (U.S. vehicles) or FSS PLUS
(Canada vehicles), or changing of oil and oil filter
at change intervals longer than those called for
by the Maintenance System (U.S. vehicles) or
FSS PLUS (Canada vehicles) will result in engine
or emission control system damage not covered
by the Mercedes-Benz Limited Warranty.
!
Excess oil must be siphoned or drained off.
It could cause damage to the engine and emis-
sion control system not covered by the
Mercedes-Benz Limited Warranty.

444 Practical hintsReplacing bulbs
Front lamps
Lamp
Type
1
Additional turn signal
lamp
LED
2
Turn signal lamp
3547 A
(28.5 W)
3
Halogen headlamp:
Low beam
Bi-Xenon* headlamp:
Low and high beam
1
1Vehicles with Bi-Xenon* headlamps: Low beam
and high beam use the same D1S-35W lamp. Do
not replace the Bi-Xenon bulbs yourself. Contact
your authorized Mercedes-Benz Center.
H7 (55 W)
D1S-35 W
4
Side marker lamp
W 5 W
Lamp
Type
5
Halogen headlamp:
High beam/high beam
flasher
Bi-Xenon* headlamp:
High beam flasher
H7 (55 W)
H7 (55 W)
Halogen headlamp:
Parking and standing
lamp
Bi-Xenon* headlamp:
Parking an standing
lamp
W 5 W
Blue Vision
LED
6
Front fog lamp
Corner-illuminating
front fog lamp*
H11 (55 W)
H11 (55 W)

478 Technical dataLayout of poly-V-belt driveE 320 BLUETEC
1Coolant pump
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Idler pulley
8Generator (alternator)
E 350 / E 550
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)
E63AMG
1Idler pulley
2Idler pulley
3Idler pulley
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

479 Technical data
Engine
Engine
Model
E 320 BLUETEC (211.022
1)
E 350 (211.056
1)
E 350 4MATIC (211.087
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.Engine
OM 642
272
Mode of operation
Diesel 4-stroke
4-stroke engine, gasoline injection
No. of cylinders
6
6
Bore
3.27 in (83.00 mm)
3.66 in (92.90 mm)
Stroke
3.62 in (92.00 mm)
3.39 in (86.00 mm)
Total piston displacement
182.9 cu in (2 987 cm
3)
213.5 cu in (3 498 cm
3)
Compression ratio
16.5:1
10.7:1
Output acc. to SAE J 1349
208 hp/3 600 rpm
(155 kW/3 600 rpm)
268 hp / 6 000 rpm
2
(200 kW / 6 000 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.Maximum torque acc. to SAE J 1349
398 lb-ft/1 600 rpm - 2 400 rpm
(540 Nm/1 600 rpm - 2 400 rpm)
258 lb-ft / 2 400 rpm - 5 000 rpm
(350 Nm / 2 400 rpm - 5 000 rpm)
Maximum engine speed
4 500 rpm
6 500 rpm
Firing order
1-4-2-5-3-6
1-4-3-6-2-5
Poly-V-belt
2 035 mm
2 404 mm

482 Technical dataRims and tiresSame size tires
16’’ tiresModel
E 320 BLUETEC
Rims (light alloy)
8 J x 16 H2
Wheel offset
1.42 in (36 mm)
All-season tires
1
1Radial-ply tires
225/55 R16 95H M+S
Winter tires
1,2
2Not available as factory equipment.
225/55 R16 95H M+S.

488 Technical dataElectrical systemModel
E 350, E 350 4MATIC
E 550, E 550 4MATIC
E63AMG
Generator (alternator)
14 V/180 A
14 V/180 A
14 V/180 A
Starter motor
14 V/1.4 kW
14 V/1.7 kW
12 V/2.1 kW
Battery
12 V/95 Ah
1
1Depending on production date, your vehicle may be equipped with a 12 V/100 Ah battery.
12 V/95 Ah
1
12 V/95 Ah
Spark plugs
Bosch Platin Y 7 MPP33
NGK PLKR 6A
Bosch F8 DPP 332U
NGK PFR 5R-11
NGK ILZKAR7A10
Electrode gap
0.031 in (0.8 mm)
0.039 in (1.00 mm)
0.039 in (1.00 mm)
Tightening torque
15 - 22 lb-ft (20 - 30 Nm)
18.5 - 22 lb-ft (25 - 30 Nm)
15 - 18.5 lb-ft (20 -25 Nm)
Model
E 320 BLUETEC
Generator (alternator)
14 V/180 A
Starter motor
14 V/2.0 kW
Battery
12 V/95 Ah
1
1Depending on production date, your vehicle may be equipped with a 12 V/100 Ah battery.