fuel reserve MERCEDES-BENZ G500 2003 W463 Owner's Manual

25 At a glance
Instrument cluster
Item
Page
1
Reset knob for:

Resetting trip odometer
109


Resetting individual or all
settings
119,
120,
131,
231


Instrument cluster illumi-
nation
108
2
L
Left turn signal indica-
tor
24
3
?
Engine malfunction in-
dicator lamp
243
v
Electronic Stability
Program (ESP)
75,
238,
239
A
High beam headlamp
indicator
46,
103
Item
Page
4
K
Right turn signal indi-
cator
24
5
Fuel gauge with:Fuel reserve warning lamp
24
1
SRS malfunction
58,
242
<
Fasten seat belts
60,
243
6
Multifunction display with:
111
Trip odometer
24
Main odometer
24
Transfer case program mode
141
Selector lever position
135
Outside temperature indica-
tor
110
Digital clock
111
Item
Page
7
Speedometer
8
Tachometer with:;
Brake warning lamp
(except Canada)
44,
241
3
Brake warning lamp
(Canada only)
44,
241
-
ABS malfunction indi-
cator lamp
71,
240

243 Practical hints
What to do if …
Problem
Possible cause
Suggested solution
?
The yellow “CHECK ENGINE”
malfunction indicator lamp
comes on while driving.
There is a malfunction of:

The fuel management system


The ignition system


The emission control system


Systems which impact emissions
Such malfunctions may result in excessive
emissions values and may switch the engine
to its limp-home (emergency operation)
mode. Serious damage can occur to the
emission system.

Have the vehicle checked as soon as
possible by an authorized
Mercedes-Benz Light Truck Center.
An on-board diagnostic connector is
used by the service station to link the
vehicle to the shop diagnostics sys-
tem. It allows the accurate identifica-
tion of system malfunctions through
the readout of diagnostic trouble
c o d e s . I t i s l o c a t e d n e a r t h e h o o d l o c k
release on the upper left of footwell.
The fuel cap is not closed tightly.

Check the fuel cap.
Your gas tank is empty.

After refuelling, start the engine three
or four times in succession. The
limp-home mode is canceled.
<
The red seat belt warning lamp
blinks for a brief period after
starting the engine.
The warning lamp reminds you to fasten seat
belts.

Fasten your seat belt.
The yellow fuel tank reserve warning lamp
illuminates while driving.
The fuel level has gone below the reserve
mark.

Refuel at the next gas station.

Also note the messages in the multi-
function display (
page 246).

244 Practical hintsWhat to do if …Lamp in center consoleProblem
Possible cause
Suggested solution
The yellow fuel tank reserve warning lamp is
blinking.
The fuel cap is not closed tight.

Check the fuel cap.
Problem
Possible cause
Suggested solution
7
The indicator lamp lights up.
A BabySmart
TM child seat is installed on the
front passenger seat. Therefore the front
passenger airbag is switched off.
The system is malfunctioning when there is
no BabySmart
TM child seat installed on the
front passenger seat.

Have the system checked as soon as
possible by an authorized
Mercedes-Benz Light Truck Center.

263 Practical hints
What to do if …
.
TURN SIGNAL F, L
CHECK LAMP
SUBSTITUTE LAMP ON!
The left front turn signal lamp is mal-
functioning. A backup bulb is being
used.

Replace the bulb as soon as
possible.
2
TURN SIGNAL F, R
CHECK LAMP
SUBSTITUTE LAMP ON!
The right front turn signal lamp is
malfunctioning. A backup bulb is be-
ing used.

Replace the bulb as soon as
possible.
2
TURN SIGNAL R, L
CHECK LAMP
SUBSTITUTE LAMP ON!
The left rear turn signal lamp is mal-
functioning. A backup bulb is being
used.

Replace the bulb as soon as
possible.
2
TURN SIGNAL R, R
CHECK LAMP
SUBSTITUTE LAMP ON!
The right rear turn signal lamp is
malfunctioning. A backup bulb is be-
ing used.

Replace the bulb as soon as
possible.
2
!
(Canada
only)
;
(USA only)
PARKING BRAKE
RELEASE PARKING BRAKE!
You are driving with the parking
brake set.

Release the parking brake
(page 44).
1
A
RESERVE FUEL
VISIT FILLING STATION!
The fuel level has dropped below the
reserve mark.

Refuel at the next gas station
(page 214).
2
Display
Possible cause
Suggested solution
Category

316 Technical dataFuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.Capacities
Vehicle components and their respective
lubricants must match.Therefore use only brands tested and rec-
ommended by Mercedes-Benz.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Light Truck Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
G500
G55AMG
8.5 US qt (8.0 l)
8.0 US qt (7.5 l)
Recommended engine oils
Automatic transmission
9.0 US qt (8.5 l)
MB Automatic Transmission Fluid
1
1MB part no. 001 989 21 03 10Transfer case
2.96 US qt (2.8 l)
MB part no. A 001 989 28 03 10
Differential lock mechanism
0.47 - 0.63 US qt
(0.45 - 0.6 l)
Brake fluid DOT 3+4, SAE J1703
Front axle
1.5 US qt (1.4 l)
Hypoid gear oil SAE 90, 85 W 90
Rear axle
1.9 US qt (1.8 l)
Hypoid gear oil SAE 90, 85 W 90
Power steering
approx. 1.06 US qt (1.0 l)
MB Power Steering Fluid, or
approved Dextron III ATF
Front wheel hubs
approx. 1.5 oz (43 g) each
High temperature roller bearing grease
Brake system
approx. 0.53 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Fuel tank
including a reserve of
25.4 US gal (96.0 l)
5.3 US gal (20.0 l)
Premium unleaded gasoline:
Posted Octane 91
(average of 96 RON / 86 MON)

338 IndexFuel 215
Additives 319
Fuel reserve warning lamp 243, 244
Gasoline additives 319
Premium unleaded gasoline 215, 316,
318
Requirements 318
Reserve warning 25
Technical data 316
Fuel additives 319
Fuel consumption statistics
After start 130
Since last reset 131
Fuel filler flap 214
Locking 214
Opening 274
Unlocking 214
Fuel requirements 318
Fuel reserve tank
Message in display 263
Fuel tank
Capacity 316
Filler flap 214
Fuels, coolants, lubricants etc.
Capacities 316Functions (control system) 112, 115
Resetting 120
Fuse box 303, 304, 305
Fuses 303
Fuse box in battery box 303
Fuse box in front passenger footwell
304
Fuse box in middle tunnel 305
Fuse box in passenger
compartment 303
G
Garage door opener 29, 191
Gasoline see Fuel 215
Gasoline additives 319
Gear range 326
Automatic transmission 137
Limiting 137
Shifting into optimal 137
Transfer case 141
Gear range limit
Canceling 137
Gear selector lever
Cleaning 235
Position 138Global
Locking 85
Unlocking 85
Global Positioning System (GPS) 326
Glossary 325
Glove box 23, 176
Closing 176
Opening 176
Good visibility 147
GPS 326
GPS see COMAND 189
H
Hard plastic trim items
Cleaning 236
Hazard warning flasher 103
Switching off 104
Switching on 104
Head restraints 92
Power seats 36
Synchronizing 93
Headlamp cleaning system 222
Headlamp switch-off delay see Delayed
switch-off, exterior lamps

340 IndexInterior storage spaces 176
Cup holder 178
Cup holders 178, 179
Glove box 176
Parcel net in front passenger
footwell 179
Storage compartment below
armrest 177
Storage compartment in front of
armrest 177
Interval wiping 48
Switching off 48
Switching on 48
J
Jack 268, 269
Jump starting 297
K
Key dependency memory
Settings 129
Key positions in starter switch 33
Key, mechanical 272
Key, SmartKey
Battery check lamp 85
Changing the batteries 273
Checking the batteries 86Factory setting 85
Global locking 85
Global unlocking 85
Loss of 86
Positions in starter switch 33
Remote controls 84
Restoring to factory setting 85
Selective setting 85
Starting the engine 44
Unlocking with 32
Keys 84
Kickdown 139, 326
Kilometers/miles in speedometer 122
Km/h or mph in speedometer 122
L
Labels, identification 310
Lamp bulbs, exterior 279
Lamps, exterior
Front 279
Light sensor 261
Messages in display 259, 261
Rear 280
Replacing bulbs for rear 286
Lamps, indicator and warning
ABS 240
Battery (SmartKey) 85Brakes 241, 242
CHECK ENGINE 243
Engine diagnostics 243
ESP 238, 239
Fuel reserve 243, 244
Instrument cluster 243, 244
Seat belts 243
Service indicator 230
SRS 55
Turn signals 25
Language
Multifunction display 123
Setting 123
LATCH child seat anchors 68
LATCH child seat mounts 68
Layout of poly-V-belt drive 311
Leather upholstery
Cleaning 236
License plate lamps
Messages in display 261
Replacing bulbs 280, 288
Light alloy wheels
Cleaning 235
Technical data 313
Light sensor 261
Lighter see Cigarette lighter 181

342 IndexMenus 112
AUDIO 116
Control system 327
In control system 114, 115
Malfunction memory 118
NAVI 118
Settings menu 119
Standard display 116
Submenus 113
TEL 132
Trip computer 130
Middle tunnel
Fuse box in 305
Miles/kilometers in speedometer
Setting 122
Mirrors
Activating exterior rear view mirror
parking position 148
Adjusting 38
Automatic antiglare for rear view mirror
147
Exterior rear view mirror 38
Exterior rear view mirror parking posi-
tions 130
Inside rear view mirror 38Storing exterior rear view mirror park-
ing position 99
MON 215
MON (Motor Octane Number) 327
Monitoring reach
Rear Park Assist* 166
Mph or km/h in speedometer 122
Multicontour seat* 94
Multifunction display 111, 327
Selecting language 123
Standard display 115
Multifunction display messages
ABS 247
BAS 248
Battery 266
Brake fluid 250
Brake pads 250
Check engine 243
Coolant 251, 252
Display 267
Doors 254
Engine 243
Engine oil level 254
ESP 257
Fuel reserve tank 263
Hood 258Key 259
Lamps 259, 261
Parking brake 263
Tailgate 266
Tele Aid 266
Telephone* 258
Washer fluid 267
Multifunction steering wheel 26, 112
Buttons 112
N
Navigation system
Operating 118
See separate COMAND operating in-
structions
Night security illumination 102
Setting 125
O
Occupant safety 54
Airbags 55
Children in the vehicle 63
Fastening the seat belt 40
Infant and child restraint systems 63
LATCH child seat mounts 68
Seat belts 40, 58
Odometer, main 25