roof MERCEDES-BENZ G500 2003 W463 User Guide
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2003, Model line: G500, Model: MERCEDES-BENZ G500 2003 W463Pages: 360, PDF Size: 6.29 MB
Page 203 of 360
203 Operation
Driving instructions
Standing water
Passenger compartment
Off-road driving
!Do not drive through flooded areas or
water of unknown depth. Before driving
through water, determine its depth. It
should not be deeper than approxi-
mately 19 inches (48 cm).
If you must drive through standing wa-
ter, drive slowly to prevent water from
entering the passenger compartment
or the engine compartment. Water in
these areas could cause damage to
electrical components or wiring of the
engine or transmission, or could result
in water being ingested by the engine
through the air intake causing severe
internal engine damage. Any such dam-
age is not covered by the
Mercedes-Benz Limited Warranty.
Warning!
G
Always fasten items being carried as secure-
ly as possible.
In an accident, during hard braking or sud-
den maneuvers, loose items will be thrown
around inside the vehicle, and cause injury
to vehicle occupants unless the items are
securely fastened in the vehicle.
The rear cargo compartment is the preferred
place to carry objects. Always use partition
net when transporting cargo. Partition net
cannot secure hard or heavy objects. Al-
ways fasten items being carried as securely
as possible using the cargo tie-down rings in
the cargo area floor and fastening material.
Do not load items on the roof. It may cause
instability during some maneuvers which
could result in an accident. This vehicle is
not intended to carry items on its roof. Thus
roof rails and roof mounted ski or bike hold-
ers must not be used.
Warning!
G
Do not load items on the roof. It may cause
instability during some maneuvers which
could result in an accident.Warning!
G
Drive slowly in unknown terrain. This will
make it easier to recognize unexpected ob-
stacles and avoid damage to the vehicle.
To help avoid the vehicle rolling over, never
turn it around on steep inclines. If the vehi-
cle cannot complete the attempted climb,
back it down in reverse gear.
Do not drive along the side of a slope (dan-
ger of vehicle rollover). If in doing so the ve-
hicle begins to show a tendency to roll,
immediately steer into a line of gravity
(straight up or downhill).
Page 204 of 360
204 OperationDriving instructionsRead this chapter carefully before you be-
gin off-road travel.
Familiarize yourself with the vehicle char-
acteristics and gear changing before you
attempt any difficult terrain off-road driv-
ing. We recommend that you start out with
easy off-road travel.Special driving features for off-road
driving
The following driving features are available
for specific kind of operation:
ABS (
page 71)
ESP (
page 75)
4-ETS (
page 74)
Differential lock (
page 145)
Transfer case (
page 141)
Off-road driving rules
Engage the transfer case in position
LOW before driving under off-road con-
ditions (
page 141).
If necessary activate differential locks
(page 145).
The ABS, BAS and ESP are switched off
automatically when the differential
locks are activated.
Fasten items being carried as securely
as possible (
page 173).
Never let the vehicle roll backwards in idle.
You may lose control of the vehicle if you
use only the service brake.
Sand, dirt, mud and other material having
friction property can cause exceptional wear
and tear as well as brake failure.
Have the brakes checked for dirt build-up
and cleaned. There is otherwise a risk that
full braking power may not be available in an
emergency.
iWhenever driving in off-road mode, we
recommend:
Keeping doors, tailgate, windows
and sliding/pop-up roof closed.
Switching cruise control off.
!Observe the following during off-road
driving:
Adjust vehicle speed to condition of
terrain. The more uneven, rutty and
steeper the terrain, the lower the
speed should be. Drive through wa-
ter slowly at an even speed, avoid-
ing a bow wave.
Be especially careful when driving
in unknown territory. It may be nec-
essary to get out of the vehicle and
scout the path you intend to take.
Watch out for obstacles, such as
rocks, holes, tree stumps and ruts.
Page 232 of 360
232 OperationVehicle care
Vehicle careCleaning and care of the vehicle
While in operation, even while parked, your
vehicle is subjected to varying external in-
fluences which, if gone unchecked, can at-
tack the paintwork as well as the
underbody and cause lasting damage.
Such damage is caused not only by ex-
treme and varying climatic conditions, but
also by:
Air pollution
Road salt
Tar, gravel and stone chippingTo avoid paint damage, you should imme-
diately remove:
Grease and oil
Fuel
Coolant
Brake fluid
Bird droppings
Insects
Tree resins, etc.
Frequent washing reduces and/or elimi-
nates the aggressiveness and potency of
the above adverse influences.
More frequent washings are necessary to
deal with unfavorable conditions:
Near the ocean
In industrial areas (smoke, exhaust
emissions)
During winter operationYou should check your vehicle from time to
time for stone chipping or other damage.
Any damage should be repaired as soon as
possible to prevent corrosion.
In doing so, do not neglect the underbody
of the vehicle. A prerequisite for a thor-
ough check is a washing of the underbody
followed by a thorough inspection. Dam-
aged areas need to be re-undercoated.
Your vehicle has been treated at the facto-
ry with a wax-base rustproofing in the body
cavities which will last for the lifetime of
the vehicle. Post-production treatment is
neither necessary nor recommended by
Mercedes-Benz because of the possibility
of incompatibility between materials used
in the production process and others ap-
plied later.
We have selected car-care products and
compiled recommendations which are
specially matched to our vehicles and
which always reflect the latest technology.
You can obtain Mercedes-Benz approved
car-care products at your authorized
Mercedes-Benz Light Truck Center.
Warning!
G
Many cleaning products can be hazardous.
Some are poisonous, others are flammable.
Always follow the instructions on the partic-
ular container. Always open your vehicle’s
doors or windows when cleaning the inside.
Never use fluids or solvents that are not de-
signed for cleaning your vehicle.
Page 276 of 360
276 Practical hintsOpening/closing in an emergency
Opening/closing in an emergencySliding/pop-up roof
You can open or close the sliding/pop-up
roof manually in the case of power failure.
The sliding/pop-up roof drive is located on
the left side of the cargo area behind the
rear panel trim.
1Edge protection
2Rear panel trim
Open the tailgate.
Remove edge protection1 from door
pillar.
Remove rear panel trim2.3Key (vehicle tool kit)
4Screwdriver (vehicle tool kit)
Fit key3 into hexagon nut of drive.
Insert screwdriver4 into the key as a
lever.
Turn crank 3 clockwise to:
close slide roof
raise roof at the rear
Turn crank 3 counterclockwise to:
open slide roof
lower roof at the rear
iDo not disconnect electrical connec-
tors.
Page 295 of 360
295 Practical hints
Battery
Battery
The battery is located in front of the rear
seat bench and below the cup holder
Batteries contain materials that can harm
the environment if disposed of improperly.
Large 12-volt storage batteries contain
lead.
Recycling of batteries is the preferred
method of disposal. Many states require
sellers of batteries to accept old batteries
for recycling.
Charging the battery
Have the battery removed at a
Mercedes-Benz Light Truck Center.
If you charge the battery yourself, make
sure to comply with the operating instruc-
tions for your battery charger.
Warning!
G
Failure to follow these instructions can re-
sult in severe injury or death.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 223).
Never lean over batteries while connecting,
you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking etc.
Warning!
G
Do not place metal objects on the battery as
this could result in a short circuit.
Use leak-proof battery only to avoid the risk
of acid burns in the event of an accident.
Warning!
G
Never charge a battery while still installed in
the vehicle. Gases may escape during charg-
ing and cause explosions that may result in
paint damage, corrosion or personal injury.!Have the battery checked regularly by
an authorized Mercedes-Benz Light
Truck Center.
Refer to Service Booklet for mainte-
nance intervals or contact your autho-
rized Mercedes-Benz Light Truck
Center for further information.
Page 334 of 360
334 IndexCHECK ENGINE malfunction indicator
lamp 243
Checking
Coolant level 215, 220
Oil level 215, 217, 218
Checklist
Off-road driving 205
Child safety 63
Infant and child restraint systems 54,
60, 63
LATCH child seat mounts 68
Child safety switch see Blocking of rear
door window operation 69
Cigarette lighter 181
Cleaning
Cup holder 235
Gear selector lever 235
Hard plastic trim items 236
Headlamps 148
Headliner 236
Illuminated door sill panels 236
Instrument cluster 235
Leather upholstery 236
Light alloy wheels 235
MB Tex upholstery 236
Plastic and rubber parts 236Rear Park Assist sensors* 234
Seat belts 236
Steering wheel 235
Windows 235
Windshield 47
Wiper blades 235
Climate control 150
Adjusting 153
Defogging windshield 153
Defrosting 154
Rear window defroster 155
Setting the temperature 152
Clock 25
Closing
Glove box 176
Hood 217
Side windows 158
Sliding/pop-up roof 160, 276
Sliding/pop-up roof
with SmartKey 161
Tailgate 88
Windows 158
Windows with SmartKey 159
Closing sliding/pop-up roof
In an emergency 276
Cockpit 22, 325Cockpit management and data system
(COMAND) 325
COMAND 325
COMAND see separate operating
instructions
Combination switch 23, 103
High beam flasher 46, 103
Turn signals 46
Windshield wipers 47
Consumer information 322
Control and operation of
radio transmitters 210
Control system 111, 325
AUDIO menu 116
Convenience submenu 128
Display digital speedometer 116
Functions 112, 115
Instrument cluster submenu 122
Lighting submenu 124
Malfunction memory menu 118
Menus 114, 115, 327
Multifunction display 111
Multifunction steering wheel 112
NAVI menu 118
Selecting radio system 117
Settings menu 119
Page 336 of 360
336 IndexDigital speedometer 116
Direction of rotation (tires) 225
Discharged battery
Jump starting 297
Disconnecting
Vehicle battery 296
Display
Selecting 123
Displays
Digital speedometer 116
Messages 218, 246
Selecting 123
Service indicator 230
Showing malfunctions 118
Distance to empty (range)
Calling up 130
Door control panel 30
Door handle 30
Door sill panels
Cleaning 236
Door unlock
With Tele Aid 190
Doors
Message in display 254
Opening from inside vehicle 87
Opening from outside 85Downhill driving
Cruise control 163
Downshifting 136
Drink holders see Cup holders
Drinking and driving 197
Driving
General instructions 40, 197
In winter 202
Problems 49
Safety systems 71
Through standing water 203
Driving abroad 211
Driving and safety systems
4-ETS 74
ABS 71
BAS 73
EBB 75
ESP 75
Driving instruction
Passenger compartment 203
Driving instructions 197
Driving off 199
Driving systems 162
Cruise control 162
Driving safety systems 71
Driving through water 207E
Easy-entry/exit feature 91
Activating 128
Interrupting movement 129
EBB 71, 75
Electrical fuses 303
Electrical outlet 181
Electrical system
Technical data 314
Electronic Stability Program see ESP 25
Electronic stability program see ESP 326
Electronic Traction System (ETS) 74
Electronic Brake Booster (EBB) 75
Emergency call system 183
Emergency calls
Initiating an emergency call 186
With Tele Aid 185
Emergency operation
(Limp Home Mode) 140
Emergency operations
Closing sliding/pop-up roof 276
Locking the vehicle 273
Opening sliding/pop-up roof 276
Remote door unlock 190
Unlocking the vehicle 272
Page 341 of 360
341 Index
Lighting 100
Automatic headlamp mode 101
Combination switch 103
Daytime running lamp mode 102
Exterior lamp switch 100
Front fog lamps 102
High beam flasher 103
High beams 103
Instrument cluster illumination 108
Instruments 108
Interior 104
Locator lighting 102
Low beam 100
Manual headlamp mode 101
Night security illumination 102
Parking lamps 100
Rear fog lamp 103
Settings (control system) 124
Limiting the gear range 137
Limp Home Mode 140
Line of fall 326
Loading 168
Cargo area cover 168
Cargo tie-down rings 175
Instructions 173
Partition net* 171Roof rack 168
Split rear bench seat 169
Locator lighting 102
Setting 125
Lock button 327
Locking 50, 84
Fuel filler flap 214
Global, SmartKey 85
Vehicle in an emergency 273
Loss of keys 86
Loss of Service and Warranty Information
Booklet 309
Low beam headlamps
Messages in display 261
Low beam lamp
Replacing bulbs 281
LOW RANGE - ABS 72
Lowering
Vehicle 294
Lubricants
Technical data 316
M
Main dimensions 315
Maintenance 230Malfunction
Displaying 118
Rear Park Assist* 167
Malfunction memory 118
Calling up 118
Clearing 119
Manual headlamp mode 101
Manual operations
Fuel filler flap 274
Interior lighting control 105
Locking the vehicle 273
Sliding/pop-up roof 276
Unlocking the driver’s door 272
Unlocking transmission selector
lever 275
MB Tex upholstery
Cleaning 236
Mechanical key 272
Memory function 97, 327
Recalling positions from memory 98
Storing exterior rear view mirror
parking positions 99
Storing key dependent settings 98
Page 343 of 360
343 Index
Off-road driving 203
Checklist 205
Crossing obstacles 208
Driving through water 207
Returning 209
Rules 204
Special driving features 204
Steep terrain 206
Oil
Adding 220
Consumption 217, 218
Dipstick 217
Filler neck 219, 220
Viscosity 326
Oil level
Checking 215
One-touch gearshifting 136
Canceling gear range limit 137
Downshifting 136
Upshifting 136
Opening
Ashtray 179
Doors from the inside 87
Fuel filler flap 214
Fuel filler flap manually 274
Glove box 176Hood 216
Side windows 159
Sliding/pop-up roof 160, 276
Sliding/pop-up roof in an
emergency 276
Sliding/pop-up roof with
SmartKey 161
Tailgate 87, 88
Windows 158
Windows with SmartKey 159
Operating
CD player 117
COMAND see separate operating
instructions
Navigation system 118
Radio 117
Radio transmitters 210
Telephone 132
Operator’s Manual 10
Ornamental moldings 234
Outside temperature indicator 110
Overdue service 230
Overhead control panel 29
Overspeed range 327P
Paintwork 233
Panic alarm 70
Panic button on SmartKey 70
Parcel net
In front passenger footwell 179
Parking 50, 199
Parking brake 44, 50
Engaging 50
Message in display 263
Releasing 44
Parking lamp, front
Replacing bulbs 281
Parking lamps
Replacing bulbs 279, 280
Switching on 100
Parking position
Exterior rear view mirrors 99, 130, 148
Parktronic see Rear Park Assist*
Partition net* 171
Installing behind front seats 172
Installing behind rear seat bench 171
Removing 173
Parts see Spare parts service 308
Page 345 of 360
345 Index
Rear bench seat
Foldable 169
Rear door window
Blocking operation 69
Rear fog lamp
Replacing bulbs 287
Switching on 103
Rear lamps see Tail lamps
Rear Park Assist* 165, 327
Cleaning sensors 234
Malfunction 167
Monitoring reach 166
Warning indicators 167
Rear seat head restraints 93
Installing 93
Removing 93
Rear towing eye 302
Rear view mirror automatic antiglare 147
Rear view mirrors see Mirrors
Rear window defroster 155
Activating 155
Deactivating 155
Rear window wiper/washer 48
Reconnecting
Vehicle battery 296Refrigerant
Air conditioning 317
Regular checks 215
Remote controls
SmartKey 84
Remote door unlock
With Tele Aid 190
Remote Vehicle Diagnostics 328
Removing
Cargo area cover 169
Wheel 293
Wiper blades 289
Replacing
Brake lamp bulbs 280
Bulbs 279
Front lamp bulbs 281
Rear lamp bulbs 280, 286
Wiper blades 289
Reset knob in the instrument cluster 119
Resetting
All functions (control system) 119
All functions of a submenu 120
Fuel consumption 131
Service indicator (FSS) 231
Trip odometer 109
Residual heat utilization 328REST (Residual engine heat utilization) 328
Restraint system 328
Restraint system see Infant and child
restraint systems 63, 67
Restraint systems 54
Airbags 54
Child seat recognition 54
Child seats 54
Emergency Tensioning Device (ETD) 54
Lower anchors and tethers for children
(LATCH) 54
Seat belts 54
Returning from off-road driving 209
Rims 313
Roadside assistance
Tele Aid 187
RON 215
RON (Research Octane Number) 328
Roof rack 168
Rotating wheels 226
Rubber parts
Cleaning 236
S
Safety
Occupant 54
Safety belts see Seat belts 40